• 한국광물학회지
• /
• 제25권3호
• /
• pp.123-130
• /
• 2012

염소-차아염소산 용액을 소성정광에 적용하여 gold와 silver를 효과적으로 용출시키고자 하였다. 염소 : 차아염소산 혼합비율 1.5 : 1, 그리고 NaCl 농도를 1 M으로 적용하였을 때 Au 용출율은 겨우 75%와 81%이였다. 그러나 광액농도를 1%로, 그리고 용출온도를 $65^{\circ}C$로 적용하자 Au 용출율이 100%에 도달되었다. 왕수분해 및 염소-차아염소산 용출 고체 잔유물을 XRD분석을 실시한 결과 석영이 관찰되었다. 따라서 석영 속에 함유된 gold는 염소-차아염소산으로 용출시키지 못할 것으로 사료된다. 따라서 석영 속의 gold를 용출시키기 위해서는 더 작은 미립자로 전처리하거나 더 강력한 산화제를 적용해야 할 것이다.

• Membrane and Water Treatment
• /
• 제5권4호
• /
• pp.235-250
• /
• 2014

The impacts of membrane degradation due to chlorine attack on the rejection of inorganic salts and trace organic contaminants by nanofiltration (NF) and reverse osmosis (RO) membranes were investigated in this study. The rejection of trace contaminants was examined at environmentally relevant concentrations. Changes in the membrane surface morphology were observed as a result of chlorine exposure. A small increase in rejection was consistently observed with all four membranes selected in this study after being exposed to a low concentration of hypochlorite (100 ppm). In contrast, a higher concentration of hypochlorite (i.e., 2000 ppm) could be detrimental to the membrane separation capacity. Membranes with severe chlorine impact showed a considerable decrease in rejection over filtration time, possibly due to rearrangement of the polyamide chains under the influence of chlorine degradation and filtration pressure. The reported results indicate that loose NF membranes are more sensitive to chlorine exposure than RO membranes. The impact of hypochlorite exposure (both positive and negative) on rejection is dependent on the strength of the hypochlorite solution and is more significant for the neutral carbamazepine compound than the negatively charged sulfamethoxazole.

• 한국지구과학회지
• /
• 제35권4호
• /
• pp.259-266
• /
• 2014

폐 PCBs의 스크랩으로부터 염소-차아염소산염 용액을 이용하여 Au와 Ag를 친환경적이고 효과적으로 용출시키고자 하였다. PCBs에 Cu, Sn, Sb, Al, Ni, Pb, Au 등과 같은 유용금속이 함유되어 있는 것을 EDS 분석으로 확인하였다. 최대 Au 용출율은 1%의 광액농도, 2:1의 염산:차아염소산나트륨 그리고 2 M의 NaCl 농도조건이다. Au 회수율이 가장 높은 메타중아황산나트륨 농도는 3 M에서였다. 염소-차아염소산염이 폐 컴퓨터에 함유되어 있는 Au와 Ag를 효과적으로 용출시킬 수 있는 용매제 임을 그리고 메타중아황산나트륨이 Au를 간단하게 침전시킬 수 있는 첨가제임을 확인하였다.

• 대한화학회지
• /
• 제5권1호
• /
• pp.1-6
• /
• 1961

It is important to study hydrazine because of the development of new uses for its derivatives. The Rasching method is the only satisfactory one for synthesizing hydrazine; it involves the oxidation of ammonia by sodium hypochlorite in the presence of some such catalyst as gelatin. Calcium hypochlorite was substituted for the sodium hypochlorite particularly in this work, applying agar-agar as catalyst. The results of the experiments are as follow: 1. The yield is proportional to the mole-ratio of ammonia to available chlorine in calcium hypochlorite and about 60% is obtained when the ratio is 20. 2. Agar-agar can be used as a catalyst and its proper concentration in the solution is 0.005%. 3. Proper concentration of available chlorine in the reaction solution is 0.23 mole/l. 4. The most effective condition for the reaction is a temperature of $60{\sim}65^{\circ}C.$ maintained for $20{\sim}25min$. 5. The reaction takes place equally well in either an open or closed container. 6. When calcium hypochlorite is applied in place of sodium hypochlorite, the yield of hydrazine is increased as much as 17%. 7. The yield of hydrazine is decreased by eliminating the suspension of $Ca(OH)_2$ which results from the use of calcium hypochlorite. 8. When $Ca(OH)_2$ is added to Rasching process, the yield of hydrazine is raised normally. 9. The fact that some metal ions, such as $Cu^{++},$ inhibit the formation of hydrazine was proved. 10. The suspension of $Ca(OH)_2$ acted as a remarkable adsorbent for $Cu^{++}$ like gelatin. The suspension of $Ca(OH)_2$ which results from the use of calcium hypochlorite acts as a catalyst, absorbing metal ions, to increase the yield of hydrazine. So I think that calcium hypochlorite is a more efficient oxidant than sodium hypochlorite in hydrazine syntheses.

• Membrane and Water Treatment
• /
• 제4권1호
• /
• pp.69-81
• /
• 2013

The pH-dependent inter-conversion of the three free chlorine species ($Cl_2$, HOCl, OCl-) present in the aqueous hypochlorite solution was theoretically investigated. Each species was found overwhelmingly present in a characteristic pH range. Hypochlorite treatment of the polyamide membrane was carried out over these pH ranges and various membrane responses were observed. As pH is less than 8, membrane tends to be N-chlorinated by $Cl_2$ and HOCl, and N-chlorinated membrane showed reduced water permeance and salt rejection. As pH rises to 10-12, $OCl^-$ appears to be the dominating chlorine species. Membrane hydrolysis was found to well interpret the improved water permeance and salt rejection. When the pH is between 8-10, both N-chlorination and hydrolysis contribute to the response of the membrane, and the treated membrane showed improved salt rejection but reduced water permeation. Excessive hydrolysis occurred while the membrane was treated at pH 13 for the much stronger alkalinity.

• Journal of Electrochemical Science and Technology
• /
• 제15권2호
• /
• pp.268-275
• /
• 2024

The study examined the electrogeneration of hypochlorite ions (ClO^-) via electrolysis of aqueous NaCl solutions using a dimensionally stable anode-type (DSA-type) electrode based on platinum and palladium oxides supported on titanium mesh (Ti/PtPd(10%)O_x). The electrogenerated ClO^- was quantified on the basis of the absorption band at 292 nm (A_λ = 292) of the UV-Vis spectrum. The effect of initial pH, concentration of NaCl, cell potential difference and electrolysis time were investigated in this study. The results showed that the electrolysis of aqueous NaCl solutions increases the solution pH up to high values (≥ 8.0) that favor the formation of ClO^- over chlorine or hypochlorous acid. The hypochlorite concentration increases significantly at pH values > 7.0 and shows a linear trend with increasing NaCl concentration and with increasing cell potential difference. When the cell potential and NaCl concentration are held constant, the maximum hypochlorite value during electrolysis depends on both the cell potential and NaCl concentration. The Ti/PtPd(10%)O_x anode favors the production of hypochlorite ions, making this anode a promising material for use in electrochemical oxidation of wastewater via an indirect mechanism.

• 한국의류산업학회지
• /
• 제10권1호
• /
• pp.101-105
• /
• 2008

This study was concerned with the influence of reaction conditions on the surface friction properties of Syrene-Butadiene Rubber(SBR) sheet when it was chlorinated by chemical treatment method using the sodium hypochlorite and sulfuric acid. The results of this study were as follows. SEM photographs of chlorinated SBR surface showed uneven etching caused by the chlorination. In the FTIR spectra, the intensity of C=C peak of SBR was decreased with increasing the concentration of sodium hypochlorite. Otherwise there was no trace of C=C peak in spectrum of SBR treated with 5 wt% NaOCl with pH 0.1 for 90 seconds. EDX spectra showed that relative content of chlorine of SBR was increased with increasing the amount of sodium hypochlorite, and also affected with pH condition of acid solution. Friction angle and friction coefficient of SBR were influenced with concentration of sodium hypochlorite, but were not with pH condition of acid solution.

• 한국수산과학회지
• /
• 제51권4호
• /
• pp.389-396
• /
• 2018

Marine pathogenic bacteria, such as Streptococcus parauberis, Edwardsiella tarda and Vibrio harveyi, can cause lethal infections in farmed fish, ozone and antibiotics, are employed to sterilize waters used for rearing fish to mitigate this threat. The most widely used method is treatment with sodium hypochlorite solution. However, the maintenance of a constant concentration of chlorine in rearing waters can be difficult. We investigated the potential of a mixed oxidant (MO) solution generated by electrolysis of sea water to improve water quality. We measured the survival rates of fish pathogenic bacteria exposed to different concentrations of MO (0.5, 1.0, 1.5 and 2.0 MO) and sodium hypochlorite (0.5, 1.0, 1.5 and 2.0 ppm) for various lengths of time (0, 5, 10, 15, 20, 25 and 30 min). We found a time-dependent decrease in the survival rates of the tested pathogenic microorganisms. The sterilization effect of the MO solution on pathogenic organisms was greater than that of sodium hypochlorite for gram-negative and gram-positive bacteria. We conclude that MO solution produced by electrolysis could be used to maintain a constant chlorine concentration in aquaculture systems.

• 한국광물학회지
• /
• 제26권1호
• /
• pp.9-18
• /
• 2013

저항성 황화광물 정광으로부터 최적의 gold를 용출시키기 위하여 염소-차아염소산 용액과 다양한 온도와 농도를 소금소성정광에 적용하였다. 정광은 황철석, 황동석, 방연석으로 구성되었으며, 공기 중에서 $750^{\circ}C$ 소성처리하자 적철석으로 변환되었고, 소금으로 소성처리하자 적철석과 난토카이트(nantokite, CuCl)으로 변환되었다. 다양한 변수로 용출실험을 수행한 결과, 염소-차아염소산 나트륨 혼합 비율 1 : 2에서, $FeCl_3$ 첨가량 1.0 M에서, 광액농도 1.0%에서, 그리고 용출온도 $60^{\circ}C$에서 최대의 금 용출율을 얻었다. 금 용출율은 정광에서보다 소성정광에서 더 높게 용출되었고, 소성정광에서보다 소금소성정광에서 더 높게 용출되었다. XRD 분석 결과, 소금소성정광에서, 그리고 $60^{\circ}C$의 염소-차아염소산 용출용액 고체 잔유물에서 석영이 관찰되었다.

• 대한기계학회논문집B
• /
• 제41권3호
• /
• pp.183-189
• /
• 2017

상수도 소독공정에서 사용되고 있는 차아염소산나트륨은 일반적으로 유효염소 0.8 %로 생산되어 투입되고 있으며, 투입량이 많아질수록 소독부산물(Chlorate)이 증가되었고 수질기준을 초과하게 된다. 이에 따라 본 연구에서는 유효염소를 12%로 높인 차아염소산나트륨 발생장치의 전해조에 대해 소독부산물을 제어할 수 있도록 양극수 pH를 조절하였다. 실험결과 전해조 내 양극수 pH를 4.2(일반적인 차아염발생장치 운전 pH)에서 1.53으로 조절함으로서 Chlorate 농도는 95% 이상 낮아진 것으로 나타났으며, 또한 낮은 전류가 인가됨에 따라 양극의 효율도 15% 개선되는 결과를 얻었다. 이 장치의 개발로 대용량 상수도에서도 안전한 차아염소산나트륨의 적용이 가능하여 소독공정의 안전성 향상에 기여할 것으로 기대된다.