• 대한전자공학회:학술대회논문집
• /
• 대한전자공학회 2001년도 The 6th International Symposium of East Asian Resources Recycling Technology
• /
• pp.437-442
• /
• 2001

In an integrated steel mill, zinc (Zn) inputs from raw materials and steel scrap are enriched in the dusts and sludges collected from gas and water cleaning systems. The reuse of these dusts and sludges must be controlled within certain limit to avoid Zn accumulation and related operational problems in blast furnace. An integrated system has been established at China Steel Corporation (CSC) to enhance the internal reuse of Zn-containing dust/sludge while keeping Zn input within control lim it. However. the performance of this system has not been very satisfactory until one and half years ago when a rationalization process was initiated. The essence of this rationalization process, the recent improvements in Zn control and dust and sludge reuse are reported and discussed.

• 한국물환경학회지
• /
• 제16권4호
• /
• pp.513-521
• /
• 2000

Intermittently aerated activated sludge process was applied as a water reuse process of $70m^3/day$ for the upgrade of organic, nitrogen and phosphorus removal efficiency and clarifier performance. After application of the intermittently aeration, removal efficiency of BOD, SS, T-N and T-P were achieved 95%, 90%, 80% and 60%, respectively. Removal efficiencies in intermittently aerated process were considerably increased. comparing to those of continuously aerated activated sludge process. Also sludge rising problem in clarifier was improved. Average concentration of supplied reusing water were BOD 5 mg/L, turbidity 4 NTU and after chlorination, residual chlorine 0.4 mg/L, coliform 0 MPN/100mL. Intermittently aerated activated sludge process could be one of the best alternative process for the retrofit of conventional activated sludge process for the removal of nutrient in water reuse system.

• 환경위생공학
• /
• 제10권1호
• /
• pp.86-96
• /
• 1995

Alum recovery has recently gained more attention because many water utilities need to improve their sludge handling and disposal practices. As part of an overall sludge management program recovery can reduce the amount of solids and allow for reuse of the recovered Alum as a coagulant. This study was examined the effectiveness of Alum recovery from the Sludge at the D water treatment plant in Kwangju city. The results were summarized as follows 1. Alum recovery was obtained sufficiently acidification(An optimum condition was pH2-3) With $H_{2}SO_{4}$ to settled sludge. In this case recovered liquid Alum from sludge of 2.1% solids concentration at pH 2.1 was contains Aluminum $1,602mg/{\ell}$(as $Al_{2}O_{3}$ 0.3% ) and other metal of low level. 2. It was an optimum condition to all reuse of recovered Alum as a coagulant that rate of Commercial Alum:Recovered Alum=$14{\mu}{\ell}/{\ell}{\;}:{\;}200{\mu}{\ell}/{\ell}$ In a result of Jar Tests. 3. It was a result of Alum recovery from sludge, the reduction effect of amount of solids was about 57.4%. 4. If all recovered Alum were reused the reduction effect of solid wastes disposal cost and chemical drug's cost was about 22%.

• 한국물환경학회지
• /
• 제22권2호
• /
• pp.308-313
• /
• 2006

Charicteristics of piggery waste and treatment processing sludges for reuse were investigated. If it was thoroughly regulated in disinfectants, antibiotic substances and heavy metals, raw piggery waste can be gratified in criteria for fermentative compost (liquid) for flowers cultivation. Also, Because it is satisfied with various criteria of heavy metals and fertilizer contents for reuse except water content, primary pre-treatment sludge is very good material for composting. If provated goods on heavy metals are used in coagulation & dewatering process, coagulation & dewatering sludges are suitable for criteria of special waste regulation and by-product compost. This study proves that, if they are accomplished with suitable composting and mature process, piggery waste and processing sludges are free from microbiological problems as well as criteria of composting.

• 상하수도학회지
• /
• 제31권3호
• /
• pp.257-262
• /
• 2017

Several disposal processes for waste sludge from wastewater treatment plants such as landfill, ocean dump, incineration, reuse as fuels or fertilizers are practiced. However, ocean dumping is prohibited by international treat. New constructions of landfill sites or incineration facilities are limited by NIMBY and reuse processes are still suffering from low energy yield. Therefore, development of alternative processes for sludge disposal are currently needed. In this study, alternative technique for sludge solubilization using HVI (high voltage impulse) was suggested and verified experimentally. Sludge solubilization was carried out for 90 minutes using HVI discharge with peak voltage of 16 kV and pulse duration for 40 microsecond. About 3~9 % of MLSS and MLVSS concentration were reduced, but the soluble COD, TN, TP of the sludge increased to 372 %, 56 % and 102 % respectively. It indicates that the flocs and/or cells of the sludge were damaged by HVI. These resulted in flocs-disintegration and cells-lysis, which means the internal matters were bursted out of the flocs as well as the cells. Thus, electrical conductivity in bulk solution was increased. All of the results verified that the HVI could be used as an alternative technique for sludge solubilization processes.

• 자원리싸이클링
• /
• 제9권1호
• /
• pp.36-43
• /
• 2000

본 연구는 B 염색조합 공동폐수처리장의염색폐수 처리공정중 Fenton 공정에서 발생되는 무기슬러지의 처리 및 재활용에 관한 연구로서, Pilot plant에 의하여 재용해철($Fe^{3+}$)과 FECL의 혼합용액을 사용한 연속식 산화실험 결과, 처리수의 $COD_{cl}$ 는 대략 100 mg/l이하였으며 이때 $COD_{cl}$제거율은 78.9%로 $H_2O_2/Fe^{total}$가 대략 1.5범위에서 최적치를 나타내었다. 슬러지의 용해공정 후에 배출되는 2차 슬러지에 대하여 3성분을 측정하여 1차 슬러지와 비교해 볼 때 회분은 약 85%가 감소되었으며, 건조기준 총 슬러지는 약 65%의 감량율을 나타내었고, 슬러지의 속의 철염의 재용해율은 대략 90~95%정도였다 슬러지 재활용공정의 예상투자비용은 시설용량 30,000 $m^3$/d/d 기준으로 약 3.5억원이 소요되며, 예상운영비는 하루에 약 130만원(연간 4.2억원)의 절감을 예상할 수 있으며, 투자비에 대한 이자비용을 감안하면 설비투자비용에 대한 투자자본금 회수기간(PP)은 약 10.5개월이 필요하고, 회계적이익율(ARR)은 179%, 순현재가치(NPV)는 7.92억원, 내부수익률(IRR)은 약 110%로 충분한 투자가치가 있는 것으로 판명되었다.

• Korean Chemical Engineering Research
• /
• 제60권1호
• /
• pp.80-85
• /
• 2022

In wastewater treatment processes huge quantities of sludge are produced continuously each year. This work investigated the reuse of two types of sludge as biosorbents of a toxic dye. The potential of granular and filamentous fungus dried sludge for the elimination of eosin from aqueous solution was studied in batch system. The effect of initial concentration and temperature was examined. Maximum uptake was observed at 100 mg l^-1 and 30 ℃. The maximum removal rate was 92% for the granular sludge and 90% for the filamentous one. Equilibrium was attained after 30 min for the studied dye concentrations. The equilibrium uptake increased with the initial eosin concentration. The Freundlich and Langmuir adsorption models were also investigated. The reuse of disposed sludge as adsorbent could be a solution for the valorization of such dangerous waste to resolve two environmental problems at the same time.

• Korean Chemical Engineering Research
• /
• 제52권4호
• /
• pp.413-424
• /
• 2014

에너지원으로 바이오가스에 대한 잠재적 가능성이 인식되면서 최근에 바이오가스의 생산기술을 제고하고 에너지 효율을 개선하기 위한 기술개발이 지속적으로 진행되고 있다. 본 논문의 목적은 혐기성 소화 과정에서 바이오가스 생산을 증가시키기 위한 효과적이고 효율적인 슬러지 전처리 방법에 대하여 분석하였다. 이를 위해 본 논문에서는 각각의 전처리 방법의 장점과 단점을 분석하여 바이오가스 생산에 미치는 영향요인을 비교 분석하였다.

• 대한환경공학회지
• /
• 제22권6호
• /
• pp.1083-1091
• /
• 2000

본 연구는 펜톤산화 공정에서 발생되는 펜톤슬러지를 응집제와 펜톤산화 공정에서의 촉매로 재이용할 수 있는지 여부를 검토하여 고농도의 난분해성 유기물질을 함유한 침출수를 효과적이고 경제적으로 처리할 수 있는 기술을 개발하는데 그 목적을 두었다. Batch-Scale 연구 결과 펜톤슬러지를 응집제와 펜톤산화 공정의 촉매제로 혼합사용하여 응집 공정과 펜톤산화 공정에 적용할 경우 약품만을 사용하는 경우보다 응집제의 사용량을 50%, 펜톤산화 공정의 촉매제 사용량을 50% 감소시킬 수 있었으며, 응집 공정과 펜톤산화 공정에서 발생되는 슬러지의 발생량도 감소시킬 수 있는 것으로 조사되었다. 실험실 규모의 연속식 처리 실험을 수행한 결과 펜톤슬러지를 응집제로 재이용함으로써 평균 8.5% 정도 유기물 제거효율이 증가하였으며, 슬러지의 발생량은 35% 감소하는 것으로 조사되었다. 또한 펜톤슬러지를 펜통촉매제로 재이용함으로써 유기물 제거면에서 평균 5.3% 정도 효율이 증가하였으며, 슬러지의 발생량은 14% 정도 감소하는 것으로 조사되었다. 이상의 결과로 펜톤산화 공정에서 발생하는 슬러지의 재이용은 약품 비용이나 슬러지 처리 비용을 절감시킬수 있을 것으로 결론지을 수 있다.

• 한국응용과학기술학회지
• /
• 제22권4호
• /
• pp.379-384
• /
• 2005

In general, water treatment sludge (WTS) had high concentration of heavy metal, thus it made the reuse or recycling of WTS difficult. The optimal solidification conditions for maximum suppression of heavy metal elution from WTS were decided in this study. Under the optimal solidification conditions (i.e., temperature, $320^{\circ}C;$ ratio of WTS and MgO, 9:1; solidification time, 1hr), all of heavy metal including aluminum were not detected. Therefore there are no problems for reuse or recycling of WTS which was solidified under the optimal solidification conditions found in the study.