• Journal of the Korean Crystal Growth and Crystal Technology
• /
• v.22 no.3
• /
• pp.127-133
• /
• 2012

To achieve low-cost and high-efficiency of thin-film solar cells applications, the sol-gel method that can be coated on a large area substrate, obtain homogeneous thin films of high purity was used. We studied structural and optical characteristics versus annealing temperature of $Cu_2ZnSnS_4$ which has kesterite structure by substitution low-cost sulfur (S) instead of high-cost selenium (Se). By analyzing XRD patterns, main peak was observed at $2{\theta}=28.5^{\circ}$ when Zn/Sn ratio is 0.8/1.2. And when we observed kesterite structure which has orientation of (112) direction, the more annealing temperature increase the bigger strength of (112) direction is. $Cu_2ZnSnS_4$ thin film showed characteristics of kesterite structure at $550^{\circ}C$. And when we calculated lattice constant, a = 5.5047 and $c=11.014{\AA}$ as same JCPDS (Joint Committee on Powder Standards) data measured. We measured optical transmittance to analyze optical characteristics. Optical transmittance was lower than 65 % at visible ray (${\lambda}=380{\sim}770nm$).

• Korean Journal of Food Science and Technology
• /
• v.45 no.3
• /
• pp.312-316
• /
• 2013

The objective of this study was to establish an analytical method to detect zearalenone (ZEA) in herbal medicines and their decoctions and investigate the ZEA transfer rate from raw materials of herbal medicines to their decoctions. Herbal medicines (Trichosanthis Semenm, Eucommiae Cortex, Rubi Fructus) spiked with a known concentration of ZEA were presoaked or unsoaked (as a pretreatment) and boiled for 3 h at $100^{\circ}C$ or autoclaved for 1 h at $121^{\circ}C$. The decoction and the remnants were separated, cleaned up with an immunoaffinity column, and analyzed using HPLC. Recoveries for decoctions and remnants were 68.39-83.68% and 72.91-80.25%, respectively. ZEA was not detected in the decoction, whereas it was found in the remnants. Although ZEA in the raw material of herbal medicines was not transferred into the decoction during heating and autoclaving, the continuous monitoring for ZEA in raw herbal medicines should be carried out for the safe ingestion and utilization of herbal medicines.

• Applied Biological Chemistry
• /
• v.46 no.3
• /
• pp.207-213
• /
• 2003

Kochujang was prepared for this study with raw material inoculated by commercial enzyme of amylase and protease. Volati1e compounds of Kochujang were analyzed using a purge and trap method during fermentation and identified with GC-MSD. Total 54 kinds of volatile flavor components like 16 kinds of alcohol, 16 kinds of ester, 7 kinds of acid, 4 kinds of aldehyde, 2 kinds of alkane, 1 kind of benzene, 3 kinds of ketone, 1 kind of alkene, 2 kind of amine, 1 kind of phenol, other 1 were found. Total number of volatile flavor detected right after manufacturing were 23 kinds like 3 kinds of alcohol, 6 kinds of ester, 3 kinds of aldehyde. After 30 days storage, total number of volatile flavor went up to 31 kinds with addition of 4 kinds of alcohol, 1 kind of ester. The total number of volatile flavor after 120 days storage were increased to 49 kinds. Volatile flavor compounds detected during the storage period were total 20 kinds like 6 kinds of alcohol such as 2-methyl-1-propanol, ethanol, 3-methyl-1-butanol, 5 kinds of ester such as ethyl acetate, isoamyl acetate, ethyl butyrate, 3 kinds of aldehyde such as butanal, acetaldehyde and 6 kinds of others. Even though peak area % of flavor compound varied depends on fermentation period, ethanol, ethyl acetate, ethyl butyrate, ethenone, 2-methyl-1-propanol, 3-methyl-1-butanol were the main compounds that consisted of flavor from Kochujang which was made with enzyme treatment. Ethly acetate showed the highest result in the treatment of right after manufacturing, 3-methyl-1-butanol had up to 90th day and ether were the other days.

• KSBB Journal
• /
• v.10 no.5
• /
• pp.510-517
• /
• 1995

The hydrolysates of three kinds [FSEH(first step enzymatic hydrolysate), SSEH(second step enzymatic hydrolysate), and TSEH(third step enzymatic hydyolysate)] were prepared by continuous hydrolysis of Alaska pollack(Theragra chalcogramma) skin gelatin with three-step membrane enzyme reactor. The molecular weight distributions of FSEH, SSEH, and THSE are 9,500∼4,800Da, 6,600∼3,400Da, and 2,300∼900Da, respectively. The contents of amino acid having sweet taste (glycine, proline, serine, alanine, hydroxyproline, glutamic acid, and aspartic acid) were about 70% of total amino acid being in the three kind hydrolysates. We also tried preparing of natural seasonings (complex seasoning and enzymeatic hydrolysale sauce) using the hydrolysates. From the results of sensory evaluations, complex seasoning containing TSEH was nearly equal to shellfish complex seasoning on the market. The mixture sauce which was made by mixing of 80% enzymatic hydrolysis sauce and 20% fermented soy sauce, was at least similar to the tradition soybean sauce in product quality, too.

• KOREAN JOURNAL OF CROP SCIENCE
• /
• v.58 no.1
• /
• pp.71-77
• /
• 2013

The world demand of renewable bioenergy as an alternative transportation fuel is greatly increasing. Research for bioethanol production is currently being progressed intensively throughout the world. Therefore it will be necessary to develop bioethanol production with cellulosic materials. In this study, the yield of ethanol production was evaluated by simultaneous saccharification and fermentation (SSF) using sodium hydroxide pretreated sorghum ${\times}$ sudangrass hybrids. Composition analysis of 11 varieties of sorghum ${\times}$ sudangrass hybrids was performed for selection of excellent variety to efficiently produce bioethanol. The content of cellulose, hemicellulose, lignin and ash of these varieties were 32~39%, 19~24%, 17~22% and 6~11%, respectively. Among these varieties, 4 varieties of sorghum ${\times}$ sudangrass hybrids were selected for the evaluation of ethanol yield and those were pretreated with 1 M NaOH solution at $150^{\circ}C$ for 30 min using high temperature explosion system. After pretreatment, samples were neutralized with tap water. It contained 52~57% of cellulose. Simultaneous saccharification and fermentation (SSF) was carried out for 48 h at $33^{\circ}C$ by Saccharomyces cerevisiae CHY1011 using Green star variety. The yield of ethanol was 92.4% and the amount of ethanol production was estimated at 6206 L/ha.

• Food Science of Animal Resources
• /
• v.30 no.3
• /
• pp.479-486
• /
• 2010

Tolerance against heat, sanitizers, and antibiotics of 112 Cronobacter isolates classified by desiccation was determined to permit effective biocontrol in powdered foods. The isolates were classified into three groups: dry-tolerant (n=37), dry-sensitive (n=7), and dry-intermediate (n=68). The strains that were highly tolerant to drying also showed high heat tolerance that they seemed to have high tolerance to heat after dry stress in powdered foods like infant formula. Sodium hypochlorite and benzalkonium chloride concentrations necessary to achieve a 5-log reduction in viable counts (CFU/mL) were 15-25 ppm and 5-15 ppm, respectively. However, there was little difference of the efficacy of these sanitizers between dry-sensitive and -tolerant strains for planktonic cells suspended in 3% albumin. The minimal inhibition concentration (MIC) of $\beta$-lactam ampicillin was 64-128 ppm for 90% of the strains. The isolates were consistently sensitive to kanamycin and naldixic acid (MIC=4 ppm). Dry-tolerant strains displayed more antibiotic resistance than dry-sensitive strains. The results indicate that dry-tolerant Cronobacter isolates often possess heat and antibiotic resistance, indicated the need for potent sterilization treatments of powdered foods.

• Food Engineering Progress
• /
• v.22 no.4
• /
• pp.315-320
• /
• 2018

This study examined the effects of drying methods of Aronia melanocarpa on contents of total polyphenols and flavonoids, antioxidant activity and anti-inflammatory activity. As a result, freeze-dried aronia extract (FDAE) significantly exhibited higher contents of total polyphenols and flavonoids (155.76 mg GAE/g and 105.70 mg QE/g) than hot-air dried aronia extract (HDAE) (134.93 mg GAE/g and 82.29 mg QE/g). Also, FDAE showed greater antioxidant activity than HDAE in both DPPH and ABTS. For anti-inflammatory activity, NO production from lipopolysaccharide activated RAW264.7 cell reduced at a dose-dependent manner in both FDAE and HDAE. However, reduction rate of NO production is higher in FDAE (62.7%) than in HDAE (33.5%). These results suggest that comparatively, freeze-drying is a better method for preserving the antioxidant and anti-inflammatory activities and of aronia.

• Journal of Food Hygiene and Safety
• /
• v.38 no.6
• /
• pp.420-429
• /
• 2023

GC-MS/MS using liquid-liquid extraction (LLE) and C18 cartridges was used to identify and quantify levels of chlorpyrifos, chlorpyrifos-methyl, cypermethrin, deltamethrin and permethrin in bulk raw milk. A calibration curve spanning 10 ng/mL to 200 ng/mL was obtained with a satisfactory correlation coefficient of 0.99. The limits of detection (LOD) and limits of quantitation (LOQ) for chlorpyrifos, chlorpyrifos-methyl, cypermethrin, deltamethrin, and permethrin in the matrix ranged from 0.06 to 1.81 ng/mL and 0.19 to 6.04 ng/mL, respectively. The recoveries of 5 pesticides from spiked samples at 37.5-125 ng/mL ranged from 86.1 to 102.1%. The measurement of uncertainty of the GC-MS/MS method for these five pesticides was developed based on the analytical process and quantification. An analysis method that is easier and faster than the method specified in the Korean food standards codes for analyzing these five pesticides in raw material milk was developed. Moreover, the analytical method for chlorpyrifos, chlorpyrifos-methyl, cypermethrin, deltamethrin, and permethrin in bulk raw milk by GC-MS/MS was established.

• Journal of Mushroom
• /
• v.15 no.4
• /
• pp.223-228
• /
• 2017

This study was conducted to investigate the effects of fermented spent mushroom substrates (F-SMS) of Flammulina velutipes on growth performance, carcass traits, and economic characteristics of Hanwoo steers. A yeast strain (Saccharomyces sp. UJ14) and Bacillus strain (Bacillus sp. UJ03) isolated from fresh spent mushroom substrates of Flammulina velutipes were used as probiotics to prepare F-SMS. Twenty-four Hanwoo steers (14 months old) were allocated to three dietary treatments via a randomized block design and were slaughtered at 30 months of age. These treatment groups included Control (TMR), T1 (TMR containing 10% of F-SMS) group, and T2 (TMR containing 30% of F-SMS). Body weight gain was not influenced by the experimental diets. DM and TDN intakes in the finishing period were significantly (p < 0.05) greater in group T1 than in other groups. CP intake was significantly (p < 0.05) greater in group T2 than in other groups during the whole experimental period. Among carcass traits, rib-eye area and back fat thickness tended to increase with F-SMS supplementation. The appearance rate (%) of a meat yield more than grade A was the highest in group T1. The net profits increased by 1.2% and 13.3% in groups T1 and T2, respectively. In conclusion, if a proper feeding program (including feed safety) can be ensured, spent mushroom substrates of Flammulina velutipes can prove to be a highly profitable feed source for Hanwoo steers.

• Korean Journal of Poultry Science
• /
• v.39 no.3
• /
• pp.195-205
• /
• 2012

The objective of this study was to evaluate the effects of different levels of dietary ME on growth performance and carcass characteristics in two different strains of broiler chicken. A total of one thousand, 1-day-old A strain and R strain male chicks were randomly assigned into 8 treatments in a $2{\times}4$ factorial arrangement. They were fed iso-nitrogenic (CP 21%) crumbled diets formulated to contain metabolizable energy (ME) 2,950 to 3,250 kcal/kg in increment of 100 kcal/kg in the starter phase (1 to 21d) and iso-nitrogenic (CP 19%) pelleted diets containing same ME levels as in the finishing phase (22 to 38d). The body weight (BW) gain of chicks fed the lower ME diets (2,950 or 3,050 kcal/kg) were higher than those of the higher ME groups. The dietary energy level showed significant effects on feed intake and feed conversion rate (FCR) from 1 to 38 days of age (p<0.05). With the increment of dietary energy, feed intake tended to be reduced, whereas FCR was improved in the two strains of broiler chickens. The lowest FCR was observed at 3,250 kcal/kg diet groups in both of the two strains from 1 to 38 days of age. Feed intake and BW gain during 38 days were significantly affected by the strain factor. Increasing dietary energy up to 3,250 kcal/kg had no effect on the relative weights of breast meat and abdominal fat. The dietary energy and strains showed significant effects on the dressing percentage. There were no significant differences in various blood profiles except for GPT activity.