• 한국환경과학회지
• /
• 제20권10호
• /
• pp.1233-1241
• /
• 2011

The main objective of this experimental investigation was $CH_4$ recovery from biogas generated in municipal and wastewater treatment plant. The polysulfone hollow fiber membrane was prepared in order to investigate the permeation properties of $CH_4$ and $CO_2$. Permeability of $CO_2$ in Polysulfone membrane was 11-fold higher than of $CH_4$ gas. A membrane pilot plant for upgrading biogas was constructed and operated at a municipal wastewater treatment plant. The raw biogas contained 66 ~ 68 Vol % $CH_4$, the balance being mainly $CO_2$. The effect of the operating pressure of feed and permeate side and feed flowrate on $CH_4$ recovery concentration and efficiency were investigated with double stage membrane pilot plant. The $CH_4$ concentration in the retentate stream was raised in these tests to 93 Vol % $CH_4$.

• Membrane and Water Treatment
• /
• 제4권3호
• /
• pp.191-202
• /
• 2013

The application of ultrafiltration operation to the dialysis in countercurrently parallel-flow rectangular membrane modules was investigated. The assumption of uniform ultrafiltration flux was made for operation with slight concentration polarization and declination of transmembrane pressure. Considerable improvement in mass transfer is achievable if the operation of ultrafiltration is applied, especially for the system with low mass transfer coefficient. The enhancement in separation efficiency is significantly increased with increasing ultrafiltration flux, as well as with increasing the volumetric flow rates. Furthermore, increasing the volumetric flow rate in retentate phase is more beneficial to mass transfer than increasing in dialysate phase.

• Membrane and Water Treatment
• /
• 제4권4호
• /
• pp.251-263
• /
• 2013

The internal reflux effect on dialysis through the retentate phase of a countercurrently cross-flow rectangular module is investigated. Theoretical analysis of mass transfer in cross-flow devices with or without recycling is analogous to heat transfer in cross-flow heat exchangers. In contrast to a device without reflux, considerable mass transfer is achievable if cross-flow dialyzers are operated with reflux, which provides an increase in fluid velocity, resulting in a reduction in mass-transfer resistance. It is concluded that reflux can enhance mass transfer, especially for large flow rate and feed-concentration operated under high reflux ratio.

• 한국식품과학회지
• /
• 제35권1호
• /
• pp.72-76
• /
• 2003

회분처리법으로 박층류식 평막 test cell에 의한 재래간장의 한외시험을 실시한 결과 공급액 주입속도별 투과유속의 감소는 용량감소율의 대수값에 비례하여 감소하였고 본 연구에서 사용한 분획분자량 200,000 dalton의 막에 의한 재래간장의 한외여과에서는 1.5L/min의 유속으로 공급액을 주입하는 것이 농도분극화현상을 최소화하면서 장시간 작업할 수 있음을 알 수 있었다. 간장의 한외여과시험에서 간장내의 총질소와 소금성분은 투과유속이 빠를수록 막에 의한 저지율이 더 높아졌고 따라서 500 nm에서의 간장의 흡광도는 더 낮아졌으며 Cu, Mn 및 Mg와 같은 무기성분도 다소 저지되었다. 미생물 균체는 공급간장의 유속에 상관없이 분획분자량 200,000 dalton의 한외여과막으로 100% 저지되었으나 유리아미노산은 거의 저지되지 않아 투과됨을 알 수 있었다.

• 한국환경과학회지
• /
• 제14권3호
• /
• pp.335-343
• /
• 2005

The objective of this research is to evaluate a feasibility of wastewater reuse by membrane treatment with vibrating membrane separation equipment. Molecular weight of compounds in wastewater, permeability of membrane and retentate characterization after membrane filtration were investigated in order to determine appropriate membrane pore size and materials for wastewater treatment. Selected membrane was evaluated with vibration membrane separation equipment to optimize operating conditions. The following conclusion are drawn. 1. We got as following test results after the distribution of particles in the semiconductor wastewater, are made up of $1\~20{\mu}m$. Si, gold and Al in turn are contained in semiconductor wastewater. 2. Recovery rate is changeless under increasing recovery rate in operation. Though a value can be if pressure can be changed, the highest value of permeate rate is presented in 150 psi. 3. The AS-100(polysulpone) was selected as the most appropriate membranes for the treatment of semi-conductor wastewater to VSEP system. The fouling almost did not occur during this experiments. The analyses of treated water with VSEP system showed conductivity: 0.059,us/cm, TDS: 40mg/l, COD: 20mg/l, SS : 5mg/l, n-Hexane: 8.3mg/l. Comparing previous systems, operating expenses is decreased by more $50\%$.

• Preventive Nutrition and Food Science
• /
• 제11권2호
• /
• pp.155-159
• /
• 2006

Models capable of predicting the product quality of mixed apple and carrot retentates (MACR) have been developed using response surface methodology and used to characterize the effects of processing conditions including average transmembrane pressure (ATP), temperature, and blend ratio. Color, soluble solids, total sugar, vitamin C, acidity, turbidity, and viscosity were used to assess the product quality following the ultrafiltration (UF) process. $L^*-value$ decreased with increased ATP, but the value was not affected by changes in temperature. Blend ratio also greatly influenced the $L^*-value$. Redness ($a^*-value$), on the other hand, was less affected by temperature and ATP. As the ATP and temperature increased, yellowness increased gradually. Soluble solids contents appeared to decrease gradually as the ATP increased for all blend samples, but the effect of temperature seemed to be less. Total sugar content was more affected by temperature than ATP. In general, samples containing 75% carrot had higher amounts of vitamin C regardless of processing conditions. Changes in acidity were also complex and appeared to respond to interactions among ATP, temperature, and blend ratio. Turbidity increased for all samples as both ATP and temperature increased. The higher the amount of carrot in the blend samples, the higher values for turbidity. Although the changes were small, viscosity appeared to increase as the ATP and temperature increased during UF.

• 한국식품저장유통학회지
• /
• 제8권4호
• /
• pp.442-448
• /
• 2001

제주산 온주 밀감 주스의 제품화 기술개발에 필요한 기초자료를 얻기 위하여 공극의 크기가 서로 다른 네종류의 한외여과 막을 사용하여 잔류액과 투과액의 성분 변화를 조사하였다. 공극의 크기에 따른 감소율은 총산, citric acid, ascorbic acid 유리당, neohesperidin은 10K에서 100K daltons 사이에서는 막의 공극 크기가 커짐에 따라서 증가하다가 500K daltons에서 감소하였다. 색도, 당도, 총 질소, 아미노태 질소, naringin, hesperidin의 함량은 막 공극의 크기에 따른 차이가 적거나 일정한 경향을 나타내지 않았다. 한외여과 처리를 한 결과 구연산이 감소하여, 당산비가 증가하였다. 연구된 한외여과 막 중 flux가 가장 높고, 성분들의 감소율이 가장 적은 500K daltons 막이 온주 밀감 주스 제조시 가장 적합할 것으로 생각된다.

• Korean Chemical Engineering Research
• /
• 제43권2호
• /
• pp.222-229
• /
• 2005

공기 중의 이산화탄소가 10% 함유된 연소가스를 5단의 다단 농축 막분리 시스템을 이용하여 분리하는 것을 Aspen plus와 Excel을 이용하여 모사하였다. 분리된 이산화탄소의 농도는 99% 이상, 이산화탄소 제거 효율을 90% 이상으로 하였다. 이때 최적화 변수를 각 단의 압력, 각 단에서의 잔여물 농도로 하였고 각 단의 막 면적의 합과 막 분리시스템의 장치비와 운전비를 고려한 목적함수를 제안하여 최적화를 행하였다. 최적화 결과, 기존 설계에 비해 막 면적 및 총괄 소요비용을 절감할 수 있었으며, 이를 바탕으로 다단농축 막분리 시스템의 설계지침을 얻었다.

• 대한토목학회논문집
• /
• 제33권2호
• /
• pp.609-617
• /
• 2013

본 연구에서는 역삼투 공정 농축수에 존재할 수 있는 내분비계 장애물질의 처리에 있어, 고급산화 공정의 적용가능성을 다양한 조건하에서 평가하였다. 오염물 제거에는 Fe(II)를 촉매로 한 과황산나트륨 산화를 이용하였으며, 초기 pH와 이온강도 등, 영향인자에 따른 산화능을 검토하였다. Fe(II) 촉매 과황산나트륨에 의한 $17{\alpha}$-ethynylestradiol(EE2) 제거효율은 초기 pH와 이온강도가 증가할수록 감소하였다. 반면, 이온강도 물질로 염소이온과 같은 할로겐족 이온을 적용 시 산화반응에 긍정적인 영향을 나타냈는데, 이는 라디칼 전이에 따른 영향으로 판단된다.

• Journal of Dairy Science and Biotechnology
• /
• 제29권2호
• /
• pp.1-15
• /
• 2011

Mozzarella cheese is recently the most consumed cheese in USA, European, South Korea, etc., and also a various different-type Mozzarella cheese could have great market appeal. However, many consumers would be more concerned about the nutritional aspects and physicochemical properties of Mozzarella cheese. Hence, ultrafiltration (UF) as a best tool of solving those concerns has been recognized. The objective of this review's paper would be suggested that the ultrafiltration (UF) techniques could be directly applied for manufacturing various different-type Mozzarella cheese with high physicochemical properties on fulfilling the consumers' various needs and desires for health.