• Korean Journal of Food Science and Technology
• /
• v.33 no.1
• /
• pp.60-65
• /
• 2001

Physicochemical properties of 4 kinds of domestic and 7 kinds of foreign starch vermicelli (1 from Chinese, 6 from Japan) were determined. Peak temperature of starch vermicelli measured by DSC were $42{\sim}48^{\circ}C$ which were much lower than gelatinization temperatures of their raw material starches. X-ray diffraction peaks of starch vermicelli were not sharp compared with those of raw material starches which indicated that starches were gelatinized by heating and retrograded by cooling and freezing during production of starch vermicelli. Hardness and compression slope of sweet potato starch vermicelli measured by rheometer were respectively $9,500{\sim}11,000\;g/cm^2$ and $18,000{\sim}26,000\;g/cm^2$ which were twice higher than those of corn starch vermicelli. Cooking loss of corn starch vermicelli, which was 19.8%, was higher than that of sweet potato starch vermicelli, $4.2{\sim}6.6%$ and mung bean starch vermicelli, 7.7%. In changes of thickness of starch vermicelli during cooking i.e swelling ratio, sweet potato starch vermicelli had $58{\sim}69%$ of swelling ratio, which was higher than that of corn starch vermicelli, 50%. Corn starch vermicelli, which was relatively less elastic and easily broken, was shown to be inferior to that of sweet potato starch vermicelli in overall quality.

• Journal of Drive and Control
• /
• v.20 no.2
• /
• pp.40-46
• /
• 2023

Fresh corn, one of the main food crops, must be harvested by hand. A harvest mechanization technology is required. In this study, a tractor-attached harvester was designed and manufactured to sequentially perform stem reaping, fresh corn detaching, and collecting. The(harvester was designed so that the main device could operate through a hydraulic pump and a generator could be operated through the tractor's PTO. Factor tests were conducted according to cultivars (Ilmichal, Super sweet corn) and working speed (0.12 m/s, 0.17, 0.22). After the factor test, detached corns ratio, collected corns ratio, and damaged corns ratio were analyzed and harvest performance was evaluated. Harvesting performance was good for super sweet corn. Considering operation efficiency, 0.22 m/s was judged to be an appropriate working speed. It was found that it took two hours to work an area of 10 a.

• KOREAN JOURNAL OF CROP SCIENCE
• /
• v.47 no.4
• /
• pp.305-310
• /
• 2002

The performance of 7 sugary (su) and 12 shrunken-2 (sh2) sweet com hybrids which are commercially grown in the United States was tested in Korea. The 100-seed weight of su hybrids (16.5-23.6 g) was much heavier compared to that of sh2 hybrids (10.9-17.5 g). The germination rate of su and sh2 hybrids at $25^{\circ}C$ ranged 93.3-100% and 86.7-98.9%, the emergence rate of su and sh2 hybrids in cold test ranged 78.9-97.8% and 62.2-97.8%, and field emergence rate of su and sh2 hybrids ranged 74.4-100.0% and 79.9-98.2%, respectively. In su hybrids, there was a significantly positive correlation between germination rate at $25^{\circ}C$ and emergence rate in cold test or early growth. In contrast, in sh2 hybrids seed weight was positively correlated with early plant growth, while not with the germination rate at $25^{\circ}C$ or emergence rate in cold test and field. Most sh2 hybrids produced larger and more marketable ears compared to su hybrids although there were significant differences among the hybrids in the same genotype. At harvest (24 days after pollination) soluble solids content of su hybrids (24.3-27.1 Brix %) was much higher than that of sh2 hybrids (13.8-18.0 Brix %), while total sugars of sh2 hybrids (21.4-28.6% on the dry weight basis) was much higher compared to su hybrids (2.4-15.9%). Considering germination and emergence rates, marketable ear production, and total sugar content, 'GCB 70' and 'Sweet Satin' in su hybrids and 'Ice Queen', 'Aspen', 'Sweet Magic', 'Bandit', 'Xtrasweet 82', 'Aspen', and 'Cambella 90' in sh2 hybrids performed better than other hybrids.

• Proceedings of the Korean Society of Crop Science Conference
• /
• 2005.04a
• /
• pp.168-169
• /
• 2005

• Korean Journal of Food Science and Technology
• /
• v.33 no.3
• /
• pp.313-318
• /
• 2001

Physicochemical properties of starch vermicelli (Dangmyun) made with different starches in laboratory were determined to develop a modified corn starch comparable to sweet potato starch which is highly expensive than corn starch but commonly used for starch vermicelli in Korea. Initial temperatures (Ti) of gelatinization of starch vermicelli made in laboratory measured by differential scanning calorimeter, which were above $60^{\circ}C$, were higher than those of starch vermicelli in the market. Their X-ray diffraction peaks were relatively sharp compared with those of starch vermicelli in the market, which showed that starches were not completely gelatinized during the process of starch vermicelli preparation in laboratory. Initial temperature (Ti) of corn starch vermicelli was decreased by $3^{\circ}C$ by hydroxypropylation but increased by $2.5^{\circ}C$ by oxidation. Hardness and compression slope of sweet potato starch vermicelli and mungbean starch vermicelli, which were $11,726{\sim}12,555\;g/cm^2$ and $29,914{\sim}30,604\;g/cm^2$, respectively, were the highest in the samples and those of waxy corn starch were lowest. Hardness and compression slope of starch vermicelli made with corn starch slightly oxidized in the concentration of 0.5% NaOCl at pH 9.0, $40^{\circ}C$ for 30 min. increased and found to be comparable to those of sweet potato starch vermicelli.

• KOREAN JOURNAL OF CROP SCIENCE
• /
• v.50 no.2
• /
• pp.97-104
• /
• 2005

Mass selection (MS) is an efficient selection method to directly improve highly heritable traits. In the present study, two cycles of MS for ear length were conducted on two sweet corn populations, BC2-l0 and $BC1-10{\times}Syn-II$ after introgression of exotic germplasm. The improved populations generated from these selections were evaluated in comparison with the base populations at two locations, to determine the genetic gains and performance of the improved populations. The two base populations showed varied average realized responses to MS. In BC2-l0 derived population, the realized responses were $9.1\%$ in BC2-l0 C1 and $1.2\%$ in BC2-l0 C2, whereas in$BC1-10{\times}Syn-II$ derived population, the realized responses were$ 5.6\%$ in $BC1-10{\times}Syn-II$ C1 and $2.9\%$ in $BC1-10{\times}Syn-II$ C2. All the improved populations showed longer ears than their respective base populations and the check varieties. Ear length, which was used as the selection criterion in this study, showed high broad-sense heritability in the BC2-l0 and $BC1-10{\times}Syn-II$ derived populations, while fresh ear yield revealed low heritability, indicating that selection for ear length in these populations would be more effective than direct selection for yield. Results of this study indicate that MS conducted on BC2­10 and $BC1-10{\times}Syn-II$ had significantly increased ear length and fresh ear yield in both populations. The improved populations obtained would serve as better germplasm sources and further selection in these populations could offer better responses.

• The Korean Journal of Food And Nutrition
• /
• v.27 no.1
• /
• pp.112-119
• /
• 2014

Ohmic heating uses electric resistance heat which occurs equally and rapidly inside food when the electrical current is transmitted into. Prior to the study, we have researched the potato starch's thermal property changes during ohmic heating. Comparing with conventional heating, the gelatinization temperature and the range of potato starch treated by ohmic heating are increased and narrowed respectively. Herein, we have studied thermal property changes of wheat, corn, potato and sweet potato starch by ohmic heating as well as conventional heating. And then we measure the water holding capacity of starches. Annealing of starch is a heat treatment method heated at 3~4% below the gelatinization point. This treatment changes the starch's thermal property. In the DSC analysis of this study, the $T_o$, $T_p$, $T_c$ of all starch levels have increased, and the $T_c$-$T_o$ narrowed. In the ohmic heating, the treatment sample is extensively changed but not with the conventional heating. From the ohmic treatment, increases from gelatinization temperature are potato ($8.3^{\circ}C$) > wheat ($5.3^{\circ}C$) > corn ($4.9^{\circ}C$) > sweet potato ($4.5^{\circ}C$), and gelatinization ranges are potato ($7.9^{\circ}C$), wheat ($7.5^{\circ}C$), corn ($6.1^{\circ}C$) and sweet potato ($6.8^{\circ}C$). In the case of conventional treatment, water holding capacity is not changed with increasing temperature but the ohmic heating is increased. Water holding capacity is related to the degree of gelatinization for starch. This result show that when treated with below gelatinization temperature, the starches are partly gelatined by ohmic treatment. When viewing the results of the above, ohmic treatment is enhanced by heating and generating electric currents to the starch structure.

• Korean Journal of Food Science and Technology
• /
• v.5 no.1
• /
• pp.6-15
• /
• 1973

In an attempt to develop composite flours based on raw materials available in Korea, six domestic resources were investigated with respect to their physical and chemical properties, nutritive value and economy. The results are summarized as follows: 1) Flours from naked barley, sweet potato, potato, corn, defatted rice bran and defatted soybean were compared in respect of their proximate composition, thiamine content and protein score. 2) In color comparison, naked barley and defatted soy flours were comparable to wheat flour whereas corn and sweet potato flours were a little inferior. In raising power, naked barley and defatted soy flours were similar to wheat flour and others were inferior. 3) In maximum viscosity of flours by amylograph, naked barley, corn and potato flours were higher than wheat flour and others were lower. In viscosity in cooling, corn flour was similar to wheat flour and naked barley and potato flours were lower. Addition of $10{\sim}20%$ defatted soy flour into other flours generally caused the lowering of viscosity. Addition of emulsifiers such as glyceryl monostearate, calcium stearyl lactylate, Methocel and Emulthin into the flours manifested different effects on the amylogram. 4) In nutritional test by rat, diets consisting of naked barley, sweet potato, potato or corn flours, each containing defatted soy flour (at 10% level with exception of 20% for sweet potato flour) and naked barley flour fortified with lysine were similar to wheat flour in digestibility, but were superior in NPU and biological value. 5) In price estimation, sweet potato and corn flours were competitive with wheat flour, but naked barley flour was a little expensive. On the other hand, barley and sweet potato are promising in terms of domestic production.

• KOREAN JOURNAL OF CROP SCIENCE
• /
• v.51 no.7
• /
• pp.632-638
• /
• 2006

Characteristics of sweet (sugary, su) and super sweet (shrunken-2, sh2) corn seeds shelled by different threshing methods at different moisture content status were studied. Hybrid seeds of a su (Early Sunglow ${\times}$ Golden Cross Bantam 70, GCB 70) and a sh2 (Xtrasweet 82 ${\times}$Fortune) were dried to moisture content of 12, 15, 18, and 21%. Hand shelling did not give any mechanical damages to seeds, while an electrical corn thresher gave some visible mechanical damages. The emergence rate of hand shelled seeds was higher than that of machine shelled seeds by $6{\sim}14%$ for a su and by $9{\sim}18%$ for a sh2 hybrid depending on seed moisture contents in cold test. The optimum seed moisture content to reduce mechanical threshing damages and to improve seed quality was 15% for su and 12% for sh2 hybrid seeds. At the optimum seed moisture contents, germination rate at $25^{\circ}C$, emergence rate in the cold test and ${\alpha}-amylase$ activity were highest, while the percentage of damaged seeds and leakage of total sugars and electrolytes in soaking water were minimized.

• Korean journal of food and cookery science
• /
• v.19 no.6
• /
• pp.772-776
• /
• 2003

This study was performed to determine the quality characteristics of lemon pyun with various kinds of getting agents: agar, gelatin, sweet Potato starch, corn starch and Potato starch. Lemon Pyun was made with lemon juice(21.4％), gelling agent(6.7％), water(53.3％), sugar(13.3％) and honey(5.3％). The quality characteristics of the sample were estimated in terms of pH, color difference, texture profile analysis and sensory evaluation. (Ed- as this is an abstract this introductional clause is unnecessary) The PH of lemon pyun showed no significant difference among the different gelling agents. Lightness was significantly(p＜0.05) lowered in the agar and gelatin groups, a value was significantly(p＜0.05) lowered in the sweet potato starch and potato starch groups, and b value was significantly(p＜0.05) lowered in the sweet potato starch group. In texture profile analysis, chewiness, gumminess and hardness were significantly(p＜0.05) increased in the sweet potato starch group. According to sensory evaluation, elasticity and hardness of the sweet potato starch and cornstarch groups were stronger(p＜0.05) than of other gelling agent groups. Lemon pyun containing sweet potato starch was most preferable in terms of Vitamin C provision.