• Journal of Microbiology and Biotechnology
• /
• 제26권4호
• /
• pp.739-747
• /
• 2016

The rational utilization of crop straw as a raw material for natural gas production is of economic significance. In order to increase the efficiency of biogas production from agricultural straw, seasonal restrictions must be overcome. Therefore, the potential for biogas production via anaerobic straw digestion was assessed by exposing fresh, silage, and dry yellow corn straw to cow dung liquid extract as a nitrogen source. The characteristics of anaerobic corn straw digestion were comprehensively evaluated by measuring the pH, gas production, chemical oxygen demand, methane production, and volatile fatty acid content, as well as applying a modified Gompertz model and high-throughput sequencing technology to the resident microbial community. The efficiency of biogas production from fresh straw (433.8 ml/g) was higher than that of production from straw silage and dry yellow straw (46.55 ml/g and 68.75 ml/g, respectively). The cumulative biogas production from fresh straw, silage straw, and dry yellow straw was 365 l^-1 g^-1 VS, 322 l^-1 g^-1 VS, and 304 l^-1 g^-1 VS, respectively, whereas cumulative methane production was 1,426.33%, 1,351.35%, and 1,286.14%, respectively, and potential biogas production was 470.06 ml^-1 g^-1 VS, 461.73 ml^-1 g^-1 VS, and 451.76 ml^-1 g^-1 VS, respectively. Microbial community analysis showed that the corn straw was mainly metabolized by acetate-utilizing methanogens, with Methanosaeta as the dominant archaeal community. These findings provide important guidance to the biogas industry and farmers with respect to rational and efficient utilization of crop straw resources as material for biogas production.

• Asian-Australasian Journal of Animal Sciences
• /
• 제29권6호
• /
• pp.823-829
• /
• 2016

Eight Holstein steers ($216{\pm}48kg$ body weight) fitted with ruminal and duodenal cannulas were used to evaluate effects of wheat straw processing (ground vs pelleted) at two straw inclusion rates (7% and 14%; dry matter basis) in dry rolled or steam-flaked corn-based finishing diets on characteristics of digestion. The experimental design was a split plot consisting of two simultaneous $4{\times}4$ Latin squares. Increasing straw level reduced ruminal (p<0.01) and total tract (p = 0.03) organic matter (OM) digestion. As expected, increasing wheat straw level from 7% to 14% decreased (p<0.05) ruminal and total tract digestion of OM. Digestion of neutral detergent fiber (NDF) and starch, per se, were not affected (p>0.10) by wheat straw level. Likewise, straw level did not influence ruminal acetate and propionate molar proportions or estimated methane production (p>0.10). Pelleting straw did not affect ($p{\geq}0.48$) ruminal digestion of OM, NDF, and starch, or microbial efficiency. Ruminal feed N digestion was greater (7.4%; p = 0.02) for ground than for pelleted wheat straw diets. Although ruminal starch digestion was not affected by straw processing, post-ruminal (p<0.01), and total-tract starch (p = 0.05) digestion were greater for ground than for pelleted wheat straw diets, resulting in a tendency for increased post-ruminal (p = 0.06) and total tract (p = 0.07) OM digestion. Pelleting wheat straw decreased (p<0.01) ruminal pH, although ruminal volatile fatty acids (VFA) concentration and estimated methane were not affected ($p{\geq}0.27$). Ruminal digestion of OM and starch, and post-ruminal and total tract digestion of OM, starch and N were greater (p<0.01) for steam-flaked than for dry rolled corn-based diets. Ruminal NDF digestion was greater (p = 0.02) for dry rolled than for steam-flaked corn, although total tract NDF digestion was unaffected (p = 0.94). Ruminal microbial efficiency and ruminal degradation of feed N were not affected (p>0.14) by corn processing. However, microbial N flow to the small intestine and ruminal N efficiency (non-ammonia N flow to the small intestine/N intake) were greater (p<0.01) for steam-flaked than for dry rolled corn-based diets. Ruminal pH and total VFA concentration were not affected ($p{\geq}0.16$) by corn processing method. Compared with dry rolled corn, steam-flaked corn-based diets resulted in decreased acetate:propionate molar ratio (p = 0.02). It is concluded that at 7% or 14% straw inclusion rate, changes in physical characteristics of wheat straw brought about by pelleting negatively impact OM digestion of both steam-flaked and dry-rolled corn-based finishing diets. This effect is due to decreased post-ruminal starch digestion. Replacement of ground straw with pelleted straw also may decrease ruminal pH.

• 한국미생물생명공학회:학술대회논문집
• /
• 한국미생물생명공학회 2005년도 2005 Annual Meeting & International Symposium
• /
• pp.204-211
• /
• 2005

The technology of Solid-State-Fermentation (SSF) with corn straw by Pichia ohmeri T021 was studied in this article. After being crushed, the corn straw powder was added into vitriol solutions to hydrolysis, which the quality proportion of corn straw: water: vitriol (98%) is 20:80:1. The mixtures was incubated at 120$^{\circ}C$ for 1 hour, and the hydrolysis rate reached 19%. Following, the mixture was adjusted to pH 4.5 by sodium carbonate and added cellulase (25IFPU/g). The hydrolysis rate reached 15% after the mixture was incubated at 50$^{\circ}C$ for 25h. The mixture which hydrolysed by vitriol was inoculated by Pichia ohmeri T021 (5${\times}10^7$cell/g) and added cellulase (25 IFPU/g) at the same time. The ethanol yield reached 2.99g per 100 gram substrate after the fermenting grains was incubated at 33$^{\circ}C$, pH 4.5 for 5 days.

• Animal Bioscience
• /
• 제35권1호
• /
• pp.29-38
• /
• 2022

Objective: The objective of this study was to compare the feeding value, meat nutrients and associative effects of a diet comprised of various corn silages inclusion with peanut vine or wheat straw in finishing beef cattle. Methods: One hundred and eighty Simmental crossbred beef steers were blocked and assigned to the follow treatments: i) whole plant corn silage-based diet (control, WPCS), ii) mixed forages-based diet (replacing a portion of corn silage with wheat straw, WPCSW), iii) corn stalklage-based diet (CS), and iv) sweet corn stalklage-based diet (SCS). Each group consisted of 5 repeated pens with 9 steers/pen. The diets were formulated to be isonitrogenous and isoenergetic with same forage to concentrate ratio. Experimental diets were fed for 90 d. Results: The effective ruminal degradability of dry matter and crude protein were highest for WPCS diet (p<0.05), for neutral detergent fiber was highest in SCS diet (p<0.05). The average daily gain was greater for cattle offered the WPCS diet, intermediate with WPCSW and SCS and lowest with CS (p<0.001). The concentration of non-esterified fatty acid in serum was higher for steers fed with CS and SCS diets than those offered WPCS and WPCSW steers (p<0.001). The treatments did not affect the general nutritional contents and amino acids composition of Longissimus dorsi of steers (p>0.05). Conclusion: The corn silage-based diet exhibited the highest feeding value. The sweet corn stalklage and wheat straw as an alternative to corn silage offered to beef cattle had limited influence on feeding value and meat nutrients. However, the value of a corn stalklage-based diet was relatively poor. To sum up, when the high quality forage resources, such as corn silage, are in short supply, or the growth rate of beef cattle decreases in the later finishing period, the sweet stalklage and wheat straw could be used as a cheaper alternative in feedlot cattle diet without sharp reducing economic benefits.

• 한국미생물·생명공학회지
• /
• 제4권4호
• /
• pp.152-158
• /
• 1976

전분박을 첨가한 왕겨및 볏짚의 산당화액을 이용하여 효모생육조건을 검토하여 다음과 같은 결론을 얻었다. 1. 왕겨와 볏짚에 전분박을 첨가하여 당화시킴으로써 당화액의 당농도가 각각 9.12%, 7.98%까지 증가되었다. 2. 산당화액을 중화할 때 사용한 중화제로서는 CaCO$_3$, Ca(OH)$_2$, NH$_4$OH순으로 효모생육이 좋았다. 3. 당화액을 기질로 하여 무기영양요구성을 검토한 결과 (NH$_4$)$_2$SO$_4$0.3%, $K_2$HPO$_4$0.4%, MgSO$_4$ㆍ7$H_2O$0.02%, NaCl 0.02%, CaCl$_2$0.02%를 가하였을 때 효모의 생육도가 가장 좋았다. 4. 전분박을 첨가한 왕겨와 볏짚의 당화액을 기질로 하여 효모를 배양하였을 때 48시간 이내에 각각 91.2% 90.8%의 당을 소화하였고 당에 대한 수율은 각각 46.5 %, 45.4%이었다.

• 한국초지조사료학회지
• /
• 제38권1호
• /
• pp.39-43
• /
• 2018

The objective of this study was to determine the effect of various roughage sources on nutrient digestibility and enteric methane ($CH_4$), and carbon dioxide ($CO_2$) production in goats. Four castrated black goats ($48.5{\pm}0.6kg$) were individually housed in environmentally controlled respiration-metabolism chambers. The experiment design was a $4{\times}4$ balanced Latin square design with 4 roughage types and 4 periods. Alfalfa, tall fescue, rice straw, and corn silage was used as representative of legume, grass, straw, and silage, respectively. Dry matter digestibility was higher (p < 0.001) in corn silage than in alfalfa hay. Dry matter digestibility of alfalfa hay was higher than those of tall fescue or rice straw (p < 0.001). Neutral detergent fiber digestibility of tall fescue was lower (p < 0.001) than those of alfalfa, rice straw, or corn silage. Daily enteric $CH_4$ production and the daily enteric $CH_4$ production per kilogram of $BW^{0.75}$, dry matter intake (DMI), organic matter intake (OMI), digested DMI, and digested OMI of rice straw did not differ from those of tall fescue but were higher (p < 0.001) than those of alfalfa or corn silage. Roughage type had no effect on enteric $CO_2$ emission in goats. Straw appeared to generate more enteric $CH_4$ production than legume or silage, but similar to grass.

• 한국농업기계학회:학술대회논문집
• /
• 한국농업기계학회 1993년도 Proceedings of International Conference for Agricultural Machinery and Process Engineering
• /
• pp.686-695
• /
• 1993

A flywheel-type, inclined axis chopper for small-area rice and livestock farmers, has been developed at IRRI Agricultural Engineering, The prototype is belt-driven by a 2.6kW engine and uses four angled blades rotating below a fixed counteredge. Manual feeding is facilitated by a convenient spout presenting the crop to the inclined blade housing and also suction created by the rotating blades . The distance between the rotating blades and the bottom of the housing determines the length of chops, set here for 25 cm. The unit would cost $200 without the engine. Tests with napier grass, corn stalks , and rice straw showed satisfactory performance within the acceptable clearance, speed and moisture content ranges of the material presented. Highest capacities were 1186, 1148 and 744kg/hr for napier grass, corn stalks and rice straw, respectively. Corn stalks required the highest power demand at 2.3kW engine would be adequate as power source. The chopper performance was comparable to higher cost commercial chippers in terms of capacity and specific energy.

• Journal of Ginseng Research
• /
• 제14권3호
• /
• pp.427-431
• /
• 1990

To search for substituents of greens, several organic materials such as rice straw, barley straw, corn stem and manufactured compost were applied in a ginseng cultivating field. The yields of six year old ginseng harvested in the rice straw, barley strait and corn stem treated field were similar to or higher than that of the greens treated one. The varied amount of applied substituents resulted in a yield change, but statistical linearity was not found. The growth of ginseng aerial part and soil physicochemical property in the field fortified with these substituents showed similar results to those of the greens treated one. So, it is though that these organic materials can substitute for greens.

• 한국미생물·생명공학회지
• /
• 제7권2호
• /
• pp.91-95
• /
• 1979

Cellulose 및 hemicellulose 를 함유하는 볏짚 등 농산폐자원을 Trichoderma로 만든 Koui와 효모를 동시에 처리하여 단일공정으로 ethanol과 xylose 를 생산할 수 있었다. 볏짚 50g을 처리하여 ethanol 18mι와 xylose 2.7g 을 생산할 수 있었으며 옥수수속대 50g에서 ethanol 3.8mι와 xylose 10.8 g을 얻을 수 있었다. 이 처리에서 토양 분리균 Tri-choderma sp. KI 7-2로 만든 Koji가 T. reesei 의 그것보다 높은 효모활성을 보였다. 볏짚의 alkali 전처리는 ethanol 및 xylose의 생산에 큰 효과가 없었으며 이에 대하여 논하였다

• 한국미생물·생명공학회지
• /
• 제11권3호
• /
• pp.193-199
• /
• 1983

보리짚이나 옥수수 속과 같은 농산폐자원으로부터 xylose를 생산하기 위한 생물전환공정에 관한 연구를 수행했다. 보리짚이나 1% 가성소다용액으로 24시간 3$0^{\circ}C$ 전처리한후 3$0^{\circ}C$에서 48시간 효소 가수분해를 시킨 결과 15.8%의 환원당을 유리시켰다. 이 환원당의 량은 보리 짚에 들어있는 전 D-xylose 함량에 87%에 해당하는 것이다. 여러 가지 농산폐자원의 효소전환공정을 시험한 결과, 보리짚과 옥수수속이 D-xylose 생산에 가장 적합한 원료가 픽수 있음을 관찰하였다.