Journal of Advanced Marine Engineering and Technology

  • 제41권1호
  • /
  • Pages.99-104
  • /
  • 2017
  • /
  • 2234-7925(pISSN)
  • /
  • 2234-8352(eISSN)
한국마린엔지니어링학회 (The Korean Society of Marine Engineering)
권호 표지
DOI QR코드

DOI QR Code

온실 태양잉여열을 이용한 히트펌프시스템의 난방 성능평가에 관한 실증 연구

Empirical evaluation of the heating performance by a heat pump system with surplus heat from a greenhouse

  • Jeon, Byung-Yong (Faculty of Applied Energy System, Jeju National University) ;
  • Park, Youn-Cheol (Department of Mechanical Engineering, Jeju National University) ;
  • Ko, Gwang-Soo (Faculty of Applied Energy System, Jeju National University)
  • 투고 : 2016.07.27
  • 심사 : 2017.01.19
  • 발행 : 2017.01.31
PDF 다운로드
⟨ 이전 논문 다음 논문 ⟩

초록

본 연구는 태양일사에 의하여 가열되는 온실상단에 고온의 태양잉여열을 축열조에 축열한 후 이를 이용하여 온실을 난방하는 히트펌프시스템의 실증연구에 관한 것으로 히트펌프시스템은 축열조를 구비하고, 각종 열교환을 위한 판형열교환기, 팬코일유닛 그리고 부가적인 에너지원으로 태양일사를 직접 집열할 수 있는 태양집열기로 구성되어 있다. 히트펌프시스템은 R410a냉매를 사용하며 일반적인 히트펌프시스템과 마찬가지로 외기열원만으로도 운전될 수 있으며, 온실내부의 설정온도에 따른 제어로직에 따라 외부조작없이 온실상단열의 축열운전, 외기공기에 의한 외기열원 및 축열조의 온수를 히트펌프의 작동 없이 난방하는 다수의 운전방식이 자동적으로 운전되도록 하였다. 개발된 축열식 히트펌프의 현장평가 성능실험을 위하여 제주시 조천리에 있는 $100m^2$ 크기의 온실에 설치하고 10월부터 12월까지 운전하였다. 실증연구 실험을 수행한 결과로써 외기열원을 이용하여 난방 할 경우 난방열량은 19.9 kW의 용량을 얻을 수 있었으며, 온실상단의 잉여열에 의하여 축열조의 온수로 히트펌프운전 없이 직접 난방 할 경우에 난방열량은 21.4 kW로 외기난방과 비슷한 난방용량을 나타내는 것을 알 수 있었다.

This study evaluated the heating performance of a hybrid heat pump system. The system was installed in a $100-m^2$ greenhouse to utilize surplus solar energy. A hybrid heat pump system was installed at Jocheon-ri, Jeju Island, for an empirical evaluation of the performance. The system consists of a heat storage tank and plate heat exchangers for several heat exchanges between the greenhouse and heat pump or storage tank. The system uses R410a as the working fluid and is controlled automatically by a defined set temperature of the greenhouse. This system incorporates two kinds of heat sources: outdoor air and a storage tank that collects heat from the topside of the greenhouse. The results showed that the heating capacity was 19.9 kW in the outdoor air source mode and 21.4 kW with direct heating from hot water in the thermal storage tank. These results are very similar to those of a previous study.

키워드

참고문헌

  1. J. H. Youn, Greenhouse Energy Reduction Guide Book, RDA, 2008 (in Korean).
  2. Y. S. Ryou, Y. K. Jang, J. K. Kim, Y. H. Kim, J. G. Kim, and G. C. Kang, "Heat exchanger design of a heat pump system using the heated effluence of thermal power generation plant as a heat source for greenhouse heating," Journal of Bio-Environment Control, vol. 21, no. 4, pp. 372-377, 2012 (in Korean). https://doi.org/10.12791/KSBEC.2012.21.4.372
  3. Y. K. Kang, Y. S. Ryou, J. G. Kim, Y. H. Kim, and J. K. Jang, "Analysis on cooling effects of the vertical type geothermal heat pump system installed in a greenhouse for raising seedling," Protected Horticulture and Plant Factory, vol. 22, no. 1, p. 19, 2013 (in Korean). https://doi.org/10.12791/KSBEC.2013.22.1.019
  4. J. H. Lim, "Study on the evaluation on the energy and energy performance of heat pump heating and cooling system," Korean Institute of Architectural Sustainable Environment and Building Systems, vol. 6, no. 2, pp. 12-16, 2012 (in Korean).
  5. G. L. Morrison, I. Budihardjo, and M. Bhnia, "Water in glass evacuated tube solar water heaters," Solar Energy, vol. 76, no. 1-3, pp. 135-140, 2004. https://doi.org/10.1016/j.solener.2003.07.024
  6. S. B. Riffat, X. Zhao, and P. S. Doherty, "Developing a theoretical model to investigate thermal performance of a thin membrane heat pipe solar collector," Applied Thermal Engineering, vol. 25, no. 5-6, pp. 899-915, 2005. https://doi.org/10.1016/j.applthermaleng.2004.08.010
  7. Y. J. Nam and X. Y. Gao, "Study on the performance prediction simulation of the heat pump system using solar and geothermal heat source," Journal of the Korean Solar Energy Society, vol. 34, no. 3, pp. 75-81, 2014. https://doi.org/10.7836/KSES.2014.34.3.075
  8. K. H. Jo, Y. C. Park, and G. S. Ko, "A study on the performance evaluation of heat pump system using waste heat in greenhouse," Journal of the Korean Solar Energy Society, vol. 335, no. 4, pp. 35-41, 2015 (in Korean).
  9. J. K. Kwon, Y. H. Choi, D. K. Park, J. H. Lee, K. Y. Kang, and Y. C. Um, "Survey on insulation and heating of greenhouse grown fruit vegetables in southern region," Korean Society for Horticultural Science, vol. 17, no. 2, p. 218, 1999 (in Korean).
  10. H. K. Song, J. G. Ro, J. K. Park, Y. K. Kang, and H. C. Kim, "A study on the heat pump - Latent heat storage system for the greenhouse heating," Proceeding of Korean Society for Agricultural Machinery, pp. 113-120, 1997 (in Korean).
  11. S. A. Kalogirou, "The potential of solar industrial process heat applications," Applied Energy, vol. 76, no. 4, pp. 337-361, 2003. https://doi.org/10.1016/S0306-2619(02)00176-9