• Korean journal of food and cookery science
• /
• v.16 no.5
• /
• pp.402-409
• /
• 2000

Jeolpyon was prepared by different moisture addition and then retrogradation characteristics and quality evaluation were investigated during storage periods. In Hunter's color value, lightness of Jeolpyon was decreased, whereas yellowness was increased during storage. In texture profile analysis, hardness, gumminess and chewiness of Jeolpyon were increased during storage and texture parameters were decrease by increasing moisture level. Jeolpyon prepared with 35% moisture addition was slowly retrograded in avrami equation. In the results of sensory evaluation, the parameters were significantly different during storage. The results showed that Jeolpyon prepared with 35% moisture addition had good sensory quality and slow rate of retrogradation.

• Journal of the Korean Society of Propulsion Engineers
• /
• v.25 no.3
• /
• pp.26-41
• /
• 2021

Titanium hydride potassium perchlorate (THPP) has played an important role as initiators of the propulsion system. However, the 'aging' may cause performance degradation and even give rise to a failure in the total system. In this study, various hygrothermal aging conditions were considered and the aging effects on thermodynamic and ignition characteristics of THPP are provided via thermal analysis and ignition measurements. Also, physical-chemical changes were identified by morphological analysis. In conclusion, thermal aging led to E_α decrease-high reactivity due to oxidizer decomposition whereas hygrothermal aging gave rise to an opposite tendency by fuel oxidation.

• Korean Journal of Food Science and Technology
• /
• v.26 no.4
• /
• pp.370-374
• /
• 1994

The effect of water activity(Aw) and storage temperature on retrogradation of pregelatinized corn starch was investigated at various temperature of $4^{\circ}C$, $20^{\circ}C$ and $30^{\circ}C$. Samples stored at different water activity, i.e., 0.43, 0.52, 0.75, 0.83, 0.88 and 0.93 by means of saturated salt solutions. The rate of retrogradation was determines. by enzymic digestibility, and evaluated by Avrami equation. The degree of retrogradation during storage showed a great difference around Aw 0.8. At Aw 0.52 and 0.75 at all temperatures, retrogradation occurred slightly. The effect of water activity on retrogradation was much greater at $4^{\circ}C$ than 300. And at Aw 0.43, the degree of retrogradation after 3-week storage was smaller than 3.9%. The critical water activity of retrogradation was inferred as Aw 0.43. At each temperature, the degrees of retrogradation of gelatinized corn starch after 24-day storage were 30% at Aw 0.8 and Aw 0.9, and greater than 50% at the Aw above 0.9. At Aw below 0.8 the degree of retrogradation was about 20%. The rate constants of retrogradation according to Aw showed small differences at $20^{\circ}C$ and $30^{\circ}C$, but showed a great difference at $4^{\circ}C$. The value of exponent of Avrami was 1.0 regardless of temperature and water activity. And the rate constants of retrogradation increased with increasing Aw, but decreased with increasing temperature.

• Journal of the Korean Society for Aeronautical & Space Sciences
• /
• v.49 no.9
• /
• pp.759-769
• /
• 2021

For aerospace propulsion systems, Titanium Hydride Potassium Perchlorate (THPP) is a material commonly used as a pyrotechnic initiator that generates gas when energy is supplied or as a supplement charge for NASA standard initiator (NSI). However, when the energetic materials are stored for a long time, it faces the problem of 'aging'. In this study, changes in thermodynamic properties of THPP aged under various humidity environments were identified through thermal analysis and surface analysis. First, a considerable amount of cracks on the surface of the oxidant was found in the aged THPPs. Particularly, when the humidity level increased, the number and length of the cracks rapidly increased. Also, the deterioration of Viton was found only in the thermally aged sample whereas the oxidation of the fuel was more pronounced in the hygrothermally aged samples. The extracted kinetic parameters of THPP on the reaction progress vary greatly by the humidity level, indicating that moisture significantly changes the performance and combustion reaction of THPP, which may eventually result in a reduced lifespan.

• Korean Journal of Food Science and Technology
• /
• v.23 no.1
• /
• pp.116-121
• /
• 1991

The effects of water contents and surfactants, sodium stearoyl-lactylate, sucrose ester and distilled monoglyceride(Dimodan) on wheat starch gelatinization and retrogradation were studied by differential scanning calorimetry. The endothermic peak patterns of starch varied with water content of starch. When water content was less than 30%, gelatinization did not occur. The onset temperature of gelatinization peak of native starch was $59{\sim}60^{\circ}C$ and that of endothermal peak of retrograded starch was $50{\sim}55^{\circ}C$. The enthalpy value of retrograded starch were greatest in the $40{\sim}50%$ water content. In the presence of surfactants, gelatinization temperatures shifted slightly to higher temperatures. DSC endothermal enthalpies of the amylose-lipid complex increased. The degree of retrogradation in starch was lower with surfactant than without surfactant, but enthalpy of amylose-lipid complex did not change during storage.

• Applied Biological Chemistry
• /
• v.40 no.6
• /
• pp.508-513
• /
• 1997

Thermal characteristics and granular morphology on enzyme-resistant starches (RS) formed during heat-moisture treatment (HMT) and retrogradation were investigated in high amylose corn starches, Hylon V and Hylon VII. With each treatment, both starches showed a similar trend in the increase of RS, but RS yield of Hylon VII is higher than that of Hylon V. Specially, RS was increased remarkably by HMT. It was more than doubled from 11.4% to 26.6% for Hylon V and from 15.9% to 32.8% for Hylon VII. A small increase of RS resulted from retrogradation. HMT on starch increased gelatinization temperature, decreased enthalpy. Retrograded starch exhibited small three endothermic transitions at $94^{\circ}C$, $110^{\circ}C$ and $140^{\circ}C$ in differential scanning calorimetry (DSC) thermogram due to the remained ungelatinized starch granules, dissociation of amylose-lipid complex and melting of recrystallized amylose, respectively. Enzyme-resistant starches isolated from native and heat-moisture treated starches showed a broad endothermic transition at higher temperature than native starch, while retrograded starch exhibited a very sharp peak at ${\sim}150^{\circ}C$ due to the melting of amylose crystallites. Under microscopy, starch granules with HMT was not changed, but retrograded starches showed the aggregates of starch granules because amylose leached out during gelatinization. Iodine stained RS clearly showed the differences in enzyme hydrolysis on the native, heat-moisture treated and retrograded starches.

• Korean Journal of Food Science and Technology
• /
• v.26 no.5
• /
• pp.579-584
• /
• 1994

Near infrared reflectance(NIR) spectroscopy was used to determine the degree of retrogradation of cooked rice. Cooked rice samples were stored at $4^{\circ}C$ for 120 hours, and the degree of retrogradation was measured at every 6 hour during the storage time. Stored cooked rices were freeze-dried, milled and passed through a 100 mesh sieve. Enzymatic method using glucoamylase was used as reference method for the determination of the degree of retrogradation. Spectral differences due to retrogradation of cooked rice were observed at 1434, 1700, 1928, 2100, 2284 and 2320 nm. 32 samples of which moisture content were below 5% were used for calibration set, and 16 samples were used for validation set. High correlations were achieved between degree of retrogradation determined by conventional enzymatic method and by NIR with multiple correlation coefficient of 0.9753, and a standard error of calibration(SEC) of 3.64%. Comparable results were obtained with 3.91% of standard error of prediction(SEP), when the calibration equation was applied to independent group of samples of which moisture contents were in the range of calibration set. But when the calibration equation was applied to samples of which moisture contents were outer range of calibration set, SEP and bias were increased and correlation coefficient was decreased. The determination of degree of retrogradation was affected by sample moisture content. To determine degree of retrogradation of cooked rice by NIR using this calibration equation, it was suggested that sample moisture content should be controlled to below 5%.

• Journal of the Korean Society of Propulsion Engineers
• /
• v.26 no.4
• /
• pp.28-43
• /
• 2022

To minimize such loss due to aging, research on energetic materials is being actively conducted though, there are difficulties in identifying the comprehensive aging mechanisms as they focused on the respective materials. In this study, thermal and surface analysis were performed on energetic materials composed of metals(W, Ti, and Zr) and KClO₄ oxidizer to solve the blind spots of this aging study. It was newly found that the metals in the hygrothermally aged compounds can cause significant changes in performance. For example, the growth in the thickness of the oxide film on the metals led to an increase in the average value of activation energy(E_α). In addition, the standard deviation of E_α tends to dependent on the type of metal, which is due to the difference in electronegativity.

• KSCE Journal of Civil and Environmental Engineering Research
• /
• v.39 no.4
• /
• pp.523-530
• /
• 2019

Pavement distress and traffic accidents are caused by pot-hole. In addition, direct and indirect damages of road users are increasing, such as loss of life due to personal injury and damage to vehicles. Generally, the asphalt concrete pavements are continuously aging from the production process to the terminal performance period. Aging causes stripping due to cracks and moisture penetration and weakening the pavement structure to induce pot-hole. In this study, adhesion performance and moisture sensitivity were evaluated according to aging degree in order to investigate the effect of aging on asphalt pavement. As a result of the study, the viscosity of the asphalt binder was increased with aging and the bond strength of the aged was increased 2~3 times than that of the unaged. The results of accelerated aging test showed an increases in indirect tensile strength and the increase in the TSR (Tensile Strength Ratio) by 4.2~8.9 %. As a result, it is noted that the anti-stripping and adhesion performances of the aged asphalt concrete are improved compared to the unaged one under the aging conditions of asphalt binder coated on aggregates.

• Journal of the Korean Society of Propulsion Engineers
• /
• v.23 no.1
• /
• pp.79-92
• /
• 2019

Titanium hydride potassium perchlorate (THPP) is one of the commonly utilized pyrotechnic materials in aerospace industries. The current study elucidates the effects of hygrothermal aging on the combustion of THPP experimentally. First, applying the Differential Scanning Calorimetry (DSC) and isocoversional method, both the delay of reaction start and decrease in maximum reaction rate were observed. The kinetics parameters tended to fluctuate depending the thermal reaction or intermediate product formation of THPP. Also, the oxidants decomposition and fuel oxidation phenomenon were discovered by X-ray photoelectron spectroscopy (XPS). The experimental heat from DSC data were verified as reasonable by comparing with the theoretical heat obtained utilizing both THPP formulation from XPS and NASA Chemical Equilibrium with Applications (CEA). Both data had identical variation trend, which expecially had the highest heat value at 10 weeks aged sample.