DOI QR코드

DOI QR Code

Seismic performance of low-rise reinforced concrete moment frames under carbonation corrosion

  • Vaezi, Hossein (The Centre of Excellence for Fundamental Studies in Structural Engineering, Iran University of Science and Technology) ;
  • Karimi, Amir (Rehabilitation and Retrofitting Research Centre, Iran University of Science and Technology) ;
  • Shayanfar, Mohsenali (The Centre of Excellence for Fundamental Studies in Structural Engineering, Iran University of Science and Technology) ;
  • Safiey, Amir (Department of Civil, Environmental and Architectural Engineering, University of Colorado Boulder)
  • Received : 2020.08.06
  • Accepted : 2021.02.10
  • Published : 2021.02.25

Abstract

The carbon dioxide present in the atmosphere is one of the main reasons for the corrosion of bridges, buildings, tunnels, and other reinforced concrete (RC) structures in most industrialized countries. With the growing use of fossil fuels in the world since the Industrial Revolution, the amount of carbon dioxide in urban and industrial areas of the world has grown significantly, which increases the chance of corrosion caused by carbonation. The process of corrosion leads to a change in mechanical properties of rebars and concrete, and consequently, detrimentally impacting load-bearing capacity and seismic behavior of RC structures. Neglecting this phenomenon can trigger misleading results in the form of underestimating the seismic performance metrics. Therefore, studying the carbonation corrosion influence on the seismic behavior of RC structures in urban and industrial areas is of great significance. In this study, a 2D modern RC moment frame is developed to study and assess the effect of carbonation corrosion, in 5-year intervals, for a 50 years lifetime under two different environmental conditions. This is achieved using the nonlinear static and incremental dynamic analysis (IDA) to evaluate the reinforcement corrosion effects. The reduction in the seismic capacity and performance of the reinforced concrete frame, as well as the collapse probability over the lifetime for different corrosion scenarios, is examined through the capacity curves obtained from nonlinear static analysis and the fragility curves obtained from IDA.

Keywords

References

  1. ACI 318 (2005), Building Code Requirements for Structural Concrete and Commentary, American Concrete Institute; Farmington Hills, MI, U.S.A.
  2. Anoop, M.B. and Rao, K.B. (2015), "Seismic damage estimation of reinforced concrete framed structures affected by chlorideinduced corrosion", Earthq. Struct., 9(4), 851-873. https://doi.org/10.12989/eas.2015.9.4.851.
  3. Ansari, M., Daneshjoo, F., Safiey, A., Hamzehkolaei, N.S. and Sorkhou, M (2019), "Fiber element - based nonlinear analysis of concrete bridge piers with consideration of permanent displacement", Struct. Eng. Mech., 69(3), 243-255. https://doi.org/10.12989/sem.2019.69.3.243.
  4. ASCE 7 (2006), Minimum Design Loads for Buildings and Other Structures, American Society of Civil engineers; Reston, U.S.A.
  5. Backus, J. and McPolin, D. (2016), "Effect of cyclic carbonation on chloride ingression in GGBS concrete", J. Mater. Civil Eng., 28(7), 1-6. https://doi.org/10.1061/(ASCe)MT.1943-5533.0001529.
  6. Basheer, L., Kropp, J. and Cleland, D.J. (2001), "Assessment of the durability of concrete from its permeation properties: A review", Construct. Build. Mater., 15(2-3), 93-103. https://doi.org/10.1016/S0950-0618(00)00058-1.
  7. Bastidas-Arteaga, e., Schoefs, F., Stewart, M.G. and Wang, X. (2013), "Influence of global warming on durability of corroding RC structures: A probabilistic approach. Engineering Structures", 51, 259-266. https://doi.org/10.1016/j.engstruct.2013.01.006.
  8. Belda Revert, A., De Weerdt, K., Hornbostel, K. and Geiker, M.R. (2018), "Carbonation-induced corrosion: Investigation of the corrosion onset", Construct. Build. Mater., 162, 847-856. https://doi.org/10.1016/j.conbuildmat.2017.12.066.
  9. Cape', M. (1999), Residual Service-Life Assessment of existing R/C Structures, Chalmers University of Technology and Milan University of Technology, Gothenburg and Milan.
  10. CEB (1997), New Approach to Durability Design: An example for carbonation induced corrosion", Comite euro-international du beton (CeB).
  11. Celarec D., Ricci P. and Dolsek M. (2012), "The sensitivity of seismic response parameters to the uncertain modelling variables of masonry-infilled reinforced concrete frames", Eng. Struct., 35, 165-177. https://doi.org/10.1016/j.engstruct.2011.11.007.
  12. Celarec D., Vamvatsikos D. and Dolsek, M. (2011) "Simplified estimation of seismic risk for reinforced concrete buildings with consideration of corrosion over time", Bull. Earthq. Eng., 9,1137-1155. https:// doi.org/10.1007/s10518-010-9241-3.
  13. Change, A.D.G. (2007), "Climate change impacts, adaptation and vulnerability", Sci. Total Environ., 326(1-3), 95-112. https://doi.org/10.1016/j.scitotenv.2003.11.022
  14. Chen, C.T. and Ho, C.W. (2013), "Influence of cyclic humidity on carbonation of concrete", J. Mater. Civil Eng., 25(12), 1929-1935. https:// doi.org/10.1061/(ASCe)MT.1943-5533.0000750.
  15. Coronelli, D. and Gambarova, P. (2004) "Structural assessment of corroded reinforced concrete beams: modeling guidelines", ASCE J. Struct. Eng., 130(8), 1214-1224. https://doi.org/10.1061/-ASCe!0733-9445-2004!130:8-1214.
  16. Couto R, Requena-Garcia-Cruz M.V., Bento, A. and Moralesesteban (2020), "Seismic capacity and vulnerability assessment considering ageing effects: Case study-three local Portuguese RC buildings", Bull. Earthq. Eng., 1-24. https://doi.org/10.1007/s10518-020-00955-4.
  17. Crane, A.P. (1983), Society of Chemical Industry (Great Britain). Materials Preservation Group., and Society of Chemical Industry (Great Britain), Road and Building Materials Group, Corrosion of reinforcement in concrete construction. Published for the Society of Chemical Industry, London, by Ellis Horwood.
  18. CSI (2018), SAP2000 Integrated Software for Structural Analysis and Design, Comput. Struct., Berkeley, California.
  19. Das, B.B., Singh, D.N. and Pandey, S.P. (2012), "Rapid chloride ion permeability of OPC- and PPC-based carbonated concrete", J. Mater. Civil Eng., 24(5), 606-611. https://doi.org/10.1061/(ASCe)MT.1943-5533.0000415.
  20. Du, Y.G., Clark, L.A. and Chan, A.H.C. (2005), "Residual capacity of corroded reinforcing bars", Mag. Concrete Res., 57(3), 135-147. https://doi.org/10.1680/macr.2005.57.3.135.
  21. DuraCrete (2000), Statistical Quantification of the Variables in the Limit State Functions, The European Union-Brite EuRam IIIContract BRPR-CT95-0132-Project BE95-1347/R9.
  22. FEMA P-2012 (2018), Assessing Seismic Performance of Buildings with Configuration Irregularities, Prepared by the Applied Technology Council, Redwood City, C.A.
  23. FEMA P-695 (2009), Quantification of Building System Performance and Response Parameters, Project ATC-63, Prepared by the Applied Technology Council, Redwood City, C.A.
  24. Ghanooni-Bagha, M., Shayanfar, M.A., Shirzadi-Javid, A.A. and Ziaadiny, H. (2016), "Corrosion-induced reduction in compressive strength of self-compacting concretes containing mineral admixtures", Construct. Build. Mater., 113, 221-228. https://doi.org/10.1016/j.conbuildmat.2016.03.046.
  25. Ghanooni-Bagha, M., YekeFallah, M.R. and Shayanfar, M.A. (2020), "Durability of RC structures against carbonationinduced corrosion under the impact of climate change", KSCE J. Civil Eng., 24(1), 131-142. https:// doi.org/10.1007/s12205-020-0793-8.
  26. Ghanooni-Bagha, M., Zarei, S., Savoj, H.R. and Shayanfar, M.A. (2019), "Time-dependent seismic performance assessment of corroded reinforced concrete frames", Periodica Polytech. Civil Eng., 63(2), 631-640. https://doi.org/10.3311/PPci.12653.
  27. Ghosh, J. and Padgett, J.E. (2012), "Impact of multiple component deterioration and exposure conditions on seismic vulnerability of concrete bridges", Earthq. Struct., 3(5), 649-673. https://doi.org/ 10.12989/eas.2012.3.5.649.
  28. Goharrokhi, A., Ahmadi, J., Shayanfar, M.A., Ghanooni-Bagha, M. and Nasserasadi, K. (2020), "Effect of transverse reinforcement corrosion on compressive strength reduction of stirrup-confined concrete: an experimental study" Sadhana, 45(1), 1-9. https://doi.org/10.1007/s12046-020-12800.
  29. Haselton, C.B. (2006), Assessing Seismic Collapse Safety of Modern Reinforced Concrete Moment Frame Buildings, Ph.D. Dissertation, Stanford University, U.S.A.
  30. Inci, P., Goksu, C., Ilki, A. and Kumbasar, N. (2013), "Effects of reinforcement corrosion on the performance of RC frame buildings subjected to seismic actions", J. Perform. Construct. Facilities, 27(6), 683-696. https://doi.org/10.1061/(ASCe)CF.1943-5509.0000378.
  31. Mazzoni, S., McKenna, F., Scott, M.H. and Fenves, G.L. (2006), OpenSEES Command Language Manual, Pacific Earthquake Engineering Research (PEER) Center, 264.
  32. Mirza, S. and Ali, M.S. (2017), "Infrastructure crisis-A proposed national infrastructure policy for Canada", Canadian J. Civil Eng., 44(7), 539-548. https://doi.org/10.1139/cjce-2016-0468.
  33. Mitchell, L.E., Lin, J.C., Bowling, D.R., Pataki, D.E., Strong, C., Schauer, A.J. and Ehleringer, J.R. (2018), "Long-term urban carbon dioxide observations reveal spatial and temporal dynamics related to urban characteristics and growth", Proceedings of the National Academy of Sciences, 115(12), 2912-2917. https://doi.org/10.1073/pnas.1702393115
  34. Molina, F.J., Alonso, C. and Andrade, C. (1993), "Cover cracking as a function of rebar corrosion: Part 2-Numerical model", Mater. Struct., 26(9), 532-548. https://doi.org/10.1007/BF02472864.
  35. Neville, A. and Brooks, J. (2010), Concrete Technology, Pearson education Limited.
  36. Sadeghi, K. and Nouban, F. (2019), "An algorithm for simulation of cyclic eccentrically-loaded RC columns using fixed rectangular finite elements discretization", Comput. Concrete, 23(1), 25-36. https://doi.org/10.12989/cac.2019.23.1.025.
  37. Sadeghi, K., Musa, M.K. and Nassrullah, H.M. (2019), "Corrosion problems in RC structures: An overview of causes, mechanism, effects, controls and evaluation", Academic Res. Int., 10(2), 15-28.
  38. Saha, M. and Eckelman, M.J. (2014), "Urban scale mapping of concrete degradation from projected climate change", Urban Climate, 9, 101-114. https://doi.org/10.1016/j.uclim.2014.07.007.
  39. Sanjuan, M.A. and Del Olmo, C. (2001), "Carbonation resistance of one industrial mortar used as a concrete coating", Build. Environ., 36(8), 949-953. https://doi.org/10.1016/S0360-1323(00)00045-7.
  40. Shayanfar, M.A. and Safiey, A. (2008a), "Hypoelastic modeling of reinforced concrete walls", Comput. Concrete, 5(3), 195-216. https://doi.org/10.12989/cac.2008.5.3.195.
  41. Shayanfar, M.A. and Safiey, A. (2008b), "A new approach for nonlinear finite element analysis of reinforced concrete structures with corroded reinforcements", Comput. Concrete, 5(2), 155-174. https://doi.org/10.12989/cac.2008.5.2.155.
  42. Shayanfar, M.A., Barkhordari, M.A. and Ghanooni-Bagha, M. (2015), "Probability calculation of rebars corrosion in reinforced concrete using css algorithms", J. Central South Univ., 22(8), 3141-3150. https://doi.org/10.1007/s11771-015-2851-9.
  43. Shayanfar, M.A., Barkhordari, M.A. and Ghanooni-Bagha, M. (2016), "Effect of longitudinal rebar corrosion on the compressive strength reduction of concrete in reinforced concrete structure", Advan. Struct. Eng., 19(6), 897-907. https://doi.org/10.1177/1369433216630367.
  44. Singh, N. and Singh, S.P. (2016), "Reviewing the carbonation resistance of concrete", J. Mater. Eng. Struct., 3(2), 35-57.
  45. Soltani, M., Safiey, A. and Brennan, A. (2019), "A state-of-the-art review of bending and shear behaviors of corrosion-damaged reinforced concrete beams", ACI Struct. J., 116(3), 53-64. https://doi.org/10.14359/51714481.
  46. Stewart, M.G., Wang, X. and Nguyen, M.N. (2011), "Climate change impact and risks of concrete infrastructure deterioration", Eng. Struct., 33(4), 1326-1337. https://doi.org/10.1016/j.engstruct.2011.01.010.
  47. Talukdar, S., Banthia, N., Grace, J.R. and Cohen, S. (2012), "Carbonation in concrete infrastructure in the context of global climate change: Part 2 - Canadian urban simulations", Cement Concrete Compos., 34(8), 931-935. https://doi.org/10.1016/j.cemconcomp.2012.04.012.
  48. United States Census Bureau (2011), Comparing 2011 American Community Survey Data. https://www.census.gov/programssurveys/acs/guidance/comparing-acs-data/2011.html.
  49. Vamvatsikos, D. and Allin Cornell, C. (2002), "Incremental dynamic analysis", Earthq. Eng. Struct. Dyn., 31(3), 491-514. https://doi.org/10.1002/eqe.141.
  50. Vecchio, F.J. and Collins, M.P. (1986), "Modified compressionfield theory for reinforced concrete elements subjected to shear", J. Amer. Concrete Institute, 83(2), 219-231. https://doi.org/10.14359/10416.
  51. Vu, N.S. and Li, B. (2018), "Seismic performance assessment of corroded reinforced concrete short columns", ASCe J. Struct. Eng., 144(4). https://doi.org/10.1061/(ASCe)ST.1943-541X.0001994.
  52. Yalciner, H., Sensoy, S. and Eren, O. (2015), "Seismic performance assessment of a corroded 50-year-old reinforced concrete building", ASCe J. Struct. Eng., 141(12), 1-11. https://doi.org/ 10.1061/(ASCe)ST.1943-541X.0001263.
  53. Yin, S., Jing, L., Yin, M. and Wang, B. (2019), "Mechanical properties of textile reinforced concrete under chloride wet-dry and freeze-thaw cycle environments", Cement Concrete Compos., 96, 118-127, https://doi.org/10.1016/j.cemconcomp.2018.11.020.
  54. Yoon, I.S., Copuroglu, O. and Park, K.B. (2007), "Effect of global climatic change on carbonation progress of concrete", Atmos. Environ., 41(34), 7274-7285. https://doi.org/10.1016/j.atmosenv.2007.05.028.
  55. Yuksel, I. and Coskan, S. (2013), "Earthquake response of reinforced concrete frame structures subjected to rebar corrosion", Earthq. Struct., 5(3), 321-341. https://doi.org/10.12989/eas.2013.5.3.321.
  56. Zhou, Y., Gencturk, B., Willam, K. and Attar, A. (2015), "Carbonation-induced and chloride-induced corrosion in reinforced concrete structures", ASCE J. Mater. Civil Eng., 27(9). https://doi.org/10.1061/(ASCe)MT.1943-5533.0001209.

Cited by

  1. Influence of chloride corrosion on tension capacity of rebars vol.28, pp.10, 2021, https://doi.org/10.1007/s11771-021-4834-3