A 1280-RGB $\times$ 800-Dot Driver based on 1:12 MUX for 16M-Color LTPS TFT-LCD Displays

16M-Color LTPS TFT-LCD 디스플레이 응용을 위한 1:12 MUX 기반의 1280-RGB $\times$ 800-Dot 드라이버

  • Kim, Cha-Dong (Dept. of Electronic Engineering, Sogang University) ;
  • Han, Jae-Yeol (System LSI division, Samsung Electronics Co., Ltd) ;
  • Kim, Yong-Woo (System LSI division, Samsung Electronics Co., Ltd) ;
  • Song, Nam-Jin (System LSI division, Samsung Electronics Co., Ltd) ;
  • Ha, Min-Woo (System LSI division, Samsung Electronics Co., Ltd) ;
  • Lee, Seung-Hoon (Dept. of Electronic Engineering, Sogang University)
  • 김차동 (서강대학교 전자공학과) ;
  • 한재열 (삼성전자(주) System. LSI사업부) ;
  • 김용우 (삼성전자(주) System. LSI사업부) ;
  • 송남진 (삼성전자(주) System. LSI사업부) ;
  • 하민우 (삼성전자(주) System. LSI사업부) ;
  • 이승훈 (서강대학교 전자공학과)
  • Published : 2009.01.25

Abstract

This work proposes a 1280-RGB $\times$ 800-Dot 70.78mW 0.l3um CMOS LCD driver IC (LDI) for high-performance 16M-color low temperature poly silicon (LTPS) thin film transistor liquid crystal display (TFT-LCD) systems such as ultra mobile PC (UMPC) and mobile applications simultaneously requiring high resolution, low power, and small size at high speed. The proposed LDI optimizes power consumption and chip area at high resolution based on a resistor-string based architecture. The single column driver employing a 1:12 MUX architecture drives 12 channels simultaneously to minimize chip area. The implemented class-AB amplifier achieves a rail-to-rail operation with high gain and low power while minimizing the effect of offset and output deviations for high definition. The supply- and temperature-insensitive current reference is implemented on chip with a small number of MOS transistors. A slew enhancement technique applicable to next-generation source drivers, not implemented on this prototype chip, is proposed to reduce power consumption further. The prototype LDI implemented in a 0.13um CMOS technology demonstrates a measured settling time of source driver amplifiers within 1.016us and 1.072us during high-to-low and low-to-high transitions, respectively. The output voltage of source drivers shows a maximum deviation of 11mV. The LDI with an active die area of $12,203um{\times}1500um$ consumes 70.78mW at 1.5V/5.5V.

본 논문에서는 ultra mobile PC (UMPC) 및 휴대용 기기 시스템 같이 고속으로 동작하며 고해상도 저전력 및 소면적을 동시에 요구하는 16M-color low temperature Poly silicon (LTPS) thin film transistor liquid crystal display (TFT-LCD) 응용을 위한 1:12 MUX 기반의 1280-RGB $\times$ 800-Dot 70.78mW 0.13um CMOS LCD driver IC (LDI) 를 제안한다. 제안하는 LDI는 저항 열 구조를 사용하여 고해상도에서 전력 소모 및 면적을 최적화하였으며 column driver는 LDI 전체 면적을 최소화하기 위해 하나의 column driver가 12개의 채널을 구동하는 1:12 MUX 구조로 설계하였다. 또한 신호전압이 rail-to-rail로 동작하는 조건에서 높은 전압 이득과 낮은 소비전력을 얻기 위해 class-AB 증폭기 구조를 사용하였으며 고화질을 구현하기 위해 오프 셋과 출력편차의 영향을 최소화하였다 한편, 최소한의 MOS 트랜지스터 소자로 구현된 온도 및 전원전압에 독립적인 기준 전류 발생기를 제안하였으며, 저전력 설계를 위하여 차세대 시제품 칩의 source driver에 적용 가능한 새로운 구조의 slew enhancement기법을 추가적으로 제안하였다. 제안하는 시제품 LDI는 0.13um CMOS 공정으로 제작되었으며, 측정된 source driver 출력 정착 시간은 high에서 low 및 low에서 high 각각 1.016us, 1.072us의 수준을 보이며, source driver출력 전압 편차는 최대 11mV를 보인다. 시제품 LDI의 칩 면적은 $12,203um{\times}1500um$이며 전력 소모는 1.5V/5.5V 전원 저압에서 70.78mW이다.

Keywords

References

  1. Y oneda K, Yokoyama R., and Yamada T, 'Development Trends of LTPS TFT LCDs for Mobile Applications,' in Symp. VLSI Circuits Dig. Tech Papers, pp. 85-90, June 2001
  2. J. C. Lee and J. Y. jeong, 'High Speed, Small Area, Reliable, LTPS TFf-based Level Shifter for System-On-Panel Technology,' in Integrated Circuit Design and Technology, May 2000, pp. 1-4
  3. Kyung-suc Nah, et al, 'A 16.7M VGA Display Driver IC with Partial Graphic RAM and 500Mb/s/ch Serial Interface for Mobile a-Si TFT-LCDs,' in ISSCC Dig. Tech Papers, pp. 140-141, Feb. 2007
  4. Imre Knausz and Robert J. Bowman, 'A 250uW 0.042mm2 2MS/s 9b DAC for Liquid Crystal Display Drivers,' in ICCSS Dig. Tech Papers, pp. 172-173, Feb. 2000
  5. Jin-Ho Kim, Byong-Deok Choi, and Oh-Kyong Kwon, '1-billion-color TFT LCD TV with full HD format,' IEEE Transactions on Consumer Electronics, Nov. 2005, pp. 1042-1050
  6. Jin-Seong Kang, et al., 'A 10b Driver IC for a Spatial Optical Modulator for Full HDTV Applications,' in ISSCC Dig. Tech Papers, pp. 138-139, Feb. 2007
  7. Chih-Wen Lu and Lung-Chen Huang, 'A 10-Bit LCD Column Driver With Piecewise Linear Digital-to-Analog Converters,' IEEE J. Solid-State Circuits, vol. 43, no. 2, pp. 371-378, Feb. 2008 https://doi.org/10.1109/JSSC.2007.914274
  8. Bell. M, 'An LCD Column Driver Using a Switch Capacitor DAC, ' IEEE J. Solid-State Circuits, vol. 40 no. 12, pp. 2756-2765, Dec. 2005 https://doi.org/10.1109/JSSC.2005.858481
  9. R Hogervorst, et al., 'A Compact PowerEfficient 3V CMOS Hail-to-Rail Input/ Output Operational Amplifier for VLSI Cell Libraries,' IEEE J. Solid-State Circuits, vol. 29, no. 12, pp. 1505-1513, Dec. 1994 https://doi.org/10.1109/4.340424
  10. Pelgrom, M. J. M., Tuinhout, H. P., and Vertregt, M., 'Transistor matching in analog CMOS application,' in International Electron Devices Meeting, pp. 915-918, Dec. 1998
  11. Kinget, P. R, 'Device mismatch and tradeoffs in the design of analog circuits,' IEEE J. Solid Stage CIrcuits, vol. 40, no. 6, pp. 1212-1224, june 2005 https://doi.org/10.1109/JSSC.2005.848021
  12. A. E. Buck, C. L. McDonald, S. H. Lewis, and T. R Viswanathan, 'A CMOS bandgap reference without resistors,' IEEE J. Solid-Stage Circuits, vol. 37, no. 1, pp. 81-83, jan. 2002 https://doi.org/10.1109/4.974548
  13. Young-Jae Cho and Seung-Hoon Lee, 'An 11b 70MHz $1.2mm^2$ 49mW O.18um CMOS ADC with On-Chip Current/Voltage References,' IEEE Trans. Circuits Syst I, voL 52, no. 10, pp. 1989-1995, Oct. 2005 https://doi.org/10.1109/TCSI.2005.853251
  14. Y. D. Jeon, B. L. Jeon, S. C. Lee, S. M. Yoo, and S. H. Lee, 'A 12b 50 MHz 3.3 V CMOS acquisition time minimized AID converter,' ASP-DAC, pp. 613-616, Jan. 2000
  15. K M. Kim, et al, 'One-Chip Driver IC for 16 Million Color WXGA LTPS TFT LCD Panel,' SID International Symp. Dig. Tech Papers, pp. 1391-1393, May 2008