Journal of Life Science (생명과학회지)

Korean Society of Life Science (한국생명과학회)
권호 표지
DOI QR코드

DOI QR Code

Effects of Cooking Method and Temperature on the Lipid Oxidation of Electron-Beam Irradiated Hanwoo Steak.

가열방법 및 온도가 전자선 조사한 한우 steak의 지질산화에 미치는 영향

  • Park T. S. (Department of Animal Science, Miryang National University) ;
  • Shin T. S. (Department of Animal Science, Miryang National University) ;
  • Lee J. I. (Advanced Swine Research Institute, GyeongNam Province) ;
  • Park G. B. (Division of Animal Science, Gyeongsang National University)
  • 박태선 (밀양산업대학교 동물자원학과) ;
  • 신택순 (밀양산업대학교 동물자원학과) ;
  • 이정일 (경상남도 첨단양돈연구소) ;
  • 박구부 (경상대학교 축산과학부)
  • Published : 2005.10.01
Download PDF
⟨ Previous Next ⟩

Abstract

This study was carried out to investigate the effect of electron beam irradiation and cooking temperature on physico-chemical characteristics and lipid oxidation of beef. A total of six beef carcasses ($280\∼300 kg$) that were quality grade $1^{+}$(marbling score No.7, meat color No.4, maturity No.1, texture No.1) was purchased at the commercial slaughter house. The carcasses were transported and washed using high pressure water, and pasteulized with $ 50\% $ ethyl alcohol in the laboratory. After the carcasses were deboned and trimmed, loin and round were taken out to make steak (1.5cm thickness) or ground beef respectively. Samples were wrap or vacuum packaged and irradiated with 0, 3, 4.5, 6 and 7.5 kGy using electron-beam accelerator at Samsung Heavy Industries Ltd. Co. (in Taejun). Irradiated samples were cooked with different methods(electronic pan and gas oven) and temperatures ($ 60^{\circ}C, 70^{\circ}C and 80^{\circ}C$) and used to measure fatty acid composition, TBARS, cholesterol oxide products and panel test scores. The content of saturated fatty acids increased by increasing heating temperature in oven boiling steak (OBS) and pan boiling steak (PBS), and there was no difference by electron-beam irradiation. Both irradiated and non-irradiated treatment were high as the heating temperature increased in TBARS by heating temperature in PBS (p < 0.05) and the amount of Malonaldehyde (MA), standard of fat deterioration, was increased in OBS (p < 0.05). Non-irradiated and 3, 6 kGy treatment produced about 2 fold amount of MA at $ 60^{\circ}C $ compared with $ 80^{\circ}C $. In comparison with PBS, OBS produced much amount of MA and a bit different from non-irradiated treatment but did not show no tendency. As irradiation levels and heating temperature increased, the amount of cholesterol oxides products was increased and also pan-heating method, direct heating method, significantly increased the degree of oxidation compared with oven-heating method, indirect heating method (p < 0.05).

본 연구는 식품의 안전성에 대한 관심이 고조되면서 위생적인 식육생산을 위한 방법으로 전자선을 조사하여 이화학적 특성 및 지방산화에 미치는 영향을 조사하고자 실시하였다. 공시재료는 한우암소 지육중 육질등급 1+판정(근내지방도 No.7. 육색 No.4, 성숙도 No.1, 조직감 No.1)을 받은 지육($280\∼300kg$) 6두를 구매하였다. 구매한 원료지육을 1차 수도물로 고압수세하고 2차 $ 50\% $에틸알콜로 소독한 후 발골 정형하여 실험재료로 사용하였다. 모든 처리에서 가열온도가 높아갈수록 포화지방산의 함량이 높아갔다. PBS는 가열온도에 따른 지방산패에서 전자선 비조사구와 조사구 모두 가열온도가 높을수록 높은 지방산 패도를 나타내 었고(P<0.05), OBS 또한 malonsldehyde양이 증가하였다(p<0.05). 가열온도별로는 $ 60^{\circ}C $에 비하여 $ 80^{\circ}C $가 비조사구와 3, 6 kCy 조사구는 약 2배정도의 MA량이 생성되었다(p<0.05). OBS가 PBS보다 많은 양의 malonaldehyde가 생성되었으며, 전자선 조사 수준의 차이에는 수준에 따라 비조사구와 약간의 차이만 나타내었다. 전자선조사수준과 가열온도가 증가함에 따라 콜레스테롤 산화물의 발생량이 증가하였으며, 또한 가열방법 중 PBS가 OBS에 비하여 산화의 정도가 유의적으로 증가하였다(p<0.05).

Keywords

References

  1. Ahn, D. V., F. H. Wolfe, J. S. Sim and D. H. Kim. 1992. Packaging cooked turkey meat patties while hot reduces lipid oxidation. J. Food Sci. 57(5), 1075 https://doi.org/10.1111/j.1365-2621.1992.tb11267.x
  2. Ahn, D. V., Olson, D. G., Lee, J. I., Jo, C., Wu, C. and Chen, X. 1998. Packaging and irradiation effects on lipid oxidation and volatiles in pork patties. J. Food Sci. 63, 15-19 https://doi.org/10.1111/j.1365-2621.1998.tb15665.x
  3. Beuchat, J. R, Doyle, M. P., and Brackett, R E. 1993. Irradiation inactivation of bacterial pathogens in ground beef. AMI Foundation, Arlington, VA
  4. Buchalla, R, C. Schu'ttler and K. W. Bo'gl. 1993a. Effects of ionizing radiation on plastic food packaging materials : A review. Part J. Chemical and physical changes. J. Food Prot. 56(11), 991 https://doi.org/10.4315/0362-028X-56.11.991
  5. Buchalla, R, C. Schu'ttler and K. W. Bo'gl. 1993b. Effects of ionizing radiation on plastic food packaging materials : A review. Part 2. Global migration, sensory changes and the fate of additives. Food Prot. 56(11), 998 https://doi.org/10.4315/0362-028X-56.11.998
  6. Buege, J. A. and Aust, J. D. 1978. Microsomal lipid peroxidation. Methods Enzymol. 52, 302 https://doi.org/10.1016/S0076-6879(78)52032-6
  7. Chan, S. H., Gray, J. I. and Gomaa, E. A. 1993. Cholesterol oxidation in whole powders as influenced by processing and packaging. Food Chem. 47, 321-328 https://doi.org/10.1016/0308-8146(93)90171-B
  8. Cleveland, M. Z. and N. D. Harris, 1987. Oxidation of cholesterol in commercially processed cow's milk. J. Food Prot. 50, 867-871 https://doi.org/10.4315/0362-028X-50.10.867
  9. Dempster, J. F. 1985. Radiation preservation of meat and meat products :a review. Meat Science, 12, 61-89 https://doi.org/10.1016/0309-1740(85)90017-8
  10. Dessouki, T. M., I. M. Soliman, Y. Mifi and S. X. Saied. 1978. Acceletation of fattening beef meat aging by means of antibiotics and ionizing irradiation. Agric. Res. Review. 56, 115-126
  11. Ehioba, R M., A. A. Kraft, R A. Molins, H. W. Walker, D. G. Olson, G. Subbaraman and R. P. Skowronski. 1987. Effect of low-dose (100 krad) gamma radiation on the microflora of vacuum-packaged ground pork with and without added sodium phosphates. J. Food Sci. 52(6), 1477
  12. Folch, J. M., M. Lees and G. H. S. Stanley. 1957. A simple method for the isolation and purification of total lipids from animal tissues. J. Bio. Chem. 226, 497
  13. Giam, I. and Dugan, Jr, J. R. 1965. The fatty acid composition of free and bound lipids in freeze dried meat. J. Food Sci. 30, 262 https://doi.org/10.1111/j.1365-2621.1965.tb00299.x
  14. Groninger, H. S, A. L. Tappel and F. W. Knapp. 1956. Some chemical and organoleptic changes in gamma-irradiated meats. Food Res. 21, 555
  15. Hwang, K. T. and G. Maerker. 1993. Quantification of cholesterol oxidatin products in unirradiated and irradiated meats. J. Am. Oil Chem. Soc. 70, 371-375 https://doi.org/10.1007/BF02552709
  16. Janicki, L. J., and H. Appeldore. 1974. Effect of Broiling, Grill Frying and Microwave cooking on moisture, some lipid components and total Fatty acids of Ground Beef. J. Food Sci. 39, 715 https://doi.org/10.1111/j.1365-2621.1974.tb17964.x
  17. Kampelmacher, E. H. 1983. Irradiation for control of salmonella and other pathogens in poultry and fresh meat. Food Technol. 37(4), 117-119, 169
  18. Kilgore, L., and M. Bailey. 1970. Degradation of linoleic acid during potato frying. J. Amer. Diet. Assn. 56, 130
  19. Land. E. J. and A. J. Swallow. 1971. One electron reactions in biochemical systems as studied by pulse radioltsis. 5. Cytochromec. Arch. Biochem. Biophts. 145, 365 https://doi.org/10.1016/0003-9861(71)90049-X
  20. Lai, S. M., J. I. Gray and M. E. Zabik. 1995. Evaluation of solid phase extraction and gas chromatography for determination of cholesterol oxidation products in spray-dried whole egg. J. Agric. Food Chem. 43, 1122-1126 https://doi.org/10.1021/jf00053a002
  21. Luby, J. M., J. I. Gray and B. R. Harte. 1986. Effects of packaging and light sources on the oxidative stability of cholesterol in butter. J. Food Sci. 51, 908-911 https://doi.org/10.1111/j.1365-2621.1986.tb11197.x
  22. Mattison, M. L., A. A. Kraft, D. G. Olson, H. W. Walker, R. E. Rust and D. B. James. 1986. Effect of low dose irradition of pork loins on the microflora, sensory characteristics and fat stability. J. Food Sci. 51(2), 284-287 https://doi.org/10.1111/j.1365-2621.1986.tb11110.x
  23. Melton, S.L. 1983. Methodology for following lipid oxidation in muscle foods. Food Technol. 37, 105
  24. Missler, S. R., B. A. Wasilchuck, C. Jr. Merritt. 1985. Separation and identification of cholesterol oxidation products in dried egg preparations. J. Food Sci. 50, 595-598, 646 https://doi.org/10.1111/j.1365-2621.1985.tb13752.x
  25. Monahan, F. J., D. J. Buckley, J. I. Gray, P. A. Morrissey, A. Asgher, T. J. Hanrahan and P. B. Lynch. 1990. Effect of dietary vitamin E on the stability of raw and cooked pork. Meat Sci. 27, 99-108 https://doi.org/10.1016/0309-1740(90)90058-E
  26. Monahan, F. J., J. I. Gray, A. M. Booren, E. R. Miller, D. J. Buckley, P. A. Morrissey and E. A. Gpmaa. 1992. Influence of dietary treatment on lipid and cholesterol oxidation in pork. J. Agric. Food Chem. 40, 1310-1315 https://doi.org/10.1021/jf00020a003
  27. Naber, E. C., and M. D. Biggert, 1985. Analysis for and generation of cholesterol oxidation products in egg yolk by heat treatment. Poultry Sci. 64, 341-347 https://doi.org/10.3382/ps.0640341
  28. Ohshima, T., N. Li and C. Koizumi. 1993. Oxidative decomposition of cholesterol in fish products. J. Am. Oil Chem. Soc. 70, 595-600 https://doi.org/10.1007/BF02545326
  29. Paniangvait, P., A. J. King, A. D. Jones and B. G. German. 1995. Cholesterol oxides in foods of animal origin. J. Food Sci. 60, 1159-1174 https://doi.org/10.1111/j.1365-2621.1995.tb04548.x
  30. Patterson. M. F., A. P. Damoglou and R. K. Buick. 1993. Effects of irradiation dose and storage temperature on the growth of Listeria monocytogenes on poultry meat Food Microbiol. 10, 197 https://doi.org/10.1006/fmic.1993.1021
  31. Park, S. W. and P. B. Addis. 1985. HPLC Determination of C-7 oxidized cholesterol derivatives in foods. J. Food Sci. 50, 1437-1441, 1444 https://doi.org/10.1111/j.1365-2621.1985.tb10494.x
  32. Park, S. W. and P. B. Addis. 1986. Identification and quantitative estimation of oxidized cholesterol derivatives in heated tallow. J. Agri. Food Chem. 34, 653 https://doi.org/10.1021/jf00070a016
  33. Schiller, E.A., D. E. Pratt and E. F. Reber. 1973. Lipid changes in egg yolks and cakes baked in microvave ovens. J. Amer. Diet. Assn. 62, 529
  34. Siedler, A. J., D. Springer, H. T. Slover and J. Kizlaitis. 1964. Nutrient content of variety meats. 3. Fatty acid composition of lipids of certain raw and cooked variety meats. J. Food Sci. 29, 877 https://doi.org/10.1111/j.1365-2621.1964.tb00465.x
  35. Smith, J. L. 1981. Cholesterol autoxidation. Plenum press. New York
  36. Terrell, R. N., R. W. Lewis, R. G. Cassens and R. W. Bray. 1967. Fatty acid composition of bovine subcutaneous fat depots determined by gas-liquid chromatography. J. Food Sci. 32, 516
  37. Wilting, J., H. Nauta and R. Braams. 1971. The reaction rate constant of hydrated electron with some hemoproteins as a function of the pH. FEBS Letters 16, 147 https://doi.org/10.1016/0014-5793(71)80354-X
  38. Zubillaga, M. P. and G. Maerker. 1991. Quantification of three cholesterol oxidation products in raw meat and chicken. J. Food Sci. 56, 1194-1196 https://doi.org/10.1111/j.1365-2621.1991.tb04732.x
  39. Zunin, P., F. Evangelisti, M. F. Caboni, G. Penzazzi, G. Lercker, and E. Tiscornia, 1995. Cholesterol oxidation in baked foods containing fresh and powdered eggs. J. Food Sci. 60, 913-916 https://doi.org/10.1111/j.1365-2621.1995.tb06260.x

Cited by

  1. Effect of Charcoal Broiling on the Formation of Volatile Compounds in Gamma-Irradiated Dakgalbi, a Korean Chicken-Based Food vol.33, pp.5, 2013, https://doi.org/10.5851/kosfa.2013.33.5.603