Animal Bioscience

Asian Australasian Association of Animal Production Societies (아세아태평양축산학회)
권호 표지
DOI QR코드

DOI QR Code

Chemical composition of copra, palm kernel, and cashew co-products from South-East Asia and almond hulls from Australia

  • Natalia S. Fanelli (Department of Animal Sciences, University of Illinois) ;
  • Leidy J. Torres-Mendoza (Department of Animal Sciences, University of Illinois) ;
  • Jerubella J. Abelilla (DSM Nutritional Products) ;
  • Hans H. Stein (Department of Animal Sciences, University of Illinois)
  • Received : 2022.09.16
  • Accepted : 2023.01.30
  • Published : 2023.05.01
Download PDF
⟨ Previous Next ⟩

Abstract

Objective: Oilseeds and nut co-products can be used as alternative feed ingredients in animal diets because they may have a lower cost than traditional ingredients. A study was, therefore, conducted to determine the chemical composition of copra, palm kernel, and nut co-products from South-East Asia or Australia. The hypothesis that country of production influences nutritional composition was tested. Methods: Oilseed meals included 2 copra expellers, 3 copra meals, and 12 palm kernel expellers. One source of almond hulls and cashew nut meal were also used. Samples were obtained from suppliers located in South-East Asia or Australia. All samples were analyzed for dry matter, gross energy, nitrogen, amino acids (AA), acid-hydrolyzed ether extract (AEE), ash, minerals, insoluble dietary fiber, and soluble dietary fiber. Copra and nut co-products were also analyzed for total starch and sugars. Results: Copra expellers had greater (p<0.05) concentrations of dry matter and AEE compared with copra meal. However, copra meal had greater (p<0.05) concentrations of total dietary fiber (soluble and insoluble) and copper than copra expellers. Palm kernel expellers from Indonesia had greater (p<0.05) concentration of histidine and tyrosine compared with palm kernel expellers from Vietnam. Almond hulls was high in dietary fiber, but also contained free glucose and fructose, whereas cashew nut meal was high in AEE, but low in all free sugars. Conclusion: Copra expellers have greater concentration of AEE, but less concentration of total dietary fiber when compared with copra meal, and except for a few AA, no differences in nutrient composition of palm kernel expellers produced in Indonesia or Vietnam were detected. According to the chemical composition of nut co-products, cashew nut meal may be more suitable for non-ruminant diets than almond hulls.

Keywords

References

  1. Adeola O, Kong C. Energy value of distillers dried grains with solubles and oilseed meals for pigs. J Anim Sci 2014;92:164-70. https://doi.org/10.2527/jas.2013-6662 
  2. Devendra C. Perspectives on animal production systems in Asia. Livest Sci 2007;106:1-18. https://doi.org/10.1016/j.livsci.2006.05.005 
  3. Stein HH, Casas GA, Abelilla JJ, Liu Y, Sulabo RC. Nutritional value of high fiber co-products from the copra, palm kernel, and rice industries in diets fed to pigs. J Anim Sci Biotechnol 2015;6:56. https://doi.org/10.1186/s40104-015-0056-6 
  4. Lee SA, Kim BG. Classification of copra meal and copra expellers based on ether extract concentration and prediction of energy concentrations in copra byproducts. J Anim Plant Sci 2017;27:34-9. 
  5. Yaophakdee N, Ruangpanit Y, Attamangkune S. Effects of palm kernel meal level on live performance and gut morphology of broilers. Agric Nat Resour 2018;52:75-8. https://doi.org/10.1016/j.anres.2018.05.007 
  6. Prgomet I, Goncalves B, Dominguez-Perles R, Pascual-Seva N, Barros AIRNA. Valorization challenges to almond residues: Phytochemical composition and functional application. Molecules 2017;22:1774. https://doi.org/10.3390/molecules22101774 
  7. Heuze V, Tran G, Lebas F. Almond hulls and almond byproducts [Internet]. Feedipedia, a programme by INRAE, CIRAD, AFZ and FAO; 2020 [cited 2021 Apr 5]. Available from: https://www.feedipedia.org/node/27 
  8. Heuze V, Tran G, Hassoun P, Bastianelli D, Lebas F. Cashew (Anacardium occidentale) nuts and by-products [Internet]. Feedipedia, a programme by INRAE, CIRAD, AFZ and FAO; 2017 [cited 2021 Apr 23]. Available from: https://www.feedipedia.org/node/56 
  9. DePeters EJ, Swanson KL, Bill HM, Asmus J, Heguy JM. Nutritional composition of almond hulls. Appl Anim Sci 2020;36:761-70. https://doi.org/10.15232/aas.2020-02035 
  10. Oluwasola AJ. Growth indices and muscle development in broiler-chickens fed equi-protein replacement of soyabean meal with discarded cashew nut meal. J Poult Sci 2006;43:215-21. https://doi.org/10.2141/jpsa.43.215 
  11. Official methods of analysis of AOAC International Association of Official, Analytical Chemists. 21th ed. Rockville, MD, USA: AOAC Int.; 2019. 
  12. U.S., Environmental Protection Agency. Acid digestion of sediments, sludges, and soils. Washington, DC, USA: U.S EPA; 2000. 
  13. Navarro DMDL, Bruininx EMAM, de Jong L, Stein HH. Analysis for low-molecular-weight carbohydrates is needed to account for all energy-contributing nutrients in some feed ingredients, but physical characteristics do not predict in vitro digestibility of dry matter. J Anim Sci 2018;96:532-44. https://doi.org/10.1093/jas/sky010 
  14. Committee on Nutrient Requirements of Swine, National Research Council. Nutrient requirements of swine. 11th ed. Washington, DC, USA: National Academy Press; 2012. 
  15. Sulabo RC, Ju WS, Stein HH. Amino acid digestibility and concentration of digestible and metabolizable energy in copra meal, palm kernel expellers, and palm kernel meal fed to growing pigs. J Anim Sci 2013;91:1391-9. https://doi.org/10.2527/jas.2012-5281 
  16. Closs EI, Simon A, Vékony N, Rotmann A. Plasma membrane transporters for arginine. J Nutr 2004;134:2752S-9S. https://doi.org/10.1093/jn/134.10.2752S 
  17. Jaworski NW, Shoulders J, Gonzalez-Vega JC, Stein HH. Effects of using copra meal, palm kernel expellers, or palm kernel meal in diets for weanling pigs. Prof Anim Sci 2014;30:243-51. https://doi.org/10.15232/S1080-7446(15)30108-X 
  18. Rojas OJ, Stein HH. Concentration of digestible, metabolizable, and net energy and digestibility of energy and nutrients in fermented soybean meal, conventional soybean meal, and fish meal fed to weanling pigs. J Anim Sci 2013;91:4397-405. https://doi.org/10.2527/jas.2013-6409 
  19. Rojas OJ, Stein HH. Effects of replacing fish, chicken, or poultry by-product meal with fermented soybean meal in diets fed to weanling pigs. Rev Colom Cienc Pecua 2015;28:22-41.  https://doi.org/10.17533/udea.rccp.324909
  20. Asghar MT, Yusof YA, Mokhtar MN, et al. Coconut (Cocos nucifera L.) sap as a potential source of sugar: Antioxidant and nutritional properties. Food Sci Nutr 2020;8:1777-87. https://doi.org/10.1002/fsn3.1191 
  21. Mahan DC, Brendemuhl JH, Carter SD et al. Comparison of dietary selenium fed to grower-finisher pigs from various regions of the United States on resulting tissue Se and loin mineral concentrations. J Anim Sci 2005;83:852-7. https://doi.org/10.2527/2005.834852x 
  22. Almaguer BL, Sulabo RC, Liu Y, Stein HH. Standardized total tract digestibility of phosphorus in copra meal, palm kernel expellers, palm kernel meal, and soybean meal fed to growing pigs. J Anim Sci 2014;92:2473-80. https://doi.org/10.2527/jas.2013-6654 
  23. Akande TO, Akinwumi AO, Abegunde TO. Cashew reject meal in diets of laying chickens: nutritional and economic suitability. J Anim Sci Technol 2015;57:17. https://doi.org/10.1186/s40781-015-0051-7 
  24. Elahi MY, Kargar H, Dindarlou MS, et al. The chemical composition and in vitro digestibility evaluation of almond tree (Prunus dulcis D. A. Webb syn. Prunus amygdalus; var. Shokoufeh) leaves versus hulls and green versus dry leaves as feed for ruminants. Agroforest Syst 2017;91:773-80. https://doi.org/10.1007/s10457-016-9964-5 
  25. Rico R, Bullo M, Salas-Salvado J. Nutritional composition of raw fresh cashew (Anacardium occidentale L.) kernels from different origin. Food Sci Nutr 2016;4:329-38. https://doi.org/10.1002/fsn3.294 
  26. Yao KSA, Kimse M, Soro D, Fantodji A. Effect of cashew nut inclusion in feed ratios on pig growth performance: Post-weaning and growth phases. Int J Biol Chem Sci 2013;7:479-88. https://doi.org/10.4314/ijbcs.v7i2.6 
  27. Sequeira RM, Lew RB. The carbohydrate composition of almond hulls. J Agric Food Chem 1970;18:950-1. https://doi.org/10.1021/jf60171a001 
  28. Asmus J. Nutritionist perspective on almond hulls as a feed ingredient [Internet]. Almond Hullers Educational Seminar - CGFA; 2015 [cited 2021 May 10]. Available from: https://www.cgfa.org/NutritionistPerspectiveonAlmondHullsasaFeed.pdf 
  29. Porte FE, Manterola BH, Cerda AD, Mira JJ, Sirhan AL. Productive performance and characteristics of Hereford beef carcass fed with rations including increasing levels of almond hull. Av Prod Anim 1991;16:165-72. 
  30. Calvert C, Parker K. Almond hulls produce unexpected results in hog trials. Calif Agric 1985;39:14-5.