Journal of Electrical Engineering and Technology

The Korean Institute of Electrical Engineers (대한전기학회)
권호 표지
DOI QR코드

DOI QR Code

Sliding Mode Control Based DTC of Sensorless Parallel-Connected Two Five-Phase PMSM Drive System

  • Kamel, Tounsi (Dept. of Electrical Engineering, Chlef University) ;
  • Abdelkader, Djahbar (Dept. of Electrical Engineering, Chlef University) ;
  • Said, Barkat (Dept. of Electrical Engineering, M'sila University) ;
  • Al-Hitmi, M. (Dept. of Electrical Engineering, Qatar University) ;
  • Iqbal, Atif (Dept. of Electrical Engineering, Qatar University)
  • Received : 2017.09.17
  • Accepted : 2017.12.14
  • Published : 2018.05.01
Download PDF
⟨ Previous Next ⟩

Abstract

This paper presents a sensorless direct torque control (DTC) combined with sliding mode approach (SM) and space vector modulation (SVM) to achieve mainly a high performance and reduce torque and flux ripples of a parallel-connected two five-phase permanent magnet synchronous machine (PMSM) drive system. In order to increase the proposed drive robustness and decrease its complexity and cost, the rotor speeds, rotor positions, fluxes as well as torques are estimated by using a sliding mode observer (SMO) scheme. The effectiveness of the proposed sliding mode observer in conjunction with the sliding mode control based DTC is confirmed through the application of different load torques for wide speed range operation. Comparison between sliding mode control and proportional integral (PI) control based DTC of the proposed two-motor drive is provided. The obtained speeds, torques and fluxes responses follow their references; even in low and reverse speed operations, load torques changes, and machines parameters variations. Simulation results confirm also that, the ripples of the torques and fluxes are reduced more than 3.33% and 16.66 %, respectively, and the speed overshoots and speed drops are reduced about 99.85% and 92.24%, respectively.

Keywords

References

  1. M. Bermudez, I. Gonzalez-Prieto, F. Barrero, H. Guzman, M. J. Duran, and X. Kestelyn, "Open-Phase Fault-Tolerant Direct Torque Control Technique for Five-Phase Induction Motor Drives," IEEE Transactions on Industrial Electronics, vol. 64, no. 2, pp. 902-911, 2017. https://doi.org/10.1109/TIE.2016.2610941
  2. S. Payami, R. K. Behera, X. Yu, and M. Gao, "An Improved DTC Technique for Low Speed Operation of a Five-Phase Induction Motor," IEEE Transactions on Industrial Electronics, vol. 64, no. 5, pp. 3513-3523, 2017. https://doi.org/10.1109/TIE.2017.2652397
  3. B. Tian, Q.-T. An, J.-D. Duan, D.-Y. Sun, L. Sun, and D. Semenov, "Decoupled Modeling and Nonlinear Speed Control for Five-Phase PM Motor under Single Phase Open Fault," IEEE Transactions on Industrial Electronics, vol. 32, no. 7, pp. 5473-5486, 2017.
  4. N. R. Abjadi, "Sliding-Mode Control of a Six-phase Series/Parallel Connected Two Induction Motors Drive," ISA Transactions, vol. 53, no. 6, pp. 1847-1856, 2014. https://doi.org/10.1016/j.isatra.2014.09.001
  5. H. H. Chen and C.-X. Su, "Current Control for Single-Inverter Fed Series-Connected Five-Phase PMSMS," IEEE International Symposium on Industrial Electronics, Taipei, Taiwan, pp.1-6, 28-31May, 2013.
  6. L. Gao and J. E. Fletcher, "A Space Vector Switching Strategy for Three-Level Five-Phase Inverter Drives, "IEEE Transactions on Industrial Electronics, vol. 57, no. 7, pp. 2332-2343, July 2010. https://doi.org/10.1109/TIE.2009.2033087
  7. L. Yuan, M.-L. Chen, J.-Q. Shen, and F. Xiao, "Current Harmonics Elimination Control Method for Six-Phase PM Synchronous Motor Drives," ISA Transactions, vol. 59, pp. 443-449, November 2015. https://doi.org/10.1016/j.isatra.2015.09.013
  8. L. Parsa and H. A. Toliyat, "Sensorless Direct Torque Control of Five-Phase Interior Permanent-Magnet Motor Drives," IEEE Transactions on Industry Applications, vol. 43, no. 4, pp. 952-959, July/August 2007. https://doi.org/10.1109/TIA.2007.900444
  9. Y. N. Tatte and M. V. Aware, "Torque Ripple and Harmonic Current Reduction in Three-Level Inverter Fed Direct Torque Controlled Five-Phase Induction Motor," IEEE Transactions on Industrial Electronics, vol. 64, no. 7, pp. 5265-5275, 2017. https://doi.org/10.1109/TIE.2017.2677346
  10. A. Ammar, A. Bourek, and A. Benakcha, "Robust SVM-Direct Torque Control of Induction Motor Based on Sliding Mode Controller and Sliding Mode Observer," Frontiers in Energy, pp. 1-14, 2017.
  11. B. Ning, S. Cheng and Y. Qin, "Direct Torque Control of PMSM Using Sliding Mode Backstepping Control with Extended State Observer," Journal of Vibration and Control, pp. 1-14, 2016.
  12. B. S. Khaldi, H. Abu-Rub, A. Iqba, R. Kennel, O. Mahmoudi, and D. Boukhetala,"Sensorless Direct Torque Control of Five-Phase Induction Motors Drives," IECON 2011, 37th Annual Conference on IEEE Industrial Electronics Society, Melbourne, VIC, pp. 3501-3506, 7-10 November 2011.
  13. M. H. Vafaie, B. M. Dehkordi, P. Moallem, and A. Kiyoumarsi, "A New Predictive Direct Torque Control Method for Improving Both Steady-State and Transient-State Operations of the PMSM," IEEE Transactions on Power Electronics, vol. 31, no. 5, pp. 3738-3753, May 2016. https://doi.org/10.1109/TPEL.2015.2462116
  14. F. Ben Salem and N. Derbel, "Second-Order Sliding-mode Control Approaches to Improve Low-speed Operation of Induction Machine under Direct Torque Control," Electric Power Components and Systems, vol. 44, no. 17, pp. 1969-1980, June 2016. https://doi.org/10.1080/15325008.2016.1199069
  15. A. Ammar, A. Bourek, and A. Benakcha, "Nonlinear SVM-DTC for Induction Motor Drive Using Input-Output Feedback Linearization and High Order Sliding Mode Control," ISA Transactions, vol. 67, pp. 428-442, 2017. https://doi.org/10.1016/j.isatra.2017.01.010
  16. X. Zhang, L. Sun, K. Zhao, and L. Sun, "Nonlinear Speed Control for PMSM System Using Sliding-Mode Control and Disturbance Compensation Techniques," IEEE Transactions on Power Electronics, vol. 28, no. 3, pp. 1358-1365, March 2013. https://doi.org/10.1109/TPEL.2012.2206610
  17. S. M. J. R. Fatemi, N. R. Abjadi, J. Soltani, and S. Abazari, "Speed Sensorless Control of a Six-Phase Induction Motor Drive Using Backstepping Control," IET Power Electron., vol. 7, no. 1, pp. 114-123, January 2014. https://doi.org/10.1049/iet-pel.2013.0081
  18. A. Hosseyni, R. Trabelsi, A. Iqbal, and M. F. Mimouni, "Backstepping Control for a Five-Phase Permanent Magnet Synchronous Motor Drive," International Journal of Power Electronics and Drive System(IJPEDS), vol. 6, no. 4, pp. 842-852, December 2015. https://doi.org/10.11591/ijpeds.v6.i4.pp842-852
  19. M. Ahmed, F. M. Karim, M. Abdelkader, and B. Abdelber, "Input Output Linearization and Sliding Mode Control of a Permanent Magnet Synchronous Machine Fed by a Three Levels Inverter," Journal of Electrical Engineering, vol. 57, no. 4, pp. 205-210, 2006.
  20. L.-B. Li, L.-L. Sun, S.-Z. Zhang, and Q.-Q. Yang, "PMSM Speed Tracking and Synchronization of Multiple Motors Using Ring Coupling Control and Adaptive Sliding Mode Control," ISA Transactions, vol. 58, pp. 635-649, September 2015. https://doi.org/10.1016/j.isatra.2015.07.010
  21. C. Lascu and A. M. Trzynadlowski, "Combining the Principles of Sliding Mode, Direct Torque Control and Space-Vector Modulation in a High-Performance Sensorless AC Drive," IEEE Transactions on Industry Applications, vol. 40, no. 1, January/February 2004.
  22. S F.-J. Lin, Y.-C. Hung, and M.-T. Tsai, "Fault-Tolerant Control for Six-Phase PMSM Drive System Via Intelligent Complementary Sliding Mode Control Using TSKFNN-AMF," IEEE Transactions on Industrial Electronics, vol. 60, no. 12, pp. 5747-5762, December 2013. https://doi.org/10.1109/TIE.2013.2238877
  23. S. Chen, Y. Luo, and Y. Pi, "PMSM Sensorless Control with Separate Control Strategies and Smooth Switch From Low Speed to High Speed," ISA Transactions, vol. 58, pp. 650-658, September 2015. https://doi.org/10.1016/j.isatra.2015.07.013
  24. M. Jones, S. N. Vukosavic, and E. Levi, "Parallel-Connected Multiphase Multidrive Systems with Single Inverter Supply," IEEE Transactions on Industrial Electronics, vol. 56, no. 6, pp. 2047-2057, June 2009. https://doi.org/10.1109/TIE.2009.2017219
  25. H. Zhang, S. Luo, Y. Yu, and L. Liu, "Study on Series Control Method for Dual Three-Phase PMSM Based on Space Vector Pulse Width Modulation," International Journal of Control and Automation, vol. 8, no. 1, pp. 197-210, 2015. https://doi.org/10.14257/ijca.2015.8.1.18
  26. M. Jones, E. Levi, and S. N. Vukosavic, "Independent Control of Two Five-Phase Induction Machines Connected in Parallel to a Single Inverter Supply," IEEE Industrial Electronics Conference, Paris, France, pp. 1257-1262, 6-10 November 2006.
  27. D. Dujic, G. Grandi, M. Jones, and E. Levi, "A Space Vector PWM Scheme for Multi Frequency Output Voltage Generation With Multiphase Voltage-Source Inverters," IEEE Transactions on Industrial Electronics, vol. 55, no. 5, pp. 1943-1955, May 2008. https://doi.org/10.1109/TIE.2008.918468
  28. N. K. Quang, N. T. Hieu, and Q. P. Ha, "FPGA-Based Sensorless PMSM Speed Control Using Reduced-Order Extended Kalman Filters," IEEE Transactions on Industrial Electronics, vol. 61, no. 12, pp. 6574-6582, December 2014. https://doi.org/10.1109/TIE.2014.2320215
  29. Z. Xu and M. F. Rahman, "Comparison of a Sliding Observer and a Kalman Filter for Direct-Torque-Controlled IPM Synchronous Motor Drives," IEEE Transactions on Industrial Electronics, vol. 59, no. 11, pp. 4179-4188, November 2012. https://doi.org/10.1109/TIE.2012.2188252
  30. D. Xu, S. Zhang, and J. Liu, "Very-Low Speed Control of PMSM Based on EKF Estimation with Closed Loop Optimized Parameters," ISA Transactions, vol. 52, no. 6, pp. 835-843, November 2013. https://doi.org/10.1016/j.isatra.2013.06.008
  31. A. Najjar-Khodabakhsh and J. Soltani, "MTPA Control of Mechanical Sensorless IPMSM Based on Adaptive Nonlinear Control," ISA Transactions, vol. 61, pp. 348-356, March 2016. https://doi.org/10.1016/j.isatra.2016.01.004
  32. M. R. Khan and A. Iqbal, "MRAS Based Sensorless Control of a Series-Connected Five-Phase Two-Motor Drive System," Journal of Electrical Engineering & Technology, vol. 3, no. 2, pp. 224-234, 2008. https://doi.org/10.5370/JEET.2008.3.2.224
  33. M. R. Khan and A. Iqbal, "Extended Kalman Filter Based Speeds Estimation of Series-Connected Five-Phase Two-Motor Drive System," Simulation Modelling Practice And Theory, vol. 17, no. 7, pp. 1346-1360, August 2009. https://doi.org/10.1016/j.simpat.2009.05.007
  34. A. Hosseyni, R. Trabelsi, M. F. Mimouni, A. Iqbal, and R. Alammari, "Sensorless Sliding Mode Observer for a Five-Phase Permanent Magnet Synchronous Motor Drive," ISA Transactions, vol. 58, pp. 462-473, September 2015. https://doi.org/10.1016/j.isatra.2015.05.007
  35. A. Hosseyni, R. Trabelsi, S. Kumar, M. F. Mimouni, and A. Iqbal, "New Sensorless Sliding Mode Control of a Five-Phase Permanent Magnet Synchronous Motor Drive Based on Sliding Mode Observer," International Journal of Power Electronics and Drive System (IJPEDS), vol. 8, no. 1, pp. 184-203, March 2017. https://doi.org/10.11591/ijpeds.v8.i1.pp184-203
  36. W. K. Wibowo1and S.-K. Jeong, "Improved Estimation of Rotor Position for Sensorless Control of a PMSM Based on a Sliding Mode Observer," Journal of Central South University, vol. 23, no. 07, pp. 1643-1656, July 2016. https://doi.org/10.1007/s11771-016-3219-5
  37. Z. Qiao, T. Shi, Y. Wang, Y. Yan, C. Xia, and X. He, "New Sliding-Mode Observer for Position Sensorless Control of Permanent-Magnet Synchronous Motor," IEEE Transactions on Industrial Electronics, vol. 60, no. 2, February 2013.
  38. J. J. E. Slotine and W. Li, Applied Nonlinear Control, Prentice Hall, Englewood Cliffs, New Jersey, 1991.
  39. M. Jones, O. Dordevic, N. Bodo, and E. Levi, "PWM Algorithms for Multilevel Inverter Supplied Multiphase Variable-Speed Drives," Electronics, vol. 16, no. 1, pp.22-31, June 2012.
  40. D. Dujic, M. Jones, and E. Levi, "Generalized Space Vector PWM for Sinusoidal Output Voltage Generation with Multiphase Voltage Source Inverters," Int. J. Industrial Electronics and Drives, vol. 1, no. 1, pp. 1-13, 2009. https://doi.org/10.1504/IJIED.2009.025341