• 센서학회지
• /
• 제24권1호
• /
• pp.10-14
• /
• 2015

This paper reports the results of a study on the optimization of the etching profile, which is an important factor in deep-reactive-ion etching (DRIE), i.e., dry etching. Dry etching is the key processing step necessary for the development of the Internet of Things (IoT) and various microelectromechanical sensors (MEMS). Large-area etching (open area > 20%) under a high-frequency (HF) condition with nonoptimized processing parameters results in damage to the etched sidewall. Therefore, in this study, optimization was performed under a low-frequency (LF) condition. The HF method, which is typically used for through-silicon via (TSV) technology, applies a high etch rate and cannot be easily adapted to processes sensitive to sidewall damage. The optimal etching profile was determined by controlling various parameters for the DRIE of a large Si wafer area (open area > 20%). The optimal processing condition was derived after establishing the correlations of etch rate, uniformity, and sidewall damage on a 6-in Si wafer to the parameters of coil power, run pressure, platen power for passivation etching, and $SF_6$ gas flow rate. The processing-parameter-dependent results of the experiments performed for optimization of the etching profile in terms of etch rate, uniformity, and sidewall damage in the case of large Si area etching can be summarized as follows. When LF is applied, the platen power, coil power, and $SF_6$ should be low, whereas the run pressure has little effect on the etching performance. Under the optimal LF condition of 380 Hz, the platen power, coil power, and $SF_6$ were set at 115W, 3500W, and 700 sccm, respectively. In addition, the aforementioned standard recipe was applied as follows: run pressure of 4 Pa, $C_4F_8$ content of 400 sccm, and a gas exchange interval of $SF_6/C_4F_8=2s/3s$.

• 한국식생활문화학회지
• /
• 제31권1호
• /
• pp.1-32
• /
• 2016

This research intended to conduct literary research on 'Jeok' of 25 jong-ga through Jong-ga Ancestral Ritual Formalities and Food, published by the Cultural Heritage National Research Institute of Cultural Heritage during 2003~2008, and compared and analyzed an arranging method and recipe transmission process by directly visiting four Jong-ga. Religious ceremony foods of Jong-ga could be divided according to the standard of the hakpa attribute (large), regional attribute (midium), and family attribute (small), which forms a complex connection structure between the attributes. 'Jeok' arranging form is divided into '3-Jeok building method (vertical structure)', '3-Jeok arrangement method (horizontal structure)', '3-Jeok replacement method', '2-Jeok arrangement method', 'Jeon-Jeok arrangement method', and 'Others-Jeok arrangement method'. Generally, 'jeok' arrangement order per hakpa is in the order of 'meat jeok - chicken jeok - fish jeok' in case of Gihohakpa, whereas Yeongnamhakpa is in the order of 'fish jeok - meat jeok - chicken jeok'. Umoringye (羽毛鱗介), the method of laying 'dojeok' of the Gyeongbuk region, could be found in the 2nd century B.C. Chinese ancient book Hoenamja and the theoretical background was Yin and yang philosophy (陰陽論). This research has significance in terms of securing advanced results compared to advanced research that has so far concentrated on some regions and hakpas.

• 한국식품조리과학회지
• /
• 제32권6호
• /
• pp.782-790
• /
• 2016

Purpose: This study aims to develop menu for tofu, which will satisfy a variety of needs of people by harmonizing tofu and other ingredients. Methods: In the present study, the standard recipes were made for tofu menu development by improving the existing recipes like Dubu-seon, Dubu-kimchi, Dubu-jeongol, and Sundubu-jjigae (soft tofu stew). Based on newly developed recipes, the nutritional analysis was conducted using the analyzing program of the Korean Nutrition Society (CAN-Pro 4.0). Food styling was devised considering the shape and color of plates, layout, and color harmony. Table design was devised empirically employing tablecloth, napkin, dinnerware, glasses, cutlery, centerpiece, and figures. Results: Food styling of Dubu-seon was devised by improving the visual aspect, using Korean traditional five cardinal colors. It turns out that the improvised version of Dubu-seon (prepared following the new recipe) can satisfy 15.1% of amount of recommended dietary fiber intake per day for both male and female adults. In case of Dubu-kimchi, the dish was developed as a one-dish meal by supplementing protein and improving food styling. Beef was added in a form of a meatballs which is especially preferred by children. However, the amount of salt was reduced due to the strong and spicy taste of kimchi itself, resulting in 32% of daily intake of sodium. Dubu-jeongol was also improvised by reducing protein content, and more vegetables were added. Food styling was also improved. Concerning Sundubu-jjigae, protein was supplemented by addition of mushrooms rather than the existing way of adding shellfish. The sodium content was 133.88 mg, which is merely 10% of daily intake. Conclusion: With the new developments in tofu menus, new food styling, and table design, this study aims to contribute towards the rise in sales in the food service industry in terms of being used as basic and critical data.

• 한국식품조리과학회지
• /
• 제32권6호
• /
• pp.800-810
• /
• 2016

Purpose: This study aimed to characterize the recipes of Hwachae in Korean cookbooks published from the 1600's to 1940's. Methods: We conducted a content analysis of thirteen old cookbooks (Eumsikdimibang, Jubangmun, Jeungbosallimgyeongje, Kyugonyoram, Imwonsibyukji, Gyuhapchongseo, Sieuijeonseo, Buinpilji, Chosunyorijebub, Chosunmusangsinsikyorijebub, Ganpyeonchosunyorijebub, Chosunyori, Chosunyoribub). We collected a total of 99 recipes of Hwachae and analyzed the ingredients used and characteristics of the recipes according to five groups of Hwachae: noodle type Hwachae, dumpling type Hwachae, fruit Hwachae, flower Hwachae, and the others. Results: The noodle type Hwachae included Changmeyon, Smyeon, Nanmyeon, and Waemyeon. Mung bean (81.0%) and Schisandra (95.2%) were mostly employed as solid ingredient and as beverage base, respectively. In the noodle type Hwachae, Wonsobyeong and Sudan belonged to the dumpling type Hwachae, in which mung bean (51.7%) was mostly used as solid ingredient and just water without any additive was used as the most popular beverage base (62.1%) unlike in other types of Hwachae. There were various types of fruit Hwachae, which used different fruits as solid ingredient such as pear, peach, cherry, strawberry, etc. Pears (44.4%) have been employed as the most popular ingredient and sweets such as honey and sugar have been used in all the fruit Hwachae. The flower Hwachae included Hwamyeon, Sunchaehwachae, Jangmihwachae, and Bomhwachae. In all the flower Hwachae, schizandra has been used as a beverage base. Conclusion: These findings provide basic information required for developing standard recipes of traditional Hwachae.

• 한국식생활문화학회지
• /
• 제32권4호
• /
• pp.275-286
• /
• 2017

The purpose of this study was to provide basic data for development of a recipe for muslim-friendly halal Korean foods through investigation of awareness of Korean foods, taste evaluation, and menu preferences. After Korean foods' menu range and standard were set up for the survey and in-depth interviews with three halal food experts were conducted, 35 kinds of halal Korean foods were examined. The present study conducted a survey on 205 foreign Muslims living in Jeonju-si, Jeonbuk and Gimpo-si, Gyeonggi who ate Korean foods. Foreign Muslims were male workers in their 20's residing in company housing, and their monthly mean income was 1.01~2 million KRW. The majority of subjects responded that meal problems were the most difficult in everyday life. Concerning the taste of Korean foods, the response rate of 'sweet' and 'spicy' was high while 'Korean food is healthy' and 'Korean food ingredients is fresh' were high for awareness of Korean foods. 'Bulgogi' was the most preferred among the selected Korean foods, which was in line with the results of previous research. There is a need to provide information on Korean foods that can be made with food ingredients certified as halal and their recipes through various media for foreign Muslims who have limitations on in meals due to religious factors.

• 한국가정과학회지
• /
• 제5권1호
• /
• pp.48-61
• /
• 2002

This study was carried out to investigate the effects of four kinds of leavening agents on Jeung-Pyun fermantation. Milk-wine(M), fresh yeast(F), dry yeast(D), instant yeast(I) were used in Jeung-Pyun ingredients. The physicochemical properties, sensory evaluation were examined. The results of this study are summarized as follows: 1. Basic recipes for Jeung-Pyun by preliminary test were developed. 2. Specific volumes and expansion ratio of Jeung-Pyun was higher in the fresh yeast-added sample. 3. The pH of Jeung-Pyun was decreased significantly as the fermentation progressed 4. In the result comparing Jeung-Pyun extracting after 1st fermentation with Jeung-Pyun extracting 2nd fermentation by SEM, the former was widely distributed in stability of bubble and pore than the latter. 5. Standard recipe by Q.D.A. test added four kinds of leavening agents were as follows: (1)Jeung-Pyun added milk wine was 240min for 1st fermentation time, 60min for 2nd fermentation time, 35$^{\circ}C$ for fermentation temperature, 80% for fermentation humidity respectively. (2) Jeung-Pyun added fresh yeast was 90min for 1st fermentation time, 40min for 2nd fermentation time, 35$^{\circ}C$ for fermentation temperature, 80% for fermentation humidity respectively. (3)Jeung-Pyun added dry yeast was 90min for 1st fermentation time, 60min for 2nd fermentation time, 35$^{\circ}C$ for fermentation temperature, 60% for fermentation humidity respectively. (4)Jeung-Pyun added instant yeast was 90min for 1st fermentation time, 40min for 2nd fermentation time, 30$^{\circ}C$ for fermentation temperature, 60% for fermentation humidity respectively. 6.Based on sensory evaluation, Jeung-Pyun added fresh yeast was significantry higher than others in color, sweetness, moistness, softness, and overall quality. There was negative significance between milk wine flavor and astrigentness, and yeast flavor.

• 한국식품과학회지
• /
• 제29권4호
• /
• pp.700-704
• /
• 1997

Gluten 대체 재료로써 gum질과 지방질 및 활성 gluten을 첨가하여 쌀빵의 특성을 비교 검토 하였다. 실험에 사용한 모든 종류의 gum질 첨가에 의해서 쌀빵의 제조는 가능하였으며, 특히 3% hydroxypropyl-methyl-cellulose를 첨가하여 제조하는 경우 제빵의 성형성이 좋았다. 쌀빵 제조시 첨가하는 지방질로는 상온에서 액체상인 식용유를 사용하는 편이 고체상의 지방인 마아가린이나 라아드 보다 쌀빵의 비용적을 증가시키며, 부드러운 조직감을 부여하고 있었다. 쌀빵 제조시의 가열방법은 습식가열보다는 건식가열이 바람직한 결과를 얻었다. 3% hydroxypropyl-methyl-cellulose를 첨가하여 품종별 쌀로서 빵을 제조한 경우, 한강찰벼를 제외한 모든 품종에서 쌀빵 제조가 가능하였으며, 특히 수원조, AC 27, IR 44 등의 쌀로서 제조한 쌀빵의 성형성은 아주 좋았다. Gluten과 강력분을 첨가하여 제조하는 경우에도 한강찰벼를 제외한 모든 품종에서 쌀빵 제조가 가능하였으며, 수원 230이나 Pusa-33-30 등의 쌀로서 제조한 것이 다른 품종의 쌀보다 제빵성이 좋았다.

• Preventive Nutrition and Food Science
• /
• 제8권2호
• /
• pp.149-153
• /
• 2003

Effects of kimchi and its ingredients, vitamin C and $\beta$-sitosterol on the growth of Helicobacter pylori were investigated. Three kimchi variations were studied: a standard recipe (kimchi I) and two functional variations for cancer prevention and treatment made with organically grown ingredients (kimch II and III). Methanol extracts and juices from kimchi I and III did not inhibit the growth of H. pylori. However, 10 mm and 12 mm inhibition zones were formed by methanol extract and juice from kimchi II, which had higher concentrations of red pepper powder (RPP) than those of kimchi I and III. Among the major kimchi ingredients, methanol extracts of RPP, garlic and ginger substantially inhibited the growth of H. pylori. The maximal inhibition zone (30 mm) was attained with garlic treatment. Inhibitory effects of the RPP, garlic and the sub-ingredient mixture (prepared with radish, garlic, RPP, ginger, green onion, sugar and fermented anchovy juice) on H. pylori were decreased by lactic acid bacteria fermentation. Neither the fermented garlic nor the fermented sub-ingredient mixture inhibited the growth of H. pylori. But, the inhibition Bone of fermented RPP was 12 mm, which was less than the 16 mm inhibition zone formed by the non-fermented RPP. Vitamin C and $\beta$-sitosterol which are known to be functional active compounds of kimchi also showed no inhibitory effect on the growth of H. pylori after 3 days of incubation. Further study is needed to determine why the inhibitory effect is removed or decreased by lactic acid fermentation, and to determine if fresh kimchi and lactic acid bacteria of kimchi can inhibit the growth of H. pylori.

• 동아시아식생활학회지
• /
• 제21권5호
• /
• pp.706-712
• /
• 2011

단순 가공 식재료 개발의 고부가가치와 국내산 식품재료의 활용도를 높이기 위하여 무생채 원재료인 무와 배를 혼합한 무배생채를 개발하여 저장 중 미생물학적 및 품질특성을 측정하였으며, 매실 소스를 개발하여 레시피 기준 설정을 위한 관능적 특성을 평가한 결과는 다음과 같다. 단순가공 과정을 거친 무배생채(SWRP)와 무생채(Control)에 오염된 총호기성균은 무배생채는 $3.20{\pm}0.08$ log CFU/g, 무생채는 $3.00{\pm}0.14$ log CFU/g으로 낮은 수준의 균이 검출되었다. 저장 기간 중 무배생채와 무생채의 총호기성균은 5.00 log CFU/g 미만의 수치를 나타내었다. 대장균 또한 무배생채는 $3.20{\pm}0.08$ log CFU/g, 무생채는 $1.84{\pm}0.17$ log CFU/g으로 낮은 수준의 균이 검출되었다. 효모 및 곰팡이의 경우 무배생채는 저장 기간 중 1.09~2.64 log CFU/g, 무생채의 저장기간 중 2.23~2.76 log CFU/g으로 낮은 수치로 검출되었다. 무배생채의 0일 pH는 5.99~6.09였으며, 무생채의 0일 pH는 5.93~5.96으로 유사한 pH 범위를 보였다. 무배생채의 경우, 3일 이후 유의적으로 pH가 증가하는 경향을 보였으나, 무생채는 1일 이후부터 유의적으로 증가하였다. 산도는 pH와 유사한 경향으로 혼합 무배생채의 산도 변화가 적었다. 명도(lightness) 측정 결과, 혼합 무배생채는 3일 이후 명도가 낮아졌으며, 무생채는 저장 5일 이후 유의적으로 감소하여 갈변이 일어난 것을 확인할 수 있었다(p<0.05). 적색도(redness)의 경우 혼합 무배생채와 무생채 모두 저장 3일 이후 적색도가 유의적으로 낮아졌다. 황색도(yellowness)는 적색도와 반대로 혼합 무배생채와 무생채 모두 저장기간이 길어질수록 황색도가 증가하는 경향을 보였다. 저장 기간에 따른 배의 경도는 저장 3일부터 경도가 유의적으로 감소하였으며, 무의 경도는 저장 5일부터 경도가 감소하였다(p<0.05). 전반적으로 배가 무보다 경도가 낮았는데, 이는 배가 무에 비해 수분함량이 높고, 배 특유의 조직감이 원인이라 사료된다. 관능적 특성 결과, 맛(taste)과 원재료의 어울림(harmony of ingrediegnt) 그리고 소스의 어울림(harmony of sauce)은 배 30% 첨가군이 가장 우수하게 평가되었다. 전반적인 바람직성(ovrall preference) 역시 배 30% 첨가군이 가장 높게 평가되었다. 따라서 본 연구 결과, 국내 외식 및 급식업체용 단순가공 식품재료로 무배생채가 이용되는 경우 미생물적 특성 및 관능적 특성을 고려할 때 무 70%와 배 30%를 혼합한 무배생채를 최대 3일 저장하는 것이 최적의 저장기간으로 바람직하며, 미생물학적 안전성을 고려할 때 매실소스를 이용한 혼합 무배생채가 관능적 품질에서도 우수한 것으로 판단된다.

• Journal of Nutrition and Health
• /
• 제38권3호
• /
• pp.232-241
• /
• 2005

Today, the role of kindergarten is more important as nutrition provider through snack and meal services. Desirable kinds and amounts of food items at school lunch menu were important factors of nutrients intakes in children. This study was performed to assess the kindergarten's meal service program (snack and lunch) and the consumption amount of lunch according to each dishes. Twenty four institutions that cared over one hundred children were observed at Seoul and Kyunggido area. Well-trained observers checked meal and snack serving activity and foodservice facilities by formal checklist. And using the weighing method assessed the consumption levels of food items at lunch. During 3 days, 30 children in each kindergarten were selected randomly according to age, observers measured serving and residual weight of each food. The data was compiles by performing ANOVA-test using SPSS WIN 10.0. The result were as follows: 1) Foodservice facilities in kindergarten was limited to provide qualified foodservice. $91.7\%$ of institution had kitchen, $41.7\%$ had dinning. The kitchen equipment possession rate was $12.5\%$ (oven), $30.8\%$ (heating cabinet), $58.3\%$ (refrigerator). The rate of using document about foodservice was used $83.3\%$ (menu list), $41.7\%$ (daily foodservice record), $25\%$ (standard recipe). $41.7\%$ of institution employed licensed dietitian. Only $41.7\%$ of subjects preserved meal after daily meal service. 2) Meal serving size was decided by teacher, $54.5\%$ at snack and $43\%$ at lunch and pre-divided individual portion type was $36.4\%$ at snack and $28.6\%$ at lunch. The rate of cleaning activity before meal was $72.2\%$ at snack, $90.5\%$ at lunch. And nutrition or sanitation education activity was more performed at lunch time, for examples brushing teeth activity was $12.5\%$ at snack $85.7\%$ at lunch. 3) The consumption amounts of plain cooked rice was $112.7{\pm}26.1{\cal}g$, cooked rice and cereal was $93.06{\pm}27.97{\cal}g$, curry rice was $208.35{\pm}64.84{\cal}g$ and the consumption amounts of these main dishes was significantly different by age (p < 0.001). The consumption amounts of soup was very different according to children's preference. The consumption amounts of seaweed soup was $120.18{\pm}82.13{\cal}g$, wild sesame and bean-paste soup was $40.64{\pm}23.16{\cal}g$. The consumption range of kimchis was from $6{\cal}g\;to\;13{\cal}g$, jorim (braised food) was from $3{\cal}g\;to\;25{\cal}g$, fried food (include stir fried, deep fat fried, pan fried) was from $14.5{\cal}g\;to\;22{\cal}g$, vegetable dish was from $3{\cal}g\;to\;16{\cal}g$. These consumption amount of each dishes was not reached recommended portion size of nutritionally planning menu by nutritionist.