Wind and Structures

  • 제27권5호
  • /
  • Pages.347-356
  • /
  • 2018
  • /
  • 1226-6116(pISSN)
  • /
  • 1598-6225(eISSN)
테크노프레스 (Techno-Press)
권호 표지
DOI QR코드

DOI QR Code

Evaluation of stress distribution with wind speed in a greenhouse structure

  • Hur, Deog-jae (Research & Business Corporation Center, Institute for Advanced Engineering) ;
  • Noh, Jung-Hun (Research & Business Corporation Center, Institute for Advanced Engineering) ;
  • Lee, Hyun ju (Research & Business Corporation Center, Institute for Advanced Engineering) ;
  • Song, Hyoung woon (Plant Engineering Division, Institute for Advanced Engineering)
  • 투고 : 2017.10.11
  • 심사 : 2018.05.30
  • 발행 : 2018.11.25
⟨ 이전 논문 다음 논문 ⟩

초록

In this paper, stress distribution for a structurally stable greenhouse is considered in the present paper with subsequent investigation into the detailed stress distribution contour with the variation of self-weight and wind pressure level designation method under wind velocity of less than 30 m/sec. For reliable analysis, wind pressure coefficients of a single greenhouse unit were modeled and compared with experiment with correlation coefficient greater than 0.99. Wind load level was designated twofold: direct mapping of fluid dynamic analysis and conversion of modeled results into wind pressure coefficients ($C_P$). Finally, design criteria of EN1991-1-4 and NEN3859 were applied in terms of their wind pressure coefficients for comparison. $C_P$ of CFD result was low in the most of the modeled area but was high only in the first roof wind facing and the last lee facing areas. Besides, structural analysis results were similar in terms of stress distribution as per EN and direct mapping while NEN revealed higher level of stress for the last roof area. The maximum stress levels are arranged in decreasing order of mapping, EN, and NEN, generating 8% error observed between the EN and mapping results under 30 m/sec of wind velocity. On the other hand, effect of dead weight on the stress distribution was investigated via variation of high stress position with wind velocity, confirming shift of such position from the center to the forward head wind direction. The sensitivity of stress for wind velocity was less than 0.8% and negligible at wind velocity greater than 20 m/sec, thus eliminating self-weight effect.

키워드

과제정보

연구 과제 주관 기관 : Ministry of Agriculture, Food and Rural Affairs

참고문헌

  1. Bronkhorst, A.J., Geurts, C.P.W., van Bentum, C.A., van der Knaap, L.P.M. and Pertermann, I. (2017), "Wind loads for stability design of large multi-span duo-pitch greenhouses. front", Built Environ., 3(18), 13031-1.
  2. Cao, Y., Wang, P. and Jin, X. (2010), "Dynamic analysis of flexible container under wind actions by ALEfinite-element method", J. Wind Eng. Ind. Aerod., 98(12), 881-887. https://doi.org/10.1016/j.jweia.2010.09.002
  3. ESDU. (2005), Computer program for wind speeds and turbulence properties: flat or hilly sites in terrain with roughness changes. Engineering Science Data Unit. ESDU Data Item: 01008
  4. Gu, M. and Huang, Y. (2015), "Equivalent static wind loads for stability design of large span roof structures", Wind Struct., 20(1), 95-115. https://doi.org/10.12989/was.2015.20.1.095
  5. Kateris, D.L., Fragos, V.P., Kotsopoulos, T.A., Martzopoulou, A. G. and Moshou, D. (2012), "Calculated external pressure coefficients on livestock buildings and comparison with Eurocode 1", Wind Struct., 15(6), 481-494. https://doi.org/10.12989/was.2012.15.6.481
  6. Khaoua, S.O., Bournet, P.E., Migeon, C., Boulard, T. and Chasseriaux, G. (2006), "Analysis of greenhouse ventilation efficiency based on computational fluid dynamics", Biosyst. Eng., 95(1), 83-98. https://doi.org/10.1016/j.biosystemseng.2006.05.004
  7. Kim, K., Yoon, J.Y., Kwon, H.J., Han, J.H., Son, J.E., Nam, S.W., Giacomelli, G.A. and Lee, I.B. (2008), "3-D CFD analysis of relative humidity distribution in greenhouse with a fog cooling system and refrigerative dehumidifiers", Biosyst. Eng., 100(2), 245-255. https://doi.org/10.1016/j.biosystemseng.2008.03.006
  8. Kim, R.W. (2015), "Evaluation of Wind Pressure Coefficients of Greenhouses using Wind Tunnel Test and Numerical Model", Doctoral dissertation, Seoul National University, Seoul, Korea
  9. Kozmar, H. (2011), "Wind-tunnel simulations of the suburban ABL and comparison with internationalstandards", Wind Struct., 14(1), 15-34. https://doi.org/10.12989/was.2011.14.1.015
  10. Kwon, K.S., Kim, D.W., Kim, R.W., Ha, T. and Lee, I.B. (2016), "Evaluation of wind pressure coefficients of single-span greenhouses built on reclaimed coastal land using a large-sized wind tunnel", Biosyst. Eng., 141, 58-81. https://doi.org/10.1016/j.biosystemseng.2015.11.007
  11. Launder, B.E. and Spalding, D.B. (1974), "The numerical computation of turbulent flows", Comput. Method. Appl. M., 3(2), 269-289. https://doi.org/10.1016/0045-7825(74)90029-2
  12. Li, L., Kareem, A., Hunt, J., Xiao, Y., Zhou, C. and Song, L. (2015), "Turbulence spectra for boundary-layer winds in tropical cyclones: a conceptual framework and field measurements at coastlines", Bound.-Lay. Meteorol., 154(2), 243-263. https://doi.org/10.1007/s10546-014-9974-7
  13. Lopes, M.F.P., Paixao Conde, J.M., Gloria Gomes, M. and Ferreira, J.G. (2010), "Numerical calculation of thewind action on buildings using Eurocode 1 atmospheric boundary layer velocity profiles", Wind Struct., 13(6),487-498. https://doi.org/10.12989/was.2010.13.6.487
  14. Moriyama, H., Sase, S., Okushima, L. and Ishii, M. (2015), "Which design constraints apply to a pipe-framed greenhouse?", Japan Agricultural Research Quarterly: JARQ, 49(1), 1-9. https://doi.org/10.6090/jarq.49.1
  15. Nayak, A.K. and Rao, K.R. (2014), "Estimation of wind load on a greenhouse and evaluation of its structural stability", Int. J. Agricultural Eng., 7(2), 461-466. https://doi.org/10.15740/HAS/IJAE/7.2/461-466
  16. Park, C.W., Lee, J.W., Lee, H.W. and Lee, S.G. (2005), "Optimum design of greenhouse structures using continuous and discrete optimum algorithms", J. Korean Association for Spatial Structures, 5(4), 61-70.
  17. Park, C.W., Yuh, B.Y., Lee, H.W. and Lee, S.G. (2007), "Optimum design of greenhouse structures using genetic algorithms", J. Korean Society of Steel Construction, 19(2), 171-179.
  18. Shademan, M., Barron, R.M., Balachandar, R. and Hangan, H. (2014), "Numerical simulation of wind loading on groundmounted solar panels at different flow configurations", Can. J. Civil Eng., 41(8), 728-738. https://doi.org/10.1139/cjce-2013-0537
  19. Shklyar, A. and Arbel, A. (2004), "Numerical model of the threedimensional isothermal flow patterns and mass fluxes in a pitched-roof greenhouse", J. Wind Eng. Ind. Aerod., 92(12), 1039-1059. https://doi.org/10.1016/j.jweia.2004.05.008
  20. Sokolnikoff, I.S. (1956), Mathematical Theory of Elasticity, McGraw-Hill Book Co, New York, NY, USA.
  21. Vieira Neto, J.G. and Soriano, J. (2016), "Distribution of stress in greenhouses frames estimated by aerodynamic coefficients of Brazilian and European standards", Scientia Agricola, 73(2), 97-102. https://doi.org/10.1590/0103-9016-2015-0072