• Journal of the Korean institute of surface engineering
• /
• v.56 no.6
• /
• pp.412-419
• /
• 2023

Anion exchange membrane electrolysis is considered a promising next-generation hydrogen production technology that can produce low-cost, clean hydrogen. However, anion exchange membrane electrolysis technology is in its early stages of development and requires intensive research on electrodes, which are a key component of the catalyst-system interface. In this study, we optimized the pressure conditions of the hot-pressing process to manufacture cobalt oxide electrodes for the development of a high uniformity and high adhesion electrode production process for the oxygen evolution reaction. As the pressure increased, the reduction of pores within the electrode and increased densification of catalytic particles led to the formation of a uniform electrode surface. The cobalt oxide electrode optimized for pressure conditions exhibited improved catalytic activity and durability. The optimized electrode was used as the anode in an AEMWE single cell, exhibiting a current density of 1.53 A cm^-2 at a cell voltage of 1.85 V. In a durability test conducted for 100 h at a constant current density of 500 mA cm^-2, it demonstrated excellent durability with a low degradation rate of 15.9 mV kh^-1, maintaining 99% of its initial performance.

• Korean journal of food and cookery science
• /
• v.16 no.1
• /
• pp.47-56
• /
• 2000

The purpose of this study was to develop a drying method of Gangjung. a traditional Korean snack, thus to reduce the drying time and to improve the quality of Gangjung. Two drying methods, hot air drying and far infrared ray drying were used by changing conditions such as air velocity(0.4, 1.2, 1.6 m/s), temperature(40, 50, 60$\^{C}$), and aging. Optimal moisture content of dried Gangjung pellet was 17% which was proper for frying. Cracks appeared on the surface of Gangjung pellet at lower levels of moisture content. Far infrared ray drying saved drying time about 20%. Both hot air drying and far infrared ray drying at 0.4 m/s of air velocity tended to show better quality of Gangjung than those dried at higher air velocities. The expansion volume and texture of Gangjung drying at 40$\^{C}$ was better than other temperature conditions, regardless of drying methods. Quality of Gangjung, dried at single stage without aging, was superior to those dried at double stage including aging process. Moreover, single stage drying save the drying time at least 24 hr. Gangjung dried at high temperature became hard and less brittle in sensory evaluation. In image analysis, air cell distribution in inner structure of Gangjung became uniform and fine as drying temperature decreased to 40$\^{C}$. Overall, Gangjung made of Gangjung pellet by the use of far infrared ray drying at 40$\^{C}$ without aging, showed the best quality in terms of physical and sensory properties.

• The Korean Journal of Food And Nutrition
• /
• v.27 no.2
• /
• pp.175-182
• /
• 2014

This study investigates the free radical-scavenging activities of Amaranth (Amaranthus spp. L.) red and purple flower extracts. The methanol and hot water extracts of flower are being evaluated for its total polyphenol and flavonoid contents, scavenging activities by the DPPH and ABTS analysis, SOD-like activity, and inhibition activities of superoxide radical on the HL-60 cells and nitric oxide of the RAW 264.7 cells. The PFM (purple flower extracted with MeOH) showed the highest total phenolic and flavonoid content, 606.95 mg GAE/100 g and 254.69 mg CE/100 g, respectively. Amongst the scavenging activities of the DPPH radicals, PFM($RC_{50}=155.06{\mu}g/m{\ell}$) is the highest of all the samples. The ABTS radical-scavenging activity is also highest for PFM (53.16%) at the $250{\mu}g/m{\ell}$ concentration. But, the SOD-like activity of the PFW (purple flower extracted with hot water) increases more than 3 folds of the PFM. In the leukemia HL-60 cell, the PFM shows strongly inhibited superoxide radical generations at a concentration of $200{\mu}g/m{\ell}$ at 72.34%, which increases with 1.79 folds more than the RFW (red flower extracted with hot water). The inhibition activity of nitric oxide in Raw 264.7 cells is the highest for PMF (46.90%) at a $250{\mu}g/m{\ell}$ concentration. In conclusion, PMF show the highest flavonoid contents and the most powerful free radical-scavenging activity. Our results suggest that the increase of antioxidant activities depend on flavonoid contents. Thus, Amaranth flower can be useful for natural antioxidant compounds.

• Korean Journal of Fisheries and Aquatic Sciences
• /
• v.34 no.3
• /
• pp.285-290
• /
• 2001

To utilize canned oyster processing waste water effectively, this study was carried out to prepare instant powdered soup using the waste water (IPSW), Instant powdered souu from oyster hot-water extracts (IPSE) was prepared by mixing hot-water extracts powder (15 g) with table salt (5 g), cream powder (19 g), milk replacer (12 g), wheat flour (20 g), corn flour (15 g), starch (5 g), glucose (7.5 g) and onion powder (1.5 g). In preparing IPSW, mixed powder from wash water and boiling liquid waste, instead of powder from hot-water extracts and table salt, was added (powder from boiling liquid waste: powder from wash water= 12: 8) and other additives were added in proportion to those in the IPSE, The IPSW consists mainly of carbohydrates (about $72\%$). It was not different from the IPSE. The volatile basic nitrogen, viable cell counts, coliform group of the IPSW contains 33.4 mg/100g, $2.2\times10^4CFU/g$, <180 MPN/100g, respectively, and its water activity has 0.257. So it was a hygienically safe and conservable instant food. The main fatty acids of IPSW were 16: 0 and 18: 1n-9. Its chemical score of protein was $61.4\%$ and its main inorganic matter was iron. According to a sensual evaluation, in contrast to the IPSE, the IPSW had a bit lower aroma but better taste, It was concluded from the above chemical and sensory evaluation that even the boiling liquid waste which had been mostly abandoned because of its high table salt content can be used as a good material for instant powdered soup if it's powdered and mixed adequately with powder from wash water, and its table salt content is properly adjusted.

• Journal of Nutrition and Health
• /
• v.51 no.6
• /
• pp.507-514
• /
• 2018

Purpose: Sargassum horneri (S. horneri) is a species of brown macroalgae that is common along the coast of Japan and Korea. The present study investigated the immuno-modulatory effects of different types of S. horneri extracts in RAW264.7 macrophages. Methods: S. horneri was extracted by three different methods, hot water extraction, 50% ethanol extraction, and supercritical fluid extraction. Cell viability was then measured by MTT assay, while the production levels of tumor necrosis factor-${\alpha}$ (TNF-${\alpha}$), interleukin-6 (IL-6), and nitric oxide (NO) were measured by enzyme-linked immunosorbent assay and Griess assay, respectively. The expression and activation levels of inducible NO synthase (iNOS), mitogen-activated protein kinase (MAPK) and nuclear factor ${\kappa}B$ ($NF-{\kappa}B$) were examined by western blot analysis. Results: The three different S. horneri extracts were nontoxic against RAW 264.7 cells up to $50{\mu}g/mL$, among which treatment with hot water extract (HWE) of S. horneri significantly enhanced the production of TNF-${\alpha}$, IL-6, and NO in a dose-dependent manner. Hot water extract of S. horneri also increased the expression level of iNOS, suggesting that up-regulation of iNOS expression by HWE of S. horneri was responsible for the induction of NO production. In addition, treatment of RAW 264.7 macrophages with HWE of S. horneri increased the phosphorylation levels of ERK, p38 and JNK. Furthermore, the activation and subsequent nuclear translocation of $NF-{\kappa}B$ was enhanced upon treatment with HWE of S. horneri, indicating that HWE of S. horneri activates macrophages to secrete TNF-${\alpha}$, IL-6 and NO and induces iNOS expression via activation of the $NF-{\kappa}B$ and MAPKs signaling pathways. Conclusion: Taken together, these findings suggest that HWE of S. horneri possesses potential as a functional food with immunomodulatory activity.

• Journal of Bio-Environment Control
• /
• v.28 no.2
• /
• pp.110-116
• /
• 2019

This study was conducted to determine the effects of a pre-planting fertilizers with various $NH_4{^+}:NO_3{^-}$ ratios in a coir dust:peatmoss:perlite (3.5:3.5:3.0, v/v/v) medium on the growth of hot pepper (Capsicum annuum L. cv. Nokkwang) plug seedling. Nitrogen levels were fixed to $300mg{\cdot}L^{-1}$ and the $NH_4{^+}:NO_3{^-}$ ratios were varied to 0:100, 27:73, 50:50, 73:27, and 100:0. The 50-cell trays were filled with treatment media containing pre-plant fertilizers, then seeds were sown. After seeds were germinated, the trays were moved to greenhouse and seedlings were feed with 13-2-13 and 20-9-20 fertilizers, alternatively. The changes in pH and EC were measured every week and soil solution for nutrient concentrations were analyzed in week 0, 3, and 7. The measurements of seedling growths as well as analysis of tissue nutrient contents were also conducted in week 7. The varied $NH_4{^+}:NO_3{^-}$ ratios did not influence on the pHs of root media after incorporation of pre-planting fertilizers, but the ECs were heightened as proportion of $NH_4{^+}$ to $NO_3{^-}$ were elevated. During the raising of seedlings, the pHs rose over time in the treatments of 0:100 and 27:73 ($NH_4{^+}:NO_3{^-}$). The concentrations of all macro-elements in root media decreased gradually as seedlings grew in all treatments. The seedling growths 7 weeks after seed sowing were the highest in the treatments of 27:73 and 50:50 ($NH_4{^+}:NO_3{^-}$) and those became worse in the treatments of higher $NH_4{^+}$ ratios than 73%. In terms of inorganic element contents based on the dry weight of above ground tissue, the treatment of 0:100 showed the lowest content of Ca, Mg, Na, Cu, Mn, and Zn. Based on the results, it is desired that $NH_4{^+}$ ratio in pre-planting fertilization is maintained to be 50% or less for the raising of hot pepper plug seedlings.

• Journal of the Korean Society of Food Science and Nutrition
• /
• v.38 no.3
• /
• pp.267-273
• /
• 2009

Antioxidative, antimicrobial activities and Raw 264.7 cell viability as cytotoxicity of various solvent extracts from leaf of Eriobotrya japonica Lindl. dried by different methods were investigated for processing as functional ingredient. In DPPH radical scavenging activity, RLE (80% EtOH extract of raw leaf) and FLE (80% EtOH extract of freeze-dried leaf) exhibited strong scavenging effect on $300{\mu}M$ DPPH radical solution (1.71 mg/mL and 2.11 mg/mL for RLE $SC_{50}$ and FLE $SC_{50}$). Also in nitric oxide scavenging activity, RLE and FLE showed strong activities (83.9% and 82.2% in 5 mg/mL sample concentration). Total phenolic compound contents of each extracts were found to be $73.7{\sim}215.4$ mg/g and RLE was showed the highest phenolic compound content. Also, total flavonoid contents were found to be $24.85{\sim}110.3$ mg/g and RLE was showed the highest flavonoid content. In antimicrobial activity, RLE was showed higher growth inhibition effect against all microbial strains. RLE, RLW (hot water extract of raw leaf), and FLW (hot water extract of freeze-dried leaf) exhibited strong antimicrobial activities against MRSA and S. aureus. In measurement of cytotoxicity by MTT assay, Raw 264.7 cell viabilities of 80% EtOH extracts showed better effect than water extracts. Especially viability of RLE was found be over 100% in every tested sample concentration.

• Journal of Korean Society of Forest Science
• /
• v.110 no.2
• /
• pp.254-265
• /
• 2021

As a result of measuring the polyphenol content of Humulus japonicus (HJ) extract according to the collection time and extraction solvent, bothhot water extract and 70% ethanol extract were collected and extracted in June, and the polyphenol content was high. When the harvesting time was the same, the polyphenol content of the ethanol extract was higher than that of the hot water extract. As a result of measuring the antioxidant activity of HJ extract by measuring electron-donating ability, SOD-like activity, and ABTS radical scavenging ability, HJ6E, which has the highest polyphenol content, showed the highest activity. In addition, in the case of the extract collected in August, the polyphenol content was similar. However, the antioxidant activity of the ethanol extract was high, sothe antioxidant activity remained high when extracted with 70% ethanol. As a result of measuring tyrosinase inhibitory activity for evaluating skin whitening activity, HJ6W did not show any activity. The activity at the highest concentration was 16.18% for HJ8W, 8.07% for HJ6E, and 14.7% for HJ8E. Therefore, the content of ingredients showing skin whitening activity was higher in August than in June. In the elastase inhibitory activity for evaluating the anti-wrinkle activityof the skin, the ethanol extract showed very little activity, and the hot water extract did not. In addition, since all extracts do not show astringent activity, it is judged that it is not appropriate to use HJ as a functional ingredient for preventing wrinkle formation. As a result of measuring the cell viability of HJ6E, which showed the highest polyphenol content and antioxidant activity, it showed a cell proliferation effect at low concentrationsbut strong cytotoxicity at concentrations above 50 ㎍/mL. In the case of the NO production inhibitory ability, as the concentration increased, the NO production of Raw 264.7 was suppressed. Theamount of NO production at 1,000 ㎍/mL decreased to 40.7%. However, whether these results are due to cytotoxicity or the extract's efficacy is a part that requires further research.

• Journal of Practical Agriculture & Fisheries Research
• /
• v.4 no.1
• /
• pp.119-127
• /
• 2002

This study was conducted to develop the heat exchanger by utilizing the heat energy of underground water(15℃), which might be used for cooling and heating system of the agricultural facilities. We developed the heat exchanger, parallel type plat fin tube made of Aluminum(Al 6063), which was named Aloo-Heat(No. of The registration design : 0247164, by Korean Intellectual property Office). The fin of exchanger was design of the granulated surface for minimizing fouling factor and dew forms, and also placed parallel to the tube in order to minimized the resistance of flows. 1. Aloo-heat was designed to have 0.03m for inside diameter, 0.036m for outside diameter of tube, 0.0012m for thickness of fin and 0.032m for length of plat fin. 2. t was also designed to have 1.5248m²/m for outside area of heat transfer, 0.0942m²/m for inside area contacting hot liquid, and the ratio (Ra) was 16.1869. 3. Efficiency of the fin was 93 percentage when fin length was 0.032m, and the fin thickness satisfied equation $\frac{h{\rho}}{k}$< 0.2 when it was 0.0012m. 4. According to the performance test of Aloo-heat, as the temperature and rate increased, the heating value also increased, heating value was 504kJ/h·m and 6,048kJ/h·m when it was 60℃, 10 𝑙/min and 80℃, 40 𝑙/min respectively. 5. The test of heating value was confident, because correlation value(R²) was 0.9898 for the temperature and 0.9721 for flow rate of hot liquid, respectively.

• Journal of Bio-Environment Control
• /
• v.26 no.4
• /
• pp.368-377
• /
• 2017

This study investigated the possibility of application of the recently introduced cylindrical paper pot seedlings in hot pepper (Capsicum annuum L.) cultivation. The seedling growth, initial rooting after planting and accumulated fruit yield were investigated with the treatments of tray type (paper pot and plug) as a main factor, tray cell number (40 cell and 50 cell) as a sub-factor, and fertigation method (continuous fertigation and fertigation after 35 days sowing) as a sub-sub factor, respectively. The growth of pepper seedlings was significantly affected by tray type and fertigation method showing the highest value at 50 cell plug tray with continuous fertigation, and the effect of fertigation was greater than that of trays. 'Cheongyang', 'Daekwonseoneon' and 'Longgreenmat' cultivar showed all the same pattern in seedling growth. These three-cultivar seedlings were planted in plastic house and in open field in Jeonju area, respectively, and another 'Daekwonseoneon' seedlings raised Yeongyang local area was also planted at the same area. There was no difference in the rooting of 'Cheongyang' pepper at 2 weeks after planting in plastic house. The accumulated fruit weight was not significantly different between paper pot seedlings and plug seedlings in three cultivar grown in plastic house. However, that of 'Cheongyang' pepper showed higher at paper pot seedlings than plug seedlings and the other two cultivar were higher at plug seedlings in open field. 'Daekwonseoneon' pepper yield grown in open field in 'Yeongyang' area was not significant between paper pot seedlings and plug seedlings. In conclusion, the pattern of seedlings growth grown in the cylindrical paper pot was the same as those of the conventional plug seedlings and also fruit yield was similar between paper pot seedlings and plug seedlings even though minute difference among cultivars. These results suggest that pepper seedlings grown in paper pot should be highly applicable to pepper cultivation.