• Journal of Food Hygiene and Safety
• /
• v.15 no.2
• /
• pp.101-107
• /
• 2000

This experiment was conducted to investigate the effect of NA formation in the human body with salted and dried yellow corvenia(Gulbi, Pseudosciaena manchurica) steamed for 30 minutes and incubated in 10 ml simulated saliva and 40 ml gastric juice at 37。C for 2 hours. And the experiment studied the NA formation after nitrite, thiocyanate and ascorbic acid treatment under simulated gastric conditions. N-nitrosodimethylamine(NDMA) was not detected when nitrite was not added to the digestate mixture. And then increasing the nitrite concentration from 0.5 mM to 8 mM gave a slight increase in the NDMA formation at all level of Gulbi utilized in the experiment. In contrast to the change of the nitrite concentration, the increase of the amount of Gulbi didn't show any marked influence on NDMA formation. At all level of thiocyanate(1∼6.4 mM) tested, concentration of NDMA was still proportional to the nitrite concentration. In the catalytic ability of thiocyanate at another high level of nitrite(100 mM) no catalytic activity was observed up to the level of 8mM thiocyanate. The same amounts of salted fish(10 g) and ascorbic acid levels in each single digestate were used to prevent NDMA formation. No prevention effect was observed at nitrite concentration of 0.5 mM and 1 mM. Most importantly, the decrease of NDMA concentration, by the increase of ascorbic acid absolutely, was remarkably shown when nitrite concentration was high. On the contrary, according to the degree of ascorbic acid, the higher the amount of nitrite the higher the prevention of NDMA formation.

• Journal of the Korea Organic Resources Recycling Association
• /
• v.20 no.1
• /
• pp.61-70
• /
• 2012

Feasibility of co-digestion was investigated by a series of anaerobic batch experiments using sewage sludge, swine waste, and food waste leachate as substrates. The organic solid wastes were collected from M city, where the daily productions of sewage sludge, swine waste, and food waste leachate were 178 ton/d, 150 ton/d, and 8 ton/d, respectively. Both swine waste and food waste leachate showed superior methane yields, methane productivities, and organic pollutant removal efficiencies compared to sewage sludge. Co-digestion of the total amounts of organic solid wastes would enhance methane production by 5.60 times $(530\;m^{3}\;CH_{4}/d\;{\rightarrow}\;2,968\;m^{3}\;CH_{4}/d)$. However, it also increase the amount of digestate by 1.88 times with 3.79 to 4.92 times higher pollutants (chemical oxygen demands total nitrogen, and total phosphorus) loading rates. Co-digestion of organic solid wastes is a valid strategy to enhance the performance of an anaerobic sludge digester and the energy independence of a wastewater treatment plant. Anyhow,the increment of digestate with higher pollutant loading would need a careful counterplan in the operation of the main stream of the treatment plant.

• Journal of the Korea Organic Resources Recycling Association
• /
• v.22 no.2
• /
• pp.35-43
• /
• 2014

The application of the Life Cycle Impact Assessment (LCIA) methodology to analyze the environmental burden of appling the digestates to corn field including different swine waste treatment systems was investigated. The first part of LCA is an inventory of parameters used to emissions released due to the system under investigation. In the following step, the Life Cycle Impact Assessment, the inventory data were analyzed and aggregated in order to finally get one index representing the each environmental burden. Each corn field applied with the aerobic and anaerobic digestates including different swine waste treatment systems was used as an example for the life cycle impact analysis. With analyzing the agricultural environmental burden, it observed that the effect of corn field applied aerobic digestate including digestion system was 7.6 times higher at eutrophication effects, but global warming potential effect was 0.9 times less than its applied anaerobic digestate.

• Journal of The Korean Society of Agricultural Engineers
• /
• v.51 no.2
• /
• pp.1-6
• /
• 2009

Acetogen과 같은 일부 혐기성미생물은 소위 acetyl-CoA 경로에 의해 아세트산, 에탄올, 그리고 몇 가지 생화학 물질을 생산한다. 이 경로에서는 일산화탄소를 기질로 이용할 수 있다. 일산화탄소 이외에 수소가 이용될 수 있다. 즉 이들 미생물은 독립영양생물로서 이산화탄소와 태양광에너지를 이용하는 녹색식물과 비유될 수 있으며, 일산화탄소는 탄소원으로서 동시에 에너지원으로서 이용된다. 본 연구에서는 혐기성 소화액 중 아세트산을 생성하는 미생물이 존재한다고 가정하고, 일산화탄소와 수소가 주 가연성분인 합성가스를 공급하면 추가의 메탄이 생성가능성을 평가하였다. 혐기성 소화과정에서 발생되는 메탄은 주로 아세트산으로부터 만들어지므로 일산화탄소를 공급하는 경우 추가로 메탄이 생성될 것으로 추측할 수 있기 때문이다. 이를 확인하기 위하여 현재 운영중인 바이오가스 생산 설비로부터 얻은 혐기성 소화액을 생물반응조에 넣은 후, 합성가스를 순환-공급하여 가스 생산량의 변화 및 조성을 분석하였다. 질소가스를 공급한 대조구와는 달리 일산화탄소 또는 합성가스를 공급한 경우에는 메탄가스가 생산되는 것을 확인하였다. 질소가스를 공급한 대조구와는 달리 일산화탄소 또는 합성가스를 공급한 경우에는 메탄가스가 생산되는 것을 확인하였다. 일산화탄소만을 공급했을 때에는 이산화탄소의 생성으로 가스 생산량이 증가하였으나, 수소가 포함된 합성가스를 공급하였을 때에는 이산화탄소가 탄소원이로 소비되어 가스 저장도 내의 가스량이 감소하는 것을 확인할 수 있었다. 가스화공정에 으해 얻어지는 합성가스는 온도와 가스 조성을 고러할 때, 바이오가스 생산을 위한 혐기성 소화조와 연계하면 소화조의 가온에 필요한 열을 공급할 수 있고 바이오가스 중 이산화탄소 농도를 낮추어 발열량을 개선할 수 있을 것으로 판단된다.

• Advances in environmental research
• /
• v.9 no.1
• /
• pp.55-64
• /
• 2020

The problems with unsorted municipal waste are always associated with disposal issues as it requires a large area for landfilling or high energy used for incineration. In recent years, an autoclaving technique has been considered a promising approach which could minimize the volume of organic waste from being directly disposed or incinerated. In this work, an attempt was done to study the saccharification potential of organic residues under elevated temperature Thermal treatment involving hot water bath was applied to treat the organic residue ranging from 60℃ to 100℃ for 30 and 60 minutes. The result obtained showed an increasing trend for the concentration of glucose and carbohydrate. However, the result for lignocellulose content which contains various component includes extractive, holocellulose, hemicellulose, cellulose and lignin show variation. Based on the thermal treatment carried out, the result indicated that the trend of glucose and carbohydrate content. The highest percentage of glucose that can be obtained 978.602 ㎍/ml which could be obtained at 90℃ at 60 minutes. The carbohydrate also shows an increasing trend with 0.234 mg/ml as the highest peak achieved at 80℃ for 30 minutes treatment. However, it was found that the lignocellulose content varies with temperature and time. The statistical analysis was carried out using two-ways ANOVA shows an interaction effect between the independent variables (temperature and contact time) and the saccharification effects on the food wastes. The result shows a variation in the significant effect of independent variables on the changes in the composition of food waste.

• Advances in environmental research
• /
• v.6 no.2
• /
• pp.95-111
• /
• 2017

The valorization of swine manure samples, i.e., de-watered cake (SMc) and solid digestate (SMd), in products with beneficial value, i.e., low cost activated carbons (ACs), is studied. For this purpose slow pyrolysis and steam activation at three different duration times are applied. Additionally, the obtained ACs are characterized and tested towards removal of Cr(VI) from aqueous solutions. It is revealed that BET surface area varies in the range of $236-267m^2/g$ for ACs prepared from SMc sample and in the range of $411-432m^2/g$ for ACs prepared from SMd sample. Despite the low determined surface area of prepared ACs, a high total Cr removal capacity is observed occurring through a "coupled adsorption-reduction" mechanism. Higher Cr(VI) removal capacity is demonstrated for ACs having higher surface area ($q_m$ is 140.9 mg/g according Langmuir modelling). Cr(VI) removal is found to be pH dependent with a maximum at pH 1. However at that pH significant amounts of Cr remain in the solution as Cr(III). At pH 2 lower amount of Cr(VI) is removed compensated by a higher removal of Cr(III) resulting in a higher amount of adsorbed $Cr_{tot}$. Therefore adsorption at pH 2 is found to be appropriate. The removal capacity of the studied ACs towards Cr(VI) is almost independent of activation time.

• Journal of Food Hygiene and Safety
• /
• v.17 no.4
• /
• pp.201-205
• /
• 2002

When it added to each designed diet groups such as control, nitrate rich, amine rich and nitrate-amine rich diet under simulated gastric conditions, effect of kumquat (Fortunella mararita) juice on formation of N-nitrosodimethylamine (NDMA) was studied. Inhibition on NDMA formation was the highest in the amine rich diet, as 69.4 $\pm$2.4%, when the juice of 10m1 added to its digestate. Phenolic portion of $C_{18}$ sep-pak cartridge in kumquat juice were separated into 20 kinds of a phenolic compounds using HPLC. These phenolic fractions such as faction no. 1, 2, 3, 4 and 5 inhibited from 3.0 $\pm$ 1.2% to 66.5 $\pm$2.0% NDMA formation in the reaction system which was mixture of nitrite and dimethylamine.

• Journal of Korean Society of Water and Wastewater
• /
• v.31 no.3
• /
• pp.229-236
• /
• 2017

In this study, a direct contact membrane module was manufactured to be used in a pilot scale membrane distillation process to treat $3m^3/day$ of the digestate produced from anaerobic digestion of livestock manure. In order to investigate the performance of the membrane module, permeate flux was measured with and without spacer inside the module under various condition of temperature difference and cross flow velocity (CFV) through the membrane surfaces. Flux recovery rate after chemical cleaning was also investigated by applying three different cleaning methods. Additionally, thermal energy consumption was theoretically simulated based on actual pilot plant operation conditions. As results, we observed flux of the module with spacer was almost similar to the theoretically predicted value because the installation of spacer reduced the channeling effect inside the module. Under the same operating condition, the permeate flux also increased with increasing temperature difference and CFV. As a result of chemical in-line cleaning using NaOCl and citric acid for the fouled membranes, the recovery rate was 83.7% compared to the initial flux when NaOCl was used alone, and 87% recovery rate was observed when only citric acid was used. However, in the case of using only citric acid, the permeate flux was decreased at a rapid rate. It seemed that a cleaning by NaOCl was more effective to recover the flux of membrane contaminated by the organic matter as compared to a cleaning by citric acid. The total heat energy consumption increased with increasing CFV and temperature difference across the membrane. Thus, further studies should be intensively conducted to obtain a high permeate flux while keeping the energy consumption to a minimum for a practical application of membrane distillation process to treat wastewater.

• Asian-Australasian Journal of Animal Sciences
• /
• v.30 no.8
• /
• pp.1198-1205
• /
• 2017

Objective: An experiment was conducted to isolate and identify new methanogens in Korea from an anaerobic digester that uses pig slurry. Methods: An anaerobic digestate sample was collected from an anaerobic digester using pig slurry. Pre-reduced media were used for the growth and isolation of methanogens. Growth temperature range, pH range, NaCl concentration range, substrate utilization, and antibiotic tolerance were investigated to determine the physiological characteristics of isolated methanogens. The isolates were also examined microscopically for their morphology and Gram-stained. Polymerase chain reaction of 16S rRNA and mcrA gene-based amplicons was used for identification purpose. Results: Four strains, designated KOR-3, -4, -5, and -6, were isolated and were non-motile, irregular coccoid, and 0.5 to $1.5{\mu}m$ in diameter. Moreover, the cell walls of isolated strains were Gram-negative. KOR-3 and KOR-4 strains used acetate for methane production but did not use $H_2+CO_2$, formate, or methanol as a growth substrate KOR-5 and KOR-6 strains utilized acetate, methanol, and trimethylamine for methanogenesis but did not use $H_2+CO_2$ or formate as a growth substrate. The optimum temperature and pH for growth of four strains were $39^{\circ}C$ and 6.8 to 7.2, respectively. The optimum concentration of NaCl for growth of KOR-3, KOR-5, and KOR-6 were 1.0% (w/v). The optimum NaCl concentration for KOR-4 was 0.5% (w/v). All of the strains tolerated ampicillin, penicillin G, kanamycin, streptomycin, and tetracycline; however, chloramphenicol inhibited cell growth. Phylogenetic analysis of 16S rRNA and mcrA genes demonstrated that strains KOR-3, -4, -5, and -6 are related to Methanosarcina mazei (M. mazei, 99% sequence similarity). Conclusion: On the basis of physiological and phylogenetic characteristics, strains KOR-3, -4, -5, and -6 are proposed to be new strains within the genus Methanosarcina, named M. mazei KOR-3, -4, -5, and -6.

• Korean Journal of Soil Science and Fertilizer
• /
• v.44 no.1
• /
• pp.104-111
• /
• 2011

In order to assess the performance of co-digester using pig slurry and food waste at the farm scale biogas production facility, the anaerobic facility that adopts the one-stage CSTR of 5 $m^3\;day^{-1}$ input scale was designed and installed under the conditions of the OLR of 2.33 kg $m^3\;day^{-1}$ and HRT of 30 days in an pig farmhouse. Several operation parameters were monitored for assessment of the process performance. The anaerobic facility was operated in three stages to compare the performance of the anaerobic co-digester. In the Stage I, that was fed with a mix of pig slurry to food waste ratio of 7:3 in the input volume, where input TS content was 4.7 (${\pm}0.8$) %, and OLR was 0.837-1.668 kg-VS $m^3\;day^{-1}$. An average biogas yield observed was 252 $Nm^3\;day^{-1}$ with methane content 67.9%. This facility was capable of producing an electricity of 626 kWh $day^{-1}$ and a heat recovery of 689 Mcal day-1. In Stage II, that was fed with a mixture of pig slurry and food waste at the ratio of 6:4 in the input volume, where input TS content was 6.9 (${\pm}1.9$) %, and OLR was 1.220-3.524 kg-VS $m^3\;day^{-1}$. The TS content of digestate was increased to 3.0 (${\pm}0.3$) %. In Stage III, that was fed with only pig slurry, input TS content was 3.6 (${\pm}2.0$) %, and OLR was 0.182-2.187 kg-VS $m^3\;day^{-1}$. In stage III, TS and volatile solid contents in the input pig slurry were highly variable, and input VFAs and alkalinity values that affect the performance of anaerobic digester were also more variable and sensitive to the variation of input organic loading during the digester operation. The biogas produced in the stage III, ranged from 11.3 to 170.0 $m^3\;day^{-1}$, which was lower than 222.5-330.2 $m^3\;day^{-1}$ produced in the stage II.