• Journal of Korea Society of Waste Management
• /
• v.35 no.8
• /
• pp.731-743
• /
• 2018

This study was performed to test the feasibility of thermophilic ($55^{\circ}$) co-digestion of municipal sewage sludge and food wastes. The management variables of co-digestion were the mixed ratios of municipal sewage sludge and food waste hydraulic retention times (HRTs). During the operation of thermophilic co-digestion, the reactor pH ranged from 7.0 to 7.5 and the reactor alkalinity remained above 3,200 to 4,000 mg/L as $CaCO_3$. The volatile fatty acids concentration increased as the HRT shortened from 20 days to 10 days and the mixture ratio increased to 1:4, but did not reach toxic levels for co-digestion of sewage sludge and food wastes. Methane productivity increased gradually as the organic loading rate increased. Maximum methane productivity reached 1.03v/v-d at an HRT of 10 days and at the mixture ratio of 1:4. The TVS removal efficiency decreased from 70.6% to 58.3% as the HRT shortened from 20 days to 10 days. TVS removal efficiency ranged from 57.0% to 77% during the entire operation. It is likely that thermophilic co-digestion of sewage sludge and food wastes is a very effective method both to environmentally treat food waste and to economically produce gas for energy.

• Journal of Environmental Health Sciences
• /
• v.29 no.4
• /
• pp.35-41
• /
• 2003

The objective of this study was investigate the generation rates, composition, proportion and calorific values each of material in the municipal solid wastes as well as the effect of incineration residual leachate on the environment in Yangsan sanitary landfill site. The results were as follows ; The annual average generation rate of municipal solid wastes in Yang-san is approximately 2.0 kg/cㆍd. The weight percent of combustible matters is on average 78∼87% and the lower heating values of municipal solid wastes is measured to be more than 2,151 kcal/kg after removing the briquette component. The food waste was major source of solid wastes in Yang-san city as 35% and its variation by seasons was negligible. Combustible part was larger than incombustible part of the domestic solid wastes in spring and summer. It is recommended that municipal solid wastes be treated by multiple methods such as the sanitary landfill, resources and recovery, composting and incineration.

• Proceedings of the Korean Environmental Health Society Conference
• /
• 2001.04a
• /
• pp.19-25
• /
• 2001

Recently in Korea, treatment and disposal of organic wastes have being the mostimportant is sue due to governmental strong regulation of landfill banning Especially the sewage sludge and food wastes will be restricted from the direct landfilling, after the year 2003 and 2005 respectively. Thus the considerable change in treatment methods of organic wastes is founded to transfer toward recycling the organic wastes, In these trends. vermicomposting is being enlightened newly in Korea. In November of 1999. the first symposium focusing the organic waste treatment using the earthworm was held with attending many peoples including earthworm company, experts. and professors. In that symposium, it was reported that the vermicomposting plants treating organic wastes had increased to about 80 plants and had treated about 110,000 tons per year in Korea Many local governments and companies showed the interest in vermicomposting of organic wastes and needed the collaboration with each other and foreign countries. In for reclamation materials, the extraction of some medical drugs from earthworm was expanding the research and development fields, In this paper, the history of vermicomposting in Korea was reviewed and the present stanls and future aspect were showed.

• Journal of the Korea Organic Resources Recycling Association
• /
• v.9 no.1
• /
• pp.49-55
• /
• 2001

For the production of probiotic feed enriched with viable yeasts, aerobic liquid culture of Kluyveromyces marxianus was attempted in pulverized residual food wastes. After the preliminary shaking culture result, the liquid food wastes was added with urea($0.5g/{\ell}$), o-phosphate($0.4g/{\ell}$ ), molasses($4g/{\ell}$), and yeast extract($1g/{\ell}$), and the fermentation was carried out in 2-litre jar fermenter. In 12 hours of aerobic mixed culture with Aspersillus oryzae, viable cell count of the yeast reached to the number of $1.4{\times}10^{10}/{\ell}$ in the cultured medium.

• Microbiology and Biotechnology Letters
• /
• v.37 no.1
• /
• pp.85-89
• /
• 2009

For the purpose of the methodological development to convert the food wastes into resources, we have attempted to culture the mushroom hypha, Pleurotus ostreatus. The food-wastes were mixed with distilled water, and the mixture was autoclaved to produce fluid, which was centrifugated and used as the growth media. Concentrations of the food wastes extracts were prepared with 10, 20, 30, 40, and 50%(W/V), and the initial pH were set variously with 4, 5, 6, and 7. These were cultured for 9 days at the temperature of $25^{\circ}C$ and the rotation rate of 120 rpm. The result is that the fluid form of the mushroom hypha have been grown best at the concentration of 30% and the optimal pH was 5 and 6.

• KSBB Journal
• /
• v.22 no.2
• /
• pp.114-118
• /
• 2007

In this study, an amylase-producing fungus, strain 15 was isolated from soil in order to saccharify food wastes with cellulolytic and amylolytic enzymes. The amylase production cultures were performed in Mandel's medium with 1% rice straw and 1% paper wastes as carbon sources. The strain produced various cellulolytic (FPase 0.25, xylanase 20.09, CMCase 3.15 U/mL-supernatant) and amylolytic ($\alpha$-amylase 1.20, gluco-amylase 0.70, $\beta$-amylase 2.40 U/mL-supernatant) enzymes in Mandel's medium. In 10 L jar fermenter, maximum amylase and FPase activities, 3.25 and 0.23 U/mL, were obtained when the culture was grown at 30$^{\circ}C$, 200 rpm and 0.6 vvm for 3 days. In 100 mL flask level and 10 L jar fermenter, amylase produced by the strain 15 showed similar cellulolytic and amylolytic enzyme activities with Trichoderma inhamatum KSJ1 isolated from rotten woods by previous researcher. The ability of saccharification to food wastes also showed similar degree. However, the isolate 15 appeared to be yellowish in YMEA plate comparing to Trichoderma inhamatum KSJ1 in greenish.

• Journal of the Korea Organic Resources Recycling Association
• /
• v.9 no.4
• /
• pp.125-134
• /
• 2001

The purpose of this study is to provide basic information for a future countermeasure municipal and to establish several wastes policy after investigating solid wastes from Sunchon City. In addition, this research can be supported to manage of recycling plant and to reuse plant of each wastes. Results are as bellows after checking up and analysis type of waste in Sunchon city Unit solid waste generation rate from single family is $0.50kg/person{\cdot}day$, and total solid wastes are 41.9ton/day. Unit solid waste generation rate from apartments is $0.45kg/person{\cdot}day$, and solid wastes generation is 55.5ton/day. Unit solid waste generation rate from agricultural is $0.22kg/person{\cdot}day$ and total solid wastes are 13.5ton/day. That show total amount of municipal solid wastes from residential are 110.9ton/day. Unit solid waste generation rate from traditional markets is $1.85kg/person{\cdot}day$, and solid waste total volume is 5,400kg/day. Unit solid waste generation rate from small store is $2.03kg/person{\cdot}day$, and solid waste total are 25,101kg/day. Therefore, this show that total wastes are 30.50kg from downtown and commercial area. Solid waste quantity from Industrial area (Factory region) is 8.5ton and in case of school and hospitals are 7.2kg/day and 3.0kg/day. Solid waste amount from Institutional is 6.6kg/day. Food wastes were eliminated from municipal solid wastes as standard 63.4ton/day, and combustible wastes were 126.9ton/day. If it schedule about 5 years (by 2006) as durable year for food wastes treatment plant, it is expected 42.5ton/day for treatment capacity. We can judge that it is effective to be set 2 lines equipment ${\times}25ton/day$ as treatment ability under considering unexpected working condition such as any repair, trouble and an electrical load. If it schedule about 10 years (by 2011) as durable year for food wastes treatment plant, it is expected 150 ton/day for treatment capacity. We can conclude that it is effective to be set 2 lines equipment ${\times}80ton/day$ as treatment ability under considering working condition such as low loaded operating and the repair for incineration.

• 한국생물공학회:학술대회논문집
• /
• 2003.04a
• /
• pp.374-377
• /
• 2003

The purpose of this study was to investigate the characteristics of anaerobic methane fermentation using several organic wastes. The substrates used in this study were food wastes, vegetable wastes, and cow manure. The substrates were mixed with inocula (mixed methanogenic fluid) at a ratio of 1:1, and several parameters such as TS, VS, sCOD, and biogas production have been monitored. Anaerobic degradation of food wastes were occurred in the intial stage of cultivation, whereas that of vegetable wastes were occurred in the late stage. However, in case of cow manure, the degradation was occurred two times both in the intial and the late stage of reaction.

• Journal of Distribution Science
• /
• v.15 no.10
• /
• pp.29-39
• /
• 2017

Purpose - The purpose of this study is to promote sales of the renewable energy industry and to advance into the Southeast Asian market. Research design, data, and methodology - This study is to develop a highly efficient food waste treatment system for Southeast Asian renewable energy industry. The radiation treatment method was applied for this purpose. Results - To investigate effects of ionization on removal of non-degradable organic matter, the results from gamma irradiation and co-digestion process was compared to those from a co-digestion process. Based on the BMP test results, food wastes were oxidized by hydroxyl radicals, and the specific methane yield was 366 mL CH4/g VS. Methane composition was 82%. A WAS/food wastes co-digestion was developed for the treated of non-degradable organic matter in food wastes. The average efficiency of non-degradable organic matter were 92.2% using the food waste co-digestion. Conclusions - Performance of gamma irradiation and co-digestion process was superior to that of a co-digestion process (10-20%). This implies that food wastes can be high efficient co-digested by the gamma irradiation. It is believed that it will be possible to enter the Southeast Asian energy industry as a strategic technology in the overseas energy recovery industry.

• Food Science of Animal Resources
• /
• v.24 no.3
• /
• pp.216-220
• /
• 2004

To investigate the effect of feeding the fermented food wastes (FFW) on meat quality, twenty pigs produced from four treatments with different mixing rates of FFW [100% concentrate (control), 25% replacement with FFW (25% FFW), 50% replacement with FFW (50% FFW) and 100% fermented food wastes (100% FFW)] were slaughtered. Carcass characteristics were differentiated if FFW replacement rate was higher than 50%. The proximate compositions of hams and loins in control pigs were not different from (p>0.05) those of the FFW replacements, regardless of mixing rate of FFW replacement. Drip loss of pork loin increased (p<0.05) with increased rate of FFW replacement. Hunter color values were affected (p<0.05) by the FFW replacement and storage time, while not significantly changed (p>0.05) when replaced with lower than 25% FFW. With replacing more than 50% FFW, redness values tended to be decreased, while yellowness values increased. Aerobic plate counts (APC) were rapidly increased 12 d for the control and 8 d for FFW replacement, and microbial stability seemed to be lowered when the rate of FFW replacement rate was more than 50%. These results indicated that the replacement of concentrate diets with FFW was still nutritious feedstuffs for pig diet, however, no more than 50% FFW replacement was recommended to have similar effect to those with the control (100% concentrate).