• Journal of the Korea Concrete Institute
• /
• v.15 no.5
• /
• pp.670-678
• /
• 2003

Recently, since industrial waste and life waste leaped into a pollution source, the building material used now a days is striking the limit. The purpose of this paper is to investigate an application of recycled coal ash using non-sintering method in the construction field. Accordingly, compressive strength, elastic modulus and drying shrinkage were experimentally studied for hardened coal ash using the non-sintering method. Also, Lineweaver and Burk method were applied to the regression analysis of drying shrinkage for the proposal equation. Elastic modulus, compressive strength of material become the basis properties of structural design. And these properties by age for hardened coal ash are important because of change by pozzolan reaction. This hardened coal ash is weak for tensile stress like that of concrete. And drying shrinkage is very important factor to make huge tensile force in early age. In the results, although some differences were shown when comparing coal ash with mortar or concrete, the application as a building material turned out to be possible if further researches were carried out. And the shrinkage characteristic of hardened coal-ash reveals to be similar to that of moderate heat cement.

• KOREAN JOURNAL OF CROP SCIENCE
• /
• v.35 no.3
• /
• pp.282-286
• /
• 1990

Currently, mechanization and automation have been introduced into rice harvest and drying process due to the shortage of man power. After rice cultivars, Chucheong and Milyang #23 were cutted with manual method (H1) or harvested with combine (H2), the threshed grain were dried in natural sun-drying (D1), in natural air in-bin system (D2), or in contineous hot-air drier (D3). We have evaluated grain losses, operation hour, and grain quality on each harvest and drying methods. Shattering loss during harvesting with combine was not dirfered significant from that of manual method, but threshing loss was 1.2% higher in combine harvest than in manual. Operation hours required for combine harvest was 3.5 times faster than for manual, even without head threshing. There was a significant difference bel ween cultivars in harvesting loss, which Milyang #23, a Tongil rice had two times more grain loss than Chucheong, a Japonica rice. Drying hours required to reduce to 14% grain moisture content were ten days for H1D1, 5-9 days for H2 D1, 2-3 days for H2D2, and only 15 hours for H2D3, respectively. In grain quality, complete grain ratio after dehulling was decreased about four percent in H2D3 compared to H1D1. while it was lower in Milyang #23 than in Chucheong, Hot-air drier increased occurence of cracked and broken grain. Combine harvest increased significantly these incomplete grain ratio of :Milyang #23, but not Chucheong.

• Journal of Applied Biological Chemistry
• /
• v.60 no.1
• /
• pp.73-78
• /
• 2017

This study provide activity for beauty food of water and 80 % ethanol extracts from Pinus koraiensis leaves. Total phenolic content of extracts from Pinus koraiensis leaves were each 12.22 mg/g (Drying under hot air) and 17.93 mg/g (Drying under shade), 14.36 mg/g (Lyophilization) in water extracts (WE) and 11.9 mg/g and 20.63 mg/g, 17.96 mg/g in 80 % ethanol extracts (EE). The 1,1-diphenyl-2-picrylhydrazyl free radical scavenging activity of extracts from Pinus koraiensis leaves was 96.20 % in EE from drying under shade at extracts concentration. The 2,2'-azino-bis(3-ethylbenzothiazoline-6-sulphonic acid) radical decolorization activity of extracts from drying under shade was 99.85 % in WE and 99.80 % in EE at extracts concentration. The antioxidant protection factor (PF) extracts from drying under shade type was 9.63 PF in WE and 10.48 PF in EE at extracts concentration. The thiobarbituric acid reactive substance from Pinus koraiensis leaf was 89.39 % in EE from drying under shade at extracts concentration. The elastase inhibition activity of EE for anti-wrinkle effect showed an excellent wrinkle improvement effect, showing 71.46 % in EE from lyophilization. Collagenase inhibition activity of EE from drying under shade was 97.48 % in extracts. Tyrosinase inhibition activity which was related to anti-melanogensis was observed. The tyrosinase inhibitory effect of extracts from lyophilization was confirmed to be 60.4 % in EE more than another drying methods at extracts concentration. Through out all results, it can be expected Pinus koraiensis leaves extracts to use as a functional material for anti-oxidant and functional beauty food.

• Polymer(Korea)
• /
• v.31 no.5
• /
• pp.447-453
• /
• 2007

In this study, we fabricated recrystallized PLGA (rPLGA) particles using the vacuum drying method. In order to investigate an applicability of the rPLGA particles for controlled release system of 5-fluorouracil (5-FU) loaded PLGA wafer, we prepared three different wafers using; 1) untreated PLGA (uPLGA), 2) rPLGA, and 3) uPLGA and rPLGA (4 : 1, 1 : 1 or 1 : 4). The rPLGA particles were characterized using NMR, IR and GPC to compare with uPLGA particles. The surface and cross section morphology of the prepared wafers were observed by the scanning electron microscope. The release profile of the 5-FU loaded wafer was measured by HPLC. The 5-FU/rPLGA wafer released the incorporated 5-FU in a sustained manner with low initial burst compared to 5-FU/uPLGA. These results showed that the ratio of pure PLGA/recrystallized PLGA can affect the release behaviors.

• Proceedings of the Korean Society for Agricultural Machinery Conference
• /
• 2003.02a
• /
• pp.360-365
• /
• 2003

미곡종합처리장은 개소 당 평균 30억이 투자되는 방대한 시설로 수확된 산물상태의 벼를 수집ㆍ건조ㆍ저장ㆍ가공 및 포장공정이 일괄적으로 처리되는 농업의 첨단기술이 결집된 시설이라 할 수 있다. 미곡처리장은 약 80개의 단위기계와 100여종의 부대시설로 구성되어 있다. 미곡종합처리장은 거의 모든 과정이 중앙제어기에 의해 제어 가능하다. 그러나 미곡종합 처리장의 상온통풍건조시설은 기상조건, 투입벼의 함수율 및 반입량에 따라서 송풍기와 히터의 운전방법을 달리해야 하며, 또한 투입벼의 함수율에 따라서 벼의 퇴적고를 달리해야 하는 등 시설의 운전에 세심한 주의가 필요하다. (중략)

• Proceedings of the Korean Society for Agricultural Machinery Conference
• /
• 2003.02a
• /
• pp.112-117
• /
• 2003

우리나라의 미곡종합처리장(Rice Processing Complex, RPC)은 1991년 시범사업으로 2개소가 설치된 이래 2002년 말 현재 328개소가 설치 운영되고 있다. 현재 RPC는 벼의 수확 후 처리공정을 일관화 한 시설일 뿐만 아니라 쌀 유통의 중심시설로 성장하였다. RPC의 건조시설은 대부분이 열풍건조와 상온통풍건조를 조합하여 사용할 수 있도록 설계되어 있다. 열풍건조에는 순환식건조기와 연속식건조기가 이용되고 있으며, 상온통풍건조에는 원형철제빈(사일로)이 주로 이용되고 있으며 일부 사각빈이 이용된다. 원형철제빈은 벼의 건조와 저장을 겸용하고 있다. (중략)

• Journal of the Korean Graphic Arts Communication Society
• /
• v.12 no.1
• /
• pp.145-157
• /
• 1994

Litho printing ink vehicles based on rosin modified phenolic are faster drying, have better durability, are harder and glosser and have greater resistance to water than ones based on ester gums. Ink-Water balance and rheological properties are important in litho printing process. These physical properties is concerned with molecular weight of Resin to use vehicle. So this paper was studied about the effects of changing molecular weight of Rosin modified phenolic on surface tension, viscosity, pseudoplasticity and printability of Litho Inks. The results were as follows. 1) The surface tension of model inks depended on the molecular \veight of the resin : Dispersion componnent of ink increase but non dispersion component decrease as molecular weight of Resin increase. 2) Water pick-up of litho ink is more fast balance, using low molecular weight of Resin. 3) Viscosity, Yield value and Newtonian value of model inks increase as molecular weight of Resin increase. 4) The litho ink prepared with the modified phenolic of which molecular weight is about 20000 showed the highest printing density and gloss.

• Journal of the Korean Graphic Arts Communication Society
• /
• v.7 no.1
• /
• pp.65-72
• /
• 1989

Modified phenolics can have a retarding effect on the gelation of wood oil. Modified phenolic resins can be used in media for paint, varnishes, primers, overprinting varnishes, litho, letterpress and rotogravure inks. Varnishes based on rosin phenolic are faster drying, have better durability, are harder and glosser, and have greater resistance to water than ones based on ester gums. These physical properties is concerned with molecular weight distribution of rosin modified phenol resin. This paper was studied about molecular weight distribution of rosin phenolics which were prepared between $130~250^{\circ}C$. The results were as follows: 1) Average molecular weights inereased with increasing reaction temperature. 2) $M_w/M_n$ were from 3.43 to 46.44 with increasing reaction temperature and so the molecular weight distributions were changed from random distribution to broad distribution. 3) The relation ship between intrinsic viscosity and weight average molecular weight was follows: $[{\;}{\;}]={\;}1{\times}{\;}10^{-6}M_w,{\;}M_w=M_w$ 4) Esterification reaction between the acid group of rosin and polyol was started about $230^{\circ}C$$.

• Journal of Biosystems Engineering
• /
• v.12 no.3
• /
• pp.50-56
• /
• 1987

중규모 벼농가에서의 벼건조 및 저장을 위하여, 한국형 개량곳간(크기: $1.8{\times}2.4m$, 높이 : 3.2m, 규모 : 2-4 M/T)을 개발하였다. 송풍기(0.5마력) 및 공기유도닥트를 부착하여 건조 및 aeration이 가능하도록 하였으며, 저장중 양곡손실을 최소한 줄이기 위해 방서용철망, 환풍창 및 구판들을 설치하였다. 그리고 양곡의 입출고가 용이하도록 내리닫이쪽문을 설치하였다. 개발된 개량곳간을 이용하여 1981년, 1982년, 1983년 가을에 각각 수확한 물벼를 수확즉시 건조하였을 때, 기후조건, 수확시기, 수확시의 수분함량, 풍량, 송풍시간, 곳간내에서의 벼의 높이 등에 따라서 차이는 있으나 상온 통풍에 의하여 벼를 잘 건조할 수 있었다. 그리고 건조조건에 따라서 건조양상은 달랐으나 180~352시간의 건조시간이 소요되었으며, 연속 상온통풍에 의하여 건조된 벼의 품질은 비교적 양호하였다.

• Proceedings of the Korean Institute of Building Construction Conference
• /
• 2006.05a
• /
• pp.77-80
• /
• 2006

This study investigated filling performance of concrete which can pass between reinforcing bars and be fully filled, and examined fundamental properties of concrete which is before or after hardened state, in response to maximum size of coarse aggregate. This study was also originally intended to find out one of the method that can improve concrete quality, using crushed coarse aggregate. Test showed that passing ratio of concrete decreased as aggregate site increased and as space between reinforcing bars decreased. In addition concrete using bigger size of coarse aggregate exhibited slightly higher compressive strength and showed lower length change ratio of drying shrinkage.