DOI QR코드

DOI QR Code

배열회수 보일러 단일 휜튜브의 양력과 항력 변동에 따른 PSD 특성 연구

The Power Spectral Density Characteristics of Lift and Drag Fluctuation of Fin Tube in a Heat Recovery Steam Generator

  • 하지수 (계명대학교 기계자동차공학과) ;
  • 이부윤 (계명대학교 기계자동차공학과)
  • Ha, Ji Soo (Mechanical&Automotive Engineering Dept., Keimyung University) ;
  • Lee, Boo Youn (Mechanical&Automotive Engineering Dept., Keimyung University)
  • 투고 : 2015.10.24
  • 심사 : 2016.03.19
  • 발행 : 2016.04.30

초록

배열회수 보일러의 전열관군은 외부에 고온의 배기가스가 흐르면서 유동 유발 진동을 야기 시키며 배열회수 보일러의 전열관군에서 파손을 야기할 수 있어서 열교환기의 구조적 안정성을 위해 열교환기의 전열관군에서 유동 유발 진동 특성을 규명할 필요가 있다. 일반적인 열교환기 전열관군에서 유동 유발 진동에 관한 실험적 연구는 기존에 많이 진행되어 오고 있으며 단일 원관이나 전열관군의 원관들에서 유동 유발 진동에 대한 무차원 PSD(Power Spectral Density) 함수를 무차원 주파수인 Strouhal 수, fD/U의 함수로 도출된 실험적 결과들이 도출되어 있다. 본 연구는 배열회수 보일러에 사용하는 휜튜브 전열관군에서 유동 유발 진동 특성을 규명하는 것을 목적으로 한다. 이러한 것을 위해 단일 휜튜브에서 비정상 상태 유동해석을 수행하여 주기적인 와동 발생 특성과 단일 휜튜브에서의 양력과 항력 변화 특성을 살펴보았다. 또한 단일 휜튜브에서 양력과 항력 변동 특성으로부터 유동 유발 진동에 따른 PSD 특성 결과를 도출하여 기존에 단순 원관에서 이루어졌던 연구들과 비교를 통해 단일 휜튜브 주위의 PSD 특성을 정립하였다.

Heat exchanger tube array in a heat recovery steam generator is exposed to the hot exhaust gas flow and it could cause the flow induced vibration, which could damage the heat exchanger tube array. It is needed for the structural safe operation of the heat exchanger to establish the characteristics of flow induced vibration in the tube array. The researches for the flow induced vibration of typical heat exchangers have been conducted by using single cicular tube or circular tube array and the nondimensional PSD(Power Spectral Density) function with the Strouhal number, fD/U, had been derived by experimental method. From the present study, the basis for the application of flow induced vibration to the heat recovery steam generator tube array would be prepared. For the previous mentioned purpose, the present CFD analysis introduced a single fin tube and calculated with the unsteady laminar flow over the single fin tube. The characteristics of vortex shedding and lift and drag fluctuation over the fin tube was investigated. The derived nondimensional lift PSD was compared with the results of the previous experimental studies and the characteristics of lift and drag PSD over a single fin tube was established from the present CFD study.

키워드

참고문헌

  1. R.D. Blevins, R. J. Gibert and B. Villard, "Experiment on vibration of heat exchanger tube arrays in cross-flow", Trans. 6th Int. Conf. on Structural Mechanics in Reactor Technology, Paper B6/9, (1981)
  2. C. Taylor, M.J. Pettigrew, F. Axisa and B. Villard, "Experimental determination of single and two-phase cross flow induced forces on tube raws", Flow Induced Vibration, pp. 31-39, PVP Vol. 104, (1986)
  3. S.S. Chen and J.A. Jendrzejczyk, "Fluid excitation forces acting on square tube array", Journal of Fluids Engineering, Vol. 109/415, (1987)
  4. F. Axisa, J. Antunes, B. Villard and M. Wullschleger, "Random excitation of heat exchanger tubes by cross-flows", Int. ASME Winter Symposium on Low-Induced Vibrations and Noise, CEA-CONF-9744, (1988)
  5. S.V. Patankar, "Numerical Heat Transfer and Fluid Flow", pp. 126-131, (1980)
  6. K.B. Lee, B.W. Kim, J.S. Yang, M.K. Kim and S.S. Jang, "A study on flow-induced vibration of tube array in uniform cross flow ( I )", Transactions of the KSME B, pp 924-932, Vol. 16, No. 5, (1982)
  7. S.S. Paul, S.J. Ormiston and M.F. Tachi, "Experimental and numerical investigation of turbulent cross-flow in a staggered tube bundle", International Journal of Heat and Fluid Flow, pp 387-414, Vol. 29, (2008) https://doi.org/10.1016/j.ijheatfluidflow.2007.10.001
  8. J.S. Ha, "The power spectral density characteristics of lift and drag fluctuation on a heat exchanger circular tube", Journal of the Korean Institute of Gas, pp 35-40, Vol. 19, No. 4, (2015) https://doi.org/10.7842/kigas.2015.19.4.35