• Journal of Korean Society of Water and Wastewater
• /
• v.17 no.4
• /
• pp.559-566
• /
• 2003

From this research, the performances of a sludge reduction in the sewage sludge aerobic digestion was experimented by using a sludge pretreatment and membrane bioreactor. The submerged plate membrane was used as the solid-liquid separation membrane. After drawing small amounts of sludge in a bioreactor and then doing the alkaline treatment and ozone treatment, the sludge was sent to back to the reactor. The HRT in the reactor was set as 5 days and the operation in the reactor was carried out at the DO of 1mg/L on average. After 100 days of operation in the reactor, it was shown that the reduction efficiency of total solids was more than 83%. Most of volatile solids were removed through mineralization, and the considerable portion of the non-volatile solids was dissolved and then flowed out with the effluent. Only about 16.3% of total solids in the sludge was accmulated in the reactor even without the loss of volatile fraction. Also, by deriving nitrification and denitrification in one reactor simultaneously, more than 90% of nitrogen removal effect was realized and the experiment was run smoothly without fouling of membrane, even in the high concentration of MLSS. Based on this experiment, sludge can be reduced considerably at a low HRT by these two newly suggested approach.

• Transactions of the Korean hydrogen and new energy society
• /
• v.2 no.1
• /
• pp.57-67
• /
• 1990

This study is proposed to investigate the effect of electrode preparation method for Alkaline Fuel Cell using NaOH as an electrolyte on the Fuel Cell performance. The materials used for the preparation of electrode are Pt and Ag on Vulcan XC-72. Surface area of Vulcan XC-72 have different values according to the pretreatment conditions and the dispersion of Pt is dependent on the impregnation Particle size of Pt impregnated on unpretreated carbon was observed to be $20{\sim}40{\AA}$ and that on pretreated carbon in $N_2$ stream at $950^{\circ}C$ was found to be finely dispersed less then $15{\AA}$. The electrode performance was affected by the particle size of metals and operating temperature. It was revealed from this study that the optimum particle size about $30{\AA}$ and optimum temperature range is between $90{\sim}100^{\circ}C$.

• Journal of the Korean Wood Science and Technology
• /
• v.22 no.3
• /
• pp.32-38
• /
• 1994

The methods in wood processing are so limited at present that a scope of its utilization is restricted. This often makes wood itself less valuable as a material comparing with other materials, that is, plastics, metals, and glass. Such differences are due to a lack of plasticity in wood, i.e. it cannot be melted, dissolved, or softened sufficiently for molding. However, once plastic properties are added to wood, it becomes more useful material. This further broadens the method in wood processing to a variety of fields. In this way, wooden material which is limited in use can be modified into a high quality product with additional value. Furthermore, utilization of wastes from wood, for example, would be made viable. In this study, thermoplasticization was carried out by benzylation of wood(sawdust). Various factors those affect the reaction were tested to produce benzylated wood with different degrees of substitution. Reaction temperature and time were the quite important factors. Optimum reaction temperature was 110$^{\circ}C$, and weight percent gains(WPG) of final products increased gradually with the increase of reaction time. The pretreatment (or preswelling) of wood with alkaline solution had a critical effect on benzylation. and the concentration of alkaline solution should be above 30% to obtain high weight percent gain. The thermal flow temperature of the benzylated wood decreased with the increase in weight percent gain, that of 80% weight percent gain is about 200$^{\circ}C$.

• Journal of Mushroom
• /
• v.14 no.2
• /
• pp.70-74
• /
• 2016

A new method to utilize spent mushroom substrates (SMS) for ethanol production was investigated. Analysis of the chemical properties of SMS revealed that they were decomposed by the mushrooms during cultivation. In particular, the free sugar content in SMS was reduced to half of that in mushrooms. Of the tested SMS, the Pleurotus eryngii SMS was determined to be suitable for saccharification. Upon pretreatment with a 1% alkaline solution, Pleurotus eryngii SMS achieved 80.7% of its maximum saccharification ratio. The optimum pretreatment conditions for enzyme saccharification were 1% NaOH solution at $120^{\circ}$ for 60 min. Further studies are required to determine ethanol production using Pleurotus eryngii SMS.

• Journal of Acupuncture Research
• /
• v.23 no.2
• /
• pp.103-111
• /
• 2006

Objectives : Deer antler Water Extract(DAE), prepared from the pilose antler of Cervus korean TEMMINCK var. mantchuricus Swinhoe (Nokyong), a traditional immuno-suppressive and immuno-activating Korean herbal-acupuncture, is thought to play an important role in human bone remodeling. Methods : To determine whether DAE can induce the differentiation of resting zone chondrocytes(RC) or not, confluent cell cultures were pretreated for 24, 36, 48, 72, and 120hrs with DAE. At the end of pretreatment, the media were replaced with new media containing $10^{-10}{\sim}10^{-8}M\;1,25-(OH)_2D_3$ and the cells incubated for an additional 24hrs. Results : This second treatment was chosen because prior studies had shown that only the more mature growth zone chondrocytes(GC) respond to this vitamin $D_3$ metabolite. The effect of DAE pretreatment on cell maturation was confirmed by measuring alkaline phosphatase (ALPase)-specific activity. Changes in matrix protein synthesis were examined by measuring collagen synthesis, as well as $^{35}SO_4$ incorporation into proteoglycans. When RC cells were pretreated for 120h with DAE, treatment with $1,25-(OH)_2D_3$ caused a dose-dependent increase in ALPase-specific activity and collagen synthesis, however, the proteoglycan production was not affected. RC cells pretreated with $1,25-(OH)_2D_3$ responded like RC cells that had not received any pretreatment. Conclusion : These results indicate that DAE directly regulates the maturation of RC chondrocytes into GC chondrocytes. Therefore it was indicated that DAE may play a significant role in regulating chondrocyte maturation during endochondral ossification.

• Korean Journal of Chemical Engineering
• /
• v.35 no.12
• /
• pp.2403-2412
• /
• 2018

The present study was aimed at evaluating the effect of variable sodium carbonate ($Na_2CO_3$) loading during wet air oxidation (WAO) pretreatment of rice straw in reducing biomass recalcitrance. The research study was intended to increase the cellulose recovery, hemicellulose solubilization, lignin removal in the solid fraction and limiting the generation of inhibitors in the liquid fraction while reducing the chemical input. The operating condition of $169^{\circ}C$, 4 bar, 18 min and 6.5 g/L $Na_2CO_3$ loading resulted in maximum cellulose recovery of 82.07% and hemicellulose solubilization and lignin removal of 85.43% and 65.42%, respectively, with a total phenolic content of 0.36 g/L in the liquid fraction. The crystallinity index increased from 47.69 to 51.25 along with enzymatic digestibility with an increase in $Na_2CO_3$ loading from 0 to 6.5 g/L as a result of removal of barriers for saccharification via effective cleavage of ether and ester bonds cross-linking the carbohydrates and lignin as indicated by FT-IR spectroscopy. A further increase in the $Na_2CO_3$ loading to 9.5 g/L did not significantly increase the sugar release. Thus, it was concluded that 6.5 g/L $Na_2CO_3$ during WAO is sufficient to increase the delignification and deacetylation, leading to significant changes in apparent cellulose crystallinity inter alia improvement in cellulose accessibility and digestibility of rice straw.

• Analytical Science and Technology
• /
• v.37 no.3
• /
• pp.174-188
• /
• 2024

This review summarized research trends regarding sample collection methods, pretreatment method, and types of analysis devices for microplastics (MPs) in soil and groundwater matrices. Soil sampling considers the selection of sampling location, depth, and volume. The typically sampling depth is within 15 cm (topsoil), and about 1 kg of mixed each sample. Among spot sampling and continuous flow sampling, groundwater sampling mainly used a continuous flow sampling, with collection rates 2 to 6 L/min in the range of 300~1,000 L, and followed by immediate on-situ filtration. Pretreatment method, applied to soil and groundwater, consist of organic digestion and density separation. In the organic digestion method, H₂O₂ is recommended among H₂O₂, acidic, alkaline, and enzymatic method. NaCl is primarily used as a reagent in density separation. However, depending on the density of MPs, other regents can be selectively used like ZnCl₂, ZnBr₂, and etc. Representative analysis device includes Fourier Transform Infrared (FTIR) and Raman spectroscopy for non-destructive analysis and Pyrolysis Gas Chromatography Mass Spectrometry (Py-GC/MS) for destructive analysis. µ-FTIR and Raman can count MPs of larger than 10 and 1 ㎛, and analyze MPs materials. However, it is need to sufficiently remove interference, like organic matter, in spectroscopic analysis using essential pretreatment method. Py-GC/MS is being continuously researched because it doesn't require complex pretreatment method and allows quantitative analysis of specific materials.

• The Korean Journal of Mycology
• /
• v.16 no.3
• /
• pp.135-143
• /
• 1988

The treatments of $H_2O_2$ were more effective on the degradation of difficult digestible materials by increasing the treatment concentration and adjusting the pH to alkaline. The smaller particle size of rice straw was, the more these effect. $2N_2CO_3{\cdot}3H_2O_2$, didn't need to adjust on pH, but the effect of treatment was lower than $H_2O_2$(pH 11.5) treatment. Lignin and hemicellulose content were decreased by the alkaline peroxide treatments. The fermentation of rice straw which pretreated with alkaline peroxide, the content of total nitrogen and ash increased. And NDF, hemicellulose and lignin were decreased, and ADF and cellulose decreased as the lower concentra­tion of treatment. The digestibility of rice straw which treated alkaline peroxide was increased with increasing the treatment concentration. The treatment of 12% $H_2O_2$(pH 11.5) and 12% $2Na_2^-CO_3{\cdot}3H_2O_2$ increased the digestibility from 31.1% to 89.4% and 76.8% compared with nontreated rice straw, respectively. The digestibility of fermented rice straw which pretreated with alkaline peroxide was effectively increased as the pretreatment concentration was low. Semi-dry treat­ment of $H_2O_2$ decreased the ADF and cellulose, and exhibited the 57.5% of digestjbility. Fer­mentation of rice straw which semi-dry treated with 4% $H_2O_2$, increased the digestibility from 33.4% to 63.4% compared with control.

• Textile Coloration and Finishing
• /
• v.5 no.3
• /
• pp.206-215
• /
• 1993

In the prior study, wool gabardines were treated with alkaline proteases which were some kinds of enzyme to decompose protein, and their tensile strengths were determined, and the surface of the fibers were also observed using a scanning electron microscope. Enzylon ASN 30 and Alkalase 2.5L DX did not show much effect on the weight loss of wool, however, the weight loss of wool increased considerably with treating Esperase 8.0L. Pretreatment of wool with dichloloisocyanuric acid before protease-treatment increased the weight loss of wool to a great extent. In this study, the enzyme treated wools dyeing behaviors with acid dye, Milling Cyanine 5R, were mainly investigated. The protease-treatment remarkably increased not only the rate of dyeing but also the saturation dye uptake. From these results, it seemed likely that the structural relaxation of adhesive filler of interscale or intercellular cement facilitated the dye penetration into the fibers, at the same time, the change in the inner structure of the wool fibers by the protease made the fixation of the dyes more efficient.

• Transactions of the Korean hydrogen and new energy society
• /
• v.26 no.1
• /
• pp.71-78
• /
• 2015

This study was performed to optimize the integrated thermal-alkali pre-treatment of flotation scum for the enhanced biodegradability. The optimum conditions of the integrated thermal-alkali pre-treatment were obtained using response surface methodology. The disintegration degree of carbohydrate (69.2%) and protein (57.3) were estimated under the optimum conditions. Although the optimum conditions were different, the disintegration degrees were similarly. A fermentative hydrogen batch test was conducted to evaluate the hydrogen production from scum with and/or without. The maximum hydrogen production from scum with pre-treatment was of 0.64 mol H2/mol hexoseadded, which about 1.4 times higher than without pre-treatment.