Browse > Article
http://dx.doi.org/10.9713/kcer.2018.56.6.856

Re-carbonation of Calcined Limestone Under Oxy-Circulating Fluidized Bed Combustion Conditions  

Kim, Ye Bin (Department of Mineral Resources and Energy Engineering, Chonbuk National University)
Gwak, You Ra (Department of Mineral Resources and Energy Engineering, Chonbuk National University)
Keel, Sang In (Environment Systems Research Division, Korea Institute of Machinery and Materials (KIMM))
Yun, Jin Han (Environment Systems Research Division, Korea Institute of Machinery and Materials (KIMM))
Lee, See Hoon (Department of Mineral Resources and Energy Engineering, Chonbuk National University)
Publication Information
Korean Chemical Engineering Research / v.56, no.6, 2018 , pp. 856-863 More about this Journal
Abstract
In order to investigate the re-carbonation behaviors of limestones in an oxy-circulating fluidized bed combustor (Oxy-CFBC), the re-carbonation characteristics of domestic 4 different limestone samples were analyzed in a thermogravimetric analyzer (TGA-N1000) with the higher concentration of $CO_2$. Effect of reaction temperature ($600{\sim}900^{\circ}C$) and $CaCO_3$ content (77~95%) of limestones were determined and the mass change of the CaO was observed. Under the temperature of $800^{\circ}C$, the conversion rate increased with increasing reaction temperature. However, the conversion rate decreased with increasing reaction temperature over $800^{\circ}C$. In the case of $CaCO_3$ content, the conversion was remarkably different at $870^{\circ}C$. In addition, reaction rate equations for simulating the re-carbonation of limestone by using gas solid reaction models were proposed in this study.
Keywords
Oxy-fuel combustion; Re-carbornation; Limestone; TGA; Kinetics;
Citations & Related Records
Times Cited By KSCI : 5  (Citation Analysis)
연도 인용수 순위
1 Gwak, Y. R., Kim, Y. B., Gwak, I. S. and Lee, S. H., "Economic Evaluation of Synthetic Ethanol Production by Using Domestic Biowastes and Coal Mixture," Fuel, 213, 115-122(2018).   DOI
2 Shin, J. H., Lee, L. S. and Lee, S. H., "Economic Assessment of a Indirect Liquefaction Process Using a Gasification with Petroleum Coke/coal Mixtures", Korean Chem. Eng. Res., 54, 501-509 (2016).   DOI
3 Lee, S. H., Kim, J. M., Eom, W. H., Ryi, S. K., Park, J. S. and Baek, L. H., "Development of Pilot WGS/multi-layer Membrane for $CO_2$ Capture," Chem. Eng. J., 207-208, 521-525(2012).   DOI
4 Lee, S. H., Park, S. T., Lee, R. S., Hwang, J. H. and Sohn, J. M., "Water Gas Shift Reaction in a Catalytic Bubbling Fluidized Bed Reactor," Korean J. Chem. Eng., 33, 3523-3528(2016).   DOI
5 Garcia-Labiano, F., Rufas, A., F. de Diego, L., de las Obras-Loscertales, M., Gayan, P., Abad, A. and Adanez, J., "Calcium-based Sorbents Behaviour During Sulphation at Oxy-fuel Fluidised Bed Combustion Conditions," Fuel, 90, 3100-3108(2011).   DOI
6 Jia, L., Tan, Y. and Anthony, E. J., "Emission of $SO_2$ and NOx During Oxy-fuel CFB Combustion Tests in a Mini-circulating Fluidized Bed Combustion Reactor," Energy Fuels, 24, 910-915 (2010).   DOI
7 Tian, L., Yang, W., Chen, Z., Wang, X., Yang, H. and Chen, H., "Sulfur Behavior During Coal Combustion in Oxy-fuel Circulating Fluidized Bed Condition by Using TG-FTIR," J. Energy Inst., 89(2), 264-270(2016).   DOI
8 Li, W., Li, S., Xu, M. and Wang, X., "Study on the Limestone Sulfation Behavior Under Oxy-fuel Circulating Fluidized Bed Combustion Condition," J. Energy Inst., 91(3), 358-368(2018).   DOI
9 Liljedahl, G., Turek, D., Nsakala, N., Mohn, N., Fout, T., "Alstom's Oxygen-fired Cfb Technology Development Status for $CO_2$ Mitigation," In:Proceedings of the 31st International Technical Conference on Coal Utilization & Fuel Systems.
10 Ramezani, M., Tremain, P., Doroodchi, E., Moghtaderi, B., "Determination of Carbonation/calcination Reaction Kinetics of a Limestone Sorbent in low $CO_2$ Partial Pressures Using TGA Experiments," E5nergy Procedia, 114, 259-270(2017).   DOI
11 Shin, J. H., Kim, Y. R., Kook, J. W., Gwak, I. S., Park, K. I., Lee, J. M. and Lee, S. H., "Desulfurization Characteristics of Domestic Limestones Through Simultaneous Calcination and Desulfurization Reaction," Appl. Chem. Eng., 26, 557-562(2015).   DOI
12 Lee, S. H. and Lee, J. M., "Introduction and Current Status of Ultra Supercritical Circulating Fluidized Bed Boiler," KEPCO J., 2, 211-221(2016).
13 Jeong, S. H., Lee, K. S., Keel, S. I., Yun, J. H., Kim, Y. J. and Kim, S. S., "Mechanisms of Direct and in-direct Sulfation of Limestone," Fuel, 161, 1-11(2015).   DOI
14 Chen, H. and Zhao, C., "$CO_2$ Capture Performance of Calciumbased Sorbents in the Presence of $SO_2$ Under Pressurized Carbonation," Chem. Eng. Technol., 39(6), 1058-1066(2016).   DOI
15 Wang, L., Li, S. and G, Eddings, E., "Fundamental Study of Indirect vs Direct Sulfation Under Fluidized Bed Conditions," Ind. Eng. Chem. Res., 54, 3548-3555(2015).   DOI
16 Kochel, A., Cieplinska, A. and Szymanek, A., "Flue Gas Desulfurization in Oxygen-enriched Atmospheres Using Modified Limestone Sorbents," Energy fuels, 29, 331-336(2015).   DOI
17 Wang, C., Jia, L., Tan, Y. and Anthony, E. J., "Carbonation of Fly Ash in Oxy-fuel CFB Combustion," Fuel, 87, 1108-1114(2008).   DOI
18 Wang, C., Jia, L. and Tan, Y., "Simultaneous Carbonation and Sulfation of CaO in Oxy-fuel Circulating Fluidized Bed Com-Bustion," Chem. Eng. Technol., 34(10), 1685-1690(2011).   DOI
19 Symonds, R. T., Lu, D. Y., Macchi, A., Hughes, R. W. and Anthony, E. J., "$CO_2$ Capture from Syngas Via Cyclic Carbonation/calcination for a Naturally Occuring Limestone:modeling and Benchscale Testing," Chem. Eng. Sci., 64, 3536-3543(2009).   DOI
20 Kook, J. W., Gwak, I. S., Gwak, Y. R., Seo, M. W. and Lee, S. H., "A Reaction Kinetic Study of $CO_2$ Gasification of Petroleum Coke, Coals, and Mixtures," Korean J. Chem. Eng., 34, 3092-3101 (2017).   DOI
21 Wen, C., "Noncatalytic Heterogeneous Solid-fluid Reaction Models," Ind. Eng. Chem., 60, 34-54(1968).
22 Ishida, M. and Wen, C., "Comparison of Kinetic and Diffusional Models for Solid-gas Reactions," AIChE J., 14, 311-317 (1968).   DOI
23 Kasaoka, S., Sakata, Y. and Tong, C., "Kinetic Evaluation of the Reactivity of Various Coal Chars for Gasification with Carbon Dioxide in Comparison with Steam," Int. Chem. Eng., 25(1), (1985).
24 Sun, P., Grace, J. R., Lim, C. J. and Anthony, E. J., "Determination of Intrinsic Rate Constants of the CaO-$CO_2$ Reaction," Chem. Eng. J., 63, 47-56(2008).   DOI
25 Abanades, J. C. and Alvarez, D., "Conversion Limits in the Reaction of $CO_2$ with Lime," Energy & Fuels, 17, 308-315(2003).   DOI
26 Obras-Loscertales, M., F. Diego, L., Garcia-Labiano, F., Rufas, A., Abad, A., Gayan, P. and Adanez, J., "Sulfur Retention in An Oxyfuel Bubbling Fluidized Bed Combustor:Effect of Coal Rank, Type of Sorbent and $O_2/CO_2$ Ratio," Fuel, 137, 384-392(2014).   DOI
27 Kim, Y. B., Gwak, Y. R., Keel, S. I., Yun, J. H. and Lee, S. H., "Direct Desulfurization of Limestones Under Oxy-circulating Fluidized Bed Combustion Conditions," Che. Eng. J., https://doi.org/10.1016/j.cej.2018.08.036.   DOI