• YAKHAK HOEJI
• /
• v.3 no.1
• /
• pp.26-34
• /
• 1957

The solar evaporation method is one of the most important and popular salt manufecturing method in Korea. The rate of evaporation of sea water depends on a complex climate factors. Of these factors, the most important is solar radiation and in particular the extent to which it is absorbed in the brine. By the addition of suitable dyestuff, a further increase in absorption is obtained and can result in all the radiation entering the brine being made available as heat. "Solivap Green", one of several dyestuffs which have been suggested for accelerating solar evaporation, was tested in this experiment. The results of the experiment. 1. Increase the evaporation rate of brine up to 20-25%. 2. Elevate the temperature of brine 2-$4^{\circ}C$. higher than that of brine adding no dyestuff. 3. Optimum dyestuff concentration is 25-30 mg/L and allowable maximum concentration can not exceeded 1000 mg/$m^2$ (50 mg/L). 4. Addition of dyestuff does not cause the degradation of salt produced. 5. A conversion table which indicates the concentrations for various depths of brine was prepared for engineering purpose. 6. Absorption spectrum of the dyestuff was studies, but toxicological and structural studies for the dyestuff have not been done in this experiment.

• Journal of the Korean Society of Food Culture
• /
• v.9 no.1
• /
• pp.87-93
• /
• 1994

This study was conducted to present a method that determine the optimum conditions for the preparation of chinese whole cabbage kimchi. After Sensory and chemical characteristics of kimchi with various salt concentration in brine, brining time and storage period at equal saltiness were measured, the optimum conditions for the preparation of chinese whole cabbage kimchi were determined with the use of the response surface methodology. The results are summarized as follows; 1. The more salt concentration in brine, the longer brining time and storage period, resulted in the lower pH and the higher titratable acidity of kimchis. As the salt concentration in brine and brining time increased, kimchi reaches at optimum titratable acidity of it within a shorter time. 2. As the salt concentration in brine and brining time increased, content of succinic acid decreased but that of lactic, acetic, and propionic acid increased. Amount of citric, malic and succinic acid decreased but that of lactic, acetic acid increased, with storage day. 3. Sensory data showed that firmness and green cabbage flavor of kimchi decreased while toughness, carbonic mouthfeel, sourness and staled flavor increased with increased salt concentration in brine, brining time and storage day. As the storage period increased, crispness of kimchi decreased. 4. The optimum conditions for the preparation of chinese whole cabbage kimchi were as follows: Optimum salt concentration in brine, brining time, and storage period were 19.5%, 3 hours and 45 minutes, and 12 hours.

• Journal of the Korean Society of Food Science and Nutrition
• /
• v.28 no.2
• /
• pp.390-395
• /
• 1999

The cucumber pickles(pieces types), soaked at 10, 15, and 20% brine concentrations, were fermented for 7 days at 25oC. The pH of sample in 10% brine was lowered faster than that of others. To reach pH 3.7, it took 4 days(10%) , 6 days(15%) and 7 days(20%), respectively. The salt permeated into cucumber rapidly, and it took only 1 day to reach maximum content, thereafter salt contents were maintained constant. The titratable acidity and turbidity of cucumber pickle liquids were increased with fermentation time. Sensory evaluation showed that taste and smell of fresh cucumber, color and texture were decreased, while yeast moldy smell and acidic taste were increased as fermentation proceeded. Higher scores were obtained in acidic taste and smell, yeast moldy taste and smell in case of fermented sample in 10% brine for 4 days. It was concluded that the quality of cucumber pickle was influenced by the salt concentrations of brine.

• Journal of the East Asian Society of Dietary Life
• /
• v.25 no.1
• /
• pp.131-138
• /
• 2015

In this study, cucumber Jangachi using Sake cake was prepared and its quality characteristics verified. After preparing various cucumber Jangachi with different salt concentrations, physicochemical characteristics, hardness and sensory evaluation were investigated. Five samples (0%, 3%, 6%, 9% and 12% brine) were used and designated as treatment plots (CJ0, CJ3, CJ6, CJ9 and CJ12, respectively). Higher concentration of brine was associated with reduced pH of cucumber Jangachi and higher total acidity. Salinity decreased significantly as storage period increased. On day 0, it shows similarity to the concentration of brine, whereas it was reduced after day 28. The soluble solid content increased significantly as the storage period increased and decreased slightly after 21 days. Regarding concentration of brine, a higher concentration shows a tendency to increase but the gaps are insignificant. Reducing sugar content increased significantly as the storage period increased. The hardness increased in all treatment plots up to the 14th day, decreased until day 21, and increased thereafter. Following the sensory evaluation, saltiness was not detected in the plots, and CJ6 showed the highest texture score ($4.46{\pm}1.41$). For overall acceptability, CJ6 showed the highest score ($4.33{\pm}1.13$). According to the above results, salinity content of cucumber Jangachi using Sake cake decrease to 0.69~1.52% in 0%, 3%, 6%, 9%, and 12% brine by the 28th day. Despite decreasing salinity, texture and overall acceptability scores were higher than the above results. Thus, we conclude that it is possible to produce low salt cucumber Jangachi of high quality using Sake cake instead of high salt one.

• Journal of Food Hygiene and Safety
• /
• v.15 no.1
• /
• pp.25-29
• /
• 2000

General composition and microbial load of brine recycled to 6 times for Chinese cabbage salting and the quality of Kimchi using every brined cabbage were investigated. The concentration of salt(NaCl) in brine after soaking dropped 1.35-2.49% and pH of the brine changed significantly until 4 times recycling. The acidities were increased as number of recycling increased. The total viable cell count in recycled brine increased from 1.58$\times$10$^{6}$ /mL in the first soaking brine to 2.3$\times$10$^{9}$ /mL in 4th soaking brine which was highest in number. The pure soluble solid and vitamin C content in brine were accumulated to 0.93% and 0.55 mg% respectively after 6th recycling. The pH, acidity and sensory evaluation results of Kimchi prepared by Chinese cabbage salted by each brine recycled 6 times showed no significant difference. It means there is a possiblity reusing brine for salting of cabbage for the preparation of Kimchi to 6 times.

• Food Science of Animal Resources
• /
• v.39 no.1
• /
• pp.102-113
• /
• 2019

In this study, the effect of sodium chloride (salt) concentration and phosphate on the quality properties of samgyetang was investigated. Increasing the salt concentration by 0.5% increased the moisture and ash content, salinity, water holding capacity (WHC), and thiobarbituric acid reactive substances (TBARS), whereas the protein content, pH, cooking losses, and shear forces were decreased. Addition of phosphate to the brine increased the pH and WHC, but decreased the TBARS, cooking losses, and shear forces. In a sensory evaluation, the scores for flavor and overall acceptability were the highest when the salt concentration of the brine was 2.0%. Overall, this study shows that the salt concentration and addition of phosphate to the brine of samgyetang substantially influences the overall quality of the chicken breast. Based on quality measurements and sensory scores, a 2.0% salt concentration with the addition of phosphate appear to be the most suitable conditions for the manufacturing of marinated samgyetang.

• Journal of the Korean Society of Food Science and Nutrition
• /
• v.20 no.6
• /
• pp.572-581
• /
• 1991

For the development of a model to predict absorbed salt quantity in radish during salting, absorbed salt quantity and water content change in radish by the hour were measured at 5%, 10%, 15% brine concentration and $10^{\circ}C,\;20^{\circ}C,\;30^{\circ}C$ respectively. Absorbed salt quantity in radish by the time showed logarithmic function, absorbed salt quantity by brine concentration and temperature showed linear relation. A model to predict absorbed salt quantity in radish at each time, brine concentration and temperature was calculated by the regression program of SPSS. Apparent diffusivity of salt in radish was calculated from appropriated diffusion equation solution of Fick's second law using computer simulation. Salt diffusivity in radish increased as brine concentration increased and the effect of temperature could by expressed by Arrhenius equation. A model equation which could predict salt diffusivity was developed by regression analysis. To specify relation between salt quantity which absorbed into radish and water content which removed out of it, Flux ratio(${\Delta}W/{\Delta}S$) was calcuated. The values showed that the removed water content was greater than the absorbed salt quantity.

• Korean Journal of Food Science and Technology
• /
• v.32 no.1
• /
• pp.97-101
• /
• 2000

Major characteristics of waste brine from the repeated salting and rinsing processes of Chinese cabbage for Kimchi were investigated. Salt concentration of brine was increased with the number of successive salting steps from 12% after 1st salting step to 14% after 5th step. Total waste brine which is the representative of wastewater produced from salting process of cabbage showed 6-8% salt concentration. The pH values in all samples decreased with the number of reuse of brine and showed pH 5.9 and pH 5.2 for the mixture of brine for quarter-cut and small-cut cabbage, respectively, after 5th salting process. Soluble solid contents increased with repetition and resulted in 14-16 $^{\circ}Brix$. Total brine showed increased COD values with the number of reuse of brine and 40-50 ppm of COD values for both quarter-cut and small-cut cabbages.

• Journal of the Korean Society of Food Science and Nutrition
• /
• v.32 no.4
• /
• pp.526-530
• /
• 2003

Changes of physicochemical properties of brined cucumber were investigated in the samples mixed cucumber and water at 1 : 1.2 ratio in various salt concentrations from 15 to 30%. As salt concentrations in brine solutions were increased, cucumber was getting constricted and decreased in the size of diameter. Salt concentrations of brined cucumber were reached an equilibrium after 30 days of brine storage. When cucumber was preserved at 30% salt concentration, pH was gradually decreased until 60 days of brine storage. When cucumber was preserved in 15% salt solution, the yellowness on the surface of cucumber peels was the most intense among the groups. Among the groups preserved by more than 20% of salt, no difference was observed in intensity of yellowness after 30 days of brine storage. The absorbances of isopropyl alcohol extracts at 410, 505, 607, and 665 nm were different from those of raw cucumbers. Regardless of salt concentration, the hardness of cucumber was increased as preservation was prolonged except the group preserved in 15% salt solution.

• Journal of the Korean Society of Food Science and Nutrition
• /
• v.33 no.8
• /
• pp.1385-1389
• /
• 2004

For the development of better Gulbi processing, brine salting method was applied for the Yellow croaker (Larimichthys polyactis). The changes of moisture contents, salt contents, and total microbial numbers in Yellow croaker were measured following different brine concentration (20, 30%), temperature (5, 25, 35$^{\circ}C$), and soaking time (1, 6, 12, 24 hours) by brine salting method. Rate of salt penetration into Yellow croaker muscle increased as higher brine concentration and higher dipping temperature. When compared to commercial products of Gulbi by dry-salting method, the moisture and salt contents in Yellow croaker showed similar values after treated with 20% brine at $25^{\circ}C$ for 1 hour. The weight of Yellow croaker increased about 4% when immersed it in 20% brine at 5$^{\circ}C$ for 24 hours. There was no weight change at $25^{\circ}C$ dipping temperature and reduced 7% of weight at 35$^{\circ}C$ dipping temperature. At 30% brine concentration, the weight of Yellow croaker reduced 1%, 9%, and 13% on weight at 5$^{\circ}C$, $25^{\circ}C$, and 35$^{\circ}C$, respectively. Total microbial counts in Yellow croaker muscle soaked at 30% brine showed 1 log lower numbers than 20%. The muscles had about 1 log higher microbial numbers than the treated brine solution. An ethanol extract of onion peel added to brine for giving better color and for preventing oxidation on Gulbi lipid. The treated group showed higher Land b values on Gulbi surface as well as antioxidant effect on the extracted oil.