DOI QR코드

DOI QR Code

Pipeline deformation caused by double curved shield tunnel in soil-rock composite stratum

  • Ning Jiao (Institute of Geotechnical Engineering, School of Transportation, Southeast University) ;
  • Xing Wan (Institute of Geotechnical Engineering, School of Transportation, Southeast University) ;
  • Jianwen Ding (Institute of Geotechnical Engineering, School of Transportation, Southeast University) ;
  • Sai Zhang (Institute of Geotechnical Engineering, School of Transportation, Southeast University) ;
  • Jinyu Liu (Institute of Geotechnical Engineering, School of Transportation, Southeast University)
  • Received : 2022.08.02
  • Accepted : 2023.12.11
  • Published : 2024.01.25

Abstract

Shield tunneling construction commonly crosses underground pipelines in urban areas, resulting in soil loss and followed deformation of grounds and pipelines nearby, which may threaten the safe operation of shield tunneling. This paper investigated the pipeline deformation caused by double curved shield tunnels in soil-rock composite stratum in Nanjing, China. The stratum settlement equation was modified to consider the double shield tunneling. Moreover, a three dimensional finite element model was established to explore the effects of hard-layer ratio, tunnel curvature radius, pipeline buried depth and other influencing factors. The results indicate the subsequent shield tunnel would cause secondary disturbance to the soil around the preceding tunnel, resulting in increased pipeline and ground surface settlement above the preceding tunnel. The settlement and stress of the pipeline increased gradually as buried depth of the pipeline increased or the hard-layer ratio (the ratio of hard-rock layer thickness to shield tunnel diameter within the range of the tunnel face) decreased. The modified settlement calculation equation was consistent with the measured data, which can be applied to the settlement calculation of ground surface and pipeline settlement. The modified coefficients a and b ranged from 0.45 to 0.95 and 0.90 to 1.25, respectively. Moreover, the hard-layer ratio had the most significant influence on the pipeline settlement, but the tunnel curvature radius and the included angle between pipeline and tunnel axis played a dominant role in the scope of the pipeline settlement deformation.

Keywords

Acknowledgement

The research described in this paper was partially supported by the National Natural Science Foundation of China (Grant No. 51978159) and the National Key R&D Program of China (Grant No. 2015CB057803).

References

  1. An, J.B., Kang, S.J., Kim, J. and Cho, G.C. (2022), "Numerical evaluation of surface settlement induced by ground loss from the face and annular gap of EPB shield tunneling", Geomech. Eng., 29(3), 291-300. https://doi.org/10.12989/gae.2022.29.3.291.
  2. Boulefrakh, L., Hebali, H., Chikh, A., Bousahla, A.A., Tounsi, A. and Mahmoud, S.R. (2019), "The effect of parameters of visco-Pasternak foundation on the bending and vibration properties of a thick FG plate", Geomech. Eng., 18(2), 161-178. https://doi.org/10.12989/gae.2019.18.2.161.
  3. Carrier III, W.D. (2005), "Pipeline supported on a nonuniform Winkler soil model", J. Geotech. Geoenviron. Eng., 131(10), 1301-1304. https://doi.org/10.1061/(ASCE)1090-0241(2005)131:10(1301).
  4. Celestino, T.B., Gomes, R.A.M.P. and Bortolucci, A.A. (2000), "Errors in ground distortions due to settlement trough adjustment", Tunn. Undergr. Sp. Technol., 15(1), 97-100. https://doi.org/10.1016/S0886-7798(99)00054-1.
  5. Civalek, O. and Ozturk, B. (2010), "Free vibration analysis of tapered beam-column with pinned ends embedded in Winkler-Pasternak elastic foundation", Geomech. Eng., 2(1), 45-56. https://doi.org/10.12989/gae.2010.2.1.045.
  6. Deng, H., Fu, H., Shi, Y., Huang, Z. and Huang, Q. (2021), "Analysis of asymmetrical deformation of surface and oblique pipeline caused by shield tunneling along curved section", Symmetry, 13(12), 2396. https://doi.org/10.3390/sym13122396.
  7. Ding, Z., Wei, X.J. and Wei, G. (2017), "Prediction methods on tunnel-excavation induced surface settlement around adjacent building", Geomech. Eng., 12(2), 185-195. https://doi.org/10.12989/gae.2017.12.2.185.
  8. Ding, J., Zhang, S., Zhang, H., Guo, C., Liao, Z. and Liu, H. (2021), "Ground settlement caused by shield tunneling in soil-rock composite strata", J. Perform. Constr. Fac., 35(5), 04021057. https://doi.org/10.1061/(ASCE)CF.1943-5509.0001631.
  9. Feng, X., Wang, P., Liu, S., Wei, H., Miao, Y. and Bu, S. (2022), "Mechanism and law analysis on ground settlement caused by shield excavation of small-radius curved tunnel", Rock Mech. Rock Eng., 55(6), 3473-3488. https://doi.org/10.1007/s00603-022-02819-6.
  10. He, C., Feng, K., Fang, Y. and Jiang, Y. (2012), "Surface settlement caused by twin-parallel shield tunnelling in sandy cobble strata", J. Zhejiang Univ. Sci. A, 13(11), 858-869. https://doi.org/10.1631/jzus.A12ISGT6.
  11. Huang, C. and Li, S. (2022), "Influence analysis on the excavation of the large-slope shield tunnel in the Guang-zhou-Shenzhen-Hong Kong Express Rail Link", Arabian J. Geosci., 15, 991. https://doi.org/10.1007/s12517-022-10207-1.
  12. Heama, N., Jongpradist, P., Lueprasert, P., Suwansawat, S. and Jamsawang, P. (2021), "Comparative effects of adjacent loaded pile row on existing tunnel by 2D and 3D simulation models", Geomech. Eng., 27(2), 151-165. https://doi.org/10.12989/gae.2021.27.2.151.
  13. Jeon, Y.J., Jeon, S.C., Jeon, S.J. and Lee, C.J. (2020), "Study on the behaviour of pre-existing single piles to adjacent shield tunnelling by considering the changes in the tunnel face pressures and the locations of the pile tips", Geomech. Eng., 21(2), 187-200. https://doi.org/10.12989/gae.2020.21.2.187.
  14. Jin, D., Yuan, D., Li, X. and Zheng, H. (2018), "Analysis of the settlement of an existing tunnel induced by shield tunneling underneath", Tunn. Undergr. Sp. Technol., 81, 209-220. https://doi.org/10.1016/j.tust.2018.06.035.
  15. Khudayarov, B.A., Komilova, K. M. and Turaev, F.Z. (2019), "The effect of two-parameter of Pasternak foun-dations on the oscillations of composite pipelines conveying gas-containing fluids", Int. J. Press. Vess. Piping, 176, 103946. https://doi.org/10.1016/j.ijpvp.2019.103946.
  16. Koyama, Y. (2003), "Present status and technology of shield tunneling method in Japan", Tunn. Undergr. Sp. Technol., 18(2-3), 145-159. https://doi.org/10.1016/S0886-7798(03)00040-3.
  17. Li, L., Du, X. and Zhou, J. (2020), "Numerical simulation of site deformation induced by shield tunneling in typical upper-soft-lower-hard soil-rock composite stratum site of changchun", KSCE J. Civil Eng., 24(10), 3156-3168. https://doi.org/10.1007/s12205-020-0124-0.
  18. Marshall, A.M., Klar, A. and Mair, R.J. (2010), "Tunneling beneath buried pipes: view of soil strain and its effect on pipeline behavior", J. Geotech. Geoenviron. Eng., 136(12), 1664-1672. https://doi.org/10.1061/(ASCE)GT.1943-5606.0000390.
  19. Mohannadpour, R. and Taheri, E. (2021), "Effect of excavation shield conicality on displacement and stress on the pipeline in layered areas during pipe jacking operations", Tunn. Undergr. Sp. Eng., 10(3), 271-285. https://doi.org/10.22044/TUSE.2022.11623.1446.
  20. Nawel, B. and Salah, M. (2015), "Numerical modeling of two parallel tunnels interaction using three-dimensional finite elements method", Geomech. Eng., 9(6), 775-791. https://doi.org/10.12989/gae.2015.9.6.775.
  21. Nagel, F., Stascheit, J. and Meschke, G. (2010), "Process-oriented numerical simulation of shield-supported tunnelling in soft soils", Geomech. Tunnelling, 3(3), 268-282. https://doi.org/10.1002/geot.201000024.
  22. Peck, R.B. (1969), "Deep excavations and tunneling in soft ground", Proceedings of the 7th International Conference on Mechanics and Foundation Engineering, Mexico City, Mexico.
  23. Qian, W., Huang, M., Sun, C., Huang, B., Wang, G. and Liu, H. (2021), "Adaptability of earth pressure balance shield tunneling in coastal complex formations: a new evaluation method", Geomech. Eng., 27(4), 375-390. https://doi.org/10.12989/gae.2021.27.4.375.
  24. Rezaei, A.H., Shirzehhagh, M. and Golpasand, M.R.B. (2019), "EPB tunneling in cohesionless soils: A study on Tabriz Metro settlements", Geomech. Eng., 19(2), 153-165. https://doi.org/10.12989/gae.2019.19.2.153.
  25. Roboski, J.F. (2001), "Soil parameters for constitutive models of compressible Chicago glacial clays", Ph.D. Dissertation, Northwestern University, Evanston.
  26. Sae-Long, W., Limkatanyu, S., Hansapinyo, C., Prachasaree, W., Rungamornrat, J. and Kwon, M. (2021), "Nonlinear flexibility-based beam element on Winkler-Pasternak foundation", Geomech. Eng., 24(4), 371-388. https://doi.org/10.12989/gae.2021.24.4.371.
  27. Sarfarazi, V. and Tabaroei, A. (2020), "Numerical simulation of the influence of interaction between Qanat and tunnel on the ground settlement", Geomech. Eng., 23(5), 455-466. https://doi.org/10.12989/gae.2020.23.5.455.
  28. Shao, X., Yang, Z., Jiang, Y., Yang, X. and Qi, W. (2022), "Field test and numerical study of the effect of shield tail-grouting parameters on surface settlement", Geomech. Eng., 29(5), 509-522. https://doi.org/10.12989/gae.2022.29.5.509.
  29. Sun, S., Rong, C., Wang, H., Cui, L. and Shi, X. (2021), "The ground settlement and the existing pipeline response induced by the nonsynchronous construction of a twin-tunnel", Adv. Civil Eng., 2021, 8815304. https://doi.org/10.1155/2021/8815304.
  30. Suwansawat, S. and Einstein, H.H. (2007), "Describing settlement troughs over twin tunnels using a superposition technique", J. Geotech. Geoenviron. Eng., 133(4), 445-468. https://doi.org/10.1061/(ASCE)1090-0241(2007)133:4(445).
  31. Tanahashi, H. (2004), "Formulas for an infinitely long Bernoulli-Euler beam on the Pasternak model", Soils Found., 44(5), 109-118. https://doi.org/10.3208/sandf.44.5_109.
  32. Xie, X. and Lu, X. (2017), "Development of a 3D modeling algorithm for tunnel deformation monitoring based on terrestrial laser scanning", Underground Sp., 2(1), 16-29. https://doi.org/10.1016/j.undsp.2017.02.001.
  33. Xue, Y., Li, X., Qiu, D., Ma, X., Kong, F., Qu, C. and Zhao, Y. (2019), "Stability evaluation for the excavation face of shield tunnel across the Yangtze River by multi-factor analysis", Geomech. Eng., 19(3), 283-293. https://doi.org/10.12989/gae.2019.19.3.283.
  34. Yue, Z., Sun, H., Zhong, R. and Du, L. (2021), "Method for tunnel displacements calculation based on mobile tunnel monitoring system", Sensors, 21(13), 4407. https://doi.org/10.3390/s21134407.
  35. Zhang, Z.G., Zhao, Q.H. and Zhang, M.X. (2016), "Deformation analyses during subway shield excavation considering stiffness influences of underground structures", Geomech. Eng., 11(1), 117-139. https://doi.org/10.12989/gae.2016.11.1.117.
  36. Zhao, S.W., Li, X.L., Li, X., Chen, L.G., Li, T., Li, S.H. and Bai, Y. (2022), "Analysis of pipeline deformation caused by shield tunnel excavation that obliquely crosses existing pipelines", Arabian J. Geosci., 15(3), 1-14. https://doi.org/10.1007/s12517-022-09462-z.
  37. Zhou, Zh., Ding, H., Miao L. and Gong, C. (2021), "Predictive model for the surface settlement caused by the excavation of twin tunnels", Tunn. Undergr. Sp. Technol., 114, 104014. https://doi.org/10.1016/j.tust.2021.104014.