Journal of Electrical Engineering and Technology

  • 제12권1호
  • /
  • Pages.78-90
  • /
  • 2017
  • /
  • 1975-0102(pISSN)
  • /
  • 2093-7423(eISSN)
대한전기학회 (The Korean Institute of Electrical Engineers)
권호 표지
DOI QR코드

DOI QR Code

Comparative Study of PI, Fuzzy and Fuzzy tuned PI Controllers for Single-Phase AC-DC Three-Level Converter

  • Gnanavadivel, J (Dept. of Electrical and Electronics Engineering, Mepco Schlenk Engineering College) ;
  • Senthil Kumar, N (Dept. of Electrical and Electronics Engineering, Mepco Schlenk Engineering College) ;
  • Yogalakshmi, P (Dept. of Electrical and Electronics Engineering, Mepco Schlenk Engineering College)
  • 투고 : 2015.06.21
  • 심사 : 2016.04.27
  • 발행 : 2017.01.02
PDF 다운로드
⟨ 이전 논문 다음 논문 ⟩

초록

This paper presents the design of closed loop controllers operating a single-phase AC-DC three-level converter for improving power quality at AC mains. Closed loop inhibits outer voltage controller and inner current controller. Simulations of three level converter with three different voltage and current controller combinations such as PI-Hysteresis, Fuzzy-Hysteresis and Fuzzy tuned PI-Hysteresis are carried out in MATLAB/Simulink. Performance parameters such as input power factor and source current total harmonic distortion (THD) are considered for comparison of the three controller combinations. The fuzzy-tuned PI voltage controller with hysteresis current controller combination provides a better result, with a source-current THD of 0.93% and unity power factor without any source side filter for the three level converter. For load variations of 25% to 100%, a THD of less than 5% is obtained with a maximum value of only 1.67%. Finally, the fuzzy-tuned PI voltage with hysteresis controller combination is implemented in a Xilinx Spartan-6 XC6SLX25 FPGA board for experimental validation of power quality enhancement. A prototype 100 W, 0-24-48 V as output converter is considered for the testing of controller performance. A source-current THD of 1.351% is obtained in the experimental study with a power factor near unity. For load variations of 25% to 100%, the THD is found to be less than 5%, with a maximum value of only 2.698% in the experimental setup which matches with the simulation results.

키워드

참고문헌

  1. M. M. Jovanovic and D. E. Crow, "Merits and limitations of full bridge rectifier with LC filter in Meeting IEC1000-3-2 Harmonic Limit Specifications," IEEE Trans. Ind. Applicat., vol. 33, pp. 551-557, Mar./Apr. 1997. https://doi.org/10.1109/28.568022
  2. R. Redl, "An economical single-phase passive powerfactor corrected rectifier: Topology, operation, extensions, and design for compliance," in Proc. IEEE Appl. Power Electron. Conf. (APEC), 1998, pp. 454-460.
  3. A. R. Prasad, P. D. Ziogas, and S. Manias, "A novel passive wave shaping method for single phase diode rectifiers," IEEE Trans. Ind. Electron., vol. 37, pp. 521-530, Dec. 1990. https://doi.org/10.1109/41.103457
  4. Limits for Harmonic Current Emissions (Equipment Input Current <16A per Phase), IEC 1000/3/2 Int. Std., 1995.
  5. "IEEE 519 Recommended practices and requirements for harmonic control in electrical power systems," Tech. Rep., IEEE Industry Applications Soc./Power Engineering Soc., 1993.
  6. B. Singh, B. N. Singh, A. Chandra, K. Al-Haddad, A. Pandey and D. P. Kothari, "A Review of Single-Phase Improved Power Quality AC-DC Converters," IEEE Trans. on Industrial Electronics, vol. 50, no. 5, pp. 962-981, Oct. 2003. https://doi.org/10.1109/TIE.2003.817609
  7. J. C. Crebier, B. Revol, and J. P. Ferrieux, "Boost-Chopper-Derived PFC Rectifiers: Interest and Reality", IEEE Trans. on Industrial Electronics, vol.52, no. 1, pp. 36-45, Feb. 2005. https://doi.org/10.1109/TIE.2004.841143
  8. S. Moon, L. Corradini and D. Maksimovic, "Autotuning of Digitally Controlled Boost Power Factor Correction Rectifiers," IEEE Trans. On Power Electronics, vol. 26, no. 10, pp. 3006-018, Oct. 2011. https://doi.org/10.1109/TPEL.2011.2125802
  9. M. Chen and J. Sun, "Feedforward Current Control of Boost Single- Phase PFC Converters", IEEE Trans. on Power Electronics, vol. 21, no. 2, pp.338-345, March 2006. https://doi.org/10.1109/TPEL.2005.869746
  10. H. C. Chen, H. Y. Li and R. S. Yang, "Phase Feedforward Control of Single-Phase PFC Boost-Type SMR", IEEE Trans. on Power Electronics, vol. 24, no. 5, pp. 1428-1432, May 2009. https://doi.org/10.1109/TPEL.2009.2013953
  11. H. C. Chang, and C. M. Liaw, "An Integrated Driving/Charging Switched Reluctance Motor Drive Using Three-Phase Power Module," IEEE Trans.on Industrial Electronics, vol. 58, no. 5, pp. 1763-1775, 2011. https://doi.org/10.1109/TIE.2010.2051938
  12. J. Y. Chai, Y. H. Ho, Y. C. Chang and C. M. Liaw, "On Acoustic-Noise-Reduction Control Using Random Switching Technique for Switch-Mode Rectifiers in PMSM Drive," IEEE Trans. on Industrial Electronics, vol. 55, no. 3, pp.2576-2584, Sep. 2008.
  13. L. S. Yang, T. J. Liang, H. C. Lee and J. F. Chen, "Novel High Step-Up DC-DC Converter With Coupled-Inductor and Voltage-Doubler Circuits", IEEE Trans. on Industrial Electronics, vol. 58, no. 9, pp. 4196-4206, Sep.2011. https://doi.org/10.1109/TIE.2010.2098360
  14. W. Li and X. He, "Review of Nonisolated High-Step-Up DC/DC Converters in Photovoltaic Grid-Connected Applications", IEEE Trans.on Industrial Electronics, vol. 58, no. 4, pp. 1239-1250, April 2011. https://doi.org/10.1109/TIE.2010.2049715
  15. A. Shahin, M. Hinaje, J. P. Martin, S. Pierfederici, S. Rael and B. Davat, "High Voltage Ratio DC-DC Converter for Fuel-Cell Applications," IEEE Trans. on Industrial Electronics, vol. 57, pp. 3944-3955, Dec. 2010. https://doi.org/10.1109/TIE.2010.2045996
  16. M. H. Todorovic, L. Palma, and P. N. Enjeti, "Design of a Wide Input Range DC-DC onverter With a Robust Power Control Scheme Suitable for Fuel Cell Power Conversion," IEEE Trans. on Industrial Electronics, vol. 55, no. 3, pp. 1247-1255, March 2008. https://doi.org/10.1109/TIE.2007.911200
  17. J. M. Kwon, B. H. Kwon and K. H. Nam, "Three-Phase Photovoltaic System with Three-Level Boosting MPPT Control," IEEE Trans. on Power Electronics, vol. 23, pp. 2319-2327, Sep. 2008. https://doi.org/10.1109/TPEL.2008.2001906
  18. V. Yaramasu, and B. Wu, "Three-Level Boost Converter Based Medium Voltage Megawatt PMSG Wind Energy Conversion Systems," Energy Conversion Congress and Exposition (ECCE), pp. 561-567, 2011
  19. M. T. Zhang, Y. Jiang, F. C. Lee, and M. M. Jovanovic, "Single-phase three-level boost power factor correction converter," in IEEE APEC,95, pp. 434-439, 1995.
  20. R. Greul, S. D. Round and J. W. Kolar, "The Delta-Rectifier: Analysis, Control and Operation" IEEE Trans. on Power Electronics, vol. 21, no. 6, pp. 1637-1648, Nov. 2006. https://doi.org/10.1109/TPEL.2006.882961
  21. B. R. Lin and H. H. Lu, "Single-Phase Power-Factor Correction AC/DC Converters with Three PWM Control Schemes" IEEE Trans. on Aerospace and Electronic Systems, vol. 36, no. 1, pp. 189-200, Jan. 2000. https://doi.org/10.1109/7.826321
  22. B. R. Lin and H. H. Lu, "A Novel PWM Scheme for Single-Phase Three-Level Power-Factor-Correction Circuit" IEEE Trans. on Industrial Electronics, vol. 47, pp. 245-252, Apr. 2000. https://doi.org/10.1109/41.836339
  23. Hung-Chi Chen and Jhen-Yu Liao, "Multiloop Interleaved Control for Three-Level Switch-Mode Rectifier in AC/DC Applications" IEEE Trans. on Industrial Electronics, Vol.61, No.7, July 2014.
  24. M.Rajesh and B.Singh, "Analysis, design and control of single phase three level power factor correction rectifier fed switched reluctance motor drive" IET power Electronics, vol.7, no.6, pp.1499-1508, June 2014. https://doi.org/10.1049/iet-pel.2013.0621
  25. N. Senthil Kumar, V. Sadasivam, H. M. Asan Sukriya "A Comparative Study of PI, Fuzzy, and ANN Controllers for Chopper-fed DC Drive with Embedded Systems Approach", Electric Power Components and Systems, vol. 36, no. 7, 2008, pp. 680-695 https://doi.org/10.1080/15325000701881944
  26. Prema Kannan, Senthil Kumar Natarajan, and Subhransu Sekhar Dash, "Design and Implementation of Fuzzy Logic Controller for Online Computer Controlled Steering System for Navigation of a Teleoperated Agricultural Vehicle," Mathematics problems in Engineering, Hindawi Publishing Corporation, Volume 2013, Article ID 590861,10 pages.
  27. A. Kessal, L. Rahmani, M. Mostefai, j. Gaubert, "Power factor correction based on fuzzy logic controller with fixed switching frequency" Electronics and Electrical Engineering - Kaunes: Technologija, 2012, no. 2(118), pp. 67-72.
  28. Sang-wha seo, Han ho choiad and yong Kim, 'Takagi-Sugeno fuzzy model based approach to robust control of boost DC-DC converters", Journal of Electrical Engineering and Technology, vol. 10, no. 3, pp. 925-934, may 2015. https://doi.org/10.5370/JEET.2015.10.3.925
  29. Hak-Seung Ro, Kyoung -GuLee, Hae-Guang Jeong and Kyo-Beun Lee, "Torque ripple minimization scheme using Torque sharing function based fuzzy logic control for a switched motor", Journal of Electrical Engineering and Technology, vol.10, no.1, pp. 118-127, January 2015. https://doi.org/10.5370/JEET.2015.10.1.118
  30. K. Prema, N. Senthil Kumar and Subhransu Sekhar Dash, "Online control of DC motors using fuzzy logic controller for remote operated robots", Journal of Electrical Engineering & Technology, vol.9, no.1, pp. 352-362, Jan 2014. https://doi.org/10.5370/JEET.2014.9.1.352
  31. H. C. Lee. "Robust adaptive fuzzy control by backstepping for a class of MIMO nonlinear systems", IEEE Trans. on Fuzzy Systems, vol.19 (2): 265-275, 2011. https://doi.org/10.1109/TFUZZ.2010.2095859
  32. Y. P. Pan, J. E. Meng, D. P. Huang, and Q. R. Wang. "Adaptive fuzzy control with guaranteed convergence of optimal approximation error", IEEE Trans. on Fuzzy Systems, pp.807-818, 2011.
  33. Manjun Cai and Yue Wang "A fuzzy-PI hybrid controller based on a disturbance Observer", IEEE Trans. Ninth International Conference on Natural Computation (ICNC) on 2013.
  34. Sima Seidi Khorramabadi and Alireza Bakhshai," Critic-based self-tuning PI structure for active and reactive power control of VSCS in microgrid systems", IEEE Trans. on smart grid, pp. 1949-3053, 2014.
  35. A. Balestroni, A. Landi, and L. Sani, "CUK converter global control via fuzzy logic and scaling factors," IEEE Trans. Ind. Applications, vol. 38, no. 2, pp. 406-413, Mar./Apr. 2002. https://doi.org/10.1109/28.993162
  36. Jin Zhao and Bimal K.Bose, "Evaluation of membership functions for fuzzy logic controlled induction motor drive", in IEEE IECONOZ, pp.229-234, 2002.