• Journal of the Korean Society of Food Science and Nutrition
• /
• v.40 no.5
• /
• pp.738-746
• /
• 2011

We manufactured rice-whole soybean curd by a microbial transglutaminase (MTGase) with a mixture of hydrolyzed rice and micronized whole soybean powder (MWSP) and analyzed its rheological properties, including texture, viscoelasticity, protein cross-linking, and surface structure. A 40% rice suspension digested with a Termamyl enzyme at $85^{\circ}C$ for 20 min showed a 9.0% reducing sugar and a consistency of $1.27\;Pa{\cdot}s^n$, resulting in a great reduction in consistency. A MWSP suspension with 22% solid content was transformed into a typical tofu texture. MWSP curd fortified with 7.5% rice showed enhanced texture properties, with a hardness of 639.6 dyne/$cm^2$, and a springiness of 0.96. In a MWSP suspension (18~22% w/v) treated with 5% MTGase, viscoelasticity increased dependently with MWSP concentration, and a 22% MWSP indicated a G' value of 5.1 Pa and a G'' value of 9.0 Pa. Furthermore, soybean proteins present in the 22% MWSP curd largely disappeared or formed polymers with a high molecular weight by MTGase reaction within 30 min. MWSP (22%) fortified with 7.5% rice showed similar polymerization patterns on SDS-PAGE. The surface structure of the rice-MWSP curds was more dense and homogeneous network due to the addition of hydrolyzed rice. However, the surface structure of all rice-MWSP curds became rough and showed a non-homogeneous network after cold storage.

• Journal of the Korean Recycled Construction Resources Institute
• /
• v.8 no.3
• /
• pp.255-262
• /
• 2020

Blended cement with fly ash and bottom ash from Circulating Fluidized Bed Combustor boiler(CFBC) burned at a low temperature, can be high heat of hydration and abnormal setting caused by higher volumn contents of Fe₂O₃, free-CaO, SO₃. In this study, the ground CFBC bottom ash powder mixed with blast furnace slag was used as substitute activator of gypsum and recycled iron slag was produced from mix and pulverized by ball mill to increase the recycling rate. The effect on compressive strength of cements with the mixture of original and hydrated bottom ash mixtures with BFS with small water, respectively, was analyzed, and it was found that the hydrated bottom ash activator was more effective in initial strength development. To improve the initial strength of blended cement, an activator mixed with a blast furnace slag and bottom ash mixing ratio of 5:95 and 10:90, respectively, the slag cement by about 6%, and it was analyzed to develop an initial strength similar to gypsum as a conventional activator.

• Journal of Aquaculture
• /
• v.22 no.1
• /
• pp.100-104
• /
• 2009

This study was conducted to evaluate the effect of dietary supplementation of paprika powder as carotenoid source with three different zooplankton on carotenoid deposition and skin pigmentation of rose bitterling Rhodeus ocellatus. Two replicate groups of fish (initial average weight 0.8 g) were fed the five experimental diets containing 5% paprika (P5) and mixture of 5% paprika with 3% three zooplankton of water flea Moina macrocopa (P5M3), Artemia nauplius Artemia sp. (P5A3) and rotifer Brachionus plicatilis (P5R3) and without supplementation of carotenoid source (Con) for 10 weeks. Survival of fish among the treatments was not affected by dietary supplementation. Total carotenoid contents of whole body in fish fed the diets containing 3% zooplankton was higher than that of fish fed other diets. Especially, the highest total carotenoid contents of whole body was observed in fish fed the P5A3 diet. Similarity, Lightness, $a^*$ and $b^*$ values of the fish fed the diets containing 3% zooplankton tended to be higher than that in fish fed control and P5 diets. The apparent color intensity of skin and fin in fish fed the diets containing paprika with Artemia nauplius and rotifer was better than those of fish fed other diets. The results of this study suggest that dietary supplementation of paprika with Artemia nauplius and rotifer can improve skin pigmentation of rose bitterling.

• Journal of the Korean Ceramic Society
• /
• v.38 no.11
• /
• pp.1023-1029
• /
• 2001

Hexagonal ferrite $Co_2$Z(B $a_3$ $Co_2$F $e_{24}$ $O_{41}$ ) was prepared by various coprecipitation-oxidation methods. The formation of $Co_2$Z was studied in order to determine the optimal method. The $Co_2$Z composition hydroxides were prepared with the different oxidation and precipitation from the aqueous solution of $Ba^{2+}$, $Co^{2+}$ and F $e^{2+}$ chloride mixture. The coprecipitates were heat-treated at various temperatures, and their formation phases and microstructures were investigated from the analyses of DTA/TGA, powder XRD and SEM. The $Co_2$Z phase was observed in the case where the precursor will have the amorphous like oxyhydoxide($\delta$-FeOOH), and formed from $Ba_3$F $e_{32}$ $O_{51}$ , BaF $e_{12}$ $O_{19}$ (M-type) and $Ba_2$ $Co_2$F $e_{12}$ $O_{22}$ (Y-type). The $Co_2$Z was synthesized by the heat-treatment of the coprecipitate, which was prepared from the precipitation after oxidizing the chloride mixed solution, above 110$0^{\circ}C$.EX>.

• Journal of the Korean Society of Food Science and Nutrition
• /
• v.34 no.2
• /
• pp.298-305
• /
• 2005

Antimicrobial packaging paper was prepared with a powder-type botanical antimicrobial agent from grapefruit seed extract (BAAG) and zeolite according to TAPPI standard method. The functional fillers containing BAAG fixed to CaCO$_3$ and zeolite were well retained in the fiber network by a retention aid such as cationic polyacrylamide, which was ascertained by the ash contents of paper and the SEM microphotographs. With addition of the functional fillers to paper, tensile strength and burst strength of the paper decreased by interference of the functional fillers with interfiber bonding but bending stiffness and tear strength increased by improved elastic modulus of paper and delayed transfer of tearing energy. Finally, it was confirmed that the antimicrobial packaging paper might be able to be used to make packaging bags and corrugated containers due to the minor deterioration of strength properties.

• Korean Journal of Food Science and Technology
• /
• v.16 no.2
• /
• pp.133-138
• /
• 1984

For the purpose of improving the precooked frozen food, the processing conditions of sardine steaks and the effect of soybean protein and corn starch on quality of the products during frozen storage were investigated. Fresh sardines were purchased from Busan Central Whole Sale Market and filleted. And then sardine meats were separated from fillets by fish meat separator. The meats were mixed with 0.5% sodium bicarbonate, 1.5% of table salt and 0.2% of polyphosphate, monosodium glutamate, white pepper, garlic powder and nutmeg, respectively. The mixture was minced with the stone grinder and filled in polyvinylidene chloride film tube and then stored at $-3^{\circ}C$ for 36 hours prior to frozen storage. Sardine steaks containing 3% of soybean protein were superior to those of containing 3% of corn starch or without soybean protein and corn starch on texture and eating quality of them during the period of frozen storage. It is convinced that addition of 3% of soybean protein to the sardine steak was benefically effective for the control of free drip, oxidative rancidity and the improvement of texture. The quality of frozen sardine steaks, by sensory evaluation, were preserved in good eating quality for 90 days during frozen storage.

• Journal of the Korean Ceramic Society
• /
• v.39 no.9
• /
• pp.846-850
• /
• 2002

A PMN-PT-BT/Ag composite was prepared by surface modification with MgO sol with hoping to suppress silver's migration during sintering. The mixture of PbO, $N_2O_5,\;TiO_2\;with\;Mg(NO_3)_2$ instead of MgO was ball milled, the solvent was removed and then the dried powders were calcined at 950$^{\circ}C$/1h. The calcined powder were treated with 3.0 mol% $Ag_2O$ and 1.0 wt% MgO sol and calcined at 550$^{\circ}C$/1h. The dielectrics sintered at 1000$^{\circ}C$/4h under a flowing oxygen showed the density of 7.84g/$cm^3$, the room temperature dielectric constant of 18400, the dielectric loss of 2.4%, the specific resistivity of $0.24{\times}10^{12}{\Omega}{\cdot}cm$. It also showed the bending strength of $120.7{\pm}11.26$ MPa and the fracture toughness of $0.87{\pm}0.002\;MPam^{1/2}$ which were comparable to commercial PZT. The microstructure sonsisted of grains of ∼4${\mu}m$. SEM and SIMS analysis showed that Ag grew as ∼1${\mu}m$ and excess MgO as ∼0.5${\mu}m$.

• Journal of the Korean Ceramic Society
• /
• v.20 no.2
• /
• pp.135-146
• /
• 1983

This study is to investigate the properties of domestic fly ash for utilization as data in regard to fly ash which is by-product of domestic coal powder plants and the possibility of utilization as insulation material of domestic fly ash. Composition refractoriness size distribution density contents of hollow particles and crystalline phase were examined as the properties of domestic fly ash. As to the fired test pieces of fly ash by itself that varied contents of hollow particles with four kinds and of the fly ash-clay-saw dust system linear shrinkage bulk density app. porosity compressive strength thermal conductivity and structures were investigated for the possibility of utilization as an insulation material. The results are as follows : 1. The properties of the fly ash I) The constituent particle of the fly ash is spherical and it contains not a few hollow particles (floats by water 0.30-0.50 floats by $ZnCl_2$ aq.(SpG=1.71) 6.97-16.72%). ii) The chemical compositions of fly ash are $SiO_243.9-54.1%$ , $Al_2O_321.0-30.7%$ Ig loss is 7.4-24.1% and the principal of Ig loss is unburned carbon. iii) Fly ash was not suitable to use for mortar and concrete mixture because Ig. loss value is higher than 5% 2. Utilization as insulation material I) The test pieces of original fly ash floats by water floats by ZnCl2 aq(SpG=1.71) p, p t by ZnCl2 aq.(SpG=1.71) that were fired at 110$0^{\circ}C$ represented 0.11-0.18 kcal/mh$^{\circ}$ C as thermal conductivity value. ii) The test pieces which (76.5-85.5) wt% fly ash-(8.5, 9.5) wt% clay-(5.0-15.0) wt% saw dust system(68.0-72.0) wt% fly ash -(17.0-18.0)wt% clay-(10.0-15.0) wt% saw dust system and 59.5 wt% fly ash-25.5 wt% clay-15.0wt% saw dust system were fired at 110$0^{\circ}C$ the thermal conductivity was less than 0.1Kcal/mh$^{\circ}$ C. iii) In view of thermal conductivity and economic aspect insulation materials which added saw dust as blowing agent and clay as inorganic binder are better than that of fly ash as it is or separated hollow fly ash particles. iv) When the saw dust contents increased in the (59.5-90.0) wt% saw dust system and when amount of clay de-creased and firing temperature decreased under the condition of equal addition of saw dust app. porosity increased but bulk density compressive strength and thermal conductivity decreased.

• The Korean Journal of Food And Nutrition
• /
• v.30 no.4
• /
• pp.710-718
• /
• 2017

Contents of water soluble vitamin $B_6$ in a total of 62 agricultural products cultivated in local areas in Korea were analyzed by high performance liquid chromatography with fluorescence detector (HPLC/FLD). To verify the method of vitamin $B_6$ analysis, a quality control chart was formulated with in-house control using a mixture of broccoli and shiitake mushrooms. Among cereals, high content of vitamin $B_6$ measured $234.3{\sim}260.3{\mu}g/100g$ in dried mung bean and soybean. Vitamin $B_6$ content of non-glutinous and glutinous black rice measured $105.0{\mu}g/100g$ and $129.7{\mu}g/100g$, respectively. In vegetables, high content of vitamin $B_6$ were measured in passion fruit ($104.3{\mu}g/100g$), gat ($55.7{\sim}84.3{\mu}g/100g$), gomchwi ($31.3{\sim}88.0{\mu}g/100g$) and garlic ($72.7{\sim}98.3{\mu}g/100g$). Among fruits, gold kiwi 'Zespri' and green kiwi 'Hayward' revealed high vitamin $B_6$ content of $116.3{\mu}g/100g$ and $78.7{\mu}g/100g$, respectively. In persimmons, daebongsi had high vitamin $B_6$ content ($36.0{\sim}72.7{\mu}g/100g$) than bansi and sweet persimmon. Vitamin $B_6$ content in dried jujube and persimmon increased more than $86.7{\mu}g/100g$ compared to fresh materials. Among specialty crops, green tea powder ($64.7{\sim}251.0{\mu}g/100g$) and sansuyu ($172.3{\mu}g/100g$) revealed high content. Of mushrooms, vitamin $B_6$ content of Sparassis crispa ($139.3{\mu}g/100g$) was the highest. Vitamin $B_6$ content information of agricultural products in local areas in Korea collected from this experiment will be used as valuable preliminary data for grasp national nutritional status.

• Food Science and Preservation
• /
• v.18 no.6
• /
• pp.961-966
• /
• 2011

This research was carried out to evaluate the value of tofu containing mushroom as a immunomodulator. Tofu was made using $CaSO_4{\cdot}2H_2O$ or Lactobacillus extract as a coagulant after adding powder of fruit bodies or mycelia of Letino edodes and Lepista nuda to soybean milk. Proximate compositions of tofu and tofu containing mushroom were analyzed. Levels of interferon ${\gamma}$ (IFN-${\gamma}$), interleukin 4 (IL-4) and tumor necrosis factor-${\alpha}$ (TNF-${\alpha}$) in culture media of lymphocytes collected from mouse spleens after being injected with mushroom, regular tofu, or tofu made with mushroom were measured by sandwich ELISA. In addition, concentrations of IgG1, IgG2a and IgE in plasma or lymphocyte culture media were analyzed. Crude protein, crude lipid and crude ash were decreased in tofu containing mushroom but phosphorus was increased significantly. IFN-${\gamma}$ concentration was significantly decreased in mice injected with fruit body or tofu alone. IL-4 level was decreased significantly in mice injected with tofu containing fruit body of L. edodes. However, TNF-${\alpha}$ was increased in mice injected with tofu containing fruit body of L. edodes. Plasma levels of IgG1 were increased in almost all groups, while there was no significant change in IgG2a levels among treated mice groups. Concentrations of IgG1 and IgG2a were increased significantly in lymphocyte culture media of mice injected with tofu containing mushroom. Plasma levels of IgE level was significantly increased in mice injected with tofu or fruit body of L. edodes, but not in mice treated with tofu containing mushroom. These results showed that tofu with mushroom affected immune activities, and it seems valuable to consider developing the mixture of tofu and L. edodes as an immunomodulator.