Journal of the Korean Geotechnical Society (한국지반공학회논문집)

Korean Geotechnical Society (한국지반공학회)
권호 표지
DOI QR코드

DOI QR Code

A Study on the Concrete Lining Behavior due to Tunnel Deterioration

터널 열화로 인한 콘크리트 라이닝의 거동에 관한 연구

  • Received : 2013.09.11
  • Accepted : 2014.04.10
  • Published : 2014.04.30
Download PDF
⟨ Previous Next ⟩

Abstract

This paper studies the time-dependent behaviors of tunnel and surrounding ground due to tunnel deterioration. In the first part, the literature on deterioration characteristics of tunnels was reviewed. In the second part, a numerical analysis was performed to investigate the behavior of concrete lining on the typical section of Korean high-speed rail tunnel (weathered rock) after determination of input variables related to deterioration impact. The result shows that the settlement at the crown of tunnel and surface ground increased up to 7.0% and 30.2% of the total settlements during construction stage, respectively, and the internal convergence reduction of 9.0 mm for concrete linings was generated within 30 years after completion of tunnel construction. Also the loosening height increased up to 2.55 times of tunnel height within 50 years, which is higher than that of Terzaghi's recommendation on ultimate state. Due to this process of extending zones, it is found that additional loads were applied to concrete lining with the axial stress about 3.20~3.66 MPa, which accelerates tunnel deterioration. Finally the quantitative design approach to evaluate time-dependent behavior of lining and surrounding ground due to tunnel deterioration was proposed.

본 연구는 터널 열화 특성과 이와 관련된 각종 문헌 및 사례조사를 통하여 비교 분석하고 정량적인 해석을 위한 영향인자를 도출하여 입력변수를 결정하고 국내 고속철도 터널의 대표단면(풍화암)에 대하여 수치해석을 실시하였다. 해석 결과는 공용 후 30년 경과 시 열화로 인하여 천단침하량은 7.0%, 지표침하량은 30.2%이 증가하고 내공변위는 9.0mm가 수축 한 이후 점차 수렴되는 경향을 보였다. 또한 이완하중고는 공사 완료 후 50년 경과 시 터널고의 2.55배까지 증가하여 극한상태에서의 Terzaghi의 제안값 보다 상당히 큰 값을 나타내었으며, 이러한 소성영역의 확장으로 인하여 터널 라이닝에 3.20~3.66MPa의 축응력이 추가로 작용하게 되는 경향을 확인하였다. 따라서 이로부터 설계에 반영할 수 있는 정량적인 예측기법을 제안하였다.

Keywords

References

  1. Akutagawa, S., Kitani, T., Abe, Y. and Sakurai, S. (1998), "A consideration on tunnel pressure derived from the Terzaghi's formula based on an equilibrium assumption in a limit state", Proceedings of Tunnel Engineering, JSCE, pp.95-100 (in Japanese).
  2. Barla, G. (2000), "Analysis and design methods of tunnels in squeezing rock conditions", Rivista Italiana Di Geotecnica, 1/2000, pp.22-29.
  3. Boidy, E., Bouvarda, A. and Pelletb, F. (2002), "Back analysis of time-dependent behaviour of a test gallery in claystone." Tunnelling and Underground Space Technology, Vol.17, Issue 4, October 2002, pp.415-424. https://doi.org/10.1016/S0886-7798(02)00066-4
  4. BTS/ICE (2004), "Tunnel lining design guide." The British Tunnelling Society and The Institution of Civil Engineers, Thomas Telford Ltd., London.
  5. Carde, C. and Francois, R. (1997), "Effect of the leaching of calcium hydroxide from cement paste on mechanical and physical properties." Cement Concrete Research, 27(4) pp.539-550. https://doi.org/10.1016/S0008-8846(97)00042-2
  6. CETu (2004), "Guide de l΄inspection du genie civil des tunnels routiers." Des desordre vers le diagnostic, Centre d'Etudes des Tunnels, France.
  7. CETu (2011), "Guide de l΄inspection du genie civil des tunnels routiers." Du desordre a l'analyse, de l'analyse a la cotatio, mai 2011, Centre d'Etudes des Tunnels, France.
  8. Choo, J.H., Park, S.W., Kim, H.T., Jee, K.H. nad Yoon, T.G. (2011), "Analysis and cause of occurrence of lining cracks on NATM tunnel based on the precise inspection for safety and diagnosis-Part I", Korean Tunelling and Underground Space Association, Vol.13, No.3, May 2011, pp.199-214.
  9. CHSRA (2010), "TECHNICAL MEMORANDUM, High-Speed Train Tunnel TM 2.4.5." California High-Speed Train Project, California High-Speed Rail Authority.
  10. Constantinescu, M. and Cristescu, N. (1983), "Creep of rock-like materials." International Journal of Engineering Science, Vol.21, Issue 1, 1983. pp.45-49. https://doi.org/10.1016/0020-7225(83)90038-1
  11. DAUB (2001), "Concrete Linings for Tunnel built by underground Construction." Recommendations by DAUB, Tunnel 5/2001, pp.50-66.
  12. Deutsche Bahn AG (2007), "Richtlinie 853: Eisenbahntunnel planen, bauen und instand halten." Frankfurt am Main.
  13. FHWA (2009), "Technical Manual for Design and Construction of Road Tunnels-Civil Elements." Federal Highway Administration, FHWA-NHI-10-034, Washington, D.C.
  14. Grobbelaar, C. (1994), "The degradation and failure of concrete linings around water conveyance tunnels" Tunnelling and Underground Space Technology, Vol.9(1), pp.67-71. https://doi.org/10.1016/0886-7798(94)90011-6
  15. Guan, Z., Jiang. and Tanabashi., Y. (2008), "Rheological parameter estimation for the prediction of long-term deformations in conventional tunnelling." Tunnelling and Underground Space Technology, Vol.24(3), pp.250-259.
  16. Hagelia, P. (2011), "Deterioration Mechanisms and Durability of Sprayed Concrete for Rock Support in Tunnels." PhD Thesis, Delft University of Technology.
  17. Jiang, Y., Fujisaki, M., Kawata, M. and Tanabashi, Y. (2005), "Deformation Prediction and Effect of Reinforcement Method by Considering Time Dependency of Rock Strength." NAOSITE, Nagasaki University's Academic Output SITE, Vol.35(65), pp.95-100 (in Japanese).
  18. Jiang, Y., Tanabashi, Y. and Kawata, A. (2007), "Simulation Models for Tunnel Convergence Prediction and Appraisement of Different Reinforcement Methods." NAOSITE, Nagasaki University's Academic Output SITE, Vol.37(68), pp.73-82 (in Japanese).
  19. Jung, H.S., Kim, D.K., Lee, G.P. Lee S.T. and Kim, S.S. (2007), "Deterioration Assessment and Case Study of Deteriorated ASSM Support in Tunnl." Korea Concrete Institute, 2007 Spring Seminar, pp.743-746.(in Korean)
  20. Kawata, A., Jiang, Y. and Tanabashi, Y. (2005), "Deformation Prediction and Effect of Reinforcing Method by Considering Strength Deterioration of Rocks." Journal of tunnel engineering, JSCE 15, pp.31-38 (in Japanese).
  21. KICT (2012), "A Study on the Optimized Design of Railroad Tunnel Lining." Final Joint Research Report, KICT/Yonsei University. 2012. 02.
  22. KISTEC (1997), "Evaluation of the cause of longitudinal cracks and the method of repairments and reinforcements for NATM tunnel," Korea Infrastructure Safety & Technology Corporation, Research Report (in Korean).
  23. KISTEC (2003), "A study on the measurements of in-situ stresses for tunnels in Service," Korea Infrastructure Safety & Technology Corporation, Research Report (in Korean).
  24. Ladanyi, B. (1974), "Use of the long-term strength concept in the determination of ground pressure on tunnel linings." Proceedings of the 3rd international congress on rock mechanics, National Academy of Sciences, Denver, pp.1150-1156.
  25. Ladanyi, B. (1980), "Direct determination of ground pressure on tunnel lining in a non-linear viscoelastic rock." Proceedings of the 13th Canadian rock mechanics symposium, CIM, Montreal, pp.126-132.
  26. Lenz, F., Marcher, T. and Neumayr, T. (2010), "A9 Bosruck Tunneldesign approaches for swelling rock." Geomechanics and Tunnelling, Vol.3, Issue 5, pp.597-608. https://doi.org/10.1002/geot.201000055
  27. Mainguy, M. and Coussy, O. (2000), "Propagation Fronts during Calcium Leaching and Chloride Penetration." J. Eng. Mech., Vol. 126(3), pp.250-257. https://doi.org/10.1061/(ASCE)0733-9399(2000)126:3(250)
  28. Marcher, T. (2011), "Tunnel Design and Construction Practice: Technical Solutions in Swelling Ground" Workshop UPC: Tunnelling through Saline and Swelling Ground, iLF Cosulting Engineers.
  29. Matsunaga, T. (2008), "Study on Prediction of Tunnel Deformation and Rationalization of Measures", PhD These, Kyoto University (in Japanese).
  30. Nakagawa, M., Jiang, Y., Sato, M. and Tanabashi, Y. (2004), "Deformation Simulation of Tunnel by Considering Time Dependency of Rock Strength." Soil mechanics and foundation engineering, JGS, 52(6), A6, pp.28-30 (in Japanese).
  31. Nguyen, V. H. (2005), "Couplage degradation chimique-comportement en compression du beton." PhD These, Ecole des Paris Tech.
  32. Osgoui, R.R. (2006), "On the Assessment of the Effect of the Anisotropy in in-situ Stress on Support Pressure in Tunnels." Proc. Int. Symp. In-Situ Rock Stress, ISRM, Trondheim, Norway, pp. 307-317.
  33. Phienwej, N., Thakur, P.K. and Cording, E.J. (2007), "Time-Dependent Response of Tunnels Considering Creep Effect." Int. J. Geomech., 7(4), pp.296-306. https://doi.org/10.1061/(ASCE)1532-3641(2007)7:4(296)
  34. Sandrone, F. and Labiouse, V. (2010), "Analysis of the evolution of road tunnels equilibrium conditions with a convergence-confinement approach." Rock Mechanics and Rock Engineering, Vol.43, Issue 2, pp.201-218. https://doi.org/10.1007/s00603-009-0056-y
  35. Sato, M. and Kamemura, K. (1984), "A Study on Time Dependency of Rock Strength." Japanese Geotechnical Society, Vol.19, pp. 783-784 (in Japanese).
  36. Seo, K.C. (2002), "Present condition of crack and analysis of conrete lining of tnnels," J. of the Korea institute for structural maintenance inspection, v.6 no.3, pp.22-29.
  37. Terzaghi, K. (1946), "Rock Defects and Loads on Tunnel Supports: In Rock Tunneling with Steel Supports by Proctor, R. V. and White, T. L." Commercial Shearing Co., Ohio, pp.17-99.
  38. Usman, M., Volderauer, C., Gschwandtner, G. and Galler, R. (2011), "Three Dimensional Load Analysis of Tunnel Linings Including Weathering Processes of the Shotcrete." BHM, December 2011, Vol.156(12), pp.487-491.
  39. Yashiro, K., Shimamoto, K., Kojima, Y., Takahashi, M., Matsunaga, T. and Asakura, T. (2009), "A study on simulation analyses of deformed tunnels due to earth pressure by ground strength reduction model and it's applicability to long term prediction." Journal of JSCE, Divi. C, Vol.65, No.2, pp.467-479 (in Japanese).
  40. Yokozeki, K., Watanabe, K., Sakata, N. and Otsuki, N. (2004), "Modeling of leaching from cementitious materials used in underground environment." Applied Clay Science, Volu. 26, Issues 1-4, August 2004, pp.293-308. https://doi.org/10.1016/j.clay.2003.12.027

Cited by

  1. Review on the buoyancy effect of the multi purpose double-deck tunnels during operation vol.17, pp.6, 2015, https://doi.org/10.9711/KTAJ.2015.17.6.623
  2. Estimation of subsea tunnel stability considering ground and lining stiffness degradation measurements vol.18, pp.5, 2016, https://doi.org/10.9711/KTAJ.2016.18.5.389
  3. Back analysis of an operating subsea tunnel considering the degradation of ground and concrete lining pp.1521-0618, 2018, https://doi.org/10.1080/1064119X.2018.1427817
  4. 에틸렌글리콜법을 활용한 국내 순환유동층보일러 석탄회의 Free CaO 평가 연구 vol.26, pp.1, 2017, https://doi.org/10.5855/energy.2017.26.1.001
  5. 정밀안전진단 결과를 활용한 NATM (철근)의 라이닝 결함 종류별 발생원인 및 분석 - Part I vol.21, pp.1, 2014, https://doi.org/10.9711/ktaj.2019.21.1.001
  6. 지반공학 분야에 대한 차분진화 알고리즘 적용성 분석 vol.35, pp.4, 2014, https://doi.org/10.7843/kgs.2019.35.4.27