Improved Convective Heat Transfer Correlations for Two-Phase Two-Component Pipe Flow

  • Kim, Dongwoo (Schol of Mechanical and Aerospace Engineering, Oklahoma State University Stillwater)
  • 발행 : 2002.03.01

초록

In this study, six two-phase nonboiling heat transfer correlations obtained from the recommendations of our previous work were assessed. These correlations were modified using seven extensive sets of two-phase flow experimental data available from the literature, for vertical and horizontal tubes and different flow patterns and fluids. A total of 524 data points from five available experimental studies (which included the seven sets of data) were used for improvement of the six identified correlations. Based on the tabulated and graphical results of the comparisons between the predictions of the modified heat transfer correlations and the available experimental data, appropriate improved correlations for different flow patterns, tube orientations, and liquid-gas combinations were recommended.

키워드

참고문헌

  1. Aggour, M. A., 1978, 'Hydrodynamics and Heat Transfer in Two-Phase Two-Component Flow,' Ph. D. Thesis, University of Manitoba, Winnipeg, MB, Canada
  2. Chu, Y.-C. and B. G. Jones, 1980, 'Convective Heat Transfer Coefficient Studies in Upward and Downward, Vertical, Two-Phase, Non-Boiling Flows,' AIChE Symp. Series, Vol. 76, pp. 79-90
  3. Davis, E. J. and M. M. David. 1964, 'Two-Phase Gas-Liquid Convection Heat Transfer,' I&EC Fundamentals, Vol. 3, No. 2, pp. 111-118 https://doi.org/10.1021/i160010a005
  4. Dorresteijn, W. R., 1970, 'Experimental Study on Heat Transfer in Upward and Downward Two-Phase Flow of Air and Oil Through 70mm Tubes,' Proc. 4th Int. Heat Transfer Conf., Vol. 5, B 5. 9, pp. 1-10
  5. Dusseau, W. T., 1968, 'Overall Heat Transfer Coefficient for Air-Water Froth in a Vertical Pipe,' M. S. Thesis, Chemical Engineering, Vanderbilt University
  6. Elamvaluthi, G. and N. S. Srinivas, 1984, 'Two-Phase Heat Transfer in Two Component Vertical Flows,' Int. J. Multiphase Flow, Vol. 10, No. 2, pp. 237-242 https://doi.org/10.1016/0301-9322(84)90021-1
  7. Groothuis, H. and W. P. Hendal, 1959, 'Heat Transfer in Two-Phase Flow,' Chemical Engineering Science, Vol. 11, pp. 212-220 https://doi.org/10.1016/0009-2509(59)80089-0
  8. Hughmark, G. A., 1965, 'Holdup and Heat Transfer in Horizontal Slug Gas Liquid Flow,' Chem. Engng. Sci., Vol. 20, pp. 1007-1010 https://doi.org/10.1016/0009-2509(65)80101-4
  9. Khoze, A. N., S. V. Dunayev and V. A. Sparin, 1976, 'Heat and Mass Transfer in Rising Two-Phase Flows in Rectangular Channels,' Heat Transfer Soviet Research, Vol. 8, No. 3, pp. 87-90
  10. King, C. D. G., 1952, 'Heat Transfer and Pressure Drop for an Air-Water Mixture Flowing in a 0.737 Inch I. D. Horizontal Tube,' M. S. Thesis, University of California, California
  11. Knott, R. F., R. N. Anderson, A. Acrivos and E. E. Petersen, 1959, 'An Experimental Study of Heat Transfer to Nitrogen-Oil Mixtures,' Ind. and Engineering Chemistry, Vol. 51, No. 11, pp. 1369-1372 https://doi.org/10.1021/ie50599a032
  12. Kudirka, A. A., R. J. Grosh and P. W. McFadden, 1965, 'Heat Transfer in Two-Phase Flow of Gas-Liquid Mixtures,' I & EC Fundamentals, Vol. 4, No. 3, pp. 339-344 https://doi.org/10.1021/i160015a018
  13. Martin, B. W. and G. E. Sims, 1971, 'Forced Convection Heat Transfer to Water With Air Injection in a Rectangular Duct,' Int. J. Heat Mass Transfer, Vol. 14, pp. 1115-1134 https://doi.org/10.1016/0017-9310(71)90208-0
  14. Oliver, D. R. and S. J. Wright, 1964, 'Pressure Drop and Heat Transfer in Gas-Liquid Slug Flow in Horizontal Tubes,' British Chem. Engrg., Vol. 9, No. 9, pp. 590-596
  15. Ravipudi, S. R. and T. M. Godbold, 1978, 'The Effect of Mass Transfer on Heat Transfer Rates for Two-Phase Flow in a Vertical Pipe,' Proc. 6th Int. Heat Transfer Conf., Toronto, Vol. 1, pp. 505-510
  16. Rezkallah, K. S. and G. E. Sims, 1987, 'An Examination of Correlations of Mean Heat Transfer Coefficients in Two-Phase and Two-Component Flow in Vertical Tubes,' AIChE Symp. Series, Vol. 83, pp. 109-114
  17. Serizawa, A., I. Kataoka and I. Michiyoshi, 1975, 'Turbulence Structure of Air-Water Bubbly Flow-III. Transport Properties,' Int. J. Multiphase Flow, Vol. 2, pp. 247-259 https://doi.org/10.1016/0301-9322(75)90013-0
  18. Shah, M. M., 1981, 'Generalized Prediction of Heat Transfer During Two Component Gas-Liquid Flow in Tubes and Other Channels,' AIChE Symp. Series, Vol. 77, No. 208, pp. 140-151
  19. Ueda, T. and M. Hanaoka, 1967, 'On Upward Flow of Gas-Liquid Mixtures in Vertical Tubes: 3rd. Report, Heat Transfer Results and Analysis,' Bull. JSME, Vol. 10, pp. 1008-1015 https://doi.org/10.1299/jsme1958.10.1008
  20. Vijay, M. M., M. A. Aggour and G. E. Sims, 1982, 'A Correlation of Mean Heat Transfer Coefficients for Two-Phase Two-Component Flow in a Vertical Tube,' Proceedings of 7th Int. Heat Transfer Conference, Vol. 5, pp. 367-372
  21. Sieder, E. N. and G. E. Tate, 1936, 'Heat Transfer and Pressure Drop of Liquids in Tubes,' Ind. Eng. Chem., Vol. 28, No. 12, pp. 1429 https://doi.org/10.1021/ie50324a027
  22. Akimenko, A. D., G. A. Zemskov and A. A. Skvortsov, 1970, 'Study of Heat Transfer to Water-Air Flow,' Heat Transfer-Soviet Research, Vol. 2, No. 2, pp. 47-49
  23. Barnea, D. and N. Yacoub, 1983, 'Heat Transfer in Vertical Upwards Gas-Liquid Slug Flow,' Int. J. Heat Mass Transfer, Vol. 26, No. 9, pp. 1365-1376 https://doi.org/10.1016/S0017-9310(83)80068-4
  24. Davis, E. J., S. C. Hung and S. Arciero, 1975, 'An Analogy for Heat Transfer with Wavy/Stratified Gas-Liquid Flow,' AIChE Journal, Vol. 21, No. 5, pp. 872-878 https://doi.org/10.1002/aic.690210507
  25. Domanskii, I. V., V. B. Tishin and V. N. Sokolov, 1969, 'Heat Transfer During Motion of Gas-Liquid Mixtures in Vertical Pipes,' J. of Applied Chemistry of the USSR, Vol. 42, No. 4, pp. 809-813
  26. Fedotkin, I. M. and L. P. Zarudnev, 1970, 'Correlation of Experimental Data on Local Heat Transfer in Heating of Air-Liquid Mixtures in Pipes,' Heat Transfer-Soviet Research, Vol. 2, No. 1, pp. 175-181
  27. Fried, L., 1954, 'Pressure Drop and Heat Transfer for Two-Phase, Two-Component Flow,' Chem. Eng. Prog. Symp. Series, Vol. 50, No. 9, pp. 47-51
  28. Ivanov, M. Y. and E. S. Arustamyan, 1971, 'Study of Heat Transfer in an Ascending Gas-Liquid Flow,' Heat Transfer Soviet Research, Vol. 3, No. 2, pp. 149-153
  29. Johnson, H. A., 1955, 'Heat Transfer and Pressure Drop for Viscous-Turbulent Flow of Oil-Air Mixtures in a Horizontal Pipe,' ASME Trans., Vol. 77, pp. 1257-1264
  30. Johnson, H. A. and A. H. Abou-Sabe, 1952, 'Heat Transfer and Pressure Drop for Turbulent Flow of Air-Water Mixture in a Horizontal Pipe,' ASME Trans., Vol. 74, pp. 977-987
  31. Kapinos, V. M., A. F. Slitenko, N. B. Chirkin and L. V. Povolotskiy, 1975, 'Heat Transfer in the Entrance Section of a Pipe with a Two-Phase Flow,' Heat Transfer-Soviet Research, Vol. 7, No. 2, pp. 126-128
  32. Lunde, K. E., 1961, 'Heat Transfer and Pressure Drop in Two-Phase Flow,' Chemical Engineering Progress Symposium Series, Vol. 57, No. 32, pp. 104-110
  33. Michiyoshi, I., 1978, 'Heat Transfer in Air-Water Two-Phase Flow in a Concentric Annulus,' Proc. 6th Int. Heat Transfer Conf., Toronto, Vol. 6, pp. 499-504
  34. Novosad, Z., 1955, 'Heat Transfer in Two-Phase Liquid - Gas Systems,' Collection Czecholav. Chem. commun., Vol. 20, pp. 477-499 https://doi.org/10.1135/cccc19550477
  35. Oliver, D. R. and A. Young Hoon, 1968, 'Two-Phase Non-Newtonian Flow. Part II: Heat Transfer,' Trans. INSTN Chem. Engrs., Vol. 46, pp. T116-T122
  36. Ovchinnikov, Y. V. and A. N. Khoze, 1970, 'Heat and Mass Transfer in Two-Component, Two-Phase Flows Inside of Cylinders,' Heat Transfer Soviet Research, Vol. 2, No. 6, pp. 130-135
  37. Ozbelge, T. A. and T. G. Somer, 1994, 'A Heat Transfer Correlation for Liquid-Solid Flows in Horizontal Pipes,' Chemical Engineering Journal, Vol. 55, pp. 39-44 https://doi.org/10.1016/0923-0467(94)87004-7
  38. Shaharabanny, O., Y. Taitel and A. E. Dukler, 1978, 'Heat Transfer During Intermittent/Slug Flow in Horizontal Tubes: Experiments,' Proceedings of the 2nd CSNI Specialists Meeting, June 12-14, Paris, pp. 627-649
  39. Shoham, O., A. E. Dukler and Y. Taitel, 1982, 'Heat Transfer During Intermittent/Slug Flow in Horizontal Tubes,' Ind. Eng. Chem. Fundam., Vol. 21, pp. 312-319 https://doi.org/10.1021/i100007a020
  40. Vijay, M. M., 1978, 'A Study of Heat Transfer in Two-Phase Two-Component Flow in a Vertical Tube,' Ph. D. Thesis, University of Manitoba, Winnipeg, MB, Canada
  41. Rezkallah, K. S., 1987, 'Heat Transfer and Hydrodynamics in Two-Phase Two-Component Flow in a Vertical Tube,' Ph. D. Thesis, University of Manitoba, Winnipeg, MB, Canada
  42. Pletcher, R. H., 1966, 'An Experimental and Analytical Study of Heat Transfer and Pressure Drop in Horizontal Annular Two-Phase, Two-Component Flow,' Ph. D. Thesis, Cornell-University, Ithaca, New York
  43. Lockhart, R. and R. C. Martinelli, 1949, 'Proposed Correlation of Data for Isothermal Two-Phase, Two-Component Flow in Pipes,' Chem. Eng. Prog., Vol. 45, No. 1, pp. 39-48
  44. Govier, G. W. and K. Aziz, 1973, The Flow of Complex Mixtures in Pipes, Van Nostrand Reinhold Company, New York
  45. Griffith, P. and G. B. Wallis, 1961, 'Two-Phase Slug Flow,' J. Heat Transfer, Trans. ASME, Ser. C 83, pp. 307-320
  46. Hewitt, G. F. and N. S. Hall-Taylor, 1970, Annular Two-Phase Flow, Pergamon Press Ltd., Oxford
  47. Taitel, Y., D. Barnea and A. E. Dukler, 1980, 'Modeling Flow Pattern Transitions for Steady Upward Gas-Liquid Flow in Vertical Tubes,' AIChE Journal, Vol. 26, No. 3, pp. 345-354 https://doi.org/10.1002/aic.690260304
  48. Taitel, Y. and A. E. Dukler, 1976, 'A Model for Predicting Flow Regime Transitions in Horizontal and Near Horizontal Gas-Liquid Flow,' AIChE Journal, Vol. 22, No. 1, pp. 47-54 https://doi.org/10.1002/aic.690220105
  49. Kim, D., Ghajar, A. J., Dougherty, R. L., and Ryali, V. K., 'Comparison of Twenty Two-Phase Heat Transfer Correlations with Seven Sets of Experimental Data, Including Flow Pattern and Tube Orientation Effects,' Heat Transfer Engineering, Vol. 20, January 1999, pp. 15-40