• Journal of Microbiology and Biotechnology
• /
• v.22 no.12
• /
• pp.1673-1680
• /
• 2012

In this study, DEAE-corncobs [delignified corncob grits derivatized with 2-(diethylamino)ethyl chloride hydrochloride ($DEAE{\cdot}HCl$)] were prepared as a carrier to immobilize yeast (Saccharomyces cerevisiae) for ethanol production. The immobilized yeast cell reactor produced ethanol under optimized $DEAE{\cdot}HCl$ derivatization and adsorption conditions between yeast cells and the DEAE-corncobs. When delignified corncob grit (3.0 g) was derivatized with 0.5M $DEAE{\cdot}HCl$, the yeast cell suspension ($OD_{600}$ = 3.0) was adsorbed at >90% of the initial cell $OD_{600}$. This amount of adsorbed yeast cells was estimated to be 5.36 mg-dry cells/g-DEAE corncobs. The $Q_{max}$ (the maximum cell adsorption by the carrier) of the DEAE-corncobs was estimated to be 25.1 (mg/g), based on a Languir model biosorption isotherm experiment. When we conducted a batch culture with medium recycling using the immobilized yeast cells, the yeast cells on DEAE-corncobs produced ethanol gradually, according to glucose consumption, without cells detaching from the DEAE-corncobs. We observed under electron microscopy that the yeast cells grew on the surface and in the holes of the DEAE-corncobs. In a future study, DEAE-corncobs and the immobilized yeast cell reactor system will contribute to bioethanol production from biomass hydrolysates.

• Asian-Australasian Journal of Animal Sciences
• /
• v.17 no.1
• /
• pp.86-93
• /
• 2004

Sixteen early lactating Nili-Ravi buffaloes, four animals in each group, were used in a Completely Randomized Design to evaluate the effect of varying levels of both ruminally protected fat and urea treated corncobs ensiled with or without corn steep liquor (CSL) on feed intake, digestibility and milk production and its composition. Four experimental diets were formulated. The control (C) diet was balanced to contain 0% fat and 35% urea treated corncobs ensiled with 0% CSL. The low fat (LF), medium fat (MF) and high fat (HF) diets had 45, 55 and 65% urea treated corncobs ensiled with 9% CSL and 2, 4 and 6% ruminally protected fat, respectively. Dry matter, crude protein (CP) and neutral detergent fiber (NDF) intakes by buffaloes remained similar across all treatments. However, DM and NDF as a percent of body weight and digestible DM intakes were higher in HF diet when compared to C, LF and MF diets. Digestible NDF intakes were also significantly higher in HF diet as compared to all other diets. The intakes of ADF and digestible ADF were higher in MF and HF than C and LF diets. The significant variation in digestible DM, ADF and NDF intakes may be attributed to the ammoniation of corncobs along with CSL that caused significant changes in the degradability and digestibility of the diets. Ether extract and digestible EE intakes differed significantly (p<0.05) among all treatments. Intakes of EE were the highest in animals fed HF diet, which was because of added fat. Apparent DM digestibility was the highest in animals C diet and was the lowest in those fed LF diet. Neutral detergent fiber and ADF digestibilities were higher in animals fed diets containing urea treated corncobs ensiled with 9% CSL when compared to those fed diets containing urea treated corncobs ensiled without CSL. Apparent digestibility of CP was noted highest (71.47%) in animals fed HF diet when compared to those fed MF (67.75%), LF (67.04%) and C (65.39%) diets. Milk yield (4% FCM) was the higher in buffaloes fed HF, MF and LF diets than those fed C diet. These results indicated that increasing levels both of fat and urea treated corncobs ensiled with CSL elevated the negative effects of poor quality fibrous feed on milk production by buffaloes.

• Asian-Australasian Journal of Animal Sciences
• /
• v.17 no.8
• /
• pp.1093-1097
• /
• 2004

This study was aimed to establish the amount of enzose (corn dextrose) for optimum N fixation in urea treated corncobs (UTC) and their dietary effect on nutrient intake, digestibility and milk yield in crossbred cows. Corncobs were treated with 5% urea and ensiled in laboratory silos with 0, 2, 4 and 6% enzose for 15 days. Total nitrogen (N), neutral detergent fiber (NDF) and neutral detergent insoluble N contents were increased in UTC with the level of enzose. Five early lactating crossbred cows (Sahiwal$\times$Holstein Frisian) were used in a 5$\times$5 Latin Square Design to see the influence of UTC ensiled with 6% enzose on nutrient intake, digestibility, milk yield and its composition. Five iso-nitrogenous and iso-caloric diets were formulated. The UTC30 (control), UTC40, UTC50, UTC60 and UTC70 diets contained 30% UTC ensiled without enzose and 40, 50, 60, 70% UTC ensiled with 6% enzose, respectively. Dry matter, NDF and ADF intakes were increased with the increasing level of UTC ensiled with enzose in the diets of cows. Dry matter, NDF and ADF digestibilities were significantly higher with diets containing UTC ensiled with enzose. Milk yield was significantly higher in cows fed UTC70 compared to those fed on other diets. The milk crude protein percentage was significantly different across treatments. However, milk fat, total solids, solid not fat, true protein and non-protein nitrogen contents of milk remained similar across all diets. Ensilation of UTC with 6% enzose improved the nitrogen retention and thus enhanced the feeding value of UTC for lactating cows.

• Mycobiology
• /
• v.46 no.1
• /
• pp.24-32
• /
• 2018

Improper disposal of herb residues in China has caused severe problems to the surrounding environment and human safety. Three herb residues, i.e., compound Kushen injection residues (CKI) and part one and part two of Qizhitongluo Capsule residues (QC1 and QC2, respectively), were used for the cultivation of Pleurotus ostreatus. The effect of the supplementation of corncobs (CC) with different herb residues on yield, nutritional composition, and antioxidant activity of P. ostreatus was investigated. Compared to the control, the higher mycelial growth rate was observed on substrates CC +30% CKI and CC +30% QC1, while the higher yield was obtained from substrates CC +30% QC2 and CC +30% CKI. Moreover, chemical analysis of fruit bodies revealed that the addition of herb residues to CC significantly increased proteins, amino acids, ashes, minerals (Na and Ca), and total phenolic contents but significantly reduced carbohydrates and $IC_{50}$ values of DPPH radicals. In addition, no heavy metals (Pb, Cd, and As) were detected in the fruiting bodies harvested from different substrate combinations. These results demonstrated that mixtures of CC with herb residues might be utilized as a novel, practical, and easily available substrate for the cultivation of P. ostreatus, which is beneficial for the effective management of herb residues.

• Asian-Australasian Journal of Animal Sciences
• /
• v.19 no.5
• /
• pp.705-712
• /
• 2006

Influences of urea treated corncobs (UTC) ensiled with or without different additives on ruminal characteristics, in situ digestion kinetics, nutrient digestibility and nitrogen metabolism were examined in a $5{\times}5$ Latin square design using five ruminally cannulated buffalo bulls. Five iso-caloric and iso-nitrogenous diets were formulated to contain 30% dry matter (DM) from concentrate and 70% DM from 5% UTC ensiled without any additive (U) or with 5% enzose (EN), 5% acidified molasses (AM), 5% non-acidified molasses (NM) and 5% acidified water (AW), respectively. These diets were fed to buffalo bulls at 1.5% of their body weight daily. Ruminal $NH_3$-N concentration at 3 hours (h) post feeding was significantly higher in bulls fed U, NM and AW diets, however, at 6, 9 and 12 h post feeding it was significantly higher in bulls fed EN and AM diets. Ruminal total volatile fatty acids (VFA) and acetate concentrations were significantly higher with EM and AM diets compared with other diets at 3, 6, 9 and 12 h post feeding. Ruminal pH at 6 and 9 h post feeding was higher with EN and AM diets; however; it was notably lower with these diets at 3 h post feeding. Total ruminal bacterial and cellulolytic bacterial counts were higher in bulls fed EN and AM diets than in those fed the other diets. In situ ruminal DM and NDF degradabilities and total tract digestibilities were significantly higher with UTC ensiled with enzose and acidified molasses than those ensiled without any additive or other additives. Nitrogen balance was significantly higher in bulls fed EN and AM diets than those fed U, AW and NM diets. The UTC ensiled with enzose or acidified molasses resulted in better digestibility and N utilization than those ensiled without any additive, with non-acidified molasses and acidified water in buffaloes.

• Environmental Engineering Research
• /
• v.24 no.1
• /
• pp.99-106
• /
• 2019

Using the abandoned agricultural by-product corncobs, the most commonly used methylene blue (MB) dyestuffs were removed. This experiment is very meaningful because it is the recycling of resources and the use of environmentally friendly adsorbents. According to the Hauser ratio and porosity analysis, the corncob has a good flow ability of the adsorbent material and many pores, which is very advantageous for MB adsorption. As a result of the experiment, MB concentration of less than 0.005 g/L was very efficiently removed with 10 g/L of bioadsorbent corncob and the maximum adsorption capacity of corncob for MB dyes was obtained at 417.1 mg/g. In addition, adsorption process of MB onto corncob was a physical process according to adsorption energy analysis. Corncob can efficiently and environmentally remove MB in aqueous solution, and is very cost effective and can recycle the abandoned resources.

• Journal of Biosystems Engineering
• /
• v.43 no.1
• /
• pp.59-71
• /
• 2018

Purpose: Cellulose nanocrystals (CNCs) are natural polymers that have been promoted as a next generation of new, sustainable materials. CNCs are invaluable as reinforcing materials for composites because they can impart improved mechanical, chemical, and thermal properties and they are biodegradable. The purpose of this review is to provide researchers with information that can assist in the application of CNCs extracted from waste agricultural byproducts (e.g. rice husks, corncobs, pineapple leaves). Methods & Results: This paper presents the unique characteristics of CNCs based on agricultural byproducts, and lists processing methods for manufacturing CNCs from agricultural byproducts. Various mechanical treatments (microfluidization and homogenization) and chemical treatments (alkali treatment, bleaching and hydrolysis) can be performed in order to generate nanocellulose. CNC-based composite properties and various applications are also discussed. Conclusions: CNC-based composites from agricultural byproducts can be combined to meet end-use applications such as sensors, batteries, films, food packaging, and 3D printing by utilizing their properties. The review discusses applications in food engineering, biological engineering, and cellulose-based hydrogels.

• Journal of Mushroom
• /
• v.10 no.4
• /
• pp.236-243
• /
• 2012

Spent mushroom substrates is composted organic material remaining after a crop of mushroom is harvested. The raw materials of mushroom substrates are same feed ingredient as corncobs, rice brown, wheat brown, cotton seeds and beet pulp. During the mushroom cultivation process, the mushroom substrates was used 15-25% by mushroom and 75-85% of mushroom substrates was remained in the SMS. Among of the spent mushroom substrates, spent mushroom substrates of pleurotus eryngii, Pleurotus ostreatus and Flammuliua velutipes is can be use the energy feedstock of animal feed. The cellulose content of spent mushroom(pleurotus eryngii) substrates containing the sawdust was high and total digestible nutrients (TDN) values was low. The spent mushroom(pleurotus eryngii) substrates fermented with cellulase and xylanase producing bacteria is may be used as an ingredient of feed in TMR for Hanwoo steer.

• Journal of Animal Science and Technology
• /
• v.58 no.8
• /
• pp.30.1-30.12
• /
• 2016

Background: The effect of choline chloride supplementation through forced drinking combined with concentrate diets containing Ca-fish oil on milk production and milk composition of Etawah Grade goats was evaluated. Choline chloride is an essential component in ruminant diets as it is required for fat metabolism. Method: The experiment was conducted in a completely randomized block design with three types of treatments and eight replications. The trial had two successive experimental periods; the first, during the eight weeks of late pregnancy, and the second, during the first 12 weeks of lactation. Twenty-four Etawah Grade does in the second gestation period were divided into three treatment groups. Commercial choline chloride 60 % in corncobs-based powder was used as a source of choline chloride. The treatments were no supplementation (control) and supplemented with either 4 g or 8 g/2days of choline chloride. Choline chloride was given to the animals through a forced drinking technique, after dissolving it in 60 ml drinking water. The initial body weight of does was $38.81{\pm}3.66kg$. The does were penned individually, and were given fresh chopped King Grass ad libitum and 700 g/day of concentrate diets containing Ca-fish oil, starting eight weeks prior to expecting kidding and continuing for 12 weeks of parturition. Results: All nutrient intakes were not significantly different (p > 0.05) among the treatments during the late pregnancy and the lactation periods. Supplementation did not affect (p > 0.05) the average daily gains and feed conversion ratio during pregnancy but gave effects (p < 0.05) on the average daily gains, feed conversion ratio and income over feed cost during lactation. The highest average daily milk yields and 4 % fat corrected milk yields were found in goats supplemented with 4 g/2days of choline chloride and increased by 17.00 % and 24.67 %, respectively, compared to the control. Moreover, milk composition percentage and milk constituent yields improved significantly (p < 0.05) in those supplemented with 4 g/2days of choline chloride. Conclusion: The supplementation of 4 g/2days of choline chloride through forced drinking increased milk yields, the 4 % fat corrected milk yields, milk composition, milk constituent yields, and improved feed conversion ratio and income over feed cost of Etawah Grade goats.

• Journal of Mushroom
• /
• v.16 no.1
• /
• pp.1-8
• /
• 2018

For the bottle cultivation of pleurotus nebrodensis, poplar tree sawdust was a better substrate than corncobs in terms of primordia and growth characteristics. The nutrition rich substrate was cottonseed dregs, cottonseed coat, bran, corn powder, and rice bran. The mixing ratio was adjusted such that the nitrogen content was ${\leq}58%$; cotton seed dregs, at the level of 20%, were particularly necessary to adjust the nitrogen content for the substrates that had high total nitrogen content. Additionally, inclusion of calcium carbonate in the substrate was better for primordia and growth characteristics than inclusion of calcium hydroxide. In the absence of calcium carbonate, the elasticity of pileus and stipe decreased and their hardness increased. Therefore, the optimum substrate composition for the cultivation of Pleurotus nebrodensis was 40:20:20:15:3:2 mixing ratio of poplar tree sawdust, cottonseed dregs, cottonseed coat, bran, corn powder, and calcium carbonate.