• Journal of Biosystems Engineering
• /
• v.1 no.1
• /
• pp.17-48
• /
• 1976

In analyzing the operational characteristics of a rice whitening machine, the internal radial pressure of the machine was measured using strain gage equipment. Changes in cylinder and feed screw configurations, screen type, cylinder speed and counter-pressure levels were examined to determine their impact on the quality and quantity of milled rice and the performance of the machine. The results are summarized as follows: 1. The internal radial pressure in the whitening chamber varied with the surface condition of the grain being processed. During the first or second pass through the machine, pressure was relatively low, reached a maximum after two to three passes with combinations I and II, three to six with combination III and then began to fall. 2. The pitch of the feed screw and the size of the feed gate opening which determine the rate of entry of grain into the whitening chamber, appeared to be the most important factor aff-::cting the degree of radial pressure, quality and quantity of milled rice and the efficiency of the machine. Using a feed screw with a wide pitch (4.8cm), radial pressure was relatively high and head rice recovery ratio \vere quite low. In this case capacity and machine effic\ulcorneriency were much higher than obtained when using a feed screw with a narrow pitch (2.3cm). Very significant responses in radial pressure, head rice recovery rates and machine capacity were observed with changes in cylinder speed and counter-pressure levels when using the wide pitch feed screw. 3. The characteristics of the screen which surrounds the whitening chamber had an important effect on whitening efficiency. The existence of small protuberances on the original screen resulted in significant increases in both machine capacity and efficiency but without a significant decrease in head rice recovery or development of excessive radial pressure. Further work is required to determine the effects of screen surface conditions and the shape of the cylinderical steel roller on the rate of bran removal, machine efficiency and recovery rates. The size of the slotted perforations 0:1 the screen affects total milled rice recovery. The opening size on the original screen was fabricated to accommodate the round shape of Japonica rice varieties but was not suitable for the more slender Indica type. Milling Indica varieties with this screen resulted in a reduction in total milled rice recovery. 4. An increase in cylinder speed from 380 to 820 rpm produced a positive effect on head rice recovery for all machine combinations at every level of counter-pressure used in the tests. Head rice recovery was considerably lower at 380rpm using a wide screw pitch when compared to the results obtained at speeds from 600 to 820 r.p.m. The effects of cylinder speed On radial pressure, capacity and machine efficiency showed contrasting results, depending on the width of the feed screw pitch. With a narrow feed screw pitch (2.3cm), a direct proportional relationship was observed bet\ulcornerween cylinder speed and both radial pressure and machine efficiency. In contrast, using a 4.8 centimeter pitch feed roller produced a series of inverse relationships between the above variables. Based on the results of this study it is recommended when milling Indica type long grain rice varieties that the cylinder speed of the original machine be increased from 500-600 rmp up to a minimum of 800 rpm to obtain a greater abrasive effect between the grain and the screen. The pitch of the feed screw should be also reduced to decr\ulcornerease the level of internal radial pressure and to obtain higher machine efficiency and increased quality of milled rice with increased cylinder speeds. Further study on the interaction between cylinder speed and feed screw pitch is recommended. 5. An increase in the counter pressure level produced a negative effect On the head rice recovery with an increase in radial pressure, capacity, and machine efficiency over all combinations and at every level of cylinder speed. 6. Head rice recovery rates were conditioned primarily by the pressure inside the whitening chamber. According to the empirical cha racteristics curve developed in this study, the relationships of head rice recovery ($Y_h$) and machine capacity ($Y_c$/TEX>) to internal radial pressure ($X_p$) followed an inverse quadratic function and a linear function respectively: $$Y_h^\Delta=\frac{1}{{1.4383-0.2951X_p^\ast+0.1425X_p^{\ast\ast}}^2} , (R^2=0.98)$$ $$Y_c^\Delta=-305.83+374.37X_p^{\ast\ast}, (R^2=0.88)$$ The correlation between capacity and power consumption per unit of brown rice expressed in the following exponential function: $$Y_c^\Delta=1.63Y_c^{-0.7786^\{\ast\ast}, (R^2=0.94)$$ These relationships indicate that when radial pressure increases above a certain range (1. 6 to 2.0 kg/$cm^2$ based On the results of the experiment) head ricerecovery decrea\ulcornerses in a quadratic relation with a inear increase in capacity but without any decrease in power consump tion per unit of brown rice. On the other hand, if radial pressure is below the range shown above, power consumption increases dramatically with a lin\ulcornerear decrease in capacity but without significant increases in head rice recovery. During the operation of a given whitening machine, the optimum radial pressure range or the correct capacity range should be selected by controlling the feed rate and/or counter-pressure keeping in mind the condition of the grain, particulary the hardness. It was observed that the total number of passes is related to radial pessure level, feed rate and counter-pressure level. The higher theradial pressure the fewer num\ulcornerber of pass required but with decreased head rice recovery. In particular, when using high feed rates, the total number of passes should be increased to more than three by reducing the counter-pressure level to avoid decreaseases in head rice recovery (less than 65 percent head rice recovery on the basis of brown rice) at every cylinder speed. 7. A rapid rise in grain temperature seemed to have a close relationship with the pressure generated inside the whitening chamber and, subsequently with head rice reco\ulcornervery rates. The higher the rate of increase, the lower were the resulting head rice recoveries.

• Korean Journal of Organic Agriculture
• /
• v.21 no.4
• /
• pp.629-646
• /
• 2013

This study was conducted to investigate effects of terpenoids-rich plant extracts (TRPE) on the in vitro ruminal fermentation characteristics and methane production. The ruminal fluid was collected from a cannulated Hanwoo cow fed concentrate and timothy in the ratio of 6 to 4. The TRPE as Mint (Mentha arvensis var. piperascens), Pine (Pinus densiflora), Japan cedar (Cryptomeria japonica), Sichuan pepper (Zanthoxylum piperitum), Hinoki cypress (Chamaecyparis obtuse) and Japanese black pine (Pinus thunbergii) were used in this study. The 15 mL of mixture, contains McDougall buffer and rumen fluid in the ratio of 2 to 1. The mixture was dispensed anaerobically 50 mL serum bottles and it is contained 0.3 g timothy substrate and 5% TRPE. The bottles were incubated at $39^{\circ}C$ for 3, 6, 9, 12, 24, 48 and 72 hours. The pH value decrease by increased incubation times and the pH values at all times were significantly (p<0.05) higher in treatments than in control. The digestibility of dry matter at 3 hours was significantly (p<0.05) higher in mint treatment than in control. Productions of total gas and carbon dioxide at before 12 hours was significantly lower (p<0.05) in treatments than in control. The methane production at 24 hours was significantly (p<0.05) lower in treatments than in control. The concentrations of acetic acid and propionic acid at 24 hours were significantly higher (p<0.05) in mint and pine treatments than in control. In conclusion, the terpenoid-rich plant extracts were shown to decreased methane emission and without adversely affected ruminal fermentation. Therefore, the terpenoid-rich plant extracts as mint and pine were shown to decreased methane production and it has potential possibility for ruminal fermentations.

• Microbiology and Biotechnology Letters
• /
• v.36 no.3
• /
• pp.201-208
• /
• 2008

To produce bioactivity-strengthen medicinal herbs, the 36 medicinal herbs which have antioxidation or blood circulation activity, were solid fermented using Phellinus baumii mycelium. Most of medicinal herbs, except Chrysanthemum indicum (flower), Zizyphus jujuba Miller (fructus), Aconitum koreanum R. Raymond (root), Magnolia denu-data (flower), and Polygonatum sibiricum Redt (root bark), showed good fermentation at $25^{\circ}C$ for 20 days under 90% of relative humidity. The poor fermentations of the herbs could be explained by lack of nutrient, structural rigidity, and the content of antifungal substance. After fermentation, the average water content of herbs were increased to $67.21{\pm}11.43%$ from $30.84{\pm}15.67%$, but the average pH and average methanol extraction ratio were slightly decreased to $11.16{\pm}7.06%$ and $4.83{\pm}0.73$ from $13.91{\pm}12.22%$ and $5.06{\pm}0.87$, respectively. The analysis of thrombin inhibition and DPPH scavenging activity of the methanol extracts of herbs showed that thrombin inhibition activities of the fermented Drynaria fortunei Kunze, Melia azedarach var. japonica, Prunus persica and Orostachys japonicus, and DPPH scavenging activities of the fermented Polygala tenuifolia, Scrophularia buergeriana, Angelica dahurica, Drynariafortunei Kunze, Cyperus rotundus, and Boschniakia rossica were increased as compared with those activities of non-fermented its cognate herbs. Our results suggest that the production of bioactivity-strengthen medicinal herbs is possible by solid fermentation of Phellinus baumii mycelium, as fermented Drynaria fortunei Kunze showed increased antioxidant and thrombin inhibitory activities than those of non-fermented herbs.

• The Korean Journal of Malacology
• /
• v.28 no.3
• /
• pp.197-213
• /
• 2012

This study was performed to know the community structure of macrobenthos and environmental factors at each 16 stations in the subtidal sandy bottoms of the southern coastal water of Jeju Island from July to November, 2011. Mean temperature and mean salinity were $20.2-22.7^{\circ}C$, 33.7-34.9 psu which shows stable water messes. Chlorophyll a concentrations of phytoplankton ranged from 0.71 to 1.71 mg/L (1.11 mg/L), showing higher July than September and November with a blooming in summer. The mean concentration values (the ranges in parentheses) of nitrate, phosphate, and silicate are 0.029-0.206 mg/L (0.101 mg/L), 0.001-0.027 mg/L (0.007 mg/L), 0.024-0.682 mg/L (0.454 mg/L), respectively. However, the values higher coastal zone due to influxes from the land. A total of 37 species was identified. of these mollusca comprised 29 secies (78.4%); Echinodermata 5 (13.5%); Arthropoda 3 (8.1%). density and biomass were estimated to be 550 ind./$m^2$ and 20,951.8 gwwt/$m^2$, respectively. Mollusca were the most dominant faunal group in terms of abundance (481 ind./$m^2$) and number of species as well, whereas bivalves were predominant in biomass (16,647.6 gwwt/$m^2$). The dominant species were Vasticardium burchardi, Oblimopa japonica, Mactar achatina, Bornatemishistrioiw akawai, Paphia vernicosa, Amusium japonicum, Glycymeris albolineata, Astriclypeus manni in 15-30 m. The seasonal variation appeared as distinct, Mollusca of individual and biomass. When summer was make a slow increase, after the highest decrease in autumn. The abundance of macrobenthic invertebrates showed significant correlation with environmental factors (Chlorophyll a, DIN, $SiO_2$, Fine sand, Very fine sand) in almost all sampling depths. The biodiversity, evenness richness index were appeared 1.56-2.50 (H'), 0.49-0.80 (E'), 4.12-4.67 (R) in each stations. The dominace index were appeared Highest in November and lowest in September.

• Korean Journal of Ichthyology
• /
• v.28 no.2
• /
• pp.125-133
• /
• 2016

Sharks (Selachii) comprising about 510 valid species worldwide. Forty-three shark species belonging to 30 genera, 19 families and 8 orders have been found in Korean coastal waters, and all these are registered at the IUCN Red List as followings: endangered (EN) 1 species (2.3%) (vs. worldwide 15 spp., 3.2%), vulnerable (VU) 11 spp. (25.6%) (vs. 48 spp., 10.3%), near threatened (NT) 10 spp. (23.3%) (vs. 67 spp., 14.4%), least concern (LC) 9 spp. (20.9%) (vs. 115 spp., 24.7%), data deficient (DD) 12 spp. (27.9%) (vs. 209 spp., 44.9%), and critically endangered (CR) absent (vs. 11 spp., 2.4%). Twelve species among 43 sharks distributing in Korean waters are assessed as Threatened in the IUCN Red List categories and criteria as followings: Sphyrna lewini (EN, A2bd+4bd), Rhincodon typus (VU, A2bd+3d), Cetorhinus maximus (VU, A2ad+3d), Carcharodon carcharias (VU, A2cd+3cd), Isurus oxyrinchus (VU, A2abd+3bd+4abd), Alopias pelagicus (VU, A2d+4d), A. vulpinus (VU, A2bd+3bd+4bd), Carcharhinus plumbeus (VU, A2bd+4bd), S. zygaena (VU, A2bd+3bd+4bd), Squalus suckleyi (VU, A2bd+3bd+4bd), Squatina japonica (VU, A2d+4d), and S. nebulosa (VU, A2d+4d). Eighteen chondrichthyan species are registered in the list of the CITES Appendices, among them five sharks are distributing in Korean waters as Appendix II, i.e., R. typus, C. maximus, C. carcharias, S. lewini and S. zygaena. The scientific name of "Gobsangeo" has been changed from Squalus acanthias of the North Pacific to S. suckleyi, and "Mojorisangeo" from S. megalops of the Northwest Pacific to brevirostris.

• Applied Biological Chemistry
• /
• v.32 no.2
• /
• pp.104-108
• /
• 1989

A 2.5 ton scale of solar energy concentration blast-grain circulation dryer (SECD) was developed in order to shorten the drying time without damaged paddy. Comparative experiments were carried out on performance, drying efficiency, consistency in moisture content, milling recovery, grade of milled rice, and energy requirement and cost against all that of in-bin drying and storage (IBDS) method. The experiments were performed using mixture of several rice varieties of Tongil type(Japonica-Indica breeding type) under the autumn weather in Korea. The circulating air temperature inside SECD was $4{\sim}5^{\circ}C$ higher than that of IBDS. The moisture content of the paddy during the drying period in SECD was uniform while substantially varied in upper, middle or bottom layer in IBDS. By SECD, 24% initial moisture content of paddy was reduced to 15% after only 3 days of drying as compared to 14 days at IBDS. The percentage of cracked kernels in upper, middle and bottom layers in IBDS was 6, 6 and 12%, respectively, whereas 7% in all layers in SECD. Both types of dryers did not significantly affect the milling recovery of dried paddy and grade of milled rice. Energy requirement of SECD(28.8Kw/2.5ton) for paddy drying was much less than that of IBDS(108Kw/2.5ton).

• Korean Journal of Food Science and Technology
• /
• v.26 no.2
• /
• pp.188-194
• /
• 1994

The inhibitory effects of rice extract on mutagenicity induced by 3-amino-1,4-dimethyl-5H-pyrido [4,3-b]indole(Trp-P-1), 3-amino-1-methyl-5H-pyrido [4,3-b]indole(Trp-P-2), sodium azide(SA), 2-nitrofluorene(2NF), mitomycin C(MMC), aflatoxin $B_1(AFB_1)$ and 4-nitroquinoline oxide(4-NQO) were investigated using Salmonella typhimurium reversion assay, SOS chromotest and spore rec-assay. In Salmonella typhimurium reversion assay, methanol extract from brown rice (Illpumbyeo, Japonica variety) showed the highest inhibitory effect among other extracting solvent including hexane, chloroform and water. Methanol extract showed stronger inhibitory effect, above 85%, on indirect-acting mutagens(Trp-P-1, Trp-P-2 and $AFB_1$) than those on direct-acting mutagens(4-NQO, 2NF). In SOS chromotest, methanol extracts showed $77.6{\sim}88.9%$ effects on SOS function induced by Trp-P-1, Trp-P-2, $AFB_1$ and 4-NQO. In spore rec-assay, methanol extracts inhibited the mutagenicity induced by $AFB_1$ and MMC. As the concentration of methanol extract increased, inhibitory effect on mutagenicity increased but reached at steady state as inhibition rate of 90% when the concentration was above 5 mg/plate. In inhibitory effects of methanol extracts by various rice varieties, all of 11 varieties turned out to have inhibitory effect on mutagenicity. There was no significant difference (p>0.05) in inhibitory effect of methanol extracts between brown and white rice against Trp-P-1, but showed difference (p<0.05) against 4-NQO.

• Journal of Korean Society of Forest Science
• /
• v.44 no.1
• /
• pp.26-35
• /
• 1979

Factors affecting the survival of out planted Cryptomena and Japaneses Cypress seedlings. (I) - Especially on the drying and water soaking duration ­ There are often the cases of poor survival percentage for the economic forest establishments of Cryplomeria japonica D. Don. and Chamaecyparis obtusa End. This study was carried out to investigate the survival factors of both 1-1 seedlings and Cryptomena cutting Seedlings by room drying conditions, day drying conditions, OED green water soaking treatment and drying duration at the forest nursery of Chonnam National University from February to September. 1979. The results are as follows: 1. From 11 a.m. to 3 p.m. fluctuation in then moisture contents(MC) rapidly decreased and M.C. fluctuation in indoor until 5 p.m. showed the same results with the amount of an hour fluctuation in outdoor. 2. M.C. fluctuations between OED green and non-treatment of these seedlings were silghtly different. 3. The survival percentage of OED green and non-treatment of seedlings were highly significant in the room drying conditions and the day drying conditions respectively The effects of water soaking treatment on rooting was negligible. The survival percentage of seedlings of OED green was higher than that of non-treatment. 4. Although survival percentage of Japanese Cypress was almost in accord with Cryptomena, the power of resistance to drying was lower m Japanese Cypress than m Cryptomeria. 5. Compared with Cryptomena seedlings the survival percentage of Cryptomeria cutting seedlings was higher and not influenced at all in case of being drying for two hours; but it was highly significant in interactions between the drying time and the water soaking time. 6. When Cryptomena and Japanese Cypress seedling become drying in indoor for four days, the survival percentage remarkably reduced after two days and also was highly significant among numbers of drying days.

• Korean journal of applied entomology
• /
• v.59 no.2
• /
• pp.153-163
• /
• 2020

This study was conducted to evaluate the fitness of Tetranychus kanzawai Kishida on different host plants: young and old leaves of the mandarin orange 'shiranuhi' ((Citrus unshiu × C. sinensis) × C. reticulata), Japanese violet (Viola japonica Langsd.) and kidney bean (Phaseolus vulgaris L.). The development and oviposition experiments were conducted at constant temperatures (20, 25 and 30℃) and a life table parameters were estimated. T. kanzawai could complete it's development on 'shiranuhi' young leaves, japanese violet and kidney bean, while all died during the immature period on 'shiranuhi' old leaves. The total developmental period of T. kanzawai feeding on 'shiranuhi' young leaves was 17.4, 13.4 and 10.2 days at each temperature, respectively, which was longer than 16.1, 9.5 and 7.0 days of kidney bean. The female longevity of T. kanzawai on young leaves of 'shiranuhi' were 19.1, 15.0 and 12.3 days at each temperature, respectively, and there was no significant difference from 22.1, 14.1 and 10.9 days investigated from kidney bean. The fecundity was 18.1, 23.9 and 17.8 eggs per female, which was less than them of japanese violet and kidney bean at each temperature, respectively. As a result of estimating the life table parameters based on the experimental data, intrinsic rate of increase (r_m) were significantly different from each other, and appeared in the following order: kidney (0.1542, 0.2563 and 0.3251), japanese violet (0.1087, 0.2007 and 0.2673) and 'shiranuhi' young leaves (0.0868, 0.1002 and 0.1217) at each temperature, respectively. Finally, the management strategy against T. kanzawai in citrus orchards was discussed based on the results.

• Korean Journal of Environment and Ecology
• /
• v.32 no.1
• /
• pp.105-117
• /
• 2018

This study conducted health assessment and multivariate vegetation analysis using the riparian vegetation index in 30 sites of the Geumgang mainstream and Mihocheon to obtain practical data on the river management of the Geumgang. The result showed that the number of plant communities was 54. The flora was 75 families, 185 genera, 243 species, 2 subspecies, 21 varieties, 2 varieties, and 268 taxa. The riparian vegetation index was 38.3 (3.3; G-D1 ~ 66.7; G-U2, G-U4, and G-M3), and the health of the rivers in this area was evaluated as normal (grade C). The health of rivers was the highest in the upper stream of Geumgang mainstream and lowest in the downstream of Geumgang mainstream. The relationship between riparian vegetation index and chlorophyll-a content was low. The riparian vegetation was divided into five groups of Digitaria ciliaris colony group, Salix gracilistyla colony group, Erigeron annuus colony group, the group dominated by Humulus japonicus, Salix koreensis, Miscanthus sacchariflorus, and Phragmites japonica colonies, and the group dominated by Conyza canadensis and Echinochloa crusgalli var. echinata colonies. They had the similar health conditions. The CCA analysis showed that the environmental factors affecting the distribution of vegetation were physical factors such as vegetation area, artificial structure area, waterway area, branch width, channel width, and bank height and the biological factors such as the number of species. As such, it is necessary to maintain the health condition through continuous monitoring where the health condition is high and to apply active measures such as ecological restoration where the health condition is low.