• Journal of the Korean Society of Marine Environment & Safety
• /
• v.23 no.4
• /
• pp.393-399
• /
• 2017

In a reciprocating compressor, the piston and connecting rod are important parts. Excess mechanical stress on these parts may cause damage, and broken parts are expensive and difficult to replace. Therefore, it is necessary to analyze the mechanical stress affecting durability and longevity. The main purpose of this study was to identify locations of maximum stress on pistons and connecting rods. Based on dynamic calculation of the working process of a specific air compressor, an analysis of piston and connecting rod performance has been completed. A three-dimensional model for the air compressor's pistons and connecting rods was built separately, and FEM analysis of these components was carried out using a numerical method. The pistons were loaded by pressure which was changed according to crankshaft angle without thermal boundary conditions. The simulation results were used to predict and estimate stress concentration as well as the value of this stress on pistons and connecting rods. The maximum equivalent stress calculated are over 190 MPa on pistons and 123 MPa on connecting rods at crank angle $135^{\circ}$ and $225^{\circ}$ but these are under tensile yield strength. Besides, the calculated safety factors of connecting rods and pistons is higher than 1. Moreover, the results obtained can be used to provide manufacturers with references to optimize the design of pistons and connecting rods for reciprocating compressors.

• Journal of Korean Society for Atmospheric Environment
• /
• v.27 no.5
• /
• pp.603-613
• /
• 2011

The collection of $PM_{10}$ and $PM_{2.5}$ samples was made at Gosan site of Jeju Island. Their ionic compositions of both inorganic and organic phases were then analyzed to examine their acidification and neutralization characteristics in atmospheric aerosols. The mass concentrations of $PM_{10}$ and $PM_{2.5}$ at Gosan site were $37.6{\pm}20.1$ and $22.9{\pm}14.3{\mu}g/m^3$, respectively, showing the content ratio of $PM_{2.5}$ to $PM_{10}$ as 61.0%. In the evaluation of ionic balance, the correlation coefficients (r) between the sums of cationic and anionic equivalent concentrations were excellent with 0.982 ($PM_{10}$) and 0.991 ($PM_{2.5}$). The concentration ratios of $PM_{2.5}/PM_{10}$ derived for nss-$SO_4^{2-}$, $NO_3^-$, and $NH_4^+$ were 0.94, 0.56, and 1.02, respectively, indicating the relative dominance of fine fractions. The acidifying capacity of inorganic anions ($SO_4^{2-}$ and $NO_3^-$) in $PM_{10}$ and $PM_{2.5}$ were 96.5% and 97.3%, while those of organic anions ($HCOO^-$ and $CH_3COO^-$) in each fraction were 2.9% and 2.0%, respectively. On the other hand, the neutralizing capacity of $PM_{10}$ and $PM_{2.5}$ by $NH_3$ were 72.8% and 82.3%, while their $CaCO_3$ counter parts were 22.5% and 13.3%, respectively.

• Korean Journal of Fisheries and Aquatic Sciences
• /
• v.31 no.2
• /
• pp.288-295
• /
• 1998

Egg production of Acartia steueri was estimated in llkwang Bay, located in the southeastern coast of Korea. The equation, combining fecundity, temperature and chlorophyll a, obtained under the laboratory experiments, was applied to the in situ temperature and chlorophyll a for the estimation of field egg production. Mean egg size was $80.52{\mu}m$. Prosome length of adult females was not correlated with egg size. Egg production of field population ranged from 0.32 to $63.32{\mu}gC\;m^{-3}d^{-1}$ with a mean of $13.33{\mu}gC\;m^{-3}d^{-1}$, which were equivalent to $7.1\~1407.1\;eggs\;m^{-3}d^{-1}$ and $296.1\;eggs\;m^{-3}d^{-1}$, respectively. Fecundity of adult females ranged from 5.4 to $12.5\;eggs\;female^{-1}d{-1}$ with a mean of $8\;eggs\;female^{-1}d^{-1}$. Specific egg production rates ranged from 0.028 to 0.117 $d^{-1}$ with a mean of 0.064 $d^{-1}$. Considering the egg Production ($\%$ female body carbon) as a function of temperature and chlorophlrll a concentration, our results showed rather low fecundity, which might be underestimated. Probable cannibalism of egg by the adults were thought to be pan of the reason for this low estimated fecundity.

• Journal of Korean Society of Environmental Engineers
• /
• v.22 no.7
• /
• pp.1345-1355
• /
• 2000

The main route of exposure of the human population to polychlorinated dibenzop-dioxins(PCDDs) and polychlorinated dibenzofurans(PCDFs) is through the diet. However in Korea, there are few studies on PCDDs/PCDFs levels in environmental samples and foods. The purpose of this study is to analyze concentration of PCDDs/PCDFs in Korean retail foods and to estimate dietary daily intake of them. 9 samples from animal food and 10 samples from plant food were analysed for PCDDs/PCDFs. Concentrations of PCDDs/PCDFs ranged from 0.02(milk) to 5.39(anchovy)pg/g. TEQ levels appeared in order of fish/shellfish, meat, vegetable, cereal, fruit and milk, and these values ranged from 0.0008 to 0.3153pgTEQ/g. The daily intake of PCDDs/PCDFs via food was calculated to be about 37.7pgTEQ/day and these values are equivalent to 0.75 pgTEQ/kg b.w./day, under consideration of 50kg for body weight. The daily intake of PCDDs/PCDFs via food was lower than that in other countries. From these results, it is important to note that fish/shellfish intake is one of the main sources of PCDDs/PCDFs exposure in Korea.

• Resources Recycling
• /
• v.11 no.1
• /
• pp.3-8
• /
• 2002

In order to make the high purity Mn$_3$O$_4$powder for the raw material of soft ferrite, Mn is extracted from the dust and the extracted solution is refined. The dust is generated in producing a medium-low carbon ferromanganese and contains 90% Mn$_3$O$_4$. Mn$_3$O$_4$in the dust was reduced into MnO by roasting with charcoal. Injection of the 180g/L of the reduced dust into 4N HCI solution increased pH of the leaching solution higher than 5 and then a ferric hydroxide was precipitated. Because the ferric hydroxide co-precipitates with Si ion etc, Fe and Si ion was removed from the solution and the about 10% Mn solution was obtained. The solution was diluted with water to Mn-15000 ppm and $NH_4$F was injected into the diluted solution at $70^{\circ}C$ to the F-3000 ppm. As a result, Ca ion is precipitated as $CaF_2$and the residual concentration of Ca was 14 ppm. Injection of the equivalent (NH$1.5M_4$)$_2$$CO_3$solution as 2 L/min at $25^{\circ}C$ into the above solution precipitated a fine and high purity $MnCO_3$powder. The deposition was filtrated and roasted at $1000^{\circ}C$ for 2 hours. As a result, $MnCO_3$powder is converted into $Mn_3$$O_4$powder and it had $8.2\mu$m of median size. The final production is above 99% $Mn_3$$O_4$powder and it satisfied the requirement of high purity $Mn_3$$O_4$powder for a raw material of soft ferrite.

• Journal of the Society of Cosmetic Scientists of Korea
• /
• v.33 no.4
• /
• pp.269-273
• /
• 2007

We studied anti-microbial and anti-oxidant activities of bio-active components in stem of Juniperus chinensis L. and leaf of Abies koreana Wilson. Those plants of needle leaf tree family were reported to contain anti-cancer compounds. The anti-bacterial activity was tested by Broth dilution method against Escherichia coli and Staphylococcus aureus. As results, Juniperus chinensis L. and Abies koreana Wilson extracts showed 17.0% and 8.5% higher anti-bacterial activity than methyl paraben, respectively. The free radical scavenging activity of Juniperus chinensis L. and Abies koreana Wilson extracts showed 45 % and 44 % at 5,000 ppm. We measured polyphenol (catechin equivalent) and flavonoids quantity. The Juniperus chinensis L. extract contained 312 mg/g of polyphenol and 105 mg/g of flavonoids. The Abies koreana Wilson extract contained 280 mg/g of polyphenol and 103.8 mg/g of flavonoids. The cytotoxicity of extracts was measured by neutral red assay. Extracts did not affect the viability of CCK-986sk cells up to a concentration of 1,250 ppm. In conclusion, these data suggest that extracts of needle leaf trees would be usefull as antiseptic agents and anti-oxidants for cosmetic products.

• Korean Journal of Soil Science and Fertilizer
• /
• v.34 no.3
• /
• pp.158-164
• /
• 2001

The purpose of this study was to assess the runoff of nitrogen derived from pig manure under upland condition. Bare and maize cultivated conditions were compared to estimate the effect of plant on the runoff loss of nitrogen and other nutrients by application of pig manure. Soil used in this experiment was sandy loam, and the fermented pig manure was applied at the rate of 0, 50, and $100ton\;ha^{-1}$. The amount of runoff was measured after every rainfall and water samples were analyzed for nitrate and other cations. Runoff was increased with the rainfall, but was depended on the application rate of pig manure at both bare and maize cultivated plots. Concentrations of nitrate in runoff at 0, 50 and $100ton\;ha^{-1}$ application of pig manure were higher at the maize cultivated plots than those at bare plots by 86.9, 42.9, and 33.6%, respectively. However, total mass of nitrate by runoff loss was higher at the bare plot ranging from 1.34 to $3.15kg\;NO_3-N\;ha^{-1}$. The equivalent ratio of nitrate to sum of cations in runoff was higher at the bare plot than that of maize cultivated plots. The concentration of cations in runoff was in the order of K> Mg> Na> Ca.

• Geophysics and Geophysical Exploration
• /
• v.2 no.2
• /
• pp.96-103
• /
• 1999

Most of saline water inousions have been diagnosed by geophysical or geochemical approach independently. The objective of this study is to provide the effective method to detect the saline water intrusion on the ground water in the vicinity of seashore using these two methods. Schulumberger sounding, frequency domain electromagnetic sounding and geochemical analysis of ground water were carried out to explore saline water intrusion. Schulumberger sounding was implemented in dry surface condition before irrigation water was introduced into the field, while electromagnetic sounding was carried out in wet ground condition after the irrigation. The purpose of duplicated measurements on the equivalent spot at different times was to investigate the variation of anomaly zone depending on the amount of ground water. It was possible to discriminate the anomalous zone due to high water saturation from the low electric resistivity zone by high salt concentrations through this way. For the verification of the geophysical result, the ground water samples in the study area were collected and analysed at the 23 points near the measuring spots. The groundwater at the spot nearest to the sea water intrusion identified by geophysical method indicates higher salinity than the standard limit concentration for agricultural irrigation water (250 mg/1). Isotope analysis of $D({^2}H)$ vs. is ${^18}O$ and PCA analysis were used to discriminate the anthropogenic pollution from those of high salinity from sea water intrusion.

• Journal of Environmental Science International
• /
• v.17 no.3
• /
• pp.287-296
• /
• 2008

A comprehensive quality survey for heavy metals, organophosphorous and organochlorine residual pesticides, and coplanar PCBs in samples such as water, sediments and soils as well as spiders has been implemented. The samples were undertaken at nine stream sites and their vicinity in August 2006, representing different surrounding environments. The levels of PCBs were expressed as concentrations and WHO-TEFs. Among 12 coplanar PCBs as target compounds in this study, 2,3', 4,4', 5-PentaCB (IUPAC # 118) was the congener with the highest concentration. The total concentrations and TEF values of coplanar PCBs in Siheung stream sediment (heavy industrial complex site located in Ansan city) were 3915.50 pg/g and 0.8366 pg-TEQ/g on a dry weight basis, respectively. Such levels were around 40 times higher compared to sediment from Gapyung stream (green site located in the upper of Myunggi mountain). It is probably due to the direct input of PCBs trom PCBs treatment materials. Organophosphorous (EPN, dementon-s-methyl, diazinon, parathion, and phenthoate) and organochlorine (alpha-BHC, aldrin, 4,4'-DDT, 4,4'-DDE, endosulfan alpha and etc.) pesticides were not detected above 5 ppb of detection limits. The concentrations of Cu and Cd in water and sediment samples from Siheung stream were 44.11 and $0.17ug/m\ell$ and $713.42{\mu}g/g$ and $3.73{\mu}g/g$, respectively, which contained $20\sim40$ times higher concentrations than those from Gapyung stream. In addition to the water and sediment samples, the levels of heavy metals in spider from designated sampling sites were also determined. Heavy metals in spider collected near Siheung stream was appeared to be equivalent and/or a little higher levels with respect to other spiders. Furthermore, the ratio of relative heavy metals (Cu, Cd, and Pb) in spider from each stream site showed a correlation as similar as that of heavy metals in soil samples.

• Journal of the Korean Society of Food Science and Nutrition
• /
• v.37 no.9
• /
• pp.1095-1100
• /
• 2008

Antioxidative and macrophage phagocytic activities and contents of functional component in selected Korean chestnuts (Dantaek, Daebo, Okkwang, Seokchu, Byunggo) were evaluated. Coumarin, gallic acid and catechin in inner skin and whole kernel of selected Korean chestnuts were detected by HPLC. The predominant functional components in inner skin of chestnut were catechin, followed by gallic acid and coumarin. However, the whole kernel had only gallic acid. Thus, the antioxidant properties of gallic acid and catechin were evaluated through DPPH radical-scavenging activity and SOD like activity. Gallic acid and catechin at 6.0 mg/100 g exhibited 69.4% and 38.3% of scavenging activities on DPPH radical, respectively. DPPH radical-scavenging activity of gallic acid increased in a concentration-dependent manner. Gallic acid was found to possess higher DPPH radical-scavenging activity than equivalent amount of catechin at all concentrations, whereas catechin was found to have higher SOD like activity than gallic acid. In addition, pre-incubation of macrophage with white kernel extract from Byunggo resulted in a significant increase of phagocytic activity and yellow kernel extracts from Byunggo, Dantaek, Daebo and Okkwang, leading to an increase in phagocytic activity compared with untreated cells. Yellow kernel extracts was found to have higher phagocytic activity than white kernel extracts. Byunggo had the highest phagocytic activity. The results suggest that the Korean chestnut may provide a natural source of antioxidants and active immunity.