산업경영시스템학회지 (Journal of Korean Society of Industrial and Systems Engineering)

  • 제35권2호
  • /
  • Pages.30-36
  • /
  • 2012
  • /
  • 2005-0461(pISSN)
  • /
  • 2287-7975(eISSN)
한국산업경영시스템학회 (Society of Korea Industrial and System Engineering)
권호 표지

비대칭무게중심을 지닌 물체 들기 작업시 허리부위 등근육 부하 및 피로 분석

The Analysis of Low Back Loading and Muscle Fatigue while Lifting an Asymmetric Load

  • 한승조 (단국대학교 공학대학 산업공학과) ;
  • 김선욱 (단국대학교 공학대학 산업공학과)
  • Han, Seung-Jo (Department of Industrial Engineering, Dankook University) ;
  • Kim, Sun-Uk (Department of Industrial Engineering, Dankook University)
  • 투고 : 2012.03.02
  • 심사 : 2012.05.14
  • 발행 : 2012.06.30
PDF 다운로드
⟨ 이전 논문 다음 논문 ⟩

초록

This study is aimed to show that an asymmetric load in the frontal plane leads to an increase in low back loading and fatigue in comparison with a symmetric load when workers lift an external weight by investigating previous studies and verifying the phenomenon with an experiment. Ten male subjects are required to lift and hold an given external load at 70cm height during 50sec, then the EMG amplitude and median frequency on bilateral low back muscle groups (Longissimus, Iliocostalis, and Multifidus) are recorded and analyzed. Independent variables are two-level load weight (13kg, 20kg) and three-level LCG (Center, 6.5cm to the right, and 13cm to the right), and dependent variables are EMG amplitude average, difference, and Fatigue Index (FI). Results show that load weight increases significantly amplitude average and FI, but LCG does significantly amplitude difference and FI significantly (P-value < 0.05). Also the correlation coefficient between amplitude difference and FI is over 0.99. These implies that trunk loading should be explained by not EMG amplitude but muscle fatigue aspect since the association between an external load and amplitude is linear, but the relationship between an external load and median frequency as muscle fatigue index is almost exponential.

키워드

참고문헌

  1. 김홍기; "한 손 들기 작업과 양 손 들기 작업의 근력 능력 비교 연구", 대한인간공학회지, 26(3) : 35-44, 2007.
  2. 노동부; "2010년도 산업재해 현황분석", 2011.
  3. 송영희, 권오윤; "관절각도에 따른 근 피로도와 등 척성 훈련 전이효과", 대한인간공학회지, 25(4) : 93-101, 2006.
  4. 여민우, 이동춘; "좌식 작업에 있어서 슬관절 각도 변화에 따른 하지 근력 및 압력분포 분서에 관한 연구", 대한인간공학회지, 27(1) : 53-60, 2008.
  5. 원종임; "등속성 운동시 근전도 주파수 분석에서 얻은 피로지수의 특성", 연세대학교박사학위논문, 2001.
  6. Butter, D., Anderson, G. B. J., Trafimow, J., Schipplein., O. D., and Andriacchi, T. P.; "The influence of load knowledge on lifting technique," Ergonomics, 36(12) : 1489-1493, 1993. https://doi.org/10.1080/00140139308968016
  7. Chaffin, D. B., Andersson, G. B. J., and Martin, B. J.; Occupational Biomechanics, 4th Edition, John Wiley and Sons, Inc., New Jersey, 131-136, 2006.
  8. Commissaris, D. A. C. M. and Toussaint, H. M.; "Load knowledge affects low back loading and control of balance in lifting tasks," Ergonomics, 40(5) : 559-575, 1997. https://doi.org/10.1080/001401397188035
  9. Coorevits, P. L. M., Danneels, L. A., Ramon, R. Van Audekercke., Cambier, D. C., and Vanderstaeten, G. G.; "Statistical modeling of fatigue-related electromyographic median frequency characteristics of back and hip muscles during a standardized isometric back extension test," Journal of Electrophyography and Kinesiology, 15 : 444-451, 2005. https://doi.org/10.1016/j.jelekin.2005.02.002
  10. Cram, J. R. and Steger, J. C.; "EMG scanning in the diagonosis of chronic pain," Biofeedback and self-regulation, 8(2) : 223-241, 1983.
  11. Dolan, P. and Adams, A.; "The relationship between EMG activity and extensor moment generation in the elector spinae muscles during bending and lifting activities," Journal of Biomechanics, 26 : 13-522, 1993.
  12. Mannion, A. F., Connolly, B., Wood, K., and Dolan, P.; "The use of surface EMG power spectral analysis in the evaluation of back muscle function," Journal of Rehabilitation Research and Development, 34(4) : 427-439, 1997.
  13. Mannion, A. F. and Dolan, P.; "The effects of muscle length and force output on the EMG power spectrum of the elector spinae," J. Electromyogr. Kinesiol, 6(3) : 159-168, 1996. https://doi.org/10.1016/1050-6411(95)00028-3
  14. Marras, W. S., Davis, K. G., and Granata, K. P.; "Trunk muscle activities during asymmetric twisting motions," Journal of Electromyography and Kinesiology, 8 : 247-256, 1998. https://doi.org/10.1016/S1050-6411(98)00011-X
  15. Mital, A. and Fard, F.; "Psychophysical and physiological responses to lifting symmetrical and asymmetrical loads symmetrically and asymmetrically," Ergonomics, 29(10) : 1263-1272, 1986. https://doi.org/10.1080/00140138608967239
  16. Ng, J. K.-F., Richard, C. A., and Jull, G. A.; "Electromyography amplitude and fatigue changes in the iliocostalis lumborum and multifidus muscles during a trunk holding test," Physical Therapy, 77(9) : 954-961, 1997. https://doi.org/10.1093/ptj/77.9.954
  17. Noone, G., Mazumdar, J., Ghista, D. N., and Tansley, G. D.; "Asymmetrical loads and lateral bending of the human spine," Med.&Bio.Eng.Comput., 21 : 131-136, 1997.
  18. Nordin, M., Andersson, G. B. J., and Pope, M. H.; Musculoskeletal Disorders in the Workplace, 2nd Edition, Mosby-Year Book, Inc., Missouri, 87, 1997.
  19. Reid, D. A. and McNair, P. J.; "Factors contributing to low back pain in rowers," Br. j. Sports Med., 34(5) : 321-322, 2000. https://doi.org/10.1136/bjsm.34.5.321
  20. Roy, S. H., De Luca, C. J., Snyder-Mackler, L. Emley, M. S., Crenshaw, R. L., and Lyons, J. P.; "Fatigue, recovery, and low back pain in varsity rowers," Medicine and Science in Sports and Exercise, 22(4) : 463-469, 1990.
  21. Seroussi, R. E. and Pope, M. H.; "The relationship between trunk muscle electromyography and lifting moments in the sagittal and frontal planes," Biomechanics, 20(2) : 135-146, 1987. https://doi.org/10.1016/0021-9290(87)90305-8
  22. Shin, G., Shu, Y., Li, Z., Jiang, Z., and Mirka, G.; "Influence of knee angle and individual flexibility on the flexion-relaxation response of the low back musculature," Journal of Electromyograhpy and Kinesiology, 14 : 485-494, 2004. https://doi.org/10.1016/j.jelekin.2003.12.001
  23. Winter, D. A.; Biomechanics and motor control of human movement, 4th Edition, John Wiley and Sons, Inc., New Jersey, 269-277, 2009.