DOI QR코드

DOI QR Code

An empirical relationship for compressive strength of preplaced aggregate concrete with modified binder

  • Kunal Krishna Das (Department of Civil and Environmental Engineering, The Hong Kong Polytechnic University) ;
  • Eddie Siu-Shu Lam (Department of Civil and Environmental Engineering, The Hong Kong Polytechnic University) ;
  • Jeong Gook Jang (Division of Architecture and Urban Design, Urban Sciences Institute, Incheon National University)
  • 투고 : 2022.11.28
  • 심사 : 2023.02.13
  • 발행 : 2023.06.25

초록

In this study, an experimental investigation was conducted to assess the influence of ground granulated blast furnace slag (GGBS) and silica fume (SF) on the fresh and hardened properties of grout specimens and preplaced aggregate concrete (PAC). Grout proportions were optimized statistically using a factorial design and were applied to 10 mm and 20 mm coarse aggregates to produce PAC. The results demonstrate that GGBS has a more significant effect on the compressive strength of grout compared to SF, with a small increase or decrease in the GGBS content having a greater influence on the compressive strength of grout than SF. The water to binder ratio had the most significant effect on the compressive strength of PAC, followed by the coarse aggregate size and sand to binder ratio. An empirical relationship to predict the compressive strength of PAC was proposed through an experimentally derived factorial design along with a statistical analysis of collectively obtained data and a deep literature review. The results predicted by the empirical relationship were in good agreement with those of PAC produced for verification.

키워드

과제정보

This work was supported by the National Research Foundation of Korea (NRF) grant funded by the Korea government (MSIT) (No. 2021R1C1C1013864). The authors wish to express their gratitude for the financial support provided by The Hong Kong Polytechnic University. The authors are grateful for the technical support provided by the laboratories of the Department of Civil and Environmental Engineering, The Hong Kong Polytechnic University.

참고문헌

  1. Abdelgader, H.S. (1995), "Polcrete economical method for dams", MWA Int. Conf. Dam Eng., 1, 1-4. 
  2. Abdelgader, H.S. (1996), "Effect of the quantity of sand on the compressive strength of two-stage concrete", Mag. Concrete Res., 48(4), 353-360. https://doi.org/10.1680/macr.1996.48.177.353. 
  3. Abdelgader, H.S. (1999), "How to design concrete produced by a two-stage concreting method", Cement Concrete Res., 29(3), 331-337. https://doi.org/10.1016/S0008-8846(98)00215-4. 
  4. Abdelgader, H.S. and Ben-Zeitun, A.E. (2005), "Tensile strength of two-stage concrete measured by double-punch and split tests", Role of Concrete in Nuclear Facilities, Thomas Telford Publishing, London, UK. 
  5. Abdelgader, H.S. and El-Baden, A.S. (2015), "Effect of silica fume on two-stage concrete strength", IOP Conf. Ser.: Mater. Sci. Eng., 96(1), 012043. https://doi.org/10.1088/1757-899X/96/1/012043. 
  6. Abdelgader, H.S., El-Baden, A.S., Abdurrahman, H.A. and Abdul Awal, A.S.M. (2018), "Two-stage concrete as a sustainable production", MATEC Web Conf., 149, 1-7. https://doi.org/10.1051/matecconf/201714902009. 
  7. Abdelgader, H.S. and Elgalhud, A.A. (2008), "Effect of grout proportions on strength of two-stage concrete", Struct. Concrete, 9(3), 163-170. https://doi.org/10.1680/stco.2008.9.3.163. 
  8. Abdelgader, H.S. and Gorski, J. (2002), "Influence of grout proportions on modulus of elasticity of two-stage concrete", Mag. Concrete Res., 54(4), 251-255. https://doi.org/10.1680/MACR.2002.54.4.251. 
  9. Abdelgader, H.S. and Gorski, J. (2003), "Stress-strain relations and modulus of elasticity of two-stage concrete", J. Mater. Civil Eng., 15(4), 329-334. https://doi.org/10.1061/(asce)0899-1561(2003)15:4(329). 
  10. Abdelgader, H.S., Najjar, M. and Azabi, T.M. (2010), "Study of underwater concrete using two-stage (preplaced aggregate) concrete in Libya", Struct. Concrete, 11(3), 161-165. https://doi.org/10.1680/stco.2010.11.3.161. 
  11. Abdelgader, H.S., Saud, A.F. and El-Baden, A.S. (2013), "Flexural strength of two-stage concrete", Proceedings of the Third International Conference on Sustainable Construction Materials and Technologies (SCMT3), Kyoto, August. 
  12. ACI 211.1. (1996), Standard Practice for Selecting Proportions for Normal, Heavyweight, and Mass Concrete, American Concrete Institute, Farmington Hills, MI, USA.
  13. ACI 233R. (1995), Ground Granulated Blast-Furnace Slag as a Cementitious Constituent in Concrete, American Concrete Institute, Farmington Hills, MI, USA.
  14. ACI 304.1. (2005), Guide for the Use of Preplaced Aggregate Concrete for Structural and Mass Concrete Applications, American Concrete Institute, Farmington Hills, MI, USA.
  15. ACI 363. (1997), State-of-the-Art Report on High-Strength Concrete, American Concrete Institute, Farmington Hills, MI, USA. 
  16. Alexander, K.M. and Wardlaw, J. (1960), "Dependence of cement-aggregate bond-strength on size of aggregate", Nature, 187(4733), 230. https://doi.org/10.1038/187230a0. 
  17. ASTM C 1202. (2012), Standard Test Method for Electrical Indication of Concrete's Ability to Resist Chloride Ion Penetration, ASTM International, West Conshohocken, PA, USA. 
  18. ASTM C 150. (2017), Standard Specification for Portland Cement, ASTM International, West Conshohocken, PA, USA. 
  19. ASTM C 39. (2005), Standard Test Method for Compressive Strength of Cylindrical Concrete Specimens, ASTM International, West Conshohocken, PA, USA. 
  20. ASTM C 496. (2011), Standard Test Method for Splitting Tensile Strength of Cylindrical Concrete Specimens, ASTM International, West Conshohocken, PA, USA. 
  21. ASTM C 939. (2002), Standard Test Method for Flow of Grout for Preplaced Aggregate Concrete (Flow Cone Method), ASTM International, West Conshohocken, PA, USA. 
  22. ASTM C 940-R03. (2016), Standard Test Method for Expansion and Bleeding of Freshly Mixed Grout for Preplaced-Aggregate Concrete in the Laboratory, ASTM International, West Conshohocken, PA, USA. 
  23. ASTM C 942. (2008), Standard Test Method for Compressive Strength of Grouts for Preplaced-Aggregate Concrete in the Laboratory, ASTM International, West Conshohocken, PA, USA. 
  24. Awal Abdul, A.S. (1988), "Failure mechanism of prepacked concrete", J. Struct. Eng., 3(114), 727-732.  https://doi.org/10.1061/(ASCE)0733-9445(1988)114:3(727)
  25. Bayer, R. (2004), Use of Preplaced Aggregate Concrete for Mass Concrete Applications, Middle East Technical University, Ankara, Turkiye. 
  26. Bisschop, J. and Van Mier, J.G.M. (2002), "How to study drying shrinkage microcracking in cement-based materials using optical and scanning electron microscopy?", Cement Concrete Res., 32(2), 279-287. https://doi.org/10.1016/S0008-8846(01)00671-8. 
  27. Bloem, D.L. and Gaynor, R.D. (1963), "Effects of aggregate properties on strength of concrete", ACI J. Proc., 10(60), 1429-1456.  https://doi.org/10.14359/7900
  28. BS EN 12504-1. (2009), Testing Concrete in Structures, Cored Specimens, Taking, Examining and Testing in Compression, British Standard Institution, London, UK. 
  29. BS EN 8500. (2002), Concrete Complementary-British Standard to BSEN206-1 Part 1: Method of Specifying and Guidance for the Specifier, Part 2: Specification for Constituent Materials and Concrete, British Standard Institution, London, UK. 
  30. BS ISO 1920-8. (2009), Determination of Drying Shrinkage of Concrete for Samples Prepared in the Field or in the Laboratory, British Standard Institution, London, UK. 
  31. Cheng, A., Huang, R., Wu, J. and Chen, C. (2005), "Influence of GGBS on durability and corrosion behavior of reinforced concrete", Mater. Chem. Phys., 93, 404-411. https://doi.org/10.1016/j.matchemphys.2005.03.043. 
  32. Cheng, Y., Liu, S., Zhu, B., Liu, R. and Wang, Y. (2019), "Preparation of preplaced aggregate concrete and experimental study on its strength", Constr. Build. Mater., 229, 116847. https://doi.org/10.1016/j.conbuildmat.2019.116847. 
  33. Coo, M. and Pheeraphan, T. (2015), "Effect of sand, fly ash, and coarse aggregate gradation on preplaced aggregate concrete studied through factorial design", Constr. Build. Mater., 93, 812-821. https://doi.org/10.1016/j.conbuildmat.2015.05.086. 
  34. Coo, M. and Pheeraphan, T. (2016), "Effect of sand, fly ash and limestone powder on preplaced aggregate concrete mechanical properties and reinforced beam shear capacity", Constr. Build. Mater., 120, 581-592. https://doi.org/10.1016/j.conbuildmat.2016.05.128. 
  35. Cordon, W.A. and Gillespie, H.A. (1963), "Variables in concrete aggregates and Portland cement paste which influence the strength of concrete", ACI J. Proc., 8(60), 1029-1052.  https://doi.org/10.14359/7889
  36. Das, K.K. and Lam, E.S.S. (2019), "Feasibility of producing two- stage (preplaced aggregate) concrete by gravity process", Struct. Concrete, 21(3), 1157-1163. https://doi.org/10.1002/suco.201900356. 
  37. Das, K.K., Lam, E.S.S. and Tang, H.H. (2020), "Partial replacement of cement by ground granulated blast furnace slag and silica fume in two-stage concrete (preplaced aggregate concrete)", Struct. Concrete, 22(S1), E466-E473. https://doi.org/10.1002/suco.201900494. 
  38. Davis, R.E. (1960), "Prepakt method of concrete repair", ACI Mater. J., 8(57), 155-172. https://doi.org/DOI: 10.14359/8016. 
  39. Diamond, S. and Sahu, S. (2006), "Densified silica fume: Particle sizes and dispersion in concrete", Mater. Struct. Mater. Constr., 39(9), 849-859. https://doi.org/10.1617/s11527-006-9087-y. 
  40. Emmons, P. (1992), Concrete Repair and Maintenance Illustrated: Problem Analysis, Repair Strategy, Techniques, John Wiley & Sons, Hoboken, NJ, USA. 
  41. Fu, T., Deboodt, T. and Ideker, J.H. (2016), "Development of shrinkage limit specification for high performance concrete used in bridge decks", Cement Concrete Compos., 72, 17-26. https://doi.org/10.1016/j.cemconcomp.2016.05.015. 
  42. Guo, Y., Wu, J., Wang, C. and Zhang, F. (2020), "Study on the influence of the shape and size of coarse aggregate on the strength of concrete", IOP Conf. Ser.: Mater. Sci. Eng., 780(4), https://doi.org/10.1088/1757-899X/780/4/042008. 
  43. IS 10262. (2009), Guidelines for Concrete Mix Design Proportioning, Bureau of Indian Standards, New Delhi, India. 
  44. Johari, M., Brooks, J. and Kabir, S. (2011), "Influence of supplementary cementitious materials on engineering properties of high strength concrete", Constr. Build. Mater., 25, 2639-2648. https://doi.org/10.1016/j.conbuildmat.2010.12.013. 
  45. Khan, M.I. and Siddique, R. (2011), "Utilization of silica fume in concrete: Review of durability properties", Resour. Conserv. Recyc., 57, 30-35. https://doi.org/10.1016/j.resconrec.2011.09.016. 
  46. Khatib, J.M. and Hibbert, J.J. (2005), "Selected engineering properties of concrete incorporating slag and metakaolin", Constr. Build. Mater., 19(6), 460-472. https://doi.org/10.1016/j.conbuildmat.2004.07.017. 
  47. Krakowiak, K.J., Thomas, J.J., James, S., Abuhaikal, M. and Ulm, F.J. (2018), "Development of silica-enriched cement-based materials with improved aging resistance for application in high-temperature environments", Cement Concrete Res., 105, 91-110. https://doi.org/10.1016/j.cemconres.2018.01.004. 
  48. Lv, J., Zhou, T., Du, Q., Li, K. and Jin, L. (2020), "Research on the bond behavior of preplaced", Mater., 2(13), 300. 
  49. Mohammadhosseini, H., Abdul Awal, A.S.M. and Sam, A.R.M. (2016), "Mechanical and thermal properties of prepacked aggregate concrete incorporating palm oil fuel ash", Sadhana Acad. Proc. Eng. Sci., 41(10), 1235-1244. https://doi.org/10.1007/s12046-016-0549-9. 
  50. Mohammadhosseini, H., Tahir, M.M., Alaskar, A., Alabduljabbar, H. and Alyousef, R. (2020), "Enhancement of strength and transport properties of a novel preplaced aggregate fiber reinforced concrete by adding waste polypropylene carpet fibers", J. Build. Eng., 27, 101003. https://doi.org/10.1016/j.jobe.2019.101003. 
  51. Montgomery, D.C. (2017), Design and Analysis of Experiments, John Wiley & Sons, Hoboken, NJ, USA. 
  52. Najjar, M. (2016), "Innovating two-stage concrete with improved rheological, mechanical and durability properties", Doctoral dissertation, The University of Western Ontario, Ontario, Canada. 
  53. Najjar, M.F., Soliman, A.M. and Nehdi, M.L. (2014), "Critical overview of two-stage concrete: Properties and applications", Constr. Build. Mater., 62, 47-58. https://doi.org/10.1016/j.conbuildmat.2014.03.021. 
  54. Najjar, M.F., Soliman, A.M. and Nehdi, M.L. (2016), "Two-stage concrete made with single, binary and ternary binders", Mater. Struct. Mater. Constr., 49(1-2), 317-327. https://doi.org/10.1617/s11527-014-0499-9. 
  55. Nehdi, M.L., Najjar, M.F., Soliman, A.M. and Azabi, T.M. (2017a), "Novel steel fibre-reinforced preplaced aggregate concrete with superior mechanical performance", Cement Concrete Compos., 82, 242-251. https://doi.org/10.1016/j.cemconcomp.2017.07.002. 
  56. Nehdi, M.L., Najjar, M.F., Soliman, A.M. and Azabi, T.M. (2017b), "Novel steel fibre-reinforced preplaced aggregate concrete with superior mechanical performance. Cement Concrete Compos., 82, 242-251. https://doi.org/10.1016/j.cemconcomp.2017.07.002. 
  57. Neville, A.M. (2011), Properties of Concrete, London Pearson Education Limited, London, UK. 
  58. Nochaiya, T., Wongkeo, W. and Chaipanich, A. (2010), "Utilization of fly ash with silica fume and properties of Portland cement-fly ash-silica fume concrete", Fuel, 89(3), 768-774. https://doi.org/10.1016/j.fuel.2009.10.003. 
  59. Nowek, A., Kaszubski, P., Abdelgader, H.S. and Gorski, J. (2007), "Effect of admixtures on fresh grout and two-stage (pre-placed aggregate) concrete", Struct. Concrete, 8(1), 17-23. https://doi.org/10.1680/stco.2007.8.1.17. 
  60. O'Malley, J. and Abdelgader, H.S. (2010), "Investigation into viability of using two-stage (pre-placed aggregate) concrete in Irish setting", Front. Arch. Civil Eng. Chin., 4(1), 127-132. https://doi.org/10.1007/s11709-010-0007-4. 
  61. Oner, A. and Akyuz, S. (2007), "An experimental study on optimum usage of GGBS for the compressive strength of concrete", Cement Concrete Compos., 29(6), 505-514. https://doi.org/10.1016/j.cemconcomp.2007.01.001. 
  62. Orchard, D.F. (1973), Concrete Technology, 3rd Edition, Applied Science Publishers Ltd., London, UK. 
  63. Poon, C.S., Kou, S.C. and Lam, L. (2006), "Compressive strength, chloride diffusivity and pore structure of high performance metakaolin and silica fume concrete", Constr. Build. Mater., 20(10), 858-865. https://doi.org/10.1016/j.conbuildmat.2005.07.001. 
  64. Prasad, N. and Murali, G. (2021), "Exploring the impact performance of functionally-graded preplaced aggregate concrete incorporating steel and polypropylene fibres", J. Build. Eng., 35, 102077. https://doi.org/10.1016/j.jobe.2020.102077. 
  65. Rajabi, A.M. and Omidi Moaf, F. (2017), "Simple empirical formula to estimate the main geomechanical parameters of preplaced aggregate concrete and conventional concrete", Constr. Build. Mater., 146, 485-492. https://doi.org/10.1016/j.conbuildmat.2017.04.089. 
  66. Rajabi, A.M., Omidi Moaf, F. and Abdelgader, H.S. (2020), "Evaluation of mechanical properties of two-stage concrete and conventional concrete using nondestructive tests", J. Mater. Civil Eng., 32(7), 04020185. https://doi.org/10.1061/(asce)mt.1943-5533.0003247. 
  67. Rao, G.A. (2001), "Long-term drying shrinkage of mortar - influence of silica fume and size of fine aggregate", Cement Concrete Res., 31, 171-175. https://doi.org/10.1016/S0008-8846(00)00347-1. 
  68. Rashid, M.A. and Mansur, M.A. (2009), "Considerations in producing high strength concrete", J. Civil Eng., 37(1), 53-63. 
  69. Saluja, S., Kaur, K., Goyal, S. and Bhattacharjee, B. (2019), "Assessing the effect of GGBS content and aggregate characteristics on drying shrinkage of roller compacted concrete", Constr. Build. Mater., 201, 72-80. https://doi.org/10.1016/j.conbuildmat.2018.12.179. 
  70. Saud, A.F., Abdelgader, H.S. and El-Baden, A.S. (2014), "Compressive and tensile strength of two-stage concrete", Adv. Mater. Res., 893, 585-592. https://doi.org/10.4028/www.scientific.net/AMR.893.585. 
  71. Siddique, S., Kim, H., Son, H. and Jang, J.G. (2021), "Characteristics of preplaced aggregate concrete fabricated with alkali-activated slag/fly ash cements", Mater., 14(3), 1-17. https://doi.org/10.3390/ma14030591. 
  72. St. John, D. (1994), The Dispersion of Silica Fume, Industrial Research Limited, Wellington, NZ. 
  73. Stempkowska, A., Gawenda, T., Naziemiec, Z., Ostrowski, K.A., Saramak, D. and Surowiak, A. (2020), "Impact of the geometrical parameters of dolomite coarse aggregate on the thermal and mechanic properties of preplaced aggregate concrete", Mater., 13(19), 1-16. https://doi.org/10.3390/ma13194358. 
  74. Tumidajski, P.J. and Gong, B. (2006), "Effect of coarse aggregate size on strength and workability of concrete", Can. J. Civil Eng., 2(33), 206-213. https://doi.org/10.1139/l05-090. 
  75. Tuyan, M., Zhang, L.V. and Nehdi, M.L. (2020a), "Development of sustainable preplaced aggregate concrete with alkali-activated slag grout", Constr. Build. Mater., 263, 120227. https://doi.org/10.1016/j.conbuildmat.2020.120227. 
  76. Tuyan, M., Zhang, L.V. and Nehdi, M.L. (2020b), "Development of sustainable alkali-activated slag grout for preplaced aggregate concrete", J. Clean. Prod., 277, 123488. https://doi.org/10.1016/j.jclepro.2020.123488. 
  77. Varghese, L., Kanta Rao, V. and Parameswaran, L. (2017), "Effect of nanosilica on drying shrinkage and creep properties of cement concrete", Adv. Mater. Proc., 2(1), 56-60. https://doi.org/10.5185/amp.2017/113. 
  78. Vieira, M., Bettencourt, A., Camelo, A. and Ferreira, J. (2010), "Self-compacting mortar for mass concrete application with PAC technology", Proceedings of SCC2010, Montreal, Canada, September. 
  79. Yildirim, H., Ilica, T. and Sengul, O. (2011), "Effect of cement type on the resistance of concrete against chloride penetration", Constr. Build. Mater., 25(3), 1282-1288. https://doi.org/10.1016/j.conbuildmat.2010.09.023.