• Proceedings of the Materials Research Society of Korea Conference
• /
• 2003.11a
• /
• pp.148-148
• /
• 2003

질석(vermiculite)을 출발물질로 하여 30$0^{\circ}C$에서 4시간 열처리하여 습식분쇄하고 325mesh 이하의 입자를 선별하여 수열조건에서 양이온 계면활성제인 hexadecyl trimethylammonium bromide (C$_{16}$TABr)를 층간 삽입시켜 유기화 질석을 제조하였다. 생성물을 XRD, TGA, FT-IR 등을 이용하여 분석하였고, 합성 및 층간 삽입조건을 조사하였다. 질석에 $C_{16}$TABr를 층간 삽입을 확인하기 위하여 XRD 분석 결과 d-spacing 값이 9.6$\AA$에서 33.5$\AA$으로 증가됨을 확인하였고, 열중량 시험결과 출발물질과 비교하여 유기화 질석은 25%감량이 확인되었다. 위 결과 값으로부터 질석의 유기화 처리로 인하여 층간 간격이 확장되었음을 확인하였다. 일반적으로 층간 간격이 넓을수록 고분자가 층 사이에 보다 쉽게 삽입될 수 있으며 고분자 매트릭스 안에서 층상화합물의 분산 및 박리가 용이해진다. 따라서 본 연구 결과로부터 합성된 유기화 질석은 고분자 나노복합재로 사용 가능성을 제시하고 있다.

• Journal of the Korean GEO-environmental Society
• /
• v.15 no.12
• /
• pp.5-13
• /
• 2014

In this study, exfoliated vermiculite (EV) coated with glycerol was tested for its abiility to remove phosphorus in aqueous solution. The glycerol modified vermiculite (GS) was prepared with EV/glycerol ratio of 1/4 where glycerol contained 4 mol% $H_2SO_4$ and heated until designated temperature. GS heated at $380^{\circ}C$ showed that the specific surface area was $53.1m^2/g$ and mass loss due to oxidation of carbon was maximum from TGA analysis. Removal of phosphorus using GS heated at $380^{\circ}C$ was well explained by Langmuir isotherm model and maximum sorption capacity of 714.3 mg/kg is comparable or greater than those of other clay orignated sorbents for phosphorus.

• Horticultural Science & Technology
• /
• v.18 no.4
• /
• pp.529-535
• /
• 2000

Organic materials such as composted rice-hull, saw dust, and pine bark, and inorganic materials such as vermiculite, perlite, and recycled rockwool were commonly employed as container media in domestic greenhouse industry. The objective of this research was to get informations in soil physico chemical properties of those materials. Composted dry-peeling bark and wet-peeling bark had 72.1% and 69.1%, respectively, in particles larger than 1.0 mm, which were much higher than 34.7% of composted rice-hull and 33.7% of composted saw dust. Imported vermiculite had 89.9%, but domestic vermiculite had 25.7% in particles larger than 1 mm. In soil physical properties, Russian peat had the highest container capacity of 79.3%, and wet-peeling bark had the lowest container capacity of 58.2%. However, Russian peat and composted saw-dust had 4.1% in air space indicating that possible problems could occur in soil aeration when those are employed for container grown crops. Saw dust had $2.3mS{\cdot}cm^{-1}$ in electrical conductivity, while other composted organic materials had less than $0.25mS{\cdot}cm^{-1}$. Imported vermiculite had 64.0 meq/100 g in cation exchange capacity, which was 2.4 times higher than those of domestic vermiculite, 27.2 meq/100 g. Domestic vermiculite had higher Ca and Mg and less Na contents than those of imported vermiculite.

• Applied Chemistry for Engineering
• /
• v.17 no.5
• /
• pp.465-470
• /
• 2006

Siloxanes are widely used in industrial processes and consumer products. When landfill gas is used as fuel for gas engines, volatile siloxane in landfill gas causes serious damage to gas engines and pretreatment facilities. In this study, the applicability of various clay minerals was evaluated as the alternative adsorbents of activated carbon. SEM and BET analyses of illite, vermiculite, and activated carbon were performed for comparing those physical properties. Siloxane adsorption capacities of illite and vermiculite were estimated very high to 1.7 g/g illite, 3.8 g/g vermiculite respectively through the adsorption experiments of D5 siloxane.

• Korean Journal of Soil Science and Fertilizer
• /
• v.42 no.2
• /
• pp.117-122
• /
• 2009

This study was carried out to investigate applicability of Spent Mushroom Media(SMM) as horticultural nursery media. After the mushroom has been harvested, the SMM contains a lot of organic material, different microorganism and high density of mushroom hypha. The pH, phosphate and exchangeable cation concentrations of SMM of Flammulina velutipes were higher than those of any other treatment. The CEC and $NH_4-N$ were the highest in SMM of bottle-cultivated oyster mushroom (Pleurotus ostreatus). Bacteria and fungi showed the highest density in SMM of Flammulina velutipes. Most dominant bacteria were Microbacterium sp., Rhodococcus sp. and Agrobacterium sp. in SMM of Flammulina velutipes and Bacillus sp., Pseudomonas sp., Curtobacterium sp. and Microbacterium sp. in that of Pleurotus eryngii. The SMM contained high density of mushroom hypha that inhibited germination of seed and growth of young seedlings. Therefore, composting process of the SMM is indispensible to decline of vitality of mushroom hypha. The SMM of Flammulina velutipes with 0~30% vermiculite showed high germination rate in red pepper and chinese cabbage seeds. SMM of Pleurotus eryngii with 20% vermiculite showed 100% germination rate in red pepper seeds, but chinese cabbage seeds nearly failed to germinate with 30% vermiculite. The growth of red pepper was increased according to increasing mixture ratio of vermiculite. Accordingly, we concluded that SMM of Flammulina velutipes contained 0~30% of vermiculite can be used to horticultural growth bed for red pepper.

• Journal of the Korean Crystal Growth and Crystal Technology
• /
• v.27 no.3
• /
• pp.135-142
• /
• 2017

In this study, we prepared the board of vermiculite materials utilizing coal bottom ash from the Western thermal power stations in Korea and obtained experimental data in applications for building interior materials with the characteristics of sound absorption. To produce the mixture materials of vermiculite and coal bottom ash, we used a microwave drying process. In addition, a ball milling process was used to produce particles of coal bottom ash with a uniform size of $65{\mu}m$. When the board made from mixture materials of vermiculite and coal bottom ash were produced with bottom ash sulfur concentrations of 5, 10 wt%, maximum bending loads were analyzed. These experimental results would contribute much to fundamental data essential to the recycling technology of coal bottom ash.

• Journal of the Korean GEO-environmental Society
• /
• v.10 no.7
• /
• pp.25-32
• /
• 2009

The main objective of this study was to examine the removal properties of Cu from water by inflated vermiculites. The component of vermiculites was analyzed by XRF and the concentration of Copper ion was measured by UV-VIS. Serial batch Kinetic tests and batch sorption tests were conducted to determine the removal characteristics for Cu in aqueous solutions. The result shows that removal rate, $K_{obs}$, of Cu are 0.73, 1.52, and 1.71 for initial pH 3, pH 4, pH 5, respectively, and are 3.19, 1.90, and 0.73 for the initial concentration of $1mg\;L^{-1}$, $5mg\;L^{-1}$, $10mg\;L^{-1}$, respectively. It leads to the conclusion that the removal rates are inversely proportional to the initial Cu concentration and are increased proportionally to the initial pHs. Finally, Sorption data were correlated with both Langmuir and Freundlich isotherms. As a result, Langmuir and Freundlich models were well fitted to batch isotherm data with good values of the determination coefficient. but the determination coefficient value for the Freundlich model fit was slightly higher than that of Langmuir model (0.965 for the Freundlich model and 0.936 for the Langmuir model). Using the Langmuir model, the maximum sorption capacity ($Q_{max}$), Freundlich partition coefficient, and the numerical value of n wrer estimated as $1,250mg\;kg^{-1}$, $635.1L\;kg^{-1}$ and 1.69, respectively. These results show that the inflated vermiculites could be used as an excellent adsorbent for copper contained in various types of aqueous solutions.

• Journal of the Mineralogical Society of Korea
• /
• v.15 no.3
• /
• pp.183-194
• /
• 2002

Biotite and its weathering Products in the weathering Profile of Andong granite were examined using X-ray diffraction, chemical analysis, and electron microscopy. Major weathering product of biotite was oxidized biotite, which is decomposed into kaolinite in the upper part. Discrete vermiculite or hydrobiotite was not detected although minor vermiculite (5%) was randomly interstratified with oxidized biotite. Excess positive charge induced by iron oxidation was balanced by release of Fe (16%) and Mg (12%) from octahedral site and K (13%) from interlayer site. After slight chemical and structural modification induced by iron oxidation, oxidized biotite persists through the weathering profiles with partial decomposition in the upper part of the profile. Formation environments and dissolution experiments of oxidized biotite highly resistant to weathering are required to understand the elemental behavior in the surface environments on the biotite-bearing bedrocks.

• Journal of the Korean GEO-environmental Society
• /
• v.10 no.6
• /
• pp.61-68
• /
• 2009

The main objective of this study was to examine the removal of heavy metals from water by inflated vermiculites. The component of vermiculites was analyzed by XRF, and the concentration of metal ion was measured by ICP-AES. Serial batch kinetic tests and batch sorption tests were conducted to determine the removal characteristics for heavy metals in aqueous solutions. As a result, solution pH values of tests with the inflated vermiculites generally increased and then stabilized. Equilibrium pHs were generally established within 5 hrs. In addition, removal rates of inflated vermiculites were tested at the initial concentration of 3 mg/L. As a result, at equilibrium concentration, except for chromium (36.23%), Most of the heavy metals were effectively removed (96.08~98.54%). Finally, sorption data were correlated with both Langmuir and Freundlich isotherms. The Qmax obtained from Langmuir isotherm were determined to Pb $725.4mg\;kg^{-1}$, Cd $568.8mg\;kg^{-1}$, Zn $540.2mg\;kg^{-1}$, Cu $457.2mg\;kg^{-1}$ Cr $0.9mg\;kg^{-1}$ respectively. The results of the study indicate that inflated vermiculites can be properly used as an adsorbent for various heavy metals because of its outstanding removal rate.

• Journal of the Mineralogical Society of Korea
• /
• v.30 no.1
• /
• pp.11-19
• /
• 2017

Reddish brown clay-silt sediments covered granitoid weathering crust in the Jangdongri area, Naju, Korea. Mineralogical and geochemical properties of the ~2 m sediment section were investigated. The sediments were composed mainly of quartz (50%) and clay minerals (45%) with minor contents of K-feldspar, goethite, hematite, and gibbsite. The clay minerals were illite, illite-smectite mixed-layers, vermiculite, hydroxy-Al vermiculite, kaolinite, and halloysite. Mineral composition varied little through the section with the minor upward enrichment of plagioclase and chlorite. Abundant illitic clay minerals indicated the remote source of the sediments because clays derived by granite weathering in Korea were dominated by kaolin minerals. A comparison with the mineral composition of Asian dust (Hwangsa) suggested that plagioclase and K-feldspar disappeared by chemical weathering after deposition, resulting in the quartz and clay-rich sediments. Plagioclase and chlorite altered to kaolin and vermiculite, respectively. Goethite and hematite derived by the weathering of iron-bearing minerals stained the sediment to reddish brown color. The mineralogical and geochemical properties of the reddish brown clay-silt sediments were consistent with those of eolian deposits identified in Korea, supporting eolian origin of the Jangdongri sediments, requiring future confirmation including age dating and isotopic analysis.