• Journal of Technologic Dentistry
• /
• v.40 no.1
• /
• pp.33-40
• /
• 2018

Purpose: The purpose of this study was to investigate the influence of mechanical properties of various ultra-dental stone by setting methods. Methods: 240 cylinder specimens($10mm{\times}20mm$) were prepared from three ultra-dental stones(Gemma, Die keen and Fuji rock; n = 80) in accordance with the manufacturers' recommendations. Half of the specimens of each stone(n = 40) were dried in open air within a room temperature; the other half(n = 40) underwent in a silicone rubber mold in open air for 30 minutes and then were dried in a microwave oven for 10 minutes to 600W. Compressive strength(CS), compressive modulus(CM) and diametral tensile strength(DTS) conducted until fracture using Instron 5966 at each of the following periods: 1 and 24 hours from mixing. One-way analysis of variance and Scheffe's post hoc test were performed for statistical comparisons at a significance level of P<.05. Results: The CS and CM values in all dental stone indicated highest after 24h(54.25 MPa < ) than the values for specimens dried in microwave method. The DTS values revealed the highest microwave method. However, in 24h, FJ(Fu-ji rock) and GM(Gemma) had lower mechanical properties than air. Conclusion : Within the limitations of this study, CS did not influence by microwave method but DTS affected according to the setting.

• Journal of the Korean Chemical Society
• /
• v.38 no.8
• /
• pp.576-584
• /
• 1994

The method described offers rapid and efficient sample preparation using on-line microwave digestion of metal oxides in water sample with direct elemental detection by ICP-AES. The open tubing digestion system(OTD) and the restraint tubing digestion system(RTD) for flow injection(FI) were designed and tested to find the optimum conditions. Comparison of OTD and RTD indicated that RTD was 3 times faster on the digestion time, and 10 times higher on sample mass. Finally, the results of RTD agree well with those by conventional microwave open vessel in all cases and show good precision; Fe and Cu show good with about 5% of RSD, while Zn and Co more or less than 10% RSD.

• Journal of the Korean Society of Food Science and Nutrition
• /
• v.42 no.3
• /
• pp.403-409
• /
• 2013

We investigated the quality characteristics of sweet potatoes [Shinyulmi (SM), Yeonhwangmi (HM) and Yunmi (YM) variety] baked and subsequently freeze thawed. Baking was performed with a far infrared radiation oven at $250^{\circ}C$ for 40 minutes. Baked sweet potatoes were frozen at $-18^{\circ}C$ for 30 days, and thawed by a microwave oven for 3 minutes. The crude fat and protein content of HM were higher than the SM and YM varieties. Total sugar, reducing sugar, and free sugar content were increased after baking. Lightness, redness, and yellowness, as well as content of ${\beta}$-carotene, decreased after baking and freeze-thawing. Hardness, gumminess, and cohesiveness decreased during thawing after freezing, except for the YM variety. In a sensory evaluation, appearance, flavor, sweetness and overall acceptance were higher from baking and freeze-thawing the SM variety, instead of the HM and YM variety. From the results, the SM variety is preferred for the production of baked sweet potatoes.

• Journal of the Korean Society of Food Culture
• /
• v.17 no.4
• /
• pp.465-472
• /
• 2002

The effect of cooking(boiling, steaming and baking) and drying on the cholesterol content and formation of oxidized cholesterols and acid value in squid(Japanese flying squid, Todarodes pacificus) was studied. Cholesterol content of live squid meat varied with the portion sampled. The data from spectophotometric assay ranged from 263.2 mg/100g(mantle) to 315.8 mg/100g(tentacle). The cholesterol levels found for squid samples analyzed by gas chromatography(GC) were lower by 7% of total cholesterol for live squid meat and 24% for processed meat than those results by spectrophotometric assay. Cooking resulted some decrease in the initial total cholesterol content of raw meat from 10%(boiling for 5 min.) to 25%(steaming for 5 min.). The amounts of cholesterol remaining after baking were 68% for microwave oven samples and 64% for convection oven samples. Drying of raw tissue caused the greater reduction in cholesterol content than cooking but brought about no significant difference in samples stored for 6 weeks at $4^{\circ}C\;and\;20^{\circ}C$. Raw squid meats contained essentially no oxidized cholesterols, while the 22-hydroxychoesterol was detected in frozen meats. The additional oxidized cholesterols as cholestane-triol was indentified with 22-hydroxycholesterol in cooked samples. Sun dried meat stored at $4^{\circ}C\;and\;20^{\circ}C$ for 6 weeks had the three kinds of oxidized cholesterols such as 22-hydroxycholesterol, cholesta-3,5-dien-7-one and cholestane-triol. For the boiled and steamed squids, 10% higher acid value and 5% higher acid value respectively were observed but oven cooked samples resulted in a 50% higher acid value than raw samples. Squids had a 45% higher acid value than raw one during sundrying and presrevation at $20^{\circ}C$ but there was not a severe difference of acid value between $4^{\circ}C\;and\;20^{\circ}C$ stored samples.

• Korean Journal of Food Science and Technology
• /
• v.31 no.5
• /
• pp.1392-1396
• /
• 1999

This work was to apply the microwave energy to HTST pasteurization of milk in order to prevent undesirable quality changes due to the fouling and overheating on the surface of heat exchanger. A continuous tubulartype microwave pasteurization system was designed using a domestic microwave oven(800w and 2,450MHz). Raw milk was HTST pasteurized$(at\;72^{circ}C\;for\;15\;sec)$ by three methods; by heating in a stainless steel tube immersed in a hot water bath(MP0), by heating in a microwave cavity to a desired temperature and then holding in a hot water bath(MP1) and by both heating and holding in a microwave cavity(MP2). The microbial quality based on the total plate count and Psychotrophic bacterial count was in the order MP0, MP2 and MP1 ; however, the quality difference was not significant(p<0.05) when the initial microbial numbers were involved in the statistical analysis. In addition, the three samples pasteurized by different methods showed the similar microbial quality based on the coliform count and phosphatase activity. The similar microbial quality of the three samples supports the potential use of microwave energy for the pasteurization of milk and other fluid food products.

• Journal of the Korean Society of Food Science and Nutrition
• /
• v.20 no.5
• /
• pp.461-466
• /
• 1991

For the purpose of improving storability and process adaptability of potato, we carried out an experiment to investigate the effects of microwave heating on the total lipid content and fatty acid composition of the potatoes in storage. The samples were made by powdering potatoes exposed to the microwave energy in a 560W, 2,450MHz oven for 0, 60, 120 and 180 seconds respectively. From the examination of the samples stored at th temperature of $25{\pm}1^{\circ}C$ for 12 months, the following results were obtained. As an over-all tendency, the longer the samples were heated and the longer they were stored, the total lipid content decreased but the microwave-heated samples showed decreasing rates less than those of the controls for the whole storage periods. As major fatty acids of the potato flour, linoleic acid (30.92 %), palmitic acid (29.34 %), linolenic acid (8.90 %) and stearic acid (8.23 %) were detected from the samples. The longer the samples were exposed with microwave, unsaturated fatty acids like 18:2, 18:3 increased. generally with the lapse of storage time, saturated fatty acids increased while unsaturated ones decreased. But in the samples heated with microwave, we observed an apparent suppression of the increasing rate of the saturated fatty acids and the decreasing rate of the unsaturated fatty acids, and the suppressing effects turned out to be proportional to the length of microwave heating.

• Journal of the Korean Society of Food Science and Nutrition
• /
• v.45 no.12
• /
• pp.1784-1791
• /
• 2016

Garlic was subjected to eight different cooking methods (raw, boiling, steaming, microwave cooking, deep-frying, oven-roasting, pan-frying, and pan-roasting) utilized for typical Korean cuisine. Garlic was analyzed for antioxidant activities and physicochemical properties to elucidate effects of cooking. Garlic cooked at higher temperatures showed significantly lower lightness and higher yellowness (P<0.001). In particular, deep-frying and pan-frying resulted in lowest lightness and soluble solid content, indicating that non-enzymatic browning reactions were more facilitated. Compared with raw garlic, all cooked garlic tended to have lower thiosulfinates, presumably due to decomposition into polysulfides and/or leaching into cooking water and oil. Microwave cooking retained organic acids, total reducing capacity, and flavonoids, which can be attributed to low microwave intensity and shorter cooking time under which heat-labile bioactive components might have undergone less decomposition. Cooking significantly increased metal-chelating activity (P<0.001). In addition, oven-roasting and pan-roasting enhanced total reducing capacity and flavonoid content, indicating that thermal treatments increased the extractability of bioactive components from garlic. However, boiling, deep-frying, and pan-frying, in which garlic is in contact directly with a hot cooking medium, reduced antioxidant activities. Deep-frying resulted in largest reduction in DPPH radical scavenging activity of garlic, which correlated well with reduction of total reducing capacity and flavonoid content. The results show that the antioxidant activity of garlic could be affected by cooking method, particularly heat intensity and/or direct contact of the cooking medium.

• Korean Journal of Food Science and Technology
• /
• v.42 no.3
• /
• pp.304-309
• /
• 2010

Instant Baekseolgi containing 0, 1, 2, and 3% trehalose prepared using a microwave oven, after which quality characteristics were investigated over 24 hr. The sample was prepared to internal and external parts. The moisture content of Baekseolgi without trehalose (control) was not reduced. However, the presence of trehalose reduced moisture content of two different groups (p<0.05). Weight reduction of Baekseolgi was decreased with increased threhalose content (p<0.05). The hardness, and chewiness of Baekseolgi with trehalose was decreased with increased trehalose (p<0.05). However adhesiveness, springiness, and cohesiveness were not significantly changed. The results of sensory evaluation showed that moisture and hardness were reduced between the internal and external parts of the Baekseolgi with increased trehalose (p<0.05). This study shows that the addition of trehalose to Baekseolgi had a positive impact on quality characteristics, including moisture content, weight reduction, texture, and sensory properites.

• Analytical Science and Technology
• /
• v.16 no.2
• /
• pp.102-109
• /
• 2003

Microwave digestion and solid-state extraction were studied for determination of trace aluminum{Al(III)} in human urine samples. A mixed acid of nitric acid and hydrogen peroxide was added to urine samples, organic materials were destructed in a home microwave oven and dried in a drying oven. The dried residues were dissolved in a sulfuric acid solution. The solution was eluted through a XAD-4 resin column adsorbed with 8-hydroxyquinoline(Oxine, HQ). Al(III)-8-hydroxyquinolinate complex was formed in the column and eluted with 0.5 M nitric acid solution. The Al(III) eluted was determined by graphite atomic absorption spectrophotometry. Various experimental conditions of followings were investigated for the optimization : the type of acid to dissolve the residues, the amount of HQ adsorbed on the resin, the pH of sample solutions, the type and concentration of acid to elute the complex from column and so on. The contents of Al(III) in real samples were determinated by a calibration curve method. The recovery in standard spiked samples was 94~101% and the detection limit of this procedure was 0.05 ng/mL.

• Journal of the Korean Recycled Construction Resources Institute
• /
• v.10 no.1
• /
• pp.101-110
• /
• 2022

In this study, water content tests were performed on various fresh concretes subjected to different binder compostions to review the estimation errors and reliability of water content test methods. Micro-oven drying method, air-meter method, capacitance method and microwave penetration method were used to estimate water content of fresh concrete. Errors in water content estimation were analyzed by each test method. Regardless of the test method of water content, the estimation error was less than 5 %, and in the case of the test using mortar, the error in the estimation value was relatively large. In addition, based on the test results of water content of various concrete, the probability density function in which the estimation error for each test method becomes the population was analyzed. Water content test methods of fresh concrete which using concrete samples showed high estimate reliability of 97 % within the estimation error range of ± 10 kg/m³. On the other hand, the reliability of water content test method using mortar samples was lower.