• The Journal of Korean Academy of Prosthodontics
• /
• v.35 no.3
• /
• pp.566-576
• /
• 1997

This study was performed to evaluate the tensile strength of solder joint in titanium and the wettability of 14K gold solder on titanium. Two pieces of titanium rod 30 mm in length and 3mm in diameter were butt-soldered with a 14K gold solder using the electric resistance heating under flux-argon atmosphere, the infrared heating under argon atmosphere, and the infrared heating under vacuum-argon atmosphere. A tensile test was performed at a crosshead speed of 0.5 mm/min, and fracture surfaces were examined by SEM. To evaluate the wettability of 14K gold solder on titanium, titanum plates of a $17{\times}17{\times}1mm$ were polished with #80-#2000 emery papers, and the spreading areas of solder 10 mg were measured by heating at 840 * for 60 seconds. The solder-matrix interface regions were etched by the solution of 10% KCN-10% (NH4)2S2O8, and analyzed by EPMA. The results obtained were summarized as follows ; 1. The maximum tensile strength was obtained when the titanium surface was polished with #2000 emery paper and soldered using the electric resistance heating under flux-argon atmosphere. Soldering strengths showed the significant difference between the electric resistance heating and the infrared heating(p<0.05). 3. The fracture surfaces showed the aspect of brittle fracture, and the failure developed along the interfaces of solder-matrix reaction zone. 4. The EPMA data for the solder-matrix interface region revealed that the diffusion of Au and Cu occurred to the titanium matrix, and the reaction zone showed the higher contents of Au, Cu and Ti than others.

• KOREAN JOURNAL OF CROP SCIENCE
• /
• v.45 no.5
• /
• pp.305-309
• /
• 2000

Ultra-drying [＜5.0% seed moisture content (SMC)] storage technique is a cost-effective storage method for oily seeds. To decide proper ultra-drying condition for soybean seeds, drying rate was compared three silica gel to seed ratios, two seed sizes with varietal difference, two kinds of container, and three seed amounts per container under :t 23$\pm$1$^{\circ}C$. When the relative humidity (RH) was reduced at the rate of less than 0.1 % a day, silica gel was replaced with dry one by 47 days. Higher silica gel to seed ratios (3:1 and 2:1) dried faster than lower ratio (1:1) until 28 days, but not after 43 days of drying. Also, large seeded variety was dried faster than small seeded variety. Kinds of container and seed amounts per container didn't show differences in drying of soybean seeds. After completion of ultra-drying, percentage germination by standard germination test (SGT) was not different among silica gel to seed ratios, kinds of container, and seed amounts per container, except among seed sizes (varieties). Before SGT, soybean seeds were premoistened using saturated ${CaCl}_2$ for 48 hours and ${NH}_4$Cl for 24 hours in desiccators. To compare germinability between ordinary-dried seeds and ultra-dried seeds, the seeds of seven soybean varieties, which were varying in size from 8.1 to 34.9 g per 100 seeds, were dried using same amount of silica gel under 23$\pm$1$^{\circ}C$. After completion of 76 days of drying, SMCs were reduced to 3.13-3.45% from 7.86-8.82%. SMC after completion of drying was not correlated with 100-seed weight (r=0.556). Before germination tests, soybean seeds were premoistened using saturated salt solutions. Percentage germination was higher with ultra-dried seeds than ordinary-dried seeds in SGT and higher with ordinary-dried seeds than ultra-dried seeds in AAT at the beginning of storage and after 6 months storage, but general trend of percentage germination was not observed among varieties classified by 100-seed weight. From these results, we concluded that further studies are needed to improve ultra-drying storage method for soybean seeds.

• Journal of Korean Society of Environmental Engineers
• /
• v.29 no.5
• /
• pp.548-555
• /
• 2007

The control of wastewater treatment has two merits; one is to regulate water quality of effluent and the other is to reduce the cost of wastewater treatment. The purpose of this study was to control the ammonium nitrogen in effluent that is known to cause eutrophication. The control was based on simplified ASM No. 1 which had 3 component materials and 8 coefficients, and the control method was as following. Firstly the ammonium concentration of inflow was measured and the optimal aeration time in effluent was determined according to simplified ASM No. 1 to be 1.0 mg/L. If ammonium concentration of effluent was not equal to 1.0 mg/L, the influent ammonium was corrected by adaptive control. These processes above were repeatedly performed. The SBR running aerobic-anoxic phase had been controlled for 1 month with this method. As a result, the ammonium concentration of the effluent showed in the range of $0.22\sim3.1$ mg/L with an average concentration of 1.1 mg/L. The adaptive control method used in this study was found very useful to control and predict the effluent concentration of ammonium.

• Korean Journal of Environmental Biology
• /
• v.32 no.1
• /
• pp.16-25
• /
• 2014

To identify distribution of epilithic diatom assemblages and the relationship between diatoms and water chemistry, samples were collected twice a year from 2008 to 2012, from at 6 streams in Jeju Island, South Korea. A total of 171 diatom taxa were identified, and Achnanthes lanceolata, Gomphonema pumilum, Melosira varians, Navicula minima and Nitzschia palea were dominantly observed. BOD ranged 0.0~1.6 mg $L^{-1}$, TN 0.230~13.240 mg $L^{-1}$ (average 4.432 mg $L^{-1}$), TP 0.020~0.316 mg $L^{-1}$ (average 0.092 mg $L^{-1}$), and N/P rate ranged 2.5~178.5. Average of epilithic algal chlorophyll-a and AFDM were 1.1 ${\mu}gcm^{-2}$ and 0.6 mg $cm^{-2}$, respectively. According to BOD standard, the water qualities of study area sites were at 'Good' level. However, the healthiness levels assessed from DAIpo and TDI were 'Fair' to 'Poor'.

• Analytical Science and Technology
• /
• v.17 no.1
• /
• pp.69-81
• /
• 2004

The formation pattern of DBPs (disinfection by-products) in raw water treated with hypochlorite, chlorine disinfectant was studied. TOC (total organic carbon), residual chlorine, turbidity and 14 DBPs in raw water from Han-river and Nakdong river during 1 ~ 14 days were determined. Total DBPs in Han river was 101.3 ng/mL (789.6 nM) after 7days and THMs (trihalomethanes) are the dominant portion of 68%. HAAs (haloacetic acids) and chloral hydrate were determined 19% and 10% respectively. In Nakdong river total DBPs was 98.4 ng/mL (678.6 nM) and dominant class was HAAs. (55.8 ng/mL, 57%) THMs(34%) and N-compounds like HANs (haloacetonitriles, 5%) and chloropicrin were increased. It may be explained that high concentration of NH4-N in Nakdong river react with chlorine produced chloramine and this formed different pattern of DBPs. As a result, total DBPs formation pattern depends on raw water and disinfectant and in generally the initial concentration of acidic HAAs was high and THMs was increased gradually.

• Journal of Animal Environmental Science
• /
• v.13 no.3
• /
• pp.171-178
• /
• 2007

This study was carried out to investigate the effect of microbial complex diets on improvement of air quality in finishing pig building. Ammonia and hydrogen sulfide concentrations were significantly(p<0.05) decreased by dietary supplementation of 0.1% level of microbial complex compared with those of control according to the time in the finishing pig building. Characteristics of piggery liquid slurry that total nitrogen and $NH_3-N$ of treatment were reduced relatively compared with those of control, and were decreased depending on the time. In conclusion, the result obtained from this study suggest that the dietary supplementation of microbial complex for finishing pigs may improve environment in the finishing pig building.

• Animal Bioscience
• /
• v.34 no.10
• /
• pp.1607-1615
• /
• 2021

Objective: Chaya (Cnidoscolus aconitifolius) leaf has been found to be an important source of protein, vitamins, minerals, as well as phytonutrients. The present study aimed to evaluate the effect of Chaya leaf pellet (CHYP) with various level of crude protein (CP) in the concentrate on rumen fermentation characteristics and nutrient degradability in in vitro gas production technique. Methods: In an in vitro rumen fermentation study the dietary treatments were arranged according to a 3×5 factorial arrangement in a completely randomized design, consisting of Factor A: three levels of CP of concentrate mixtures (14%, 16%, and 18% CP, respectively) and Factor B: five levels of CHYP supplementation (at 0%, 2%, 4%, 6%, and 8% of dry matter substrates). Results: The gas production kinetics, fraction (a) and fraction (b) were lower (p<0.05) with an increasing CHYP addition. Additionally, the fraction (a+b) was found to yield a significant interaction (p<0.05) while the fraction (c) was not impacted by CHYP addition. However, in vitro DM degradability was enhanced and interactive (p<0.05), using 16% CP of concentrate with 6% and 8% CHYP, when compared with 18% CP in the non-addition. Additionally, the treatment with higher CP of the concentrate was higher in NH₃-N concentration (p<0.001) and by CHYP supplementation group (p<0.05). Nevertheless, protozoal counts in the rumen were remarkably decreased (p<0.05) with increasing level of CHYP supplementation. Furthermore, rumen C₂ concentration was lower (p<0.05) in the treatments with CHYP supplementation, while C₃ was significantly increased and interactive (p<0.05) between levels of CP and CHYP supplementation especially at 8% CHYP supplementation. Conclusion: Based on this study, the results revealed CHYP as a promising feed supplement to enhance rumen fermentation and to mitigate methane production. However, in vivo feeding experiments should be subsequently conducted to elucidate the effect of CHYP supplementation on rumen fermentation, as well as ruminant production efficiency.

• Proceedings of the Korea Water Resources Association Conference
• /
• 2023.05a
• /
• pp.151-151
• /
• 2023

본 연구는 호우(heavy rain) 발생 시 대기 중 미세먼지(particulate matter, PM) 저감효과를 규명하고 강우 지속에 따른 빗물 수질(pH, 전기전도도(electrical conductivity, EC), 수용성 이온) 분석을 통해 대기 중 PM이 빗물 수질에 미치는 영향을 평가하였다. 2020년 3월부터 2021년 2월까지강우 강도(7.5 mm/h)를 기준으로 총 6회의 강우를 대상으로 하였으며 빗물 샘플은 집수장치를 통해 50 mL를 연속적으로 수집하여 수질을 분석하였다. 대기 중 PM_2.5 (≤ 2.5 ㎛ in diameter) 및 PM₁₀ (≤ 10 ㎛ in diameter) 농도는 기상청 내 부산 남구 대연동 관측소의 automatic weather system (AWS)에서 측정된 일평균 자료를 이용하였다. 강우에 따른 대기 중 PM의 저감효율은 상대적으로 PM₁₀에서 뚜렷하게 나타났으며, 특히 강우 강도 7.5 mm/h 이상(유형 1)의 호우 발생 시60% 이상의 저감효율을 보였다. 반면, 강우 강도 7.5 mm/h 이하(유형 2)일 때는 10% 이하의 저감효율을 보였으며, 강우 지속에 따라 대기 중 PM₁₀ 농도가 증가하는 경향을 보이기도 하였다. 총108개의 빗물 샘플 수질을 분석한 결과, 유형 1의 경우 초기 빗물의 평균 EC는 58.5 µS/cm으로 상대적으로 높았으며 대기 중 PM₁₀과 양의 상관관계(r = 0.99)를 보였고 평균 pH는 4.3으로 산성도가 높게 나타났으며 대기 중 PM₁₀과 음의 상관관계(r = -0.99)를 보였다. 반면, 유형 2의 경우 대기 중 PM₁₀과 EC (r = -0.56) 및 pH (r = -0.41) 간 뚜렷한 상관관계가 나타나지 않았다. 또한 강우가 지속됨에 따라 EC와 수용성 양이온(Na⁺, Mg²⁺, K⁺, Ca²⁺, NH₄⁺) 및 음이온(Cl^-, NO₃^-, SO₄^2-)의 농도는 지속적으로 감소하는 경향을 보였으나 pH의 경우 강우 강도에 따라 증감의 경향이 다르게 나타났다. 유형 1의 경우 강우 지속에 따라 pH가 증가하여 산성도가 낮아졌으나 유형 2는 pH의 증감 형태를 뚜렷하게 확인하기 어려웠다. 연구 결과를 통해 강우 초기 높은 강도로 강우가 지속될 경우 대기 중 PM₁₀이 빗물 수질에 영향을 미칠 수 있는 것으로 판단되며, 이에 따라 호우 발생 시 강우가 대기 중 오염물질을 지표면으로 유입시킬 수 있는 매개체로 작용할 수 있음을 지시한다.

• Proceedings of the Korea Water Resources Association Conference
• /
• 2020.06a
• /
• pp.213-213
• /
• 2020

최근 나타나는 지구온난화와 이상기후로 인해 가뭄과 홍수피해 같은 자연재해 발생 빈도가 높아졌고, 하천에서는 오염된 수질과 수생태계 복원 및 수변공간 조성, 수자원 관리 등의 목적으로 수질환경 개선사업이 진행되고 있다. 수질환경 측면에서 하천에서 발생하는 가장 큰 문제점으로는 녹조 즉, 남조류의 발생을 예로 들 수 있다. 본 연구에서는 최근 보 개방을 통하여 수질개선 효과가 나타나고 있는 금강을 대상으로 세종보, 공주보, 백제보 구간에 대하여 주요 수질인자에 대한 상관관계 분석을 수행하였다. 특히 남조류 세포수와 주요 하천 수질인자를 Pearson's correlation analysis를 이용하여 상관관계를 분석하였고, 보 위치별 남조류 세포수를 종속변수로 하고, 상관도가 높은 수질인자를 독립변수로 하는 다중회귀식을 도출하여 금강 내 주요 하천 수질인자의 농도에 따른 남조류 세포수 관계를 규명하고자 하였다. 분석기간은 2012년 1월부터 2019년 12월까지 보 건설 이후 시점으로 선정하였고, 월 평균 남조류 개체수가 조류경보제 발령기준 관심단계이상에 해당하는 금강수계의 3개 보에 대하여 남조류 세포수와 수질에 영향을 끼치는 인자인 강수량, (수온)W·T, (수소이온농도)pH, (용존산소)DO, (생물화학적산소요구량)BOD, (화학적산소요구량)COD, (부유물질량)SS, (총질소)TN, (총인)TP, (클로로필-a)Chl-a, (전기전도도)EC, (질산성질소)NO₃-N, (암모니아성 질소)NH₃-N, (인산염 인)PO₄-P, (용존총질소)DTN, (용존총인)DTP, (총유기탄소)TOC 와의 상관관계를 분석하였다. 분석 결과 측정 지점별 남조류 세포수와 상관관계가 있는 인자는 서로 상이했지만 (수온)W·T과 pH의 경우 모든 지점에서 남조류 세포수와 양의 상관관계가 나타났다. 세종보는 W·T(0.383, P<0.01), pH(0.391, P<0.05)의 양의 상관계수를 나타냈고, 공주보에서는 (수온)W·T(0.436, P<0.05), pH(0.412, P<0.05)의 양의 상관관계를 나타냈다. 백제보에서는 (수온)W·T(0.415, P<0.01), pH(0.221, P<0.01)의 양의 상관성을 나타냈다. 남조류 세포수와 수질인자 간의 상관관계 분석에 따라 통계적으로 유의한 인자 중 (수온)W·T과 pH에 영향을 받는 영양염류와 퇴적물에 대한 후속 연구가 필요할 것으로 사료되며, 연구를 통해 제시된 남조류 세포수 다중회귀식은 주요 수질인자 농도에 따라 발생 가능한 남조류세포수를 예측하여 금강의 수질 관리에 활용될 수 있을 것으로 기대된다.

• Korean Chemical Engineering Research
• /
• v.62 no.3
• /
• pp.225-232
• /
• 2024

The reduction of CO₂ emissions in the energy production sector, which accounts for 86.8% of total greenhouse gas emissions, is important to achieve carbon-neutrality. At present, 60% of total power generation in South Korea is coal and natural gas. Replacing fossil fuel with renewable energy such as wind and solar has disadvantages of unstable energy supply and high costs. Therefore, this study was conducted through the co-firing of natural gas, ammonia and hydrogen utilizing the natural gas combined cycle process. The results demonstrated reduction in CO₂ emissions and 34%~238% of the power production compared to using only natural gas. Case studies on mass fractions of natural gas, ammonia and hydrogen indicated that power production and NO_x emissions were inversely proportional to the ammonia ratio and directly proportional to the hydrogen ratio. This study provides guidelines for the use of various fuel mixtures and economic analysis in co-firing power generation.