• Korean Chemical Engineering Research
• /
• 제47권2호
• /
• pp.190-194
• /
• 2009

In this study sodium dodecyl sulfate (SDS), which was anionic surfactant, was added for forming micelles to remove iron ion that could be contained with small amount in industrial water. Then aggregates binding between iron ions and micelles were rejected by a ceramic microfiltration membrane. As result of SDS concentration effect on removal rates of iron and SDS in modified iron solution, the removal rate of iron was the highest value of 92.26% and the removal rate of SDS was 61.10% a little higher than the result of calcium ion at 8 mM which was CMC (Critical micelle concentration) of SDS. As final resistance of membrane fouling $R_f$ increased the more at the higher SDS concentration, it showed the highest value at 4 mM and the lowest at 10 mM of SDS. The final permeate flux $J_{180}$ had the highest value and the largest total permeate volume could be finally acquired at SDS 10 mM. In case of CMC 8 mM, low $R_f$ was shown as same as that of 10 mM until 80 minutes of operation, and tended to increase dramatically to 120 minutes and increase slowly again until 180 minutes.

• Korean Chemical Engineering Research
• /
• 제56권1호
• /
• pp.24-28
• /
• 2018

The redox flow battery (RFB) is a large-capacity energy storage equipment, and the vanadium redox flow cell is a typical RFB, but VRFB is expensive. Iron-chrome RFBs are economical because they use low-cost active materials, but their low performance is a urgent problem. In this study, the crossover of iron and chromium ion through Nafion membrane and the stability of Nafion membrane in HCl solution were investigated. The permeability of iron and chrome ion through Nafion were $5.5{\times}10^{-5}$ and $6.0{\times}10^{-5}cm^2/min$, respectively, which was 18.9~20.7 times higher than that of vanadium ion ($2.9{\times}10^{-6}cm^2/min$). The crossover of iron and chromium ions were shown to be a cause of performance decrease in Iron-chrome RFB. As the temperature increases, the crossover increases rapidly (activation energy 38.8 kJ/ mol), indicating that operation at low temperature is a methode to reduce the performance loss due to crossover. Nafion membranes were relatively stable in 3 M HCl solution.

• Proceedings of the Korean Vacuum Society Conference
• /
• 한국진공학회 1994년도 제6회 학술발표회 논문개요집
• /
• pp.120-121
• /
• 1994

• Proceedings of the Korean Vacuum Society Conference
• /
• 한국진공학회 2009년도 제36회 동계학술대회 초록집
• /
• pp.202.2-202.2
• /
• 2009

• Bulletin of Korea Environmental Preservation Association
• /
• 제12권13호
• /
• pp.30-37
• /
• 1990

• Proceedings of the Korean Vacuum Society Conference
• /
• 한국진공학회 2008년도 제34회 동계학술대회 초록집
• /
• pp.370-370
• /
• 2008

• Proceedings of the Korean Institute of Resources Recycling Conference
• /
• 한국자원리싸이클링학회 2006년도 춘계임시총회 및 제27회 학술발표대회
• /
• pp.105-109
• /
• 2006

본 연구는 Karr column을 이용하여 희토류 염화물 수용액상에서 비희토성분인 철의 분리에 대한 기초 연구로서, 아민계 추출제인 Alamine336을 이용하여 염화물 수용액상에서 유기상의 농도, 염소이온 농도, 염산 농도에 따른 철 성분의 분리특성을 파악 하였다. Batch 실험결과 추출제 농도가 증가함에 따라 철성분 제거율이 급격히 상승하였으며, 염산 및 염소이온 농도의 경우도 유사한 결과를 나타내었다. Batch 실험을통해 확인된 불순물(Fe)을 추출하기위한 최적 조건은 염산농도 2M, 추출제 농도 0.1M, 상비 1, 추출시간 30분으로서, 이때 희토류 염화물 수용액상의 철 성분 함량은 0.7ppm 이하로서 제거율은 99.9%였다. 또한 최적의 batch 실험조건에서 반응시간(=체류시간)을 변화시키며 실험한 결과, 반응시간 60분의 조건에서 batch 실험과 유사한 결과를 얻을 수 있었다.

• Proceedings of the Korean Institute of Electrical and Electronic Material Engineers Conference
• /
• 한국전기전자재료학회 2004년도 하계학술대회 논문집 Vol.5 No.2
• /
• pp.790-793
• /
• 2004

이중의 망간 perovskite 블록을 가진 Ruddlesden-Popper 상(R-P phase) $Sr_3Mn_2O_7$ 은 공기중에서 불안정하다. 본 연구에서는 망간 이온 자리에 철 이온을 소량 치환 함으로써 R-P 상을 안정화 시켰으며 이들의 결정구조는 X-선회절 데이터를 이용하여 Rietveld 법으로 정밀화하였다. 안정화에 필요한 Fe 이온의 양은 약 x=0.15로 나타났으며 Fe이온의 양이 증가함에 따라 쉽게 안정화 되었다. 자화율 측정결과 x=0.20 시료는 120K에서 paramgnetic-antiferromagnetic 전이를 나타내었고 이 전이 온도는 치환되는 Fe이온의 양이 증가함에 따라 감소하는 경향을 나타내었다.

• Proceedings of the KIEE Conference
• /
• 대한전기학회 2002년도 하계학술대회 논문집 C
• /
• pp.1612-1614
• /
• 2002

본 논문에서는 엑시머 레이저 조사에 의한 이온 농도의 분포 변화를 알아보기 위해 붕소 이온이 선택적으로 주입된 비정질 실리콘 박막 위에 XeCl (${\lambda}$=308nm) 엑시머 레이저를 조사하여 붕소이온의 수평 확산 현상을 관찰하였다. 도핑 농도의 분포를 알아보기 위해 불산/질산 용액에 의한 고농도 도핑 영역의 습식 식각을 이용하여 약 $10^{18}/cm^3$ 이하의 붕소이온을 가지는 실리콘 박막의 형태를 전자주사 현미경을 이용해서 관찰하였다. 실험 결과, $200mJ/cm^2$의 레이저 에너지가 조사될 경우, 약 100nm의 수평 확산이 일어났음을 확인 할 수 있었다.

• Resources Recycling
• /
• 제2권2호
• /
• pp.1-8
• /
• 1993

This study was carried out in order to define the effective collectors and the opitimum conditions for the removal of iron ion in waste water by flotation method. The results obtained in this study are summarized as follows. Fe(II) and Fe(III) were removed effectively at pH7 and 6 respectively by using sodium lauryl sulfate, an anionic collector. The anionic collector, aeropromotor 845, removed both Fe(II) and Fe(III) effectively in pH ranges of from 5 to 9. The cationic collector, trimetyl dodecyl ammonium chloride, removed both Fe(II) and Fe(III) effectively in pH ranges from 10 to 11 and from 4 to 10, respectively. Therefore, Fe(II) and Fe(III) could be effectively removed by forming the iron hydroxide precipitates by simple pH adjustment of the solutions above precipitation point of ferrous and ferric ion by flotation method. Then, the effective pH regulator and collector were NaOH and $Na_2CO_3$,aeropromotor 845 and trimetyl dodecyl ammonium chloride, respectively.