• Korean Chemical Engineering Research
• /
• 제44권5호
• /
• pp.468-475
• /
• 2006

압축성이 큰 케이크에 의한 여과에서는 압력의 증가가 여과속도를 거의 향상시키지 못한다. 이 경우 높은 압력은 여과매체 옆의 케이크 공간률을 급격히 감소시켜 dense skin(치밀층, 緻密層)을 형성하여 이 층이 물의 통과속도를 매우 느리게 하기 때문이다. 실제로 압축성이 큰 케이크의 여과에서 여과속도를 향상시키기 위한 특별한 방법이 없었다. 본 연구에서는 여과 대상액을 여과조작 전에 $CO_2$ 가스로 포화시켜 용액에 녹아 있던 $CO_2$ 가스가 압력이 급격히 변하는 치밀층에서 기체 상태로 변화하여 치밀층 내에 작은 공간을 확보하고, 그 공간이 물길을 형성하여 여과속도를 향상시 킬 수 있는 가능성에 대해 연구하였다.

• 한국패류학회지
• /
• 제21권1호
• /
• pp.19-24
• /
• 2005

This study was undertaken with the intent to describe the influence of water temperature and food concentration on the filtration rates of the Asiatic clam, Corbicula fluminea. The clams were collected at Lake Geumho near Yeongsan river, during March 2001. Food organism, Scenedesmus sp. (KMCC FC-34), was indoor-cultured in f/2 medium, and was used to measure the filtration rate of the clams. Filtration rate of the clams was measured by indirect method. Cell concentrations of food organisms were determined by direct counting cells using the hemacytometer under the light microscope. The filtration rate of the clams increased with water temperature up to circa $25^{\circ}C$. Above this temperature, the filtration rate decreased rapidly. The minimal filtration rate of the clams was recorded at $5^{\circ}C$. Thermal coefficient, $Q_10$ values at low temperature range were much higher than those at high temperature range. These results indicate the asiatic clam is more sensitive in cold water like most of marine bivalves. There was a strong reversed correlation between filtration rate and food concentration. Filtration rate of the clams was reduced as food concentration was increased.

• 상하수도학회지
• /
• 제14권3호
• /
• pp.260-270
• /
• 2000

The objective of this study is to evaluate the effect of filter aids in the dual-media rapid filtration. Paper-filter tests were conducted to determine the proper dosages of coagulant and filter aid, and pilot plant tests using two dual-media filter columns were performed for a variety of filtration rates. Using a filter aid (non-ionic polymer), the maximum feasible filtration rate is 480m/day, while turbidity is less than 0.3 NTU and filter run-time is about 70 hours. It is possible to increase the filtration rate up to 360 m/day for keeping the turbidity less than 0.1 NTU. Turbidity increases for the filtration rate greater than 360m/day. In general, the quality of filtered water with a filter aid is stable, while the filter maintains a sufficient filter run-time for a maximum allowable head loss. Particularly, the initial breakthrough can be effectively controlled. The use of a filter aid may be one of the methods applicable if the turbidity of filtered water is required to be improved or if the filter breakthrough limits filter run-time.

• 한국물환경학회지
• /
• 제31권3호
• /
• pp.262-271
• /
• 2015

Laboratory study was undertaken to pursue the filter performance of a micro-filter module employing highly porous fiber media under a high filtration rate (over 1,500 m/day), faster than that of any conventional filter process. The effects of filtration rate, head loss, raw water turbidity, and filter aid chemicals on filter performance were analyzed. In spite of the extremely high filtration rate, the filter achieved an attractive efficiency, reducing the raw water turbidity by over 80%. As with other filter systems, the filter aid used (PAC in this study) greatly affected the performance of this particular fiber filter. Long term repetitive runs were additionally carried out to confirm the reproducibility of the filter performance. Finally, a comparison was carried out with other high rate filter systems which are either being tested for use in experimental studies, or are already commercially available.

• 한국정밀공학회지
• /
• 제20권9호
• /
• pp.205-213
• /
• 2003

This study describes the mathematical equation of drawdown test model and introduces the experimental test apparatus and procedure to estimate the desorption rate ratio of a filter. The characteristics of a hydraulic filtration system of drawdown test were demonstrated by numerical simulation for various properties of filters and operation conditions. Experiments for three kinds of fuel filters were conducted according to the proposed test method. And the test results of desorption rate ratio were compared with those values anticipated in precedent multipass filtration tests. Experimental results revealed the validation of drawdown test method proposed in this study. Domestic fuel filter yielded high desorption rate ratio comparing with other foreign products, which means that the Beta ratio decreases a lot during the test. The results also showed that filtration system model could be developed including desorption rate ratio to estimate the variable Beta ratio in service life.

• 한국패류학회지
• /
• 제24권3호
• /
• pp.175-188
• /
• 2008

본 연구는 말백합, Meretrix petechialis의 기초 생리, 생태학적 정보를 파악하기 위한 일환으로 수온 및 염분의 변화가 이들의 여과율에 어떠한 영향을 미치는지 파악하고자 수행되었다. 말백합은 전라북도 김제시 거전리 갯벌에서 채집하였고, 먹이생물은 Phaeodactylum tricornutum(KMCC B-128)을 실내에서 단일종 배양하여 사용하였으며, 여과율 측정은 Coughlan(1969)의 간접측정법을 사용하였다. 먹이생물의 농도는 혈구계산판을 이용하여 광학현미경하에서 직접 계수하였다. 전체적인 실험과정은 Shin and Lim(2003)과 동일하였다. 수온별 말백합의 여과율 변동의 경우 연령에 관계없이 $25-30^{\circ}C$에서 대체적으로 높은 여과율을 나타내었고, 전반적으로 $5^{\circ}C$에서 최소 여과율을 나타내는 경향이었다. 염분별 말백합의 여과율 변동의 경우 전반적으로 20-35 psu의 염분구간에서 비교적 높은 여과율을 나타내는 경향이었다. 연령별 여과율 변동의 경우 대체적으로 연령이 낮을수록 건중량당 여과율은 상대적으로 높은 경향이었다. $Q_{10}$ 값의 경우 전반적으로 낮은 수온 구간($5-15^{\circ}C$)에서 높은 값을 나타내는 경향이었다.

• Applied Biological Chemistry
• /
• 제40권1호
• /
• pp.18-22
• /
• 1997

Bifidobacterium longum을 고농도 배양하기 위하여 최적 생육 조건을 조사하고 cross-flow filtration으로 생육 저해 대사산물인 lactic acid와 acetic acid를 제거하면서 균체 순환 배양을 사용하였다. 회분 배양에서는 탄소원으로 glucose를 50 g/l 농도로 사용하고 초기 pH 6.5인 경우 생육이 가장 높았다. B. longum을 cross-flow filtration으로 12시간 배양한 결과, 희석속도 $0.31h^{-1}$에서 최대 균체농도에 도달하여 16.4g/l의 건조균체량을 얻었으며 이로써 회분 배양시 보다 약 4배 높은 균체를 생산하였다.

• 한국물환경학회지
• /
• 제18권2호
• /
• pp.221-228
• /
• 2002

Abundant growth of algae in raw water sources caused by eutrophication brings about significant side effects on water supply, such as taste and order problem, oxygen depletion, toxic material secretion, and filter clogging problem in water treatment process, etc. The purpose of this research is to remove the algae and phosphorus compounds in the Pal-dang reservoir promptly by using the upflow filtration system with coagulant addition. The filter tower consisted of sand media and sieve filter with air back-washing process. By using coagulation and filtration with $132{\mu}m$ pore size filter, about 55% and 70% of algae and phosphorus compounds were removed respectively. The experimental conditions were as follows; head loss of 0.2m, linear velocity of 200m/day, and filtration flux of 1000($L/m^2/day$). In the case of filtration with cartridge type filter of $25{\mu}m$ pore size, the filtration flux was about 7800 LMH, and the removal ratios of COD, SS, T-P, and Chlo-a. were 61%, 99%, 54%, and 98%, respectively. However, high pressure air back-washing process with should be required for the maintenance of such high filtration flux.

• 한국환경과학회지
• /
• 제12권12호
• /
• pp.1235-1243
• /
• 2003

Under controlled conditions in an environmental chamber, 24 experiments were performed to compare the ability of a Variable-Air-Volume/Bypass Filtration System(VAV/BPFS) to remove indoor pollutants and to conserve energy with the ability of conventional Variable Air Volume(VAV) system. The specific conclusions of this paper were; first, the VAV/BPFS was more efficient than the VAV system in removing particulate matter, TVOC, and target VOCs. The total effective removal rate of PM for the VAV/BPFS was two times as high as that of the VAV system. The total effective removal rate of TVOC for the VAV/BPFS was 20 percent higher than that of the VAV system. Also each target VOC concentration was reduced by using the VAV/BPFS. Second, clean air delivery rate was increased by using VAV/BPFS due to additional filtration rate. Otherwise, the VAV/BPFS decreased outdoor supply air rate above 25 percent relative to the rate of VAV system. Third, total energy consumption by the VAV/BPFS was lower than that of the VAV system during the period with indoor thermal load, occupied time. The energy saving of the VAV/BPFS ranged from 11 to 16 percent. The VAV/BPFS improves indoor air quality more efficiently than the VAV system, and it reduced energy consumption. Retrofitting the VAV system with the VAV/BPFS was easy The use of VAV/BPFS is, therefore, recommended far buildings with VAV system as well as for buildings at designing stage.

• 한국패류학회지
• /
• 제19권1호
• /
• pp.1-8
• /
• 2003

본 연구는 바지락의 기초 생물, 생태학적 정보의 하나로써, 수온 및 염분의 변화가 바지락의 여과율에 미치는 영향을 파악하기 위하여 수행되었다. 실험에 사용된 바지락은 전남 여수시 화양면에 위치한 갯벌에서 채집하여 사용하였고, 먹이생물은 규조류, Phaeodactylum tricornutum을 실내에서 단일종 배양하여 사용하였다. 여과율측정은 간접측정법을 사용하였고 먹이생물의 농도는 광학현미경하에서 혈구계산판을 이용하여 직 접 계수하였다. 1, 2, 3년생 바지락 모두 수온이 증가할수록 여과율도 증가하였고 20-25$^{\circ}C$에서 최대여과율을 보였으며 25$^{\circ}C$이상에서 대체로 감소하는 경향이었다. 염분 변화에 대해서는 대체로 25-35 psu에서 최대여과율을 보였고 염분이 감소할수록 여과율도 감소하였다. 연령별 바지락의 여과율은 수온,염분 변화에 관계없이 1년생 바지락이 2, 3년생 바지락에 비해 뚜렷하게 높은 여과율을 나타내었다. 온도계수 Q$_{10}$값은 대체적으로 저온(5-15$^{\circ}C$) 에서 높게 나타났고 회귀분석의 결과, 수온변화에 대한 바지락의 여과율 곡선은 대체적으로 오른쪽으로 치우친 경향이었다. 이러한 결과로 바지락의 여과율은 저온의 수온범위에서 더욱 민감하게 영향을 받는 것으로 생각된다.