한국수산과학회지 (Korean Journal of Fisheries and Aquatic Sciences)

  • 제36권4호
  • /
  • Pages.340-345
  • /
  • 2003
  • /
  • 0374-8111(pISSN)
  • /
  • 2287-8815(eISSN)
한국수산과학회 (The Korean Society of Fisheries and Aquatic Science)
권호 표지
DOI QR코드

DOI QR Code

추출 및 건조방법이 다시마 (Laminaria japonica) 알긴산의 물성에 미치는 영향

Effects of Extracting and Drying Method on Physical Properties of Alginates from Sea Tangle, Laminaria japonica

  • 유병진 (강릉대학교 식품과학과) ;
  • 임영선 (강릉대학교 동해안해양생물자원센터)
  • YOU Byeong Jin (Department of Food Science, Kangnung National University) ;
  • LIM Yeong Seon (East coastal Marine Bioresources Research Center (EMBRC), Kangnung National University)
  • 발행 : 2003.08.01
PDF 다운로드
⟨ 이전 논문 다음 논문 ⟩

초록

In order to choose the manufacturing method for extracting alginates from sea tangle, Laminaria japonica, three methods were applied. In Method I, alginates were extracted with NaOH solution from sea tangle powder and extracted alginates were precipitated and converted to alginic acid by $CaCl_2$ and HCI solution. Then alginic acid was converted to sodium alginates with $Na_2CO_3$ solution. Sodium alginates were precipitated with methyl alcohol and were resolved with hot water and this step was repeated three times. Method II was same to Method I except final step including that sodium alginates were precipitated and washed with methyl alcohol three times. Method III included that sodium alginates were extracted with $Na_2CO_3$ solution from sea tangle powder then sodium alginates were precipitated and washed with methyl alcohol three time. Extracting time increased with Increasing extracted alginates amounts but increasing rates were below $0.4\%/h.$ Alginates amounts recovered by Method III showed above 2 times more to those by Method I and II. Extracting time increased with increasing ash amount of sodium alginates but increasing rates were below $0.1\%/h.$ and that of sodium alginates extracted by Method III showed higher value $(5\%)$ than those by Method I and II. In the sodium alginates prepared by Method III, the amount of ash in alginates dried by air was $34.4\%,$ that by vacuum freeze drying was $47.8\%.$ Extracting time increased with decreasing average molecular weight (MW) and degree of polymerization (DP) of sodium alginates, MW and DP of alginates prepared by Method III were higher than those by Method I and II In same extracting time. Extracting time increased with decreasing rate of apparent viscosity change (SAV) of alginates solution, and SAV of alginates prepared by Method III showed higher value than those by Method I and II in same extracting time. SAV of alginates dried by air was higher than that by vacuum freeze drying. Relating equation among SAV MW and DP were MW = 60.066 (SAV) -93.950, DP =309.760 (SAV) -485.084 and MW = 0.914 (DP)+0.213.

키워드

참고문헌

  1. AOAC. 1990. Official Methods of Analysis, 15th ed. Association of Official Analytical Chemists. Arling-ton, pp. 17
  2. Armstrong, B., A.J. Van Merwyk and H. Coates. 1977. Blood pressure in seventh-day advantist vegeterians. Am. J. Epidemiol., 105, 444-449 https://doi.org/10.1093/oxfordjournals.aje.a112403
  3. Brussard, J.H., J.M.A. Van Raaij, M. Stasse-Wolthuis, M.B. Katan and J.G.A.J. Hautvast. 1981. Blood pressure and diet in normotensive volunteers: Absence of an effect of dietary fiber, protein, or fat. Am. J. Clin. Nutr., 34, 2023-2029
  4. Chapman, D.J. 1980. Algin and alginates. In: Seaweeds and Their Uses, Chapman, V.J. ed. Chapman and Hall, New York, pp. 194-225
  5. Dubois, M., K.A. Gilles, J.K. Hamilton, P.A. Rebers and F. Smith. 1956. Colarimetric method for determination of sugars and related substances. Anal. Chem., 28, 350-357 https://doi.org/10.1021/ac60111a017
  6. Ducan, D.B. 1955. Multiple-range and multiple F tests. Biometics, 11, 1-42 https://doi.org/10.2307/3001478
  7. Fujihara, M. and T. Nagumo. 1993. An influence of the structure of alginate on the chemotectic activity of macrophages and the antitumor activity. Carbohydr.Res., 243, 211-215 https://doi.org/10.1016/0008-6215(93)84094-M
  8. Fujiki, K., H. Matsuyama and T. Yano. 1994. Protective effect of sodium alginates against bacterial infection in common carp, Cyprinus Carpio. L. J. Fish Dis., 17, 349-354 https://doi.org/10.1111/j.1365-2761.1994.tb00230.x
  9. Gardey, T., P.G. Burstyn and T.G. Taylor. 1978. Fat induced hypertention in rabbits. I. The effects of fibre on the blood pressure increase induced by coconut oil. Proc. Nutr. Soc., 37, 97A
  10. Hajime, O., S. Yasushi, Y. Kanto, U. Isamu and K. Koichi. 1994. Possible antitumor promoting properties of marine algae and in vitro activity of Wakame seaweed extract. Biosci. Biotech. Biochem., 56, 994-999 https://doi.org/10.1271/bbb.56.994
  11. Harrison, G.E., E.R. Humphreys, A. Sutton and H. Shephard. 1966. Strontium uptake in rats on alginate-supplemented diet. Science, 152, 655-656 https://doi.org/10.1126/science.152.3722.655
  12. Haug, A. 1959. Ion exchange properties of alginate fractions. Acta Chem. Scand., 13, 1250-1251 https://doi.org/10.3891/acta.chem.scand.13-1250
  13. Haug, A. 1961. The affinity of some divalent metals to different types of alginates. Acta Chem. Scand., 15, 1794-1795 https://doi.org/10.3891/acta.chem.scand.15-1794
  14. Haug, A. 1964. Composition and properties of alginates. Rept. 30, Norwegian Institute Seaweed Reserch, Trondheim, Norway
  15. Haug, A. and B. Larsen. 1962. Quantitative determination of the uronic acid composition of alginates. Acta Chem. Scand., 16, 1908-1918 https://doi.org/10.3891/acta.chem.scand.16-1908
  16. Hedeki, O., S. Jitsuo and K. Yoshinari. 1993. Direct control of the constituents ratio in a wide range in alginate produced by Azobacter vinelandii. Biosci. Biotech. Biochem., 57, 332-336 https://doi.org/10.1271/bbb.57.332
  17. Hidaka, H., T. Eida, T. Takizawa, T. Tokuzawa and Y. Tashiro. 1986. Effect of fructooligosaccharide on intestinal flora and human health. Bifido. Microbiol.,5, 37-50
  18. Hirst, E.L., E. Percival and J.K. Wold. 1964. The structure of alginic acid. Part IV. Partial hydrolysis of the reduced polysaccharide. J. Chem. Soc., 8, 1493-1499
  19. Kennedy, M., P.G. Burstyn and D.R. husbands. 1978. Fat induced hypertension in rabbits. 2. The effects of feeding diets containing high concentrations of safflower oil & palm oil. Proc. Nutr. Soc., 37, 98A
  20. Kimmura, T., K. Takahashi, Y. Ueda, H. Obika, Y. Kobayashi and K. Tsuji. 1993. Effects of the primary structure of alginate on fecal excretion of sodium in rats. Nippon Nogeikagaku Kaishi, 67, 1177-1183 https://doi.org/10.1271/nogeikagaku1924.67.1177
  21. Kobayashi, N., Y. Kanazawa, S. Yamabe, K. Iwata, M. Nishizawa, T. Yamagishi, O. Nishikaze and K. Tsuji. 1997. Effects of depolymerized sodium alginate on serum total cholesterol in healthy women with a high cholesterol intake. J. Home Econo. Japan, 48, 255-230
  22. Mancini, M., M. Moresi and F. Sappino. 1996. Rheological behaviour of aqueous dispersions of algal sodium alginates. J. Food Eng., 28, 283-295 https://doi.org/10.1016/0260-8774(95)00068-2
  23. Mitchell, J.R. and D.A. Ledward. 1986. Functional Pro-perties of Food Macromolecules. Elsvier Applied Science Pub., London, pp. 1-78
  24. Oerther, S., H. Le Gall, E. Payan, F. Lapicque, N. Presle, P. Hubert, J. Dexheimer, P. Netter and F. Lapicque. 1999. Hyaluronate-alginate gel as a novel biomaterial: Mechanical properties and formation mechanism. Biotech. Bioengin., 63, 206-215 https://doi.org/10.1002/(SICI)1097-0290(19990420)63:2<206::AID-BIT9>3.0.CO;2-8
  25. Penman, A. and G.R. Sanderson. 1972. A method for the determination of uronic acid sequence in alginate. Carbohydr. Res., 25, 273-282 https://doi.org/10.1016/S0008-6215(00)81637-7
  26. Somogyi, M. and N. Nelson. 1952. Notes on sugar determi-nation. J. BioI. Chem., 195, 19-23
  27. SPSS, Inc. 2001. Sigma Plot 7.0 for window, SPSS. Inc., 233 South Wacker Drive, Chicago, USA, 11 60606-6307
  28. Suzuki, T., K. Nakai, Y. Yoshie, T. Shirai and T. Hirano. 1993. Digestibility of dietary fiber in brown alga, kombu, by rats. Nippon Suisan Gakkaishi, 59, 879-884 https://doi.org/10.2331/suisan.59.879
  29. Turquois, T. and H. Gloria. 2000. Determination of the absolute molecular weight averages and molecular weight distributions of alginates used as ice cream stabilizers by using multiangle laser light scattering measurements. J. Agric. Food Chem., 48, 5455-5458 https://doi.org/10.1021/jf000003v
  30. Wright, A., P.G. Burstyn and M.J. Gibney. 1979. Dietary fibre and blood pressure. Br. Med. J., 2, 1541-1543 https://doi.org/10.1136/bmj.2.6204.1541
  31. You, B.J., Y.S. Im, I.H. Jeong and K.H. Lee. 1997. Effect of extraction conditions on bile acids binding capacity in vitro of alginate extracted from sea tangle (Laminaria spp.). J. Kor. Fish. Soc., 30, 31-38 (in Korean)

피인용 문헌

  1. Effects of Hydrolysis pH on Distribution of Molecular Weights of Alginates of Sea Tangle Laminaria japonica vol.39, pp.4, 2006, https://doi.org/10.5657/kfas.2006.39.4.313
  2. Effects of Hydrolysis Time on the Molecular Weight Distribution of Alginates Prepared from Sea Tangle Laminaria japonicus vol.8, pp.3, 2005, https://doi.org/10.5657/fas.2005.8.3.113
  3. Effects of Dialysis and Various Drying Methods on Physical Properties of Alginates Prepared from Sea Tangle, Laminaria japonica vol.38, pp.4, 2005, https://doi.org/10.5657/kfas.2005.38.4.226
  4. 다시마 Laminaria iaponicus 알긴산의 분자량 분포에 미치는 가수분해 온도의 영향 vol.40, pp.4, 2003, https://doi.org/10.5657/kfas.2007.40.4.187
  5. 글루텐의 표면소수성에 미치는 전해질, pH 및 다시마(Sacchrina japonicas) 알긴산나트륨의 분자량의 영향 vol.54, pp.4, 2003, https://doi.org/10.5657/kfas.2021.0543