• 공업화학
• /
• 제30권3호
• /
• pp.297-302
• /
• 2019

열분해 연료유(pyrolysis fuel oil)의 열처리 시 발생되는 구조변화를 파악하기 위하여 열처리 온도에 따라 발생되는 휘발유분(volatile matters) 및 중질유분을 분리하였다. 열처리 온도가 증가함에 따라 중질유분의 수율은 낮아지며, 탄화수율은 높아지는 것을 확인하였다. 휘발유분의 $^1H-NMR$ 구조분석 결과, 원료에 포함되어 있던 1~2환 방향족 성분들은 $340^{\circ}C$ 이전의 온도에서 대부분 제거되었으며, $320^{\circ}C$부터는 크래킹 반응에 의하여 방향족 화합물로부터 지방족 탄화수소 곁사슬이 분해됨에 따라 새로운 휘발유분을 생성하는 것을 확인하였다. 한편 중질유분의 원소분석 및 $^1H-NMR$ 구조분석 결과로부터, 열처리 온도가 증가할수록 C/H 몰비 및 방향족화도 값이 증가함을 알 수 있었다. 이러한 구조분석 결과를 통하여 PFO의 $280{\sim}360^{\circ}C$에서의 열처리에 따른 구조 변화는 비점 차이에 따른 휘발유분의 분리 및 크래킹 반응에 의한 지방족 곁사슬의 분해가 가장 큰 영향을 미치며, 일부 화학종 간 중합반응 또한 발생된 것을 확인하였다.

• 대한기계학회논문집
• /
• 제18권7호
• /
• pp.1833-1839
• /
• 1994

Experiments have been carried out to investigate the burning characteristics of waste tires in high temperature environments. The burning of waste tire chips consists of four stages ; evaporation of volatile matters, ignition, burning of volatile matters, and burning of solid carbon. Burning time of waste tire chips depends on the gas temperature and the initial weight of the chip. However, the environments. In the ceramic matrix burner with a ceramic radiation shield, the burning time of the waste tire chips becomes shorter than that without the shield. This is due to the increase in heat transfer to the tire chips by radiation.

• 한국막학회:학술대회논문집
• /
• 한국막학회 1996년도 제4회 하계분리막 Workshop (초순수 제조와 막분리 공정)
• /
• pp.177-189
• /
• 1996

Raverase osmosis or ultrafiltration systems have generally been regarded as hard to validate about WFI production. Though the Japanese and US Pharmacopoeias have allowed distillation and RO to be applied to WFI production process, only water stills, especially multiple effects have practically been employed for parenteral water production. On the other hand, the latest analysis has shown that even distillate contains such volatile organic matters as trihalomethanes and traces of heavy metals at a little higher concentration than supposed. The JP requires TOC to be monitored in WFI process based on RO or UF systems to control the concentration below 300ppb, but very few monographs or papers have so far been published about the concentrations of organic volatile matters in distillate. (See table 1-1) Therefore, this paper proposes a new applicable WFI systems based on the result of purified water analysis with some membranes used in the process. A well combined membrane system with other units could be expected to provide less amount of impurities in membrane-treated water than in distillate.

• 한국수소및신에너지학회논문집
• /
• 제24권5호
• /
• pp.413-420
• /
• 2013

Effect of inherent volatile matters in fuels on electrochemical reactions of anode was investigated for a single direct carbon fuel cell (DCFC). Raw coals used as power source in the DCFC release light gases into the atmosphere under the operating temperature of DCFC ($700^{\circ}C$) by thermal decomposition and only char remained. These exhausted gases change the gas composition around anode and affect the electrochemical oxidation reaction of system. To investigate the effect of produced gases, comparative study was conducted between Indonesian sub-bituminous coal and its char obtained through thermal treatment, carbonizing. Maximum power density of raw coal ($52mW/cm^2$) was appeared higher than that of char ($37mW/cm^2$) because the gases produced from the raw coal during thermal decomposition gave additional positive results to electrochemical reaction of the system. The produced gases from coals were analyzed using TGA and FT-IR. The influence of volatile matters on anodic electrolyteelectrode interface was observed by the equivalent circuit induced from fitting of impedance spectroscopy data.

• 한국연소학회:학술대회논문집
• /
• 한국연소학회 2012년도 제44회 KOSCO SYMPOSIUM 초록집
• /
• pp.209-212
• /
• 2012

This study was performed to analyze coal flames and measure tar and soot yields and structures of chars for two coals depending on the volatile content by the LFR(Laminar Flow Reactor) which can be applied to a variety of coal researches. The results show that volatile contents and oxygen concentration have significant influence on length and width of the soot cloud and it also indicate that the length and width of the cloud in condition of combustion decrease than those of pyrolysis atmosphere. Until the sampling height reach at 50 mm, the tar and soot yields of Berau (Sub-bituminous) coal contained relatively lots of volatile matters are less than those of Glencore A.P. (Bituminous) coal. On the other hand, tar and soot yields of Berau coal are higher than those of Glencore A.P. coal by reacted residual volatile matter. In addition, the images of samples obtained from the particle separation system of the sampling probe support for above results with the yields, and the pore development of char surface by devolatilization.

• 한국연소학회:학술대회논문집
• /
• 한국연소학회 2012년도 제45회 KOSCO SYMPOSIUM 초록집
• /
• pp.183-186
• /
• 2012

The characteristics of particulate matters (PM) from an exhaust gas for conventional and low temperature diesel combustion (LTC) in a compression ignition engine was experimentally investigated by the elemental, thermogravimetric analysis. Morphology of PM was also studied by the transmission electron microscopy. PM for LTC shows that it contains more volatile hydrocarbons, which can be easily evaporated than conventional regime. PM for LTC is comprised of smaller primary particles.

• 한국분무공학회지
• /
• 제12권1호
• /
• pp.65-70
• /
• 2007

This paper is to investigate the characteristics of exhaust emissions and nano-particle emission from diesel passenger vehicle according to using biodiesel fuel as an alternative fuel. In this work, the particulate matters (PM) of exhaust emissions in diesel engine were investigated by number of particles and mass measurement. The mass of the total PM was measured using the standard gravimetric measurement method, the total number concentrations were measured on a ECE15+EUDC driving cycle using Condensation Particle Counter (CPC). Total PM emission was reduced $2{\sim}38%$ and number concentration was reduced $1{\sim}27%$ according to increasing blended ratio of biodiesel with diesel fuel. Total PM emission was reduced more than particle number emission because volatile particles were measured in total PM but were not measured in particle number emissions.

• 한국물환경학회지
• /
• 제29권6호
• /
• pp.739-745
• /
• 2013

This paper investigated the runoff characteristics of different properties of suspended solids in streams according to the watershed characteristics and dry/rainy season. Suspended solids were divided into VSS and NVSS depending on volatilization. The main results of this study were as follows. TSS were more correlated with NVSS than VSS. Suspended solids were positively related with the proportion of urban > paddy > upland, negatively related with forest cover. VSS were positively correlated with POP and POC. VSS, measured in dry season, would partly result from autochthonous production and could be an indirect indicator of organic suspended solids.

• Asian-Australasian Journal of Animal Sciences
• /
• 제29권4호
• /
• pp.594-598
• /
• 2016

We studied airborne contaminants (airborne particulates and odorous compounds) emitted from compost facilities in South Korea. There are primarily two different types of composting systems operating in Korean farms, namely mechanical aerated pile composting (MAPC) and aerated static pile composting (SAPC). In this study, we analyzed various particulate matters (PM10, PM7, PM2.5, PM1, and total suspended particles), volatile organic compounds and ammonia, and correlated these airborne contaminants with microclimatic parameters, i.e., temperature and relative humidity. Most of the analyzed airborne particulates (PM7, PM2.5, and PM1) were detected in high concentration at SAPC facilities compered to MAPC; however these differences were statistically non-significant. Similarly, most of the odorants did not vary significantly between MAPC and SAPC facilities, except for dimethyl sulfide (DMS) and skatole. DMS concentrations were significantly higher in MAPC facilities, whereas skatole concentrations were significantly higher in SAPC facilities. The microclimate variables also did not vary significantly between MAPC and SAPC facilities, and did not correlate significantly with most of the airborne particles and odorous compounds, suggesting that microclimate variables did not influence their emission from compost facilities. These findings provide insight into the airborne contaminants that are emitted from compost facilities and the two different types of composting agitation systems.

• 한국환경농학회지
• /
• 제26권2호
• /
• pp.179-185
• /
• 2007

미생물연료전지는 유기성 폐기물을 처리하면서 동시에 전기에너지를 얻을 수 있다는 측면에서 커다란 장점을 가지고 있다. 대부분의 유기성폐기물들이 발효과정을 거치면서 고농도의 VFAs가 생성되므로 미생물연료전지가 이들 VFAs로부터 전기를 얻을 수 있는지 알아보는 것은 아주 중요하다. 따라서 본 연구에서는 acetate, propionate, butyrate 및 실제 폐수인 식품가공폐수로부터 미생물 연료전지를 이용하여 전기발생 여부를 알아보았으며 다음과 같은 결론을 얻었다. 미생물연료전지를 이용하여 VFAs(acetate, propionate, butyrate)와 식품가공폐수로부터 전기를 얻을 수 있었고 투여한 acetate 농도에 비례하여 cathode로 전달되는 전자(Coulomb)는 비례하였다. 낮은 농도의 acetate에서 발생파워와 acetate 농도 사이에는 비례관계를 보였다. 이는 미생물연료전지가 낮은 농도의 유기물을 측정하는 센서로서의 가능성을 보여준다. acetate에 순화된 산화전극에 butyrate를 넣었을 때 순화의 시간이 필요하였으며 일정 순화시간 후 voltage가 증가하였다. 그러나 propionate를 넣었을 때는 순화시간 없이 급격하게 voltage가 상승하였다. 따라서 미생물연료전지의 생성파워가 향상된다면 유기성 폐기물을 처리하면서 실생활에 이용할 수 있는 전기로 변환하는 장치로서 이용될 수 있을 것으로 판단된다.