Utilization of Waste Tires as Soil Reinforcement; (1) Soil Reinforcing Effect

지반보강재로서 폐타이어의 활용; (1) 지반보강 효과

  • 윤여원 (인하대학교 환경토목공학부) ;
  • 최경순 (에스코 컨설턴) ;
  • 윤길림 (한국해양연구원 연안항만공학연구본) ;
  • 김방식 (충주대학교 환경토목공학부)
  • Published : 2004.04.01

Abstract

This paper is to investigate the reinforcing effects of newly devised Tire-cell mat made of waste tires in sand. Parametric study on number of connection bolts between Tirecells, relative density of sand, embedded depth, number of reinforced layers and width of Tirecell mat was made by using plate loading tests. It is found that the number of connection bolt was enough to maintain the given pressure. The bearing capacity ratio(BCR), which is defined as the rate of ultimate bearing capacity of reinforced soil to that of unreinforced soil, is the highest at the lowest density. And the reinforcing effect can be obtained in case of embedded depth within 1.0B, where B is loading width. Also settlement reduction is the highest at the lowest density of sand. The effect of number of Tirecell reinforced layers with 0.4B to 0.5B interval is limited to 2 layers and further reinforcing effects can not be obtained beyond 3 layers. Especially, the bearing capacity increased remarkably at 1 layer of reinforcement and the degree of increase was small from 1 layer to 2 layers of reinforcement. The effect of mat width of Tirecell was not significant because of high stiffness of Tirecell although the maximum bearing capacity was shown at the 2.0B mat width and the reinforcing effects of Tirecell, in general, was prominent compared with those of commercial Geoweb.

본 연구에서는 폐타이어를 활용하여 새롭게 고안한 타이어셀 매트의 모래지반 보강효과를 알아보기 위하여 다양한 조건의 평판재하시험을 수행하였다. 계하시험조건은 셀 간의 연결을 위한 볼트 수, 상대밀도, 복토두께, 보강층수, 타이어셀 매트 폭을 변수로 보강효과를 조사하였다. 재하시험 결과 연결용 볼트의 수는 지지력에 큰 영향을 미치지 않는 것으로 나타났으며 1개의 볼트로 주어진 하중을 충분히 견딜 수 있었다. 보강토의 극한지지력과 무보강토의 극한지지력의 비로 정의되는 지지력비(BCR)는 낮은 밀도에서 최대값을 나타내었다. 또한 극한상태에서의 침하감소효과도 낮은 밀도에서 큰 것으로 나타났다. 복토에 따른 보강효과는 복토두께가 1.0B이내에서 보강효과를 얻을 수 있었으나 그 이상에서는 보강효과가 나타나지 않았다. 보강층의 간격이 재하판폭의 0.4내지 0.5배일 경우 보강효과는 보강층이 2층일 때까지는 보강효과가 있으나 3층 이상에서는 효과가 없는 것으로 나타났다. 특히 보강층이 1개층일 때 지지력 증가 효과가 크며 2개층으로 증가함에 따라 증가율은 저하되는 것으로 나타났다. 타이어셀 매트폭이 2.0B에서 최대지지력을 보였으나 매트폭의 영향은 타이어셀의 강성이 크기 때문에 미소하였다. 타이어셀 매트의 지반보강효과는 문헌상의 상업용 지오웹과 비교하여 뛰어난 것으로 나타났다.

Keywords

References

  1. 한양대학교 산업대학원 석사학위논문 옹벽 뒤 채움재로서 폐타이어 활용방안에 관한 연구 김규래
  2. 토목섬유 학술발표회 논문집 연약지반상 고속철도 노반 축조시 지오셀 시스템의 효과 김진만;조삼덕;윤수호;정문경;김영윤
  3. 한국지반공학회지 v.10 no.3 지오그리드 보강 여부에 따른 정방샹 얕은 기초의 지지력에 관한 연구 신방웅;여병철;김수삼;Das,B.M.
  4. 한국지반환경공학회 논문집 v.4 no.3 모래지반에서 모형 지오셀에 의한 보강 효과 윤영원;김풍식;천성한
  5. 한국지반공학회 봄학술발표회 논문집 지반보강재로서 폐타이어의 보강 효과 윤여원;최경순;천성찬
  6. 경희대학교 석사학위 논문 연약지반상 촐도 노반에 적용한 지오셀 시스템의 보강 효과에 관한 연구 이상구
  7. KGS '93 National Conference Ground Stabilization and Reinforcement 지오셀을 이용한 지반 안정 이진웅;이종덕
  8. 재활용종합정보 한국자원재생공사
  9. ASCE, No.GT6 Stability of Loaded Footings on Reinforced Soil Akinmusuru,J.O.;Akinbolade,J.A.
  10. Proc. Transportation Research Record 1188 Large-Scale Model Tests of Geocomposite Mattresses over Peat Subgrades Barthurst,R.J.;Jarett,P.M.
  11. Geotextile and geomembrances v.19 Bearing Capacity of Strip footing s supported on geocell-reinforced sand Dash,S.K.;Krishinaswany,N.R.;Rajagopal,K. https://doi.org/10.1016/S0266-1144(01)00006-1
  12. Journal of Geotechnical Engineering v.122 Sand Reinforced with Shredded Waste Tire Foose,G.J.;Benson,C.H.;Boscher,P.I. https://doi.org/10.1061/(ASCE)0733-9410(1996)122:9(760)
  13. Canadian Geotechnical Journal v.37 Tire-reinforced earthfill Part1:Cosnstruction of a test fill performance and retaining wall design Garga,V.K.;O'Shaughnessy,V. https://doi.org/10.1139/cgj-37-1-75
  14. Proc. of the 13th ISMGE v.2 Field pallout test of scrap tire teinforcement layers under different soil surcharges Gersovich,D.M.S.;de Medleiros,L.V.;Sayao,A.S.F.J.
  15. Proc. ASCE 1988 Spring Meeting Bearing Capacity and Settlement Characteristics of Geoweb-Reinforeced Earth Slabs Guido,V.A.;Christou,S.N.
  16. Investigation of exothernic reaction inthe shred fill located on SR 100 in Ilwaco, Washington. Federal Highway Administration Humphrey,D.N.
  17. Grouting, Soil Improvement and Geosynthesis v.30 no.2 Properties of the chips for light weight fill Humphrey,D.N.
  18. Proc. The 1986 International Conference on Bearing Capacity of Roads and Airfields Polymer Grid Cell Reinforcement in Pavement Constraction Jamnejad,G.;Kazerani,B.;Harvey,R.C.;Clarke,J.D.
  19. Designing with Geosynthetics(Third Edition) Koemer,R.M.
  20. Proc. The American Society for Testing and Materials Model Studies on Geocell Supposrted Enbankments Constructed over a Soft Clay Foundation Krishnaswarry,N.R.;Rajagopal,K.;Madhavi Latha,G.
  21. Journal of Grouting Soil Improvement and Geosynthetics v.2 Soft Clay Subgrade Stabilisation Using Ceocells Mhaiskar,S.Y.;Mandal,J.N.
  22. Proc. of the 2nd Int'l Congrass on Environmental Geotechnics Utilization of used tyres in civil engineering - The Pnesol "Tyresoil" Nguyen,T.H.
  23. Proc. ASCE Symposium on Earth reinforcement Sand Reinforcement Using Paper Grid Cells Res,C.;Mitcheti,J.K.
  24. Proc. of the 15th ISMGE v.3 Geotchnical and environmental properties of tire shreds in landfill drainage applications Westerberg,B.;Macsik,J.