• KSBB Journal
• /
• 제20권5호
• /
• pp.350-354
• /
• 2005

수소생산을 최적화하기 위하여 Enterobacter cloacae YJ-1을 이용해 생산성에 미치는 탄소원 농도, 질소원 농도, 금속이온 농도, 아미노산 효과로서 회분식 배양을 통하여 실험을 수행하였다. 각종 탄소원의 종류에 따라 수소생산을 검토한 결과 glucose 첨가시에 가장 양호하였다. 따라서 glucose 농도를 변화시켜 수소생산량을 조사한 결과 $2\%$(w/v) 농도에서 최대를 보여 975.4 mL/L를 생산하였다. 각종 질소원 중에서 가장 효과적인 질소원은 yeast extract이었으며, 최대 수소생산량은 $1.5\%$(w/v) 농도에서 1651.5mL/L이었다. 금속이온으로는 $Na_2MoO_4$가 가장 효과적으로 나타나 $0.04\%$(w/v) 농도에서 1753.3 mL/L를 생산하였다. 아미노산은 cystein에서 가장 생산량이 많았으며, 다음은 proline, histidine, alanine 등 순이었다. 회분식 배양의 최적 조건하에 수소를 연속적으로 생산하기 위하여 반연속배양을 행한 결과 $3\%$ (w/v) 농도에서 2215.4 mL/L로 가장 높았다. 생산균주의 대사에 관한 물질을 보다 세밀히 조사하고 연속적인 수소생산을 살펴 산업적인 공정개발도 가능하리라 생각된다.

• Asian-Australasian Journal of Animal Sciences
• /
• 제26권1호
• /
• pp.122-127
• /
• 2013

The hypochlorite ion ($OCl^-$) is a widely used disinfecting agent in pig rearing in Korea, but its residual effect on $CH_4$ production from pig slurry is unclear. The objective of this study was to investigate the inhibition effects of residual $OCl^-$ on $CH_4$ production during the initial anaerobic digestion stage of pig slurry. Three organic concentrations (9.9, 26.2 and 43.7 g/L) of volatile solids (VS) were tested with the addition of 52.3 mg/L $OCl^-$, ten times of the typical concentration used in Korea, or without $OCl^-$ (Control) in anaerobic batch culture. The culture was run under mesophilic ($38^{\circ}C$) conditions for 20 d. At the lowest organic concentration with $OCl^-$, the VS degradation was 10.3% lower (p<0.05) than Control, while at the higher organic concentration with $OCl^-$, it did not differ from Control. $CH_4$ yields were higher in the control treatments than their $OCl^-$ counterpart cultures, and $CH_4$ yields of Control and $OCl^-$ treatments at the organic concentrations of 9.9, 26.2 and 43.7 g/L differed in the probability level (p) of 0.31, 0.04, and 0.06, respectively. Additionally, $CH_4$ concentration increased steeply and reached 70.0% within 4 d in the absence $OCl^-$, but a gradual increase up to 60.0% was observed in 6 d in the $OCl^-$ treated cultures. The $R_m$ (the maximum specific $CH_4$ production rate) and ${\lambda}$ (lag phase time) of 9.9 g/L with $OCl^-$ were 8.1 ml/d and 25.6 d, while the $R_m$ was increased to 15.1 ml/d, and ${\lambda}$ was reduced to 11.4 d in PS-III (higher organic concentration) with $OCl^-$. The results suggest that a prolonged fermentation time was necessary for the methanogens to overcome the initial $OCl^-$ inhibitory effect, and an anaerobic reactor operated with high organic loadings was more advantageous to mitigate the inhibitory effect of residual hypochlorite ion.

• Environmental Engineering Research
• /
• 제15권1호
• /
• pp.3-7
• /
• 2010

To better understand the ecology of tetrade forming organisms (TFOs) floating in a large amount of dairy wastewater treatment plant (WWTP) effluent (sequencing batch reactor [SBR]) during the inefficient phosphorus (P) removal process of an enhanced biological P removal system, the TFOs from the effluent of a full scale WWTP were separated and attempts made to culture the TFOs in presence/absence of oxygen. The intact TFOs only grew aerobically in the form of unicellular short-rods. Furthermore, to identify the intact TFOs and unicellular short-rods the DNAs of both were extracted, analyzed using their denaturing gradient gel electrophoresis (DGGE)-profiles and then sequenced. The TFOs and unicellular short-rods exhibited the same banding pattern in their DGGE-profiles, and those sequencing data resulted in their identification as Acinetobacter sp. The intact TFOs appeared in clumps and packages of tetrade cells, and were identified as Acinetobacter sp., which are known as strict aerobes and efficient P-removers. The thick layer of extracellular polymeric substance surrounding Acinetobacter sp. may inhibit phosphate uptake, and the cell morphology of TFOs might subsequently be connected with their survival strategy under the anaerobic regime of the SBR system.

• 한국환경농학회지
• /
• 제23권1호
• /
• pp.1-6
• /
• 2004

혐기성 소화에서 미생물에 저해/독성 물질로 알려진 암모니아의 농도와 식종원에 따른 영향을 회분식 반응기를 이용하여 분석하였다. 식종원은 고농도의 암모니아에 장기간 적응된 축산농가 축산폐수 집수조의 슬러지 그리고 저농도의 암모니아에 노출된 하수종말처리장 혐기성 소화조 슬러지를 사용하였다. 식종원에 상관없이 암모니아는 TAN 1,500 mg-N/L에서 COD 제거율과 biogas 발생량으로 측정된 혐기성 미생물의 활성에 저해영향을 주기 시작하여 3,500 mg-N/L에서는 더욱 심하였다. 암모니아 저해 농도 범위에서 휘발성 유기산의 농도는 50 mg/L 범위로 유지되므로 메탄생성균 뿐만 아니라 산생성균도 저해영향을 받는 것으로 나타났다. 축산폐수 집수조 슬러지로 식종된 경우 암모니아 농도 TAN으로 $2,500{\sim}3,500\;mg-N/L$ 범위에서도 COD 제거율과 biogas 발생량의 감소폭은 미미하였으나 하수종말처리장 혐기성 소화조 슬러지로 식종된 경우 암모니아 농도가 증가할수록 COD 제거율과 biogas 발생량은 큰 폭으로 감소하였다. 결과적으로 암모니아에 장기간 순응된 슬러지로 식종한 경우 암모니아의 저해 농도에 대하여 적응도 빨랐으며 저해영향도 적었다.

• KSBB Journal
• /
• 제14권1호
• /
• pp.71-75
• /
• 1999

인 축적능이 우수한 균주를 자연계로부터 위노그라드스키 칼럼을 이용해 분리하여 Acinetobacter 속으로 동정하였고, Aci-netobacter CW3로 망명하였다. 인 축적균주의 배양초기조건은 $20^{\circ}C$. pH 7, 200rpm, 18.5mg $FO_4-P/\ell$가 최적임을 보였다. Acinetobacter CW3은 회분배양에서는 최적조건에서 12시간만에 인의 제거가 완료되었다. 이 균주는 호기조건에서는 인을 균주 내부에 과량 축적하고 첨가조건에서 인을 다시 방출함을 보였다.

• 한국토양비료학회지
• /
• 제45권6호
• /
• pp.1049-1057
• /
• 2012

본 연구는 메탄생성에 직접적으로 관여하는 혼합 메탄균과 셀롤로스 등의 고분자 물질의 가수분해 반응에 활성이 뛰어난 반추위 내 혐기성 섬유소분해균 중에서 대표적인 Fibrobacter succinogenes, Ruminococcus flavefaciens 및 Ruminococcus albus를 biochemical methane potential (BMP) 시험에 첨가하였을 때 메탄 발생에 미치는 영향을 조사하고자 수행되었다. BMP시험은 멸균증류수를 첨가한 control과 각각의 미생물 배양액을 첨가한 혼합 메탄균 첨가구 (M), F. succinogenes 첨가구 (FS) R. flavefaciens 첨가구 (RF), R. albus 첨가구 (RA) 및 RA+FS 혼합첨가구와 M+RA+FS 혼합 첨가구로 총 7개 처리구로 각 처리구별 3반복으로 진행되었다. 미생물 배양액의 첨가량은 식종액과 양돈슬러리에 1% (0.5 mL), 3% (1.5 mL) 및 5% (2.5 mL) 씩 첨가 하였다. BMP 시험을 위해 60일간 배양이 지속되었고 중온소화를 위해 $38^{\circ}C$의 배양기에서 수행되었다. 실험의 결과 총 바이오가스 발생량은 5% RF와 RA+FS가 대조구에 비하여 8.1 및 8.4%로 가스발생량이 유의적으로 높았다(p<0.05). 메탄발생량은 3% 미생물 배양액 첨가구 중 M+RA+FS를 제외하고 대조구에 비하여 증가시키는 경향을 보였으며, 5% 배양액을 첨가하였을 때는 대조구에 대하여 5%의 M, FS, RF, RA, RA+FS, 및 M+RA+FS RF가 각각 12.1, 12.6, 17.3, 13.7, 17.9 및 14.7%로 메탄가스발생량을 증가시켰다 (p<0.05). TS 및 VS 분해율은 가스발생량과는 관계없이 모든 처리구에서 미생물 배양액의 첨가량이 증가하더라도 차이가 없었다. BMP 종료시 배양액내 pH는 모든 처리구가 7.527~7.657의 범위로 메탄발효에 큰 영향을 주지 않았다. 결론적으로, 본 실험에서는 양돈 슬러리의 성분특성으로 인해 가수분해단계와 메탄생성단계 모두에 첨가한 미생물 배양액이 효과가 있었으나, 5% 첨가수준을 제외하고 낮은 첨가수준에서는 첨가효과가 나타나지는 않았다.

• Journal of Microbiology
• /
• 제44권2호
• /
• pp.155-161
• /
• 2006

Comparative analysis of microbial communities in a sequencing batch reactor which performed enhanced biological phosphorus removal (EBPR) was carried out using a cultivation-based technique and 16S rRNA gene clone libraries. A standard PCR protocol and a modified PCR protocol with low PCR cycle was applied to the two clone libraries of the 16S rRNA gene sequences obtained from EBPR sludge, respectively, and the resulting 424 clones were analyzed using restriction fragment length polymorphisms (RFLPs) on 16S rRNA gene inserts. Comparison of two clone libraries showed that the modified PCR protocol decreased the incidence of distinct fragment patterns from about 63 % (137 of 217) in the standard PCR method to about 34 % (70 of 207) under the modified protocol, suggesting that just a low level of PCR cycling (5 cycles after 15 cycles) can significantly reduce the formation of chimeric DNA in the final PCR products. Phylogenetic analysis of 81 groups with distinct RFLP patterns that were obtained using the modified PCR method revealed that the clones were affiliated with at least 11 phyla or classes of the domain Bacteria. However, the analyses of 327 colonies, which were grouped into just 41 distinct types by RFLP analysis, showed that they could be classified into five major bacterial lineages: ${\alpha},\;{\beta},\;{\gamma}-$ Proteobacteria, Actinobacteria, and the phylum Bacteroidetes, which indicated that the microbial community yielded from the cultivation-based method was still much simpler than that yielded from the PCR-based molecular method. In this study, the discrepancy observed between the communities obtained from PCR-based and cultivation-based methods seems to result from low culturabilities of bacteria or PCR bias even though modified culture and PCR methods were used. Therefore, continuous development of PCR protocol and cultivation techniques is needed to reduce this discrepancy.

• Biotechnology and Bioprocess Engineering:BBE
• /
• 제9권4호
• /
• pp.252-255
• /
• 2004

A pfl ldhA double mutant Escherichia coli strain NZN 111 was used to produce succinic acid by overexpressing the E. coli malic enzyme gene (sfcA). This strain, however, produced a large amount of malic acid as well as succinic acid. After the analyses of the metabolic pathways, the fumB gene encoding the anaerobic fumarase of E. coli was co-amplified to solve the problem of malic acid accumulation. A plasmid, pTrcMLFu, was constructed, which contains an artificial operon (sfcA-fumB) under the control of the inducible trc promoter. From the batch culture of recombinant E. coli NZN 111 harboring pTrcMLFu, 7 g/L of succinic acid was produced from 20 g/L of glucose, with no accumulation of malic acid. From the metabolic flux analysis the strain was found under reducing power limiting conditions by severe reorientation of metabolic fluxes.

• Journal of Microbiology and Biotechnology
• /
• 제19권2호
• /
• pp.167-171
• /
• 2009

The effects of culture conditions on succinic acid production and its possible scale-up have been studied. Mannheimia succiniciproducens LPK7, engineered for enhanced production of succinic acid and reduced by-product secretion, was used for the experiments. Mannheimia succiniciproducens LPK7 is a knock-out strain of wild type deficient in the ldhA, pflB, and pta-ackA genes, and is derived from Mannheimia succiniciproducens MBEL55E. Process optimization of factors including optimal temperature, pH, carbon source, and nitrogen source was performed to enhance the production of succinic acid in flasks. To observe scale-up effects, batch fermentation was carried out at various working volumes. At a working volume of 7.0 l, the final succinic acid concentration and yield were 15.4g/l and 0.86g/g. This result shows similar amount of succinic acid obtained in lab-scale fermentation, and it is possible to scale up to larger fermentors without major problems.

• Journal of Microbiology and Biotechnology
• /
• 제18권5호
• /
• pp.908-912
• /
• 2008

To achieve a higher succinic acid productivity and evaluate the industrial applicability, this study used Mannheimia succiniciproducens LPK7 (knock-out: ldhA, pflB, pta-ackA), which was recently designed to enhance the productivity of succinic acid and reduce by-product secretion. Anaerobic continuous fermentation of Mannheimia succiniciproducens LPK7 was carried out at different glucose feed concentrations and dilution rates. After extensive fermentation experiments, a succinic acid yield and productivity of 0.38 mol/mol and 1.77 g/l/h, respectively, were achieved with a glucose feed concentration of 18.0 g/l and $0.2\;h^{-1}$ dilution rate. A similar amount of succinic acid production was also produced in batch culture experiments. Therefore, these optimal conditions can be industrially applied for the continuous production of succinic acid. To examine the quantitative balance of the metabolism, a flux distribution analysis was also performed using the metabolic network model of glycolysis and the pentose phosphate pathway.