Membrane and Water Treatment

  • 제11권6호
  • /
  • Pages.383-389
  • /
  • 2020
  • /
  • 2005-8624(pISSN)
  • /
  • 2092-7037(eISSN)
테크노프레스 (Techno-Press)
권호 표지
DOI QR코드

DOI QR Code

Single- and multi-stage dairy wastewater treatment by vibratory membrane separation processes

  • Kertesz, Szabolcs (Department of Process Engineering, Faculty of Engineering, University of Szeged) ;
  • Szerencses, Szabolcs Gyula (Department of Process Engineering, Faculty of Engineering, University of Szeged) ;
  • Vereb, Gabor (Department of Process Engineering, Faculty of Engineering, University of Szeged) ;
  • Csanadi, Jozsef (Department of Food Engineering, Faculty of Engineering, University of Szeged) ;
  • Laszlo, Zsuzsanna (Department of Process Engineering, Faculty of Engineering, University of Szeged) ;
  • Hodur, Cecilia (Institute of Environmental Science and Technology, University of Szeged)
  • 투고 : 2019.08.01
  • 심사 : 2020.10.27
  • 발행 : 2020.11.25
⟨ 이전 논문 다음 논문 ⟩

초록

Before discharge into sewage or living waters, dairy effluents need to be effectively treated to meet the requirements defined by environmental protection regulations. In addition to the commonly used technologies, membrane separation might offer a novel solution with many remarkable advantages. Although membrane fouling often limits its industrial scale application, module vibration can reduce membrane fouling. In this study, multi-stage membrane separations with ultrafiltration (UF), as pre-filtration, and nanofiltration (NF) were investigated. On the one hand, our aim was to separate the wastewater to reach the cleanest permeate possible, on the other hand to achieve the highest organic content in the smallest volume for further energetic utilization. Firstly, with one-stage separations the effects of Vibratory Shear Enhanced Processing (VSEP) on shear rate, fluxes and rejections were investigated. These tests revealed that vibration has a positive effect on fluxes and rejections. Secondly, two types of multi-stage UF/NF separation experiments were carried out and membrane fluxes, COD rejections and flux decreasing rates were examined. In type 1, permeates of nanofiltered UF permeates achieved the lowest organic load in purified wastewater to meet European environmental threshold limits for living waters. In type 2, concentrates of nanofiltered UF concentrates reached the highest possible volume reduction ratio (VRR) resulting in higher organic content in a smaller volume, which could increase the efficiency of biogas production as an alternative post-treatment for waste management.

키워드

과제정보

The authors are grateful for the financial support of the Hungarian Science and Research Foundation (OTKA contract number K 115691), the Hungarian State and the European Union (EFOP-3.6.2-16-2017-00010). Sz. K. thanks the support of the Janos Bolyai Research Scholarship of the Hungarian Academy of Sciences and the New National Excellence Program of the Ministry of Human Capacities (BO/00576/20/4 & UNKP-20-5-SZTE-384). Supported by the UNKP-20-2 New National Excellence Program of the Ministry for Innovation and Technology.

참고문헌

  1. Akoum, O., Jaffrin, M.Y. and Ding, L.H. (2005), "Concentration of total milk proteins by high shear ultrafiltration in a vibrating membrane module", J. Membr. Sci., 247, 211-220. https://doi.org/10.1016/j.memsci.2004.09.021
  2. Akoum, O., Richfield, D., Jaffrin, M.Y., Ding, L.H. and Swart, P. (2006), "Recovery of trypsin inhibitor and soy milk protein concentration by dynamic filtration", J. Membr. Sci., 279, 291-300. https://doi.org/10.1016/j.memsci.2005.12.030
  3. Andrade, L.H., Mendes, F.D.S., Espindola, J.C. and Amaral, M.C.S. (2014), "Nanofiltration as tertiary treatment for the reuse of dairy wastewater treated by membrane bioreactor", Sep. Purif. Tech., 126, 21-29. https://doi.org/10.1016/j.seppur.2014.01.056
  4. Badvipour, S., Eustance, E. and Sommerfeld, M.R. (2016), "Process evaluation of energy requirements for feed production using dairy wastewater for algal cultivation: Theoretical approach", Algal Res., 19, 207-214. https://doi.org/10.1016/j.algal.2016.08.017
  5. Bian, R., Yamamoto, K. and Watanabe, Y. (2000), "The effect of shear rate on controlling the concentration polarization and membrane fouling", Desalination, 131(1-3), 225-236. https://doi.org/10.1016/S0011-9164(00)90021-3
  6. Burak, D., Orhan, Y. and Turgut, T.O. (2005), "Anaerobic treatment of dairy wastewaters: a review", Process Biochem., 40(8), 2583-2595. https://doi.org/10.1016/j.procbio.2004.12.015
  7. Chandra, R., Castillo-Zacarias, C., Delgado, P. and Parra-Saldivar, R. (2018), "Review: A biorefinery approach for dairy wastewater treatment and product recovery towards establishing a biorefinery complexity index", J. Clean. Prod., 183, 1184-1196. https://doi.org/10.1016/j.jclepro.2018.02.124
  8. Chen, Z., Luo, J., Wang, Y., Cao, W., Qi, B., Wan, Y. (2017), "A novel membrane-based integrated process for fractionation and reclamation of dairy wastewater", Chem. Eng. J., 313, 1061- 1070. https://doi.org/10.1016/j.cej.2016.10.134
  9. Danner, M.C., Robertson, A., Behrends, V. and Reiss, J. (2019), "Review: Antibiotic pollution in surface fresh waters: Occurrence and effects", Sci. Total Environ., 664, 793-804. https://doi.org/10.1016/j.scitotenv.2019.01.406
  10. Delaunay, D., Rabiller-Baudry, M., Gozalvez-Zafrilla, J.M., Balannec, B., Frappart, M. and Paugam, L. (2008), "Mapping of protein fouling by FTIR-ATR as experimental tool to study membrane fouling and fluid velocity profile in various geometries and validation by CFD simulation", Chem. Eng. Process., 47(7), 1106-1117. https://doi.org/10.1016/j.cep.2007.12.008
  11. Ding, L. and Jaffrin, M.Y. (2014), "Benefits of High Shear Rate Dynamic Nanofiltration and Reverse Osmosis: A Review", Sep. Sci. Tech., 49, 1953-1967. https://doi.org/10.1080/01496395.2014.914538
  12. Frappart, M., Jaffrin, M. and Ding, L. H. (2008), "Reverse osmosis of diluted skim milk: Comparison of results obtained from vibratory and rotating disk modules", Sep. Purif. Tech., 60(3), 321-329. https://doi.org/10.1016/j.seppur.2007.09.007
  13. Hyun, U.C., Minjeong, L., Jingyeong, S., Eun-Sik, K. and Young, M.K. (2020), "Lignin fractionation from waste wood using organosolv treatment combined with membrane filtration", Membr. Water Treat., 11, 25-29. https://doi.org/10.12989/mwt.2020.11.1.025
  14. Karadag, D., Koroglu, O. E., Ozkaya, B. and Cakmakci, M. (2015), "A review on anaerobic biofilm reactors for the treatment of dairy industry wastewater", Process Biochem., 50, 262-271. https://doi.org/10.1016/j.procbio.2014.11.005
  15. Kertesz, Sz., Bor, P., Hodur, C., Csanadi, J., Vereb, G., Kovacs, I., Keszthelyi-Szabo, G. and Laszlo, Zs. (2017), "Effects of shear rate on membrane filtration", Desalin. Water Treat., 69, 43-49. doi:10.5004/dwt.2017.0645
  16. Khosroyar, S. and Arastehnodeh, A. (2018), "Using response surface methodology and Box-Behnken design in the study of affecting factors on the dairy wastewater treatment by MEUF", Membr. Water Treat., 9(5), 335-342. https://doi.org/10.12989/mwt.2018.9.5.335
  17. Leh-Togi Zobeashia, S.S., Aransiola, S.A., Ijah U.J.J. and Abioye O.P. (2018), "Anaerobic digestion and agricultural application of organic wastes", Adv. Environ. Res., 7(2), 73-85. https://doi.org/10.12989/aer.2018.7.2.073
  18. Luo, J., Ding, L., Qi, B., Jaffrin, M.Y. and Wan, Y. (2011), "A two-stage ultrafiltration and nanofiltration process for recycling dairy wastewater", Bioresour. Technol., 102(16), 7437-7442. https://doi.org/10.1016/j.biortech.2011.05.012
  19. Prince, A., Sanjai, J.P., Amy, P.S., Kate, M.S., Minseung, P. and Sungpyo, K. (2018), "The effect of organic matter on the removal of phosphorous through precipitation as struvite and calcium phosphate in synthetic dairy wastewater", Membr. Water Treat., 9(3), 163-172. https://doi.org/10.12989/mwt.2018.9.3.163
  20. Thines, R.K., Mubarak, N.M., Nizamuddin, S., Sahu, J.N., Abdullah, E.C. and Ganesan, P. (2017), "Application potential of carbon nanomaterials in water and wastewater treatment: A review", J. Taiwan Inst.Chem. Eng., 72, 116-133. https://doi.org/10.1016/j.jtice.2017.01.018
  21. Wang, J., Cahyadi, A., Wu, B., Pee, W., Fane, A.G. and Chew, J.W. (2020), "The roles of particles in enhancing membrane filtration: A review", J. Membr. Sci., 595, 117570. https://doi.org/10.1016/j.memsci.2019.117570
  22. Zhang, W., Xiao, P. and Wang, D. (2014), "Central treatment of different emulsion wastewaters by an integrated process of physicochemically enhanced ultrafiltration and anaerobic-aerobic biofilm reactor", Bioresour. Technol., 159, 150-156. https://doi.org/10.1016/j.biortech.2014.02.067