한국전기전자재료학회논문지 (Journal of the Korean Institute of Electrical and Electronic Material Engineers)

  • 제16권12호
  • /
  • Pages.1131-1135
  • /
  • 2003
  • /
  • 1226-7945(pISSN)
  • /
  • 2288-3258(eISSN)
한국전기전자재료학회 (The Korean Institute of Electrical and Electronic Material Engineers)
권호 표지
DOI QR코드

DOI QR Code

Yttrium Iron Garnet의 소결시 나타나는 비정상 입성장 현상과 그의 억제

Suppression of the Abnormal Grain Growth in the Sintering of Yttrium Iron Garnet

  • 김동영 (한국전자통신연구원 유전체RF소자팀) ;
  • 이홍열 (한국전자통신연구원 유전체RF소자팀) ;
  • 전동석 (한국전자통신연구원 유전체RF소자팀) ;
  • 이상석 (한국전자통신연구원 유전체RF소자팀)
  • 발행 : 2003.12.01
PDF 다운로드
⟨ 이전 논문 다음 논문 ⟩

초록

In the sintering of YIG, abnormal grain growth phenomena were observed. This abnormal grain growth is related to the sintering temperature in this experiment. In the sintering below 1450$^{\circ}C$, the sintered body showed narrow size distribution. However, in the sintering at 1450$^{\circ}C$, a few grains grew rapidly with respect to other grains, and bimodal size distribution was appeared. From the observation of the microstructure, liquid phase was not observed far from the abnormally grown large grains, but only near the large grains. This means that the abnormal grain growth was caused by the nonuniform distribution of liquid phase which promote the grains growth. Because the growth rate of grains near the liquid phase is much higher than that of the other grains, a few grains grow rapidly. This nonuniform distribution of liquid phase was thought to be due to the nonuniform mixing of the calcined powders. This abnormal grain growth was suppressed by enhancement of the compositional uniformity by multiple calcination.

키워드

참고문헌

  1. Microwave Magnetics (Ch9) R.F.Soohoo
  2. Proc. of the IEEE v.63 no.5 A review of ferrites for microwave applications G.F.Dionne https://doi.org/10.1109/PROC.1975.9827
  3. IEEE Trans. Mag. v.MAG 23 no.5 Narrow FMR linewidth dependence of growth conditions in LPE YIG films J.M.Desvignes;D.Mahasoro;H.Le.Gall
  4. J. Am. Ceram. Soc. v.54 no.1 Influence of Milled powder Partiele Size Distribution on the Microstructure and Electrical Properties of Sintered Mn Zn Ferritc G.R.Chol
  5. Materials Scienee Monograms v.16 Microstructural studies of abnormal grain growth development in $Al_2O_3$ S.J.Bennison;M.P.Harmer
  6. J.Am.Ceram.Soc v.70 no.1 Controlof liquid phasc cnhanccd discontinuous grain growth in barium titanate D.F.K.Hennings;R.Janssen;P.J.S.Rcynen https://doi.org/10.1111/j.1151-2916.1987.tb04847.x
  7. J. Appl. Phys. v.51 no.8 Sintering and varistor charac teristics of ZnO‥$Bi_2O_3$ ceramics J.Wong https://doi.org/10.1063/1.328266
  8. Metall. Mater. Trans v.27[A] Abnormal grain growth of faceted WC grains in a Co matrix Y,J.Park;N.M.Hwang;D.Y.Yoon
  9. Mater. Lett. v.20 Effect of Heating Rate on the Exaggerated Grain Growth During the Sintering of Sr Hexaferrite H.H.Yoon;D.Y.Kim https://doi.org/10.1016/0167-577X(94)90033-7
  10. 한국요업학회지 v.36 no.12 BaTiO₃에서 이차 비정상 입성장과 (111) 쌍정판 김재석;이종봉;허태무;이호용;김도연;