• Magazine of the Korean Society of Agricultural Engineers
• /
• v.16 no.1
• /
• pp.3293-3301
• /
• 1974

An experimental work was conducted by using a laboratory-made model dryer to investigate the effect of the rate of natural forced-air on the drying rate of rough rice which was deposited in the deep-bed. The dryer consisted of 8 cylinderical containers with grain holding screen at their bottoms, each of which having 30cm in diameter and 15cm in height. The containers were sacked vertically with keeping them air-tight by using paper tape during dryer operation. Two separate layers of containers were operated in the same time to have two replications. The moisture contents of grains within each bins after predetermined period of dryer operation were determined indirectly by measuring the weight of the individual containers. The air-rates were maintained at 6 levels, or 5, 8, 10, 15, 18 and 20 millimenters of static head of water. The roomair conditions during dryer operation were maintained in the range of 10-l5$^{\circ}C$ in temperature and 40-60% in relative humidity. The results of the study are summarized as follows: 1. Drying characteristics of the grains in the bottom layers were approximately the same regardless of airdelivery rates, giving the average drying rate as about 0.35 percent per hour after 40-hour drying period, during which moisture content (w. b.) reduced from 24 percent to about 10 percent. 2. After about 40-hour drying period, the mean drying rates increased from 0.163 percent per hour to 0.263 percent per hour as air-flow rates increased from 5mm to 87.16mm of static head of water. In the same time, the moisture differences of grains between lower and upper layers varied from 12.7 percent at the air rate of 5mm of water head to 7.5 percent at the air-flow rate of 20mn of water head. Thus, the greater the air-flow rate was, the more overall improvement in drying performance was. Additionally, from the result of ineffectiveness of drying grain positioned at 70cm depth or above by the air rate of 5mm of static head of water it may be suggested in practical application that the height of grain deposit would be maintained adequately within the limits of air-rates that may be actually delivered. 3. Drying after layer-turning operation was continued for about 30 hours to test the effectiveness of reducing moisture differences in the thick layers. As a result of this layer-turning operation, moisture distribution through layers approached to narrow ranges, giving the moisture range as about 7 percent at air-flow rate of 5mm head of water, about 3 percent at 10mm head about 2 percent at 15mm head, and less than 1 percent at 20mm head. In addition, from the desirable results that drying rate was rapid in the lower layers and dully in the upper layers, layer-turning operation may be very effective in natural air drying with deep-layer grain deposit, especially when the forced air was kept in low rate. 4. Even though the high rate of air delivery is very desirable for deep-layer natural-air drying of rough rice, it can be happened that the required air delivery rate could not be attained because of limitation of power source available on farms. To give a guide line for the practical application, the power required to perform the drying with the specified air rate was analyzed for different sizes of drying bin and is given in Table (5). If a farmer selects a motor of which size is 1 or {{{{1 { 1} over {2 } }}}} H.P. and air-delivery rate which ranges from 8~10mm of head, the diameter of grain bin may be suggested to choose about 2.4m, also power tiller or other moderate size of prime motor may be recommended when the diameter of grain bin is about 5.0m or more for about 120cm grain deposit.

• KOREAN JOURNAL OF CROP SCIENCE
• /
• v.63 no.2
• /
• pp.98-105
• /
• 2018

The sale of brown rice batches composed of rice produced in different years is prohibited in Korea. Thus, new methods for the identification of the year of production are critical for maintaining the distribution of high quality brown rice. Here, we describe the exploitation of an enzyme that can be used to discriminate between freshly harvested and one-year-old brown rice. The degree of enzyme activity was visualized through freshness test with Guaiacol, Oxydol, and p-phenylenediamine reagents. With electronic eye equipment, we selected 29 color codes for identifying new brown rice and old brown rice. The discrimination power of selected color codes showed a minimum of 0.263 to a maximum of 0.922 and an average value of 0.62. The accuracy with which new brown rice and old brown rice could be identified was 100% in principal component analysis (PCA) and discriminant function analysis (DFA). The DFA analysis had greater discriminatory power than did the PCA analysis. A verification test using new brown rice, old brown rice, or a mixture of the two was then performed to validate our method. The accuracy of identification of new and old brown rice was 100% in both cases, whereas mixed brown rice samples were correctly classified at a rate of 96.9%. Additionally, in order to test whether the discriminant constructed in winter can be applied to samples collected in summer, new and old brown rice stored for 8 months were collected and tested. Both new and old brown rice collected in summer were classified as old brown rice and showed 50% identification accuracy. We were able to attribute these observations to changes in enzyme content over time, and therefore we conclude, it will be necessary to develop discriminants that are specific to distinct storage periods in the near future.

• Economic and Environmental Geology
• /
• v.18 no.1
• /
• pp.1-9
• /
• 1985

To understand the characteristics of uranium distribution, and the correlation of the uranium content and major constituents in uraniferous black slates from the Jinsan area of Ogcheon Fold Terrain, forty representative specimens were analyzed by mineralogical and radiometric techniques. According to statistical analysis, the uranium has a positive correlation with organic carbon and limonite, but a negative relation to muscovite and other opaques. The relationship with the highest and meaningful correlation is between log uranium and organic carbon. The log uranium-organic carbon correlation coefficient is 0.845 and these two constituents have about 71.4% association. It suggests that the abundance of organic carbon controlled the uranium precipitation. The relationship of organic carbon to log uranium can be expressed by following regression equation log ($U_3O_8{\times}10^4+1$)=-1.3447+2.5599 log (organic carbon). The multiple regression equation of different major components to log uranium is log ($U_3O_8{\times}10^4+1$)=0.77396+ 0.04465 (organic carbon)+0.00574 (quartz)-0.00964 (muscovite)+0.37827 (biotite)-0.02286 (clay substance)+0.01268 (other silicates)+0.1032 (barite)-0.00224 (apatite)+0.01606 (calcite)+0.08258 (hematite)-0.02406 (limonite)-0.01715 (other opaques).

• Korean Journal of Ecology and Environment
• /
• v.41 no.2
• /
• pp.216-227
• /
• 2008

To understand eutrophication in the upper regions of brackish Lake Sihwa with a limited water exchange, temporal and spatial distributions of pollutants in water and sediment were investigated from March to October in 2005 and 2006. Also, pollution levels of water and sediment were estimated by trophic state index (TSI) and sediment quality guideline (SQG). Total nitrogen (TN), total phosphorus (TP), organic matter (COD), and chlorophyll $\alpha$ (Chl-$\alpha$) concentrations in the surface waters were largely varied temporally and spatially, and the variations were highest in the middle areas where strong halocline was formed. Chl-$\alpha$ concentrations in the middle area were very high in April (>$900\;{\mu}g\;L^{-1}$) when algal blooms (red tides) occurred. The relationships between TN and Chl-$\alpha$ (r=0.31), and TP and Chl-$\alpha$ (r=0.65) indicated that the algal growth was primarily affected by phosphorus rather than nitrogen. The distribution of COD was similar to that of Chl-$\alpha$, indicating that the autochthonous organic matters may be a more important carbon source, especially in the middle areas. The brackish water regions were classified as eutrophic or hypertrophic based on their TSI values ($69{\sim}76$). In addition, the content of nutrients (especially TP) in surface sediments were classified as severe polluted state, except the upper areas. Major causes of the eutrophication observed were probably due to high nutrients loading from watersheds, the phosphorus release from anaerobic sediment, and long retention time by the limited water exchange through the sluice gates.

• Analytical Science and Technology
• /
• v.30 no.5
• /
• pp.262-269
• /
• 2017

The concentration of natural radioactivity in the sediment of the Geum River was investigated. The river and lake sediment samples were collected at 23 points during September to November, 2015 and March to April, 2015, respectively. The gamma-rays emitted from the $^{226}Ra$ and $^{232}Th$ decay series and $^{40}K$ were measured with a high purity germanium (HPGe) gamma detector. The average radioactivity concentrations of the $^{226}Ra$, $^{232}Th$ decay series and $^{40}K$ for the river sediment was found to be $15.6{\pm}0.6$, $33.8{\pm}1.2$, $789.8{\pm}26.0Bq/kg$, respectively, while for the lake sediment, the concentrations were $17.1{\pm}0.5$, $37.8{\pm}1.1$, $269.4{\pm}9.6Bq/kg$, respectively. Spearman's correlation was conducted to compare the radioactivity concentration and properties of the sediment. The radioactivity concentration of the $^{232}Th$ decay series showed a negative correlation with the particle size of the sediment, and was measured to be higher than the $^{226}Ra$ decay series according to mobility of the radionuclides. The radioactivity concentration of $^{40}K$ showed a negative correlation with organic matter content. The concentration of $^{40}K$ in the lake sediment was lower than that in the river sediment.

• Horticultural Science & Technology
• /
• v.30 no.4
• /
• pp.345-356
• /
• 2012

We investigated the changes of fruit quality parameters, polysaccharide contents and cell wall components during maturation and ripening of two Korean pear cultivar 'Hanareum' and 'Manpungbae' compared with 'Niitaka' pear (Pyrus pyrifolia Nakai) which showed different physiological maturity based on days after full bloom (DAFB). Flesh firmness decreased continuously with fruit development and maturation, reaching a final level of 29.4, 33.5, and 27.4N at maturity in 'Hanareum' (127 DAFB), 'Manpungbae' (163 DAFB), and 'Niitaka' (170 DAFB), respectively. The level of ethylene production was very low in early season 'Hanareum' pear which showed at most 0.39 ${\mu}L{\cdot}L^{-1}$ at maturity and no ethylene was detected in 'Manpungbae' and 'Niitaka' at maturity. Fructose was the most abundant soluble sugar during fruit maturation in the pears tested and an increase of sucrose was observed during fruit ripening in the Asian pears commonly. Ethanol insoluble solids (EIS) content decreased gradually with different levels among the pear cultivars as fruit ripens consisted of 10.79, 12.72, and 12.75 $mg{\cdot}g^{-1}$ FW. The amount of total soluble polyuronides was higher in early season cultivars 'Hanareum' than those of mid-season cultivar 'Manpungbae' and 'Niitaka'. In 'Niitaka' which harvested most late season, the level of 4% KOH soluble hemicelluloses was lower than 'Hanareum' and 'Manpungbae' and maintained constantly during fruit ripening period. Cellulosic residues were determined high level in 'Niitaka' which showed 612.33 ${\mu}g{\cdot}mg^{-1}$ EIS at maturity when compared with 'Hanareum' (408.0 ${\mu}g{\cdot}mg^{-1}$ EIS) and 'Manpungbae' (538.67 ${\mu}g{\cdot}mg^{-1}$ EIS). The main constituents of cell wall neutral sugars which consisted of arabinose, xylose, galactose, and glucose were decreased gradually with onset of fruit ripening regardless of cultivar. Arabinose which was predominant in 'Hanareum' pear decreased at the last stage of ripening, but the changes of cell wall neutral sugar during ripening were not occurred in 'Niitaka' pear. The change of molecular mass distribution in water soluble pectin observed dominantly at the early stage of fruit development. Depolymerization of 4% KOH-soluble hemicelluloses and degradation of xyloglucan showed in early-season cultivar 'Hanareum' during fruit maturation, and degradation of those fractions were detected only at the early stage fruit development in mid-season cultivar 'Manpungbae' and 'Niitaka'. The molecular mass profile of CDTA soluble pectin, $Na_2CO_3$-SP and 24% KOH soluble hemicelluloses showed no significant change during fruit maturation regardless of cultivar.

• Proceedings of the SOHE Conference
• /
• 1997.12a
• /
• pp.39-43
• /
• 1997

Toha-jeod was manufactured by seven methods ; low salt group (L:15% sodium chloride), high salt g group (H:23% sodium chloride), 50% conventional soybean sauce group (S), low salt group containing 2% w wheat bran (W2%-L), high saIt group containing 2% wheat bran (W2%-H),high salt group containing 2% wheat bran (W2%-H), high salt group containing 4% wheat bran (W4%-H). After these seven groups were refrigerated at $4{\pm}1^{\circ}C$, they were sampled at intervals of three months and analyzed functional components. The free amino acid in Toha-jeod which are omitine, glutamic acid, leucine, alanine, lysine and valine increased gradually up to six months of fermentation and decreased by nine months. Conventional soybean sauce group increased continuously during the fermentation process. Hypoxanthine was altered almost among other nueletides. ATP was not detected, IMP and inosine had disapapted after the six months fermentation. Polyene fatty acids and n-3 fatty acids were decreased and s saturated fatty acids were not altered in the group containing wheat bran during fermentation. In the Hunter values, the group containing wheat bran and high salt group showed lower level than the group n not containing wheat bran and low salt group. Redness indicating the value of Toha-jeod increased as Toha-jeod was fermentated. Low salt group and conventional soybean sauce group were superior to other groups in the extent of redness. As the fermentation of Toha-jeod progressed for a long time, molecular weight distribution tended to become less molecular and the formation of chitin oligosaccharides was increased significantly. After nine months of fermentation, 24.75% chitin oligosaccharides [($GlcNAd_4$ ~ ($GlcNAd_8$, M.W. 823~1789] were created in the high salt group containing 2% wheat bran. [($GlcNAd_6$. M.W. 1236J , that is NACOS-6, which was reported as an antitumor activity material, was present in 4.01~4.37% of total Toha chitin content. 66.30% chitin oligosaccharides were created in conventional soybean sauce.

• Korean Journal of Food Science and Technology
• /
• v.26 no.4
• /
• pp.442-447
• /
• 1994

Effect of different mixing ratio of non-glutinous and glutinous rice on physical and rheological properties of extrudate prepared in a single screw extruder were examined. The extrusion conditions in term of screw speeds, moisture content and die temperature were 258 rpm, 18% and $120^{\circ}C$, respectively. The resisdence time distribution of the most of materials were within 30 second and small portion of them went up to 80 second. The expansion ratio was the highest value (2.93) for 70% of glutinous rice in the mixture, while the lowest value for 100% of non-glutinous rice. Breaking strength was in the range between 1,051g and 1,117g for $10{\sim}20%$ of glutinous rice in the mixture, while the lowest value (737g) for 80%r of glutinous rice. As the amount of glutinous rice increased, L and a values were increased and b value was decreased. The uncooked cold paste viscosity had 400 B.U. for 100% non-glutinous rice , while no peak for the 100% glutinous rice. As the amount of glutinous rice increased up to 100%, the water absorption index (WAI) was decreased, while water solubility index (WSI) was increased. The rheological properties of extrudate were accounted by the law of Oswald. The flow behavior index of extrudate was less than 1.0, which showed pseudoplastic behavior. Yield stress was the highest value for 20% of glutinous rice in the mixture and the lowest value for $80{\sim}100%$ of glutinous; rice. Number of air cell was between 128 and 159 for $80{\sim}100%$ of glutinous rice in the mixture, while $81{\sim}84%$ for $0{\sim}20%$ of glutinous rice. The degree of shapefact was increased more when the mixtures of glutinous and non-glutinous rice was used than when glutinous or non-glutinous rice was only used.

• Korean Journal of Fisheries and Aquatic Sciences
• /
• v.29 no.3
• /
• pp.345-356
• /
• 1996

Properties of enzymatic hydrolysates from ascidian tunic were assessed on supernatant ratio, solid yields and solid concentration. The concentartion of solid and yields in the extracts were increased as the enzyme concentration raised from $100\;{\mu}l\;to\;1000{\mu}l$ during the extraction period. The optima concentration and reaction time of each enzyme on digestion were $400\;{\mu}l$ 60 minutes, through treated with Duncan's multiple test. The percent of yields of solid, protein and carotenoids for 60 minutes extraction at $400\;{\mu}l$ were $32.32\%,\;1.34\%\;and\;74.60\;mg\%$, respectively, in Viscozyme systems. The extracts were composed with many kinds of carbohydrates such as arabinose, ribose, xylose, galactose, glucose, N-acetyl-D-galactosamine, and N-acetyl-D-glucosamine. Aspartic and glutamic arid were noted as predominant amino acids in all parts. Amino acid profiles of various ascidian tunic part were similiar to each other, but most of essential amino acids content of inter coat was higher than that of root and tunic (body). About sixty six fatty acids components were observed, and their distribution among neutral and polar lipids was compared. The main fatty acids were found to be 14:0, 16:0, 16:1n7, 18:0, 18:1n9, 18:1n7, 18:2n6, 20:5n3, and 22:6n3.

• Journal of the Korean Society of Food Science and Nutrition
• /
• v.34 no.8
• /
• pp.1265-1273
• /
• 2005

The purpose of this study was to prepare accelerated salt-fermented anchovy sauce using a shrimp processing byproducts (head, shell and tail) as a fermenting accelerator, and to investigate its physicochemical and enzymatic properties. Four types of sauces were prepared with 0, 10, 20, and 30$\%$ (w/w) addition of shrimp byproduct and fermented at 24$\pm$2$^{\circ}C$ for 360 days. During fermentation, all four type sauces decreased moisture content (67.5$\%$68.0$\%$ to 64.0$\∼$64.8$\%$) and pH (5.52$\∼$7.10 to 5.03$\∼$6.58), but showed increase in their crude protein (7.0$\∼$8.2 to 10.8$\%$) and volatile basic nitrogen contents (40$\∼$75 to 180$\∼$200 mg/100 g of sauce). The ratio of amino nitrogen to total nitrogen contents of control (0$\%$) and sauce with 10$\%$ shrimp byproducts (10$\%$ sauce) were maximized at 270 days, whereas 20$ \% $ and 30$\%$ added sauces were at 180 days. Endoprotease and exoprotease activities of anchovy sauces added with 20$\%$ and 30$\%$ of shrimp byproducts tend to be higher than those of control (0$\%$) and 10$\%$ addition. Proteolytic activities of sauces at pH 9 were about 2 times higher than those at pH 6. Amidolytic activities for LeuPNA decreased remarkably during fermentation, and control (0$\%$) almost lost their activity at 180 days, while additional sauces were relatively stable. These suggest that alkaline pretense of anchovy and shrimp byproducts as a endoprotease mainly contributed to the fermentation of salt-fermented sauces. The protein molecular weight distribution of sauces indicated 2 groups of peaks (peak 1,>70,000 da and peak 2, 3,000$\∼$29,000 da). As the fermentation proceeded, peak 1 tended to decrease in all of sauces, but peak 2 increased rapidly from 30 to 270 days. Optimum fermentation periods of control and 10$\%$ sauces were 270 days and those of 20$\%$ and 30$\%$ sauce were 180 days. The results suggest that shrimp byproduct can be used as accelerator of salt-fermented sauce.