Journal of Pharmaceutical Investigation

The Korean Society of Pharmaceutical Sciences and Technology (한국약제학회)
권호 표지
DOI QR코드

DOI QR Code

Rheological Properties of Antiphlamine-S® Lotion

안티푸라민-에스® 로션의 레올로지 특성 연구

  • Kuk, Hoa-Youn (Department of Organic Material Science and Engineering, School of Chemical Engineering, Pusan National University) ;
  • Song, Ki-Won (Department of Organic Material Science and Engineering, School of Chemical Engineering, Pusan National University)
  • 국화윤 (부산대학교 응용화학공학부 유기소재시스템공학과) ;
  • 송기원 (부산대학교 응용화학공학부 유기소재시스템공학과)
  • Published : 2009.06.20
Download PDF
⟨ Previous Next ⟩

Abstract

Using a strain-controlled rheometer [Advanced Rheometric Expansion System (ARES)], the steady shear flow properties and the dynamic viscoelastic properties of $Antiphlamine-S^{(R)}$ lotion have been measured at $20^{\circ}C$ (storage temperature) and $37^{\circ}C$ (body temperature). In this article, the temperature dependence of the linear viscoelastic behavior was firstly reported from the experimental data obtained from a temperature-sweep test. The steady shear flow behavior was secondly reported and then the effect of shear rate on this behavior was discussed in detail. In addition, several inelastic-viscoplastic flow models including a yield stress parameter were employed to make a quantitative evaluation of the steady shear flow behavior, and then the applicability of these models was examined by calculating the various material parameters. The angular frequency dependence of the linear viscoelastic behavior was nextly explained and quantitatively predicted using a fractional derivative model. Finally, the strain amplitude dependence of the dynamic viscoelastic behavior was discussed in full to elucidate a nonlinear rheological behavior in large amplitude oscillatory shear flow fields. Main findings obtained from this study can be summarized as follows : (1) The linear viscoelastic behavior is almostly independent of temperature over a temperature range of $15{\sim}40^{circ}C$. (2) The steady shear viscosity is sharply decreased as an increase in shear rate, demonstrating a pronounced Non-Newtonian shear-thinning flow behavior. (3) The shear stress tends to approach a limiting constant value as a decrease in shear rate, exhibiting an existence of a yield stress. (4) The Herschel-Bulkley, Mizrahi-Berk and Heinz-Casson models are all applicable and have an equivalent validity to quantitatively describe the steady shear flow behavior of $Antiphlamine-S^{(R)}$ lotion whereas both the Bingham and Casson models do not give a good applicability. (5) In small amplitude oscillatory shear flow fields, the storage modulus is always greater than the loss modulus over an entire range of angular frequencies tested and both moduli show a slight dependence on angular frequency. This means that the linear viscoelastic behavior of $Antiphlamine-S^{(R)}$ lotion is dominated by an elastic nature rather than a viscous feature and that a gel-like structure is present in this system. (6) In large amplitude oscillatory shear flow fields, the storage modulus shows a nonlinear strain-thinning behavior at strain amplitude range larger than 10 % while the loss modulus exhibits a weak strain-overshoot behavior up to a strain amplitude of 50 % beyond which followed by a decrease in loss modulus with an increase in strain amplitude. (7) At sufficiently large strain amplitude range (${\gamma}_0$>100 %), the loss modulus is found to be greater than the storage modulus, indicating that a viscous property becomes superior to an elastic character in large shear deformations.

Keywords

References

  1. J.H. Kim, K.W. Song, J.O. Lee and C.H. Lee, Studies on the flow properties of semi-solid dosage forms (I) : Steady shear flow behavior of toothpastes, J. Korean Pharm. Sci., 25, 213-221 (1995)
  2. J.H. Kim, K.W. Song, G.S. Chang, J.O. Lee and C.H. Lee, Studies on the flow properties of semi-solid dosage forms (II) : Temperature-dependent flow behavior of vaseline, J. Pharm. Soc. Korea, 41, 38-47 (1997)
  3. B.W. Barry and M.C. Meyer, Sensory assessment of spreadability of hydrophilic topical preparations, J. Pharm. Sci., 62, 1349-1354 (1973) https://doi.org/10.1002/jps.2600620828
  4. M.L. De Martine and E.L. Cussler, Predicting subjective spreadability, viscosity and stickiness, J. Pharm. Sci., 64, 976-982 (1975) https://doi.org/10.1002/jps.2600640618
  5. R. Brummer, Rheology essentials of cosmetic and food emulsions, Springer-Verlag, Berlin (2006)
  6. M.D. Planas, F.G. Rodriguez, R.B. Maximinno and J.V.H. Dominguez, Thixotropic behavior of a microcrystalline cellulose-sodium carboxymethyl cellulose gel, J. Pharm. Sci., 77, 799-801 (1988) https://doi.org/10.1002/jps.2600770917
  7. G.B. Thurston and A. Martin, Rheology of pharmaceutical system : Oscillatory and steady shear of non-Newtonian viscoelastic liqiuds, J. Pharm. Sci., 67, 1499-1506 (1978) https://doi.org/10.1002/jps.2600671103
  8. J. Ceulemans, L.V. Santvliet and A. Ludwig, Evaluation of continuous shear and creep rheometry in the physical characterisation of ointmets, Int. J. Pharm., 176, 187-202 (1999) https://doi.org/10.1016/S0378-5173(98)00319-6
  9. C. Viseras, G.H. Meeten and A. Lopez-Galindo, Pharmaceutical grade phyllosilicate dispersions : The influence of shear history on floc structure, Int. J. Pharm., 182, 7-20 (1999) https://doi.org/10.1016/S0378-5173(99)00075-7
  10. S. Ishikawa and M. Kobayashi, Effect of the powder addition to carboxyvinyl polymer hydrogel on viscoelasticity, Chem. Pharm. Bull., 40, 1897-1901 (1992) https://doi.org/10.1248/cpb.40.1897
  11. L. Bromberg, M. Temchenko, V. Alakhov and T.A. Hatton, Bioadhesive properties and rheology of polyether-modified poly(acrylic acid) hydrogels, Int. J. Pharm., 282, 45-60 (2004) https://doi.org/10.1016/j.ijpharm.2004.05.030
  12. V.S. Rudraraju and C.M. Wyandt, Rheology of microcrystalline cellulose and sodium carboxymethyl cellulose hydrogels using a controlled stress rheometer (part II), Int. J. Pharm., 292, 63-73 (2005) https://doi.org/10.1016/j.ijpharm.2004.10.012
  13. K.S. Anseth, C.N. Bowman and L. Brannon-Peppas, Mechanical properties of hydrogels and their experimetal determination, Biomaterials, 17, 1647-1657 (1996) https://doi.org/10.1016/0142-9612(96)87644-7
  14. D.S. Jones, Dynamic mechanical analysis of polymeric systems of pharmaceutical and biomedical significance, Int. J. Pharm., 179, 167-178 (1999) https://doi.org/10.1016/S0378-5173(98)00337-8
  15. K.W. Song, H.Y. Kuk and G.S. Chang, Rheology of concentrated xanthan gum solutions : Oscillatory shear flow behavior, Korea-Australia Rheol. J., 18, 67-81 (2006)
  16. L. Ma and G.V. Barbosa-Canovas, Simulating viscoelastic properties of selected food gums and gum mixtures using a fractional derivative model, J. Texture Studies, 27, 307-325 (1996) https://doi.org/10.1111/j.1745-4603.1996.tb00077.x
  17. A.B. Metzner, Rheology of suspensions in polymeric liquid, J. Rheol., 29, 739-775 (1985) https://doi.org/10.1122/1.549808
  18. J.C. Boylan, Rheological study of selected pharmaceutical semisolids, J. Pharm. Sci., 55, 710-715 (1966) https://doi.org/10.1002/jps.2600550708
  19. S.S. Davis, Viscoelastic properties of pharmaceutical semisolid II : Creams, J. Pharm. Sci., 58, 418-421 (1969) https://doi.org/10.1002/jps.2600580405
  20. G.W. Radebaugh and A.P. Simonelli, Phenomenological viscoelasticity of a heterogeneous pharmaceutical semisolid, J. Pharm. Sci., 72, 415-422 (1983) https://doi.org/10.1002/jps.2600720423
  21. G.W. Radebaugh and A.P. Simonelli, Temperature-frequency equivalence of the viscoelastic properties of anhydrous lanolin USP, J. Pharm. Sci., 72, 422-425 (1983) https://doi.org/10.1002/jps.2600720424
  22. S.L. Rosen, Fundamental principles of polymeric materials, Wiley Interscience, New York (1993)
  23. E.B. Vadas, H.L. Goldsmith and S.G. Mason, The microrheology of colloidal dispersions. III. Concentrated emulsions, Trans. Soc. Rheol., 30, 373-407 (1976) https://doi.org/10.1122/1.549431
  24. P. Sherman, Proceedings of the fourth international congress on rheology, E.H. Lee Ed., Interscience, New York (1965)
  25. E.G. Richardson, Flow properties of disperse systems, J.J. Hermans Ed., North-Holland, Amsterdam (1953)
  26. C.D. Han and R.G. King, Measurement of the rheological properties of concentrated emulsions, J. Rheol., 24, 213-237 (1980) https://doi.org/10.1122/1.549562
  27. A.Y. Malkin, I. Masalova, P. Slatter and K. Wilson, Effect of droplet size on the rheological properties of highlyconcentrated w/o emulsions, Rheol. Acta, 43, 584-591 (2004) https://doi.org/10.1007/s00397-003-0347-2
  28. I. Masalova and A.Y. Malkin, Flow of super-concentrated emulsions, AIP Conf. Proc., 832, 412-418 (2006) https://doi.org/10.1063/1.2204533
  29. I. Masalova and A.Y. Malkin, Peculiarities of rheological properties and flow of highly concentrated emulsions : The role of concentration and droplet size, Colloid J., 69, 206-219 (2007) https://doi.org/10.1134/S1061933X0702007X
  30. S.R. Derkatch, S.M. Levachov, A.N. Kuhkushkina, N.V. Novosyolova, A.E. Kharlov and V.N. Matveenko, Rheological properties of concentrated emulsions stabilized by globular protein in the presence of nonionic surfactant, Colloids Surf., 298, 225-234 (2007) https://doi.org/10.1016/j.colsurfa.2006.10.066
  31. T.G. Mason, J. Bibette and D.A. Weitz, Yielding and flow of monodisperse emulsions, J. Colloid Interface Sci., 179, 439-448 (1996) https://doi.org/10.1006/jcis.1996.0235
  32. R. Pal, Dynamic of flocculated emulsion, Chem. Eng. Sci., 52, 1177-1187 (1997) https://doi.org/10.1016/S0009-2509(96)00451-4
  33. P. Manoj, A.D. Watson, D.J. Hibberd, A.J. Fillery-Travis and M.M. Robins, Characterization of a depletion-flocculated polydisperse emulsion. II. Steady-state rheological investigations, J. Colloid Interface Sci., 207, 294-302 (1998) https://doi.org/10.1006/jcis.1998.5802
  34. T.G. Mason, New fundamental concepts in emulsion rheology, Curr. Opin. Colloid Interface Sci., 4, 231-238 (1999) https://doi.org/10.1016/S1359-0294(99)00035-7
  35. I. Masalova, A.Y. Malkin, P. Slatter and K. Wilson, The rheological characterization and pipeline flow of high concentration water-in-oil emulsions, J. Non-Newt. Fluid Mech., 112, 101-114 (2003) https://doi.org/10.1016/S0377-0257(03)00064-8
  36. R. Brummer and S. Godersky, Rheological studies to objectify sensations occurring when cosmetic emulsions are applied to the skin, Colloids Surf., 152. 89-94 (1998)
  37. K.W. Song, Y.J. Kim and C.H. Lee, Rheological behavior of semi-solid ointment base (vaseline) in steady shear flow fields, J. Korean Pharm. Sci., 37, 137-148 (2007)
  38. H.A. Barnes and K. Walters, The yield stress myth?, Rheol. Acta, 24, 323-326 (1985) https://doi.org/10.1007/BF01333960
  39. H.A. Barnes, The yield stress : A review of '$\pi\;\alpha\;\beta\;\nu\;\tau\;\alpha\;\rho\;\varepsilon\;\iota$' - Everything flows?, J. Non-Newt. Fluid Mech., 81, 133-178 (1999). https://doi.org/10.1016/S0377-0257(98)00094-9
  40. H. Zhu, Y.D. Kim and D. De Kee, Non-Newtonian fluids with a yield stress, J. Non-Newt. Fluid Mech., 129, 177-181 (2005) https://doi.org/10.1016/j.jnnfm.2005.06.001
  41. P.H.T. Uhlherr, J. Guo, C. Tiu, X.M. Zhang, J.Z.Q. Zhou and T.N. Fang, The shear-induced solid-liquid in yield stress materials with chemically different structures, J. Non-Newt. Fluid Mech., 125, 101-119 (2005) https://doi.org/10.1016/j.jnnfm.2004.09.009
  42. H. Zhu and D. De Kee, A numerical study for the cessation of Couette flow of non-Newtonian fluids with a yield stress, J. Non-Newt. Fluid Mech., 143, 64-70 (2007) https://doi.org/10.1016/j.jnnfm.2007.01.006
  43. D.M.A. Buzza, C.-Y.D. Lu and M.E. Cates, Linear shear rheology of incompressible foams, J. Phys. II (France), 5, 37-52 (1995) https://doi.org/10.1051/jp2:1995112
  44. K.W. Song and G.S. Chang, Steady shear flow and dynamic viscoelastic properties of semi-solid food materials, Korean J. Rheol., 11, 143-152 (1999)
  45. D.Y. Song and T.Q. Jiang, Study on the constitutive equation with fractional derivative for the viscoelastic fluids : Modified Jeffreys model and its application, Rheol. Acta, 37, 512-517 (1998) https://doi.org/10.1007/s003970050138
  46. Y. Isono and J.D. Ferry, Stress relaxation and differential dynamic modulus of polyisobutylene in large shearing deformations, J. Rheol., 29, 273-280 (1985) https://doi.org/10.1122/1.549791
  47. W. Wilhelm, Fourier transform rheology, Macromol. Mater. Eng., 287, 83-105 (2002) https://doi.org/10.1002/1439-2054(20020201)287:2<83::AID-MAME83>3.0.CO;2-B
  48. J.H. Cha, G.S. Chang and K.W. Song, Large amplitude oscillatory shear flow behavior of commercial mayonnaise : Preliminary experimental study, Theor. Appl. Rheol., 6, 121-125 (2002)
  49. K. Hyun, S.H. Kim, K.H. Ahn and S.J. Lee, Large amplitude oscillatory shear as a way to classify the complex fluids, J. Non-Newt. Fluid Mech., 107, 51-65 (2002) https://doi.org/10.1016/S0377-0257(02)00141-6
  50. W.H. Li, H. Du and N.Q. Guo, Dynamic behavior of MR suspensions at moderate flux densities, Mater. Sci. Eng., A 371, 9-15 (2004) https://doi.org/10.1016/S0921-5093(02)00932-2