• Journal of Korean Society of Environmental Engineers
• /
• v.38 no.11
• /
• pp.618-626
• /
• 2016

The influence of ferric ion ($Fe^{+3}$) on bioelectrochemical anaerobic digestion for sewage sludge was explored at ambient temperature ($25^{\circ}C$). Before the addition of ferric ion, the removal of volatile solids (VS) was 65.9% and the specific methane production rate was 370 mL/L/d. After the addition of ferric ion (200 ppm) to feed sludge, the bioelectrochemical anaerobic digester was more stable in the state variables including pH, alkalinity, COD and VFAs, and the VS removal and specific methane production rate were increased to 69.8% and 396 mL/L/d, respectively. However, the methane content in biogas was slightly reduced by the addition of ferric ion, indicating that the activity of planktonic anaerobic bacteria (PAB) was more improved after the addition of ferric ion. The dominances of syntrophic bacteria (Cloacamonas) and hyrolytic bacteria (Saprospiraceae, Ottowia pentelensis) in the PAB were increased by the addition of ferric ion. The addition of ferric ion improved the performance of bioelectrochemical anaerobic digestion for sewage sludge at ambient temperature.

• Journal of Korean Society on Water Environment
• /
• v.26 no.5
• /
• pp.754-760
• /
• 2010

This study was carried out not only to evaluate optimal operating condition to increase biogas production, but also to estimate feasibility of renewable energy from anaerobic digester of sewage sludge. Semi- continuous Fed and Mixed Reactors (SCFMRs) were operated in various condition to quantify the reactor variables. The result of SCFMR operation showed that the biogas productivity and total volatile solids (TVS) removal of total solids (TS) 4% reactor at hydraulic retention time (HRT) 20 days with Organic Loading Rate (OLR) of $1.45kg/m^3-d$ were $0.39m^3/m^3-d$ and 26.7%, respectively which was two times higher than that of TS 2.5% reactor. Consequently the daily biogas production of $20,000m^3$ would be possible from the total volume of $52,000m^3$ of anaerobic digesters of the municipal wastewater treatment plant in D city. In feasibility study for the Biogas utilization, combined heat and power system (CHP) and CNG gasification were examined. In case of CHP, the withdrawal period of capital cost for gas-engine (GE) and micro gas-turbine (MGT) were 7.7 years and 9.1 years respectively. biogas utilization as Clean Natural Gas (CNG) shows lower capital cost and higher profit than that of CHP system. CNG gasificaion after biogas purification is likely the best alternative for Biogas utilization which have more economic potential than CHP system. The withdrawal period of capital cost appeared to be 2.3 years.

• Journal of the Korea Organic Resources Recycling Association
• /
• v.18 no.1
• /
• pp.73-80
• /
• 2010

Two nitrite oxidizing bacteria, NOB1 and NOB2, were isolated from anaerobic digester liquer of food wastewater and analyzed for their growth characteristics and the ability to oxidize nitrite under different temperature, pH, and DO( dissolved oxygen) concentrations. Both of the isolated strains have shown the best growth at pH 7.0 and at $35^{\circ}C$, and also shown higher growth rate with the increasing dissolved oxygen concentrations. As the factors to restrict the growth of these strains, parameters such as pH and DO were found to be effective ones, by increasing (up to 9.0) or decreasing pH (up to 5.0), or lowing DO below 1.0 ppm. Especially, the ability to oxidize nitrite in both strains was about 50% lower in below 1.0 ppm of DO than above of 1.0 ppm. NOB2 was found to be two times greater in both the growth rate and the nitrite-oxidizing ability than NOB1.

• Microbiology and Biotechnology Letters
• /
• v.25 no.1
• /
• pp.1-8
• /
• 1997

Carbon monoxide (CO)-utilizing acetogens were enriched and KIST612 isolated from anaerobic digester fluid was selected for its abilities to tolerate high CO and acetate concentration. The isolate KIST612 was identified as Eubacterium limosum based on the morphological and biochemical characteristics, G+C content of DNA and 16S rRNA sequence analysis. E. limosum KIST612 produced acetate and butyrate from CO. The optimum temperature and pH for the growth and acids formations were 37$\cdot $C and 7.0, respectively. The growth rate and acids productivity of E. limosum KIST612 were higher than those of any other known acetogens when CO was used as the sole energy and carbon source.

• Journal of Korean Society of Water and Wastewater
• /
• v.28 no.4
• /
• pp.411-417
• /
• 2014

The performance of the new aerobic digestion system combined with inorganic sludge separation unit and sludge solubilization unit, CaviTec II, is evaluated. Anaerobic digester effluent sludge is used for feed sludge of CaviTec II system. By addition of CaviTec II, the amount of cake generated is reduced by 27%, and the soluble nitrogen is reduced by 92%.

• Journal of Environmental Science International
• /
• v.20 no.10
• /
• pp.1233-1241
• /
• 2011

The main objective of this experimental investigation was $CH_4$ recovery from biogas generated in municipal and wastewater treatment plant. The polysulfone hollow fiber membrane was prepared in order to investigate the permeation properties of $CH_4$ and $CO_2$. Permeability of $CO_2$ in Polysulfone membrane was 11-fold higher than of $CH_4$ gas. A membrane pilot plant for upgrading biogas was constructed and operated at a municipal wastewater treatment plant. The raw biogas contained 66 ~ 68 Vol % $CH_4$, the balance being mainly $CO_2$. The effect of the operating pressure of feed and permeate side and feed flowrate on $CH_4$ recovery concentration and efficiency were investigated with double stage membrane pilot plant. The $CH_4$ concentration in the retentate stream was raised in these tests to 93 Vol % $CH_4$.

• Journal of Korean Society of Water and Wastewater
• /
• v.28 no.1
• /
• pp.135-142
• /
• 2014

The performance of inorganic sludge separation system is evaluated. Anaerobic digester effluent sludge is used for feed sludge of this system and hydrocyclone is used for inorganic sludge separation. For phosphorus removal and recovery $MgCl_2$ is pumped into MAP growth tank, a component of inorganic sludge separation system. Using this system inorganic sludge which contained less than 40 % of organic matter can be discharged stably and the maximum amount of separated inorganic sludge is 13.4 % of influent sludge based on dry solid. The amount of phosphorus recovered as MAP(as P) is 16.7 % to influent T-P.

• Journal of Korean Institute of Industrial Engineers
• /
• v.22 no.1
• /
• pp.155-164
• /
• 1996

Biomass to methane via anaerobic digestion conversion is a good supply method of substitutable energy resources. The economic viability of this technology is contingent upon managing the production facilities in a cost effective manner. The problem is to determine the batch production sequence as well as the batch residence times in the digester so as to maximize total gas production over a given planning horizon. The problem is difficult to solve since the batch sequencing decisions and the batch residence time decisions cannot be isolated. This paper developes a heuristic algorithm which is based on a dynamic programming procedure for the multiple feedstock sequencing and scheduling biogas production systems and demonstrates to yield good results.

• Journal of the Korea Organic Resources Recycling Association
• /
• v.21 no.1
• /
• pp.53-61
• /
• 2013

The characteristics of methane production from pig manure slurry was investigated using anaerobic digestor combined with compost filtration bed. In this study, raw pig manure slurry was digested in mesophilic rectangular digester (effective volume $250m^3$) for 25 days and anaerobic digestion wastewater was filtered through compost filtration bed, which is composed of double layer, sawdust and chaff. The characteristics of anaerobic digestion wastewater were BOD 1,800 mg/L, COD 3,500 mg/L, SS 11,800 mg/L, T-N 1,200 mg/L and T-P 350 mg/L. After the filtration process, the contents of BOD, COD, SS, T-N and T-P of the anaerobic digestion wastewater were reduced by 97%, 62%, 89%, 39% and 57%, respectively. The concentrations of N, $P_2O_5$, and $K_2O$ of the leachate were 1,024, 111 and 407 mg/L, respectively. However, there was no odor emitted from the leachate.

• Korean Journal of Soil Science and Fertilizer
• /
• v.22 no.4
• /
• pp.323-328
• /
• 1989

This study was conducted to find out the behavior of anaerobic microorganisms and anaerobic decomposition products of rice straw in the strict anaerobic condition. The number of methanogenic bacteria were more isolated than cellulolytic bacteria from the digester decaying rice straw during the entire incubation time. The activity of anaerobic microorganisms, such as methanogens and cellulolytics, were high the early incubation time in the treatment of rice straw with urea, but without urea was low at that time and increased moderately after 10 days incubation. Volatile fatty acid as intermediate anaerobic decomposition products had a longer retention time and higher accumulation rate in the treatment of rice straw without urea than with urea, and predominant fatty acid was propionic acid. Gas generation rate as final products were very intimate relationship with the activity of methanogenic bacteria. Average Eh value was -250mV during the incubation time and $CH_4$ : $CO_2$ percent ratio was about 60~65 : 35~40 in this Eh value. Decomposition rate of rice straw calculated from $CH_4$ and $CO_2$ gas wars 45.6% for 50 days in the treatment of rice straw with urea, and 36.8% without urea.