• Journal of the Korean Wood Science and Technology
• /
• v.48 no.3
• /
• pp.303-314
• /
• 2020

Gambir is a non-wood forest product with a potential of being used as wood adhesive, due to about 33% catechin in it. Meanwhile, catechins and sucrose have not been studied as adhesives. Therefore, basic characteristics of gambir-sucrose adhesives were investigated. In this research, adhesives were prepared by dissolving gambir and sucrose in distilled water, at different blending ratios of the gambir/sucrose such as 100/0, 75/25, 50/50, and 25/75 wt%. Furthermore, gas chromatography-mass spectrometry (GC-MS) was employed to determine the gambir chemical compositions, and Fourier transform-infrared (FTIR) spectroscopy was carried out to identify chemical bonds. Particleboards with a target density of 0.8 g/㎤ were then manufactured by hot-pressing for 10 min at 200℃. The internal bond (IB) strength of particleboard was subsequently measured. Based on the GC-MS analysis, 31.11% of catechin was identified. In addition, the viscosity, density, solid content, and gelation time of the adhesives, and insoluble matter content (IMC) in boiling water were 7.30~33.24 mPa.s, 1.2~1.3 g/㎤, 25.56~28.44%, 73~420 min, and 29.75~62.10%, respectively. Adding sucrose to the adhesive was observed to raise the IMC from 49.05 to 62.10%, at 180℃ and 200℃. FT-IR analysis showed that the gambir absorption peaks occurred at approximately 1620 cm^-1, assigned to the C=O stretching of 5-hydroxymethylfurfural, which tended to increase with the addition of sucrose. The reaction between gambir and sucrose was observed in the form of the dimethylene ether bridge. The 25/75 wt% gambir-sucrose adhesives and 200℃ hot-pressed temperature resulted in the highest IB strength (0.89 MPa), and met the requirement of JIS A5908-2003 type 18. Consequently, the gambir-sucrose adhesive could be used as a particleboard adhesive.

• Animal Bioscience
• /
• v.36 no.5
• /
• pp.768-775
• /
• 2023

Objective: Oilseeds and nut co-products can be used as alternative feed ingredients in animal diets because they may have a lower cost than traditional ingredients. A study was, therefore, conducted to determine the chemical composition of copra, palm kernel, and nut co-products from South-East Asia or Australia. The hypothesis that country of production influences nutritional composition was tested. Methods: Oilseed meals included 2 copra expellers, 3 copra meals, and 12 palm kernel expellers. One source of almond hulls and cashew nut meal were also used. Samples were obtained from suppliers located in South-East Asia or Australia. All samples were analyzed for dry matter, gross energy, nitrogen, amino acids (AA), acid-hydrolyzed ether extract (AEE), ash, minerals, insoluble dietary fiber, and soluble dietary fiber. Copra and nut co-products were also analyzed for total starch and sugars. Results: Copra expellers had greater (p<0.05) concentrations of dry matter and AEE compared with copra meal. However, copra meal had greater (p<0.05) concentrations of total dietary fiber (soluble and insoluble) and copper than copra expellers. Palm kernel expellers from Indonesia had greater (p<0.05) concentration of histidine and tyrosine compared with palm kernel expellers from Vietnam. Almond hulls was high in dietary fiber, but also contained free glucose and fructose, whereas cashew nut meal was high in AEE, but low in all free sugars. Conclusion: Copra expellers have greater concentration of AEE, but less concentration of total dietary fiber when compared with copra meal, and except for a few AA, no differences in nutrient composition of palm kernel expellers produced in Indonesia or Vietnam were detected. According to the chemical composition of nut co-products, cashew nut meal may be more suitable for non-ruminant diets than almond hulls.

• Animal Bioscience
• /
• v.36 no.6
• /
• pp.908-919
• /
• 2023

Objective: Information about the chemical composition of cassava-based feed ingredients is needed to accurately formulate animal diets. A study was conducted to determine the chemical composition of cassava-based feed ingredients and to test the hypothesis that there is variation in chemical composition among cassava products originating from different South-East Asian countries. Methods: Sources of dried peeled and unpeeled cassava roots, cassava chips, cassava meal, high-ash cassava meal, and cassava residue were used. All samples were analyzed for dry matter, gross energy, nitrogen, amino acids (AA), acid-hydrolyzed ether extract (AEE), ash, minerals, total starch, insoluble dietary fiber, and soluble dietary fiber. Samples of peeled and unpeeled cassava roots, cassava chips, and cassava meal were also analyzed for sugars. Results: High-ash cassava meal had greater (p<0.05) dry matter and ash, but lower (p<0.05) total starch and gross energy than all other cassava products. Peeled cassava roots, unpeeled cassava roots, and cassava chips had greater (p<0.05) total starch than the other cassava-based ingredients. Cassava residue had greater (p<0.05) concentrations of lysine, insoluble dietary fiber, and soluble dietary fiber compared with the other cassava products, but tryptophan and glutamic acid were greater (p<0.05) in peeled cassava roots, cassava chips, and cassava meal samples compared with the other ingredients. Concentration of most minerals was greater (p<0.05) in high-ash cassava meal than in the other cassava products. Conclusion: Cassava-based ingredients sold as peeled roots, unpeeled roots, chips, or meal have chemical compositions that are not different from each other, and peeling has little impact on chemical composition. High-ash cassava meal has lower nutritional quality compared with other cassava products due to low starch and gross energy. The high fiber content in cassava residue makes this ingredient more suitable for ruminants and sows than for younger pigs or poultry.

• Journal of Korean Society for Atmospheric Environment
• /
• v.13 no.6
• /
• pp.475-486
• /
• 1997

The characteristics of atmospheric aerosols were investigated as a function of particle size and water solubility. The atmospheric aerosols were sampled with classifying into 12 size ranges by the use of Andersen low-pressure impactor. Collected aerosol particles were extracted by ultrapure water and filtered to be separated into water-soluble and insoluble components. The concentrations 12 elements in both components were determined by PIXE analysis. And the concentrations of 8 ions in the soluble component were analyzed by ion chromatography. In general, the mass size distribution of particulate matter was represented as a bimodal distribution. The mass size distributions of S$(SO_4^{2-}), K(K^+), Zn and NH_4^+$ skewed to the smaller size range and those of Si, Ca$(Ca^{2+}), Fe, Na^+ and Mg^{2+}$ skewed to the larger size range. They had roughly one peak in the fine and coarse particle region,respectively. On the other hand, the mass size distribution of Ti, Mn, Ni, Cu, $Cl^- and NO_3^-$ were represented as the bimodal distribution. Fe and Si in the aerosol particles extracted into pure water are existing in high insoluble state. Conversely, almost the whole of S is dissolved in water.

• Journal of the Korean Professional Engineers Association
• /
• v.18 no.2
• /
• pp.6-15
• /
• 1985

A new process disregraded the H$_2$SO$_4$ treatment process heretofore in use, was developed and substituted for mineral base engine used oil of homemade SAE-30 grade H.V.I., which was used covering 4,500km, as samples, and the following results in research, was obtained. (1) A good quality of rerefinded base oil was obtained through roughly a course of developed processes of vacuum distillation process, solvent extraction process, neutralization treatment process and clay treatment process. (2) Through vacuum distillation process, the size of fine grains of insoluble colloid carbon that is, colloid carbon which was produced by burning of internal combustion engine oil and fuel, could be brought up and precipitated (3) The insoluble matters and admixtures could be easily dispersed and dissolved by mixing and extracting solvent disregarded the H$_2$SO$_4$ treatment process heretofore in use (4) waste matter heretofore called acid sludge in consequence of the process, did not appear at all. accordingly, the environmental pollution could be removed. (5) The troubles of corrosion to copper strip which was faults of the usual used oil refined products and peculiar offensive odor of the rerefined oil, could be solved through the neutralization process. (6) The yield of rerefined oil obtained through a course of processes was over 86 percent, and it is of practical use, not to speak of commercial value.

• Journal of Nutrition and Health
• /
• v.30 no.2
• /
• pp.210-219
• /
• 1997

Retarding effects of the dietary fibers from tangerine peels on glucose, bile acid and cadmium transport were evaluated by dialysis method, and were compared with those of commercial dietary fibers(citrus pection, CM-cellulose, guar gum, $\alpha$-cellulose). Yields of total (TDF), insoluble(IDF) and soluble dietary fibers(SDF) from tangerine peels on the fresh matter basis were 2.84%, 1.95% and 0.39% respectively. The amount of insoluble fibers was 5.2 times higher than that of soluble fibers. Soluble fibers(guar gum, CM-cellulose, SDF, pectin) had the retarding effect on glucose transport, while IDF, TDF and $\alpha$-cellulose did not have. Guar gum showed the greatest effect, followed by CM-cellulose, SDF and pectin. Among the extracted fibers, only SDF had the effect on glucose transport retardation. Regarding bile acid dialysis, guar gum had the greatest retarding effect, and all dietary fibers from tangerine peels, especially SDF, showed the effect of bile acid retardation. On cadmium transport retardation, CM-cellulose had the greatest effect, followed by SDF, TDF, IDF, guar gum and pectin. Among the extracted fibers, SDF had the greatest effect on Cd trasport transport retardation. The extracted dietary fibers showed higher retarding effect on Cd transport than glucose and bile acid transport, and the effect of SDF was higher than IDF.

• Journal of Korean Society for Atmospheric Environment
• /
• v.17 no.E1
• /
• pp.1-7
• /
• 2001

The elemental characteristics of atmospheric aerosols were investigated as a function of particle size and water solubility. The aerosol particles were samples at 12 individual size ranges between 0.01 and 30㎛. Collected aerosol particles were separated into both soluble and insoluble components. The concentrations of 15 elements in both components were determined by a PIXE analysis using a 2.0 MeV-proton beam. In general, the mass size distribution of particulate matter was represented as a bimodal distribution. The maximum rations of S in July and December were 5.5 and 3.8 %, and they appeared in the size range of 0.47∼1.17㎛(stage No. 6 or 7) . The ratios of a S at non-separated size were 3.1 and 2.2 % in July and December, respectively, On the other hand, the maximum rations of Si in July and December were 7.0 and 5.4% and they appeared in the size range of 5.1∼30㎛(stage No. 0∼2). The ratios of Si at the non-separated size were 2.1 and 1.8% in July and December, respectively, The mass diameter of 12 elements ranged between 0.59㎛ of S and 3.20 of Fe. More than 90% of atmospheric aerosols consisted of the light elements such as C, N, O, H and Al. The soluble component was dominant in the smaller size range and the insoluble component in the larger size range. Large portions of Si. Ti and Fe existed in insoluble state. By contrast, S, Cl, Ca, Zn and Br were dissolved in water.

• Journal of the Korean Society of Food Science and Nutrition
• /
• v.33 no.4
• /
• pp.700-704
• /
• 2004

This study was conducted to determine the several structural carbohydrate of 9 kinds of brassica vegetables. The samples were dried at 6$0^{\circ}C$ for 24 hrs and ground to pass a 0.5 mm screen. The crude protein and crude fat contents of brassica vegetables were 2∼3 times higher than those of grain as dry matter basis. However, the crude ash content of brassica vegetables was 7 times higher than that of grain. Total dietary fiber (TDF) was ranged from 24.26% (Narinosa) to 47.33% (Chinensis) as dry matter basis. Insoluble dietary fiber (IDF) was ranged from 17.75% (Narinosa) to 26.81% (Toscana) as dry matter basis. Soluble dietary fiber (SDF) was ranged from 3.20% (Toscana) to 23.45% (Narinosa) as dry matter basis. The correlation of brassica vegetables was r=0.30 between TDF and IDF, r=0.89 between TDF and SDF (p＜0.01), r =0.25 between TDF and CHO, and r=0.29 between DFi and NDF (p＜0.05), respectively.

• Animal Bioscience
• /
• v.34 no.10
• /
• pp.1653-1662
• /
• 2021

Objective: This experiment was conducted to investigate the effect of insoluble cellulose supplementation to diets on the growth performance, intestinal morphology, the incidence of diarrhea, nutrients digestibility, and inflammatory responses in altering environmental conditions of animals housing. Methods: A total of 108 male pigs (Duroc×[Yorkshire×Landrace]) were randomly allocated to one of three dietary treatments (cellulose 0%, 1%, 2%) and two environmental conditions (good sanitary condition vs. poor sanitary condition) to give 6 replicate pens per treatment with three pigs per each pen at 14 days post-weaning. Results: Pigs were in good sanitary condition had higher average daily gain (p<0.01) and improved feed efficiency (p<0.05) from day 1 to 14 after weaning compared to their counterparts. The interactions were found between environmental conditions and dietary treatments (day 7: crypt depth [p<0.01], villous height to crypt depth [p<0.001]; day 14: crypt depth [p<0.001], villous to crypt ratio [p<0.01]) in ileum morphology. Crypt depth was decreased (p<0.05), and villous to crypt ratio was increased (p<0.05) only in poor sanitary conditions. Pigs exposed to the good sanitary condition had higher (p<0.05) apparent ileal digestibility (day 7, gross energy; day 14, dry matter), apparent total tract digestibility (day 14, dry matter and crude protein) compared to pigs housed in the poor sanitary condition. Meanwhile, pigs fed a diet supplemented with 2% cellulose had decreased (p<0.05) apparent ileal digestibility (day 7, dry matter; day 14, crude protein), apparent total tract digestibility (day 7, dry matter; day 14, crude protein, gross energy) compared to pigs fed a diet supplemented with 0% or 1% cellulose. Conclusion: Our results indicated that a diet supplemented with 1% cellulose increased villous to crypt ratio, however feeding a diet containing cellulose (1% or 2%) impaired nutrient digestibility for 14 day after weaning in both good sanitary and poor sanitary conditions.

• Fisheries and Aquatic Sciences
• /
• v.21 no.11
• /
• pp.32.1-32.7
• /
• 2018

Trout production is a growing activity in recent years but requires new alternative sources of feed to be sustainable over time. The objective of this research was to determine the apparent digestibility coefficient (ADC) of dry matter (DM), organic matter (OM), crude protein (CP) and digestible energy (DE) of $ka{\tilde{n}}iwa$ (Chenopodium pallidicaule Aellen), kiwicha (Amaranthus caudatus L), quinoa (Chenopodium quinoa Willd), beans (Phaseolus vulgaris L.), sacha inchi, (Plukenetia volubilis L) and jumbo squid (Dosidicus gigas) meal in juvenile rainbow trout. The experimental diets were composed of a 70% basal diet and 30% of any raw materials. The ADC was determined by the indirect method using insoluble ash as a non-digestible marker. Jumbo squid, sacha inchi and quinoa showed the highest values of ADC (%) of DM (84.5, 73.5 and 69.7), OM (89.1, 78.4 and 72.9), CP (93.2, 98.0 and 90.3), and DE (4.57, 4.15 and 2.95 Mcal/kg DM), respectively. The ADC values for $ka{\tilde{n}}iwa$, kiwicha and bean were significantly lower. In conclusion, quinoa meal and jumbo squid meal have an acceptable digestibility but sacha inchi meal is a potential alternative for rainbow trout feeding in the future.