• Journal of Environmental Science International
• /
• v.10 no.4
• /
• pp.281-286
• /
• 2001

Wastewater from the pigment industry has high levels of organics and is known as hardly biodegradable. The objective of this study is to evaluate the applicability of aerobic fixed-bed boifilm reactor packed with ceramic support carrier for the pigment wastewater treatment. Orange 2(widely used azo pigment) adsorption experiment onto biofilm and activated sludge, and continuous treatment experiments were performed. In batch adsorption experiment, maximum adsorption quantity of biofilm was at least two times higher than that of activated sludge. In continuous experiment using aerobic fixed-bed biodilm reactor, the influent concentration of COD and Orange 2 were 75~500mg/${\ell}$(0.45~3.00kg COD/$m^3.day), 5~50mg/$\ell$(0.03~0.30kg Orange 2/$m^3$.day), respectively. At a COD loading rate 2.5kg COD/$m^3$.day and Orange 2 loading rate of 0.18kg Orange 2/$m^3$.day, removal efficiency of COD and Orange 2 were over 95%, 97%, respectively.

• Korean Journal of Food Science and Technology
• /
• v.6 no.1
• /
• pp.1-5
• /
• 1974

The extraction mode of orange-yellow pigment from Gardenia is depended upon the extraction time, extraction temperature and volume of solvent. The amounts of the extracted-pigment (C) is proportional to the log ${\theta}^{1.15}$ of extraction time $({\theta}:0{\cdots}{\cdots}{\cdots}60$ min.), the log $T^{3.73}$ of extraction temperature $(T:5{\cdots}{\cdots}{\cdots}60^{\circ}C)$ and the log $S^{3.7}$ of volume of solvent $(S:5{\cdots}{\cdots}{\cdots}50ml)$ at $18^{\circ}C$ for 10 minutes. Finally, the general emperical equation was derived as follows; C=1.15 log ${\theta}$+3.73 log T+3.7 log S-7.0

• Journal of the Korean Society of Food Science and Nutrition
• /
• v.23 no.1
• /
• pp.143-149
• /
• 1994

Carotenoids isolated from orange peels were determined physicocohemical properties with TLC, UV-spectrophotometer and HPLC etc., and the results were as follows . Maximum absorption wavelength of the isolated carotenoids was 415nm when the result was similar to $\beta$-carotene as 423nm. Eight spots were obtianed from TLC, and identified lutein, lycopene, $\alpha$-carotene and $\beta$-carotene with HPLC. The effect pH during the storage period of isolate carotenoids, the period when the amount of pigment retention was over 50% in pH 5, 6 and 7 , after 10 days . The amount of pigment retention was lower in control than in treatment of sugars such as fructose, glucose and sorbitol , but sucrose was similar to the control, Isolated carotenoids were stable to ascorbic acid, and the amount of pigment retention was over 70% after 10 days. The amount of pigment retention in the effect oforganic acid was higher in treated citric acid , lactic acid and tartaric acid than in control, but lower in treated maleic acid and succinic acid. Isolated carotenoids were stable at 50 $^{\circ}C$, and the amount of pigment retention was over 50% at 10$0^{\circ}C$.

• Korean Journal of Food Science and Technology
• /
• v.7 no.1
• /
• pp.30-36
• /
• 1975

The extraction efficiency of orange-yellow pigment from the Gardenia was greatly depended upon the extraction time, extraction temperature, volume of solvent used and fat contents of the Gardenia. From the experimental results, the amounts of extracted pigment (P) was proportional to the $log\;t^{\;1{\cdot}15}$ of extraction time$(t;\;0{\sim}60\;min.)$, the $log\;T^{3{\cdot}73}$ of extraction temperature$(T;\;5{\sim}60^{\circ}C)$, the $log\;S^{3{\cdot}7}$ of volume of solvent$(S;\;5{\sim}50\;ml)$, and the -4X of fat contexts of sample $(X;\;0{\sim}0.\;15)$ at $18^{\circ}C$ for 10 minutes. Finally, the modified empirical equation was derived as follow; $P{\simeq}1.15\;log\;t+3.73\;log\;T+3.7\;log\;S-4X-6.4$ In addition to that, the most optimum conditions of pigment extraction were determined as 30 minutes of operation time, $40^{\circ}C$ of temperature. Deffated Gardenia was more productive than natural Gardenia in the pigment extraction.

• Journal of Applied Biological Chemistry
• /
• v.60 no.3
• /
• pp.249-256
• /
• 2017

The Monascus azaphilone (MAz) pigment is a well-known food colorant that has yellow, orange and red components. The structures of the yellow and orange MAz differ by two hydride reductions, with yellow MAz being the reduced form. Orange MAz can be non-enzymatically converted to red MAz in the presence of amine derivatives. It was previously demonstrated that mppE and mppG are involved in the biosynthesis of yellow and orange MAz, respectively. However, ${\Delta}mppE$ and ${\Delta}mppG$ knockout mutants maintained residual production of yellow and orange MAz, respectively. In this study, we deleted the region encompassing mppD, mppE and mppG in M. purpureus and compared the phenotype of the resulting mutant (${\Delta}mppDEG$) with that of an mppD knockout mutant (${\Delta}mppD$). It was previously reported that the ${\Delta}mppD$ strain retained the ability to produce MAz but at approximately 10% of the level observed in the wildtype strain. A chemical analysis demonstrated that the ${\Delta}mppDEG$ strain was still capable of producing both yellow and orange MAz, suggesting the presence of minor MAz route(s) not involving mppE or mppG. Unexpectedly, the ${\Delta}mppDEG$ strain was observed to accumulate fast-eluting pigments in a reverse phase high-performance liquid chromatography analysis. A LC-MS analysis identified these pigments as ethanolamine derivatives of red MAz, which had been previously identified in an mppE knockout mutant that produces high amounts of orange MAz. Although the underlying mechanism is largely unknown, this study has yielded an M. purpureus strain that selectively accumulates red MAz.

• 한국생물공학회:학술대회논문집
• /
• 2000.11a
• /
• pp.321-324
• /
• 2000

The Effect of pH red pigment production by Monascus purpureus ATCC 16365 has been studied in pH-controlled batch fermenter culture. A maximum of yellow and red pigments were detected using UV-Vis spectrophotometer at 385nm and 495nm, respectively. Fungal growth and pigment production were favoured at low pH(pH 4.0-5.5). Especially extracellular formation rate of orange to yellow pigment was decreased compared with that of orange to red pigment at pH 7.0. In addition, the enhancement of ratio of extracellular to intracellular pigment and the red pigment production in pH 7.0-controlled batch fermenter was observed. However, the pH 7.0-controlled batch cultures depressed the total production of pigments. The pH change from 4.0 to 7.0 during batch fermenter cultivations sharply increased both red pigment production and the extracellular composition.

• Korean Journal of Microbiology
• /
• v.41 no.2
• /
• pp.130-134
• /
• 2005

Isolation of a pigment overproducing mutant, P-57, by ultraviolet irradiation of Monascus purpureus KCCM 60016 and investigation of the optimal conditions for pigment production of the mutant were carried out. P-57 mutant produced pigment on solid state culture. Unpolished rice was the best cereal source for pigment production among eight kinds of tested cereal sources for the solid culture of the mutant. The optimal culture condition for pigment production were obtained from the cultivated at $30^{\circ}C,\;90\%$ humidity for 30 days. The P-57 mutant strain showed the best pigment productivity of 160.0 unit at red pigment, 193.6 unit at orange pigment, and 141.6 unit at yellow pigment on solid state culture under optimal condition.

• Proceedings of the Korean Aquaculture Society Conference
• /
• 2003.10a
• /
• pp.71-71
• /
• 2003

This study was conducted to investigate effects of dietary pigment sources on shell color of juvenile abalone, Haliotis discus hannai. Three replicate groups of the abalone, average weight 173 mg, were fed the diets containing various pigment sources such as Porphyra powder, Spirulina, yeast astaxanthin and paprika extract for 16 weeks. Survival and weight gain were not affected by dietary pigment sources (P>0.05). Shell color of abalone fed diets containing Porphyra powder and Spirulina was approached to yellow-red and orange which are similar to shell color of wild abalone. However, shell color of abalone fed the diets containing yeast astaxanthin and paprika extract were similar to that of control diet showing bright green. Porphyra powder and Spirulina contain not only fat-soluble pigment such as chlorophyll and carotenoids but also water-soluble pigment such as phycoerythrin and phycocyanin. These results would be useful information to change shell color of abalone in aquaculture.

• Journal of the Korean Crystal Growth and Crystal Technology
• /
• v.26 no.5
• /
• pp.181-187
• /
• 2016

In this study, new composition of orange color pigment was developed by replacing formerly used lead and chromium with environment-friendly elements. $TiO_2-SnO-ZnO$ composite was synthesized using the solid state reaction under the reducing atmosphere with the LPG and air mixture gas. The synthesized pigments were characterized by spectrophotometer, X-ray Diffraction (XRD), Scanning Electron Microscopy (SEM) and X-ray Photoelectron Spectroscopy (XPS). The colorimetric analysis of pigments exhibited color values ranging from yellow to orange-red. Five different crystalline phases were formed after the heat treatment for 4 and 6 hours. The color of pigments was strongly influenced by the crystalline structure of $SnO_2$, having either cubic or tetragonal structure. The oxidation state study of elements revealed that the color of pigment is getting close to rYR with the increase of $Sn^{4+}$ ratio.

• Journal of Korea Technical Association of The Pulp and Paper Industry
• /
• v.35 no.1
• /
• pp.48-53
• /
• 2003

The objective of this study was to find in what color Korean handmade paper(Hanji) is dyed when it is dyed with a pigment extracted from waste onion peelings using different kinds of mordant, and how the paper is discolored and variety of strength under the condition of accelerated aging test. The results of this experiment are as follows. 1. Korean handmade paper was dyed in different colors according to the kinds of mordant. Mainly it was dyed in orange-brown, and sometimes in gold or khaki. 2. Korean handmade paper dyed was not discolored much, which suggests that the pigment is strong under the condition of aging. 3. As for durability, Korean handmade paper dyed in gold was strongest. Korean handmade paper, to which aluminum sulfate, iron sulfate or sodium dichromate was applied as mordant, had poor durability. Thus, these were not suitable as mordant.