DOI QR코드

DOI QR Code

규소강판을 이용한 실드케이스의 차폐효과

A Study on Shield Effect of Shield Case using SiFe Sheet

  • 신동규 (부경대학교 전기공학과) ;
  • 김영학 (부경대학교 전기공학과)
  • Shin, Dong-Gyu (Dept. of Electrical Eng. Pukyong National University) ;
  • Kim, Young-Hak (Dept. of Electrical Eng. Pukyong National University)
  • 투고 : 2013.11.01
  • 심사 : 2013.12.04
  • 발행 : 2014.02.28

초록

The shield effect of 4 layered shield case was investigated in this paper. The material of the case was non-oriented SiFe sheet with a thickness of 0.5mm. The size of the case was 100mm wide, 100mm high and 300mm long. Relative permeability of SiFe sheet was needed to calculate shield effect. It was obtained from the measurement by a ferrite yoke and from the calculation by eddy current FEM analysis. Three configurations were used to connect both ends of SiFe sheet. First one is a connection by double-welded butt. Second one is to put the sheet the same material above the confronted both ends of the sheet to avoid a leakage magnetic flux. The last one is ideally without any connection. The shield effect of the second one agreed well with the last one and showed the shield effect of -40dB.

키워드

참고문헌

  1. D. Cohen, "Large-volume conventional magnetic shields," Rev. Phys.Appl., Vol. 5, pp. 53-58, 1970. https://doi.org/10.1051/rphysap:019700050105300
  2. V. O. Kelha et al., "Design, construction, and performance of a large-volume magnetic shield," IEEE Trans. Magn., Vol. 18, no. 1, pp.260-269, Jan. 1982. https://doi.org/10.1109/TMAG.1982.1061780
  3. J. Bork et al., "The 8-layered magnetically shielded room of the PTB:Design and construction," in Proc. Biomag2000, 12th Int. Conf. Biomagnetism,Espoo, Finland, pp. 970-973.
  4. K. Tashiro and I. Sasada, "A Low-Cost Magnetic Shield Consisting of Nonoriented Silicon Steel", IEEE Trans. Magn., Vol. 41, 2005.
  5. Vaino O. Kelpha, R. Peltonnen and Borje Rantala, "The effect of shaking on magnetgic shields", IEEE Trans. Magn., Vol. 16, 1980.
  6. K. S. Shin, "3-D Magnetic Feild Simulation of Open-ended Cylinder Type Magnetic Shield", Jounal of the Korean Magnetic Society, Vol. 21, No. 3, , pp 99-103, 2011. https://doi.org/10.4283/JKMS.2011.21.3.099
  7. http://www.posco.co.kr/homepage/docs/kor3/dn/product/info/k_electrical_pdf_2011.pdf, 2013.
  8. Y. H. Kim, "B-H Loop Measurement of a High Tensile Steel Plate", Jounal of the Korean Magnetic Society, Vol. 20, No. 3, , pp 94-99, 2010. https://doi.org/10.4283/JKMS.2010.20.3.094